Bioresource and Agricultural Engineering Commons^™

Fuel Consumption Models For Tractor Test Reports, Michael F. Kocher, Bryan J. Smith, Roger M. Hoy, Jeffrey C. Woldstad, Santosh Pitla

Department of Agricultural and Biological Systems Engineering: Faculty Publications

Five models for estimating fuel consumption for agricultural tractors with partial drawbar loads were compared. Data were collected from eight John Deere tractors, JD 7230R (e23), 7250R (e23), 7270R (e23), 7290R (e23), 8320R (16 speed), 7290R (IVT), 8345RT (IVT), 8370R (IVT), on the drawbar test track at the Nebraska Tractor Test Lab. The tractors were tested with seven load levels per speed at three different travel speeds as close as possible to 7.5, 10, and 13 km h-1. The IVT tractors were operated in auto mode, and the geared tractors were shifted up three gears and throttled back to the …

Fate And Impacts Of Priority Pollutant Metals In Coal Fly Ash–Soil–Switchgrass Plant Mesocosms, Olushola M. Awoyemi, E. Kudjo Dzantor

Coal Combustion and Gasification Products Journal Archive

Coal fly ash (CFA) is a coal combustion by-product containing heavy metals (HMs) that can enter and accumulate in environmental matrices. The current study assessed the fate and effects of HMs contained in CFA on Armour silt loam (ASL) soil, switchgrass plant, and leachate. Soil impact indices compared levels of HMs in the CFA-soil admixtures to control soil (without CFA). These indices include contamination factor (*C*~f~), modified degree of contamination (m*C*~d~), and pollution load index (PLI). The ratio of the levels of HMs in switchgrass root and shoot tissues to their levels in the CFA-soil admixtures were used to determine …

Field-Observed Angles Of Repose For Stored Grain In The United States, Rumela Bhadra, Mark E. Casada, Sidney A. Thompson, Josephine M. Boac, Ronaldo G. Maghirang, Michael D. Montross, Aaron P. Turner, Samuel G. Mcneill

Biosystems and Agricultural Engineering Faculty Publications

Bulk grain angle of repose (AoR) is a key parameter for inventorying grain, predicting flow characteristics, and designing bins and grain handling systems. The AoR is defined for two cases, piling (dynamic) or emptying (static), and usually varies with grain type. The objective of this study was to measure piling angles of repose for corn, sorghum, barley, soybeans, oats, and hard red winter (HRW) wheat in steel and concrete bins in the United States. Angles were measured in 182 bins and 7 outdoor piles. The piling AoR for corn ranged from 15.7° to 30.2° (median of 20.4° and standard deviation …

Automated Calibration Of Electrochemical Oxygen Sensors For Use In Compost Bedded Pack Barns, John T. Evans, Michael P. Sama, Joseph L. Taraba, George B. Day

Biosystems and Agricultural Engineering Faculty Publications

The objective of this study was to develop an automated calibration process for a galvanic cell type oxygen sensor. The manufacturer recommended a two-point calibration at room temperature; however, testing revealed that the response was not linear when both the temperature and oxygen concentrations varied. Thus, additional points were needed to generate a representative calibration equation and to reduce the sensor prediction interval. The calibration process needed to be capable of automatically recording sensor response (voltage) at an array of temperatures and oxygen concentrations. Calibration gases were used to precisely control the oxygen concentration inside a small manifold, and an …

Application Of Hyperspectral Imaging And Acoustic Emission Techniques For Apple Quality Prediction, Nader Ekramirad, Ahmed Rady, Akinbode A. Adedeji, Reza Alimardani

Biosystems and Agricultural Engineering Faculty Publications

There is a growing demand for developing effective non-destructive quality assessment methods with quick response, high accuracy, and low cost for fresh fruits. In this study, hyperspectral reflectance imaging (400 to 1000 nm) and acoustic emission (AE) tests were applied to ‘GoldRush‘ apples (total number, n = 180) to predict fruit firmness, total soluble solids (TSS), and surface color parameters (L*, a*, b*) during an eight-week storage period. Partial least squares (PLS) regression, least squares support vector machine (LS-SVM), and multivariate linear regression (MLR) methods were used to establish models to predict the quality attributes of the apples. The results …

Ammonia And Carbon Dioxide Emissions Of Three Laying-Hen Housing Systems As Affected By Manure Accumulation Time, Timothy A. Shepherd, Hongwei Xin, John P. Stinn, Morgan D. Hayes, Yang Zhao, Hong Li

Biosystems and Agricultural Engineering Faculty Publications

Laying-hen housing design and management are the most significant factors affecting the generation and release of gaseous ammonia to the atmosphere. Transitioning the hen housing type from traditional high-rise (where manure is stored within the house for about one year) to modern manure-belt style (where manure is removed every 1 to 4 d and placed into long-term storage) has significantly improved in-barn air quality and reduced farm-level ammonia emissions. As a direct result of the advantages, 100% of new construction for U.S. egg production incorporates manure-belt systems that regularly remove manure from the houses. However, manure-belt system designs (e.g., active …

Development And Evaluation Of A Low-Cost Probe-Type Instrument To Measure The Equilibrium Moisture Content Of Grain, Paul R. Armstrong, Samuel G. Mcneill, Naomi Manu, Augustine Bosomtwe, James K. Danso, Enoch Osekre, George Opit

Biosystems and Agricultural Engineering Faculty Publications

Storage of grain in bags is common in Africa, Asia, and many other less developed countries making a bag probing method well-suited for moisture content (MC) measurement. A low-cost meter was developed under a USAID project to reduce post-harvest loss (PHL). The meter, referred to as the PHL meter, measures the MC of maize and other grains based on relative humidity (RH) and temperature (T) measurements obtained by a small digital sensor located in the tip of a tubular probe that can be inserted into bags of grain or other grain bulks. Measurements are used by equilibrium moisture content (EMC) …

Evaluating Ventilation Rates Based On New Heat And Moisture Production Data For Swine Production, Yanxi Lu, Morgan D. Hayes, John P. Stinn, Tami M. Brown-Brandl, Hongwei Xin

Biosystems and Agricultural Engineering Faculty Publications

Heat and moisture production (HMP) rates of animals are used for calculation of ventilation rate (VR) in animal housing. New swine HMP data revealed considerable differences from previously reported data. This project determined new design VRs and evaluated differences from previously recommended VRs. The swine production stages evaluated included gestation, farrowing, nursery, growing, and finishing. The ranges of ambient temperature and ambient relative humidity (RH) evaluated for VR were -25°C to 15°C in 10°C increments and 15% to 75% in 15% increments, respectively. Indoor set points for temperature and RH were, respectively, 15°C, 20°C, 25°C and 60%, 70%, 80% for …

Evaluation Of Flocculation, Sedimentation, And Filtration For Dewatering Of Scenedesmus Algae, Nicholas A. Rhea, Jack Groppo, Czarena Crofcheck

Biosystems and Agricultural Engineering Faculty Publications

Algae can be used as a feedstock for agricultural fertilizers, livestock and poultry feeds, anaerobic digestion, and biofuel production. For each end product, the requirements for moisture content (or solids content) vary, such that a desirable water removal strategy needs to be adaptable to varying levels of water removal. Flocculation, sedimentation, and filtration were evaluated as possible strategies for thickening and dewatering of algae. The goal of this study was to validate that algae cells treated by such means could be processed by vacuum belt filters and to determine the conditions under which the solids content could be increased to …

Effects Of Biochar Treatment Of Municipal Biosolids And Horse Manure On Quality Of Runoff From Fescue Plots, Rachel Williams, Dwayne R. Edwards

Biosystems and Agricultural Engineering Faculty Publications

Land-applied horse manure and municipal biosolids can increase nutrient and bacteria concentrations in runoff. Biochar has been demonstrated to have beneficial impacts on nutrient retention and runoff quality when used to treat other land-applied organic soil amendments (e.g., poultry manure). The objective of this study was to evaluate the effects of biochar addition to horse manure and municipal biosolids on runoff concentrations of nutrients and fecal coliforms. Biochar was added at 5% to 8% (wet basis) to horse manure and biosolids that were applied to 2.4 m x 6.1 m fescue plots followed by application of simulated rainfall (102 mm …

A Novel Diffuse Fraction-Based Two-Leaf Light Use Efficiency Model: An Application Quantifying Photosynthetic Seasonality Across 20 Ameriflux Flux Tower Sites, Hao Yan, Shao-Qiang Wang, Kai-Liang Yu, Bin Wang, Qin Yu, Gil Bohrer, Dave P. Billesbach, Rosvel Bracho, Faiz Rahman

Department of Agricultural and Biological Systems Engineering: Faculty Publications

.

Diffuse radiation can increase canopy light use efficiency (LUE). This creates the need to differentiate the effects of direct and diffuse radiation when simulating terrestrial gross primary production (GPP). Here, we present a novel GPP model, the diffuse-fraction-based two-leaf model (DTEC), which includes the leaf response to direct and diffuse radiation, and treats maximum LUE for shaded leaves (ε_msh defined as a power function of the diffuse fraction (D_f)) and sunlit leaves (ε_msu defined as a constant) separately. An Amazonian rainforest site (KM67) was used to calibrate the model by simulating the linear relationship between …

Geopolymerization Of Coal Ash To Produce Cementless Binders, Hamid Akbari, Robert Mensah-Biney, Jonathan Simms

Coal Combustion and Gasification Products Journal Archive

The main objective of this study was to evaluate geopolymer concrete made from coal combustion by-products, disposed of in landfills, as a potential substitute for the ordinary Portland cement (OPC), which is responsible for 5-8% of the total CO2 emissions in the world. In this study, a coal fly ash sample from the Carolinas was used in a chemical process known as geopolymerization to produce a “geopolymer” binder. The developed geopolymer binder could competently substitute the OPC binder in regular concrete applications. An experimental design program was conducted to optimize parameters of the geopolymerization affecting the strength of the final …

Groundwater Monitoring And Data Analysis Under The Coal Combustion Residuals Rule, Bruce Hensel

Coal Combustion and Gasification Products Journal Archive

No abstract provided.

Ponded And Landfilled Fly Ash As A Source Of Rare Earth Elements From A Kentucky Power Plant, James C. Hower, John G. Groppo, Kevin R. Henke, Uschi M. Graham, Madison M. Hood, Prakash Joshi, Dorin V. Preda

Coal Combustion and Gasification Products Journal Archive

Twenty samples, with one composite sample built out of the 20 individual samples, of ponded ash were collected at a Kentucky power plant. The coal feed throughout the history of the power plant was central eastern Kentucky low- to moderate-S high volatile A bituminous coal. The pond was in the process of being excavated, with the ash moved to a landfill on another company property. In spite of the long history of the pond and the expected variation in coal supply, and perhaps because of the mixing due to the excavation, there is little variation in ash-basis rare earth elements …

Rare Earth Element Distribution In Fly Ash Derived From The Fire Clay Coal, Kentucky, Madison M. Hood, Ross K. Taggart, Ryan C. Smith, Heileen Hsu-Kim, Kevin R. Henke, Uschi Graham, John G. Groppo, Jason M. Unrine, James C. Hower

Coal Combustion and Gasification Products Journal Archive

Fly ash was collected from individual mechanical and electrostatic precipitator (ESP) hoppers at a 130-MW pulverized-coal utility unit burning a southeastern Kentucky moderate- to high-S Pennsylvanian Fire Clay coal. The fly ash particle size is generally similar within each row of the mechanical and ESP hoppers, with the mean particle diameter decreasing from >36 μmin the mechanical hoppers to 6 μm in the last ESP row. Rare earth element (REE)–bearing phases occur within fine minerals and, possibly, as part of the fly ash glass phase. Transmission electron microscopy was used to identify Y-Ce-Nd-La–bearing regions within a glassy matrix. Y- and …

The Relative Impact Framework For Evaluating Coal Combustion Residual Surface Impoundment Closure Options: Applications And Lessons Learned, Ari S. Lewis, Andrew B. Bittner

Coal Combustion and Gasification Products Journal Archive

In response to the U.S. Environmental Protection Agency’s new rule regarding the disposal of coal combustion residuals (CCRs), many utilities need to re-examine their waste disposal practices and make decisions regarding if and how unlined surface impoundments (SIs) should be closed. The two primary options for closing SIs are in-place closure, with capping and engineering controls, and excavation of the CCR for transport to and re-disposal in a lined landfill. To help inform closure option decisions, we supported the Electric Power Research Institute’s development of a practical, science-based decision framework that comprehensively evaluates the potential impacts to human health and …

Modeling Streamflow And Water Quality Impacts Of Grassland Establishment, Conversion, And Management In Skunk Creek Watershed, Jiyeong Hong

Electronic Theses and Dissertations

Grassland is a valuable natural resource with many environmental benefits, which include erosion control, wildlife habitat promotion, water quality protection, and flood prevention. Conversion of grassland to cultivated cropland has been linked to environmental quality concerns. The goal of this study was to model the impacts of grassland establishment, depletion, and management on hydrology and water quality in Skunk Creek watershed in eastern South Dakota. The specific objectives are to quantify the impacts of grassland conversion and selected management regimes on streamflow and water quality, and explore the optimum grassland establishment location within a watershed to achieve water quality benefits. …

Using Remote Sensing To Estimate Crop Water Use To Improve Irrigation Water Management, Arturo Reyes-Gonzalez

Electronic Theses and Dissertations

Irrigation water is scarce. Hence, accurate estimation of crop water use is necessary for proper irrigation managements and water conservation. Satellite-based remote sensing is a tool that can estimate crop water use efficiently. Several models have been developed to estimate crop water requirement or actual evapotranspiration (ETa) using remote sensing. One of them is the Mapping EvapoTranspiration at High Resolution using Internalized Calibration (METRIC) model. This model has been compared with other methods for ET estimations including weighing lysimeters, pan evaporation, Bowen Ratio Energy Balance System (BREBS), Eddy Covariance (EC), and sap flow. However, comparison of METRIC model outputs to …

Impact Of Subsurface Drainage On Water Yield For Typical Soil And Weather In Eastern South Dakota, Govinda Karki

Electronic Theses and Dissertations

Subsurface drainage in agricultural land changes the field water balance by providing an alternate pathway for subsurface water. Determining the effects of subsurface drainage on downstream hydrology requires quantifying the components of the water balance. A number of studies have looked at the hydrological impacts of subsurface drainage. However, the effects are complex and difficult to generalize. The complex interaction involves the interrelation among variables such as soil type and properties, climate (rainfall and evapotranspiration), and drainage design configuration (drainage intensity and drainage coefficient), which all are local in nature. Additionally, most studies have been conducted in humid climates, whereas …

Assessment Of Varying Model Representations In Cfd Simulations, Caitlin R. Gerdes

Electronic Theses and Dissertations

This thesis investigates the effects of varying model refinement and representation of computational fluid dynamics (CFD) simulations in two case studies. Product and process realization in engineering design requires substantial resources (time and money) in order to test novel designs for effectiveness. In recent decades, engineering has been relying more heavily on simulation-based analysis in the design process with computer models to help reduce the demands for real-life testing. The first case study analyzed in this thesis is a photobioreactor, which is used to grow microalgae for biofuel and require a balance of nutrients, light, and mixing for growth. The …