Food Processing Commons^™

Advances In Biological Activities Of Rape Bee Pollen And Its Development And Utilization, Yan Wenrui, Ji Le, Hu Yingjun, Chen Simin, Zheng Hongxing, Qi Shanshan

Food and Machinery

The research and development value of rape bee pollen, a natural health raw material, is increasing as public awareness of health issues develops. This review introduced the various nutrients and active substances contained in rape bee pollen and summarized the biological activities and pharmacological effects of rape bee pollen in antioxidant, anti-inflammatory, immune enhancement, antibacterial, prostate protection, anti-diabetic complications, anti-tumor, intestinal regulation, and ovarian protection. The application of rapeseed bee pollen in bee products, health care products, food, medicine and cosmetics was discussed. The development direction of rapeseed bee pollen was prospected.

Determination Of Abietic Acid Compounds In Poultry By Ultra Performance Liquid Chromatography-Quadrupole Time-Of-Flight Mass Spectrometry Coupled With Dispersive Solid Phase Extraction, Lin Xiaojun, Yan Wanying, He Minheng, Huang Jiale, Wu Yiqi, Ye Ling, Zhang Ruirui

Food and Machinery

Objective： An ultra performance liquid chromatography-quadrupole/time-of-flight mass spectrometry （UPLC-Q-TOF/MS） method was established for the determination of abietic acids in poultry. Methods： The samples were extracted with acetonitrile, then salted out and stratified. The supernatant was purified by C₁₈ solid phase extractant and finally determined by UPLC-Q-TOF/MS in ESI negative mode. Results： Abietic acid compounds exhibited a good linear relationship in the concentration range of 10~500 μg/L with good correlation coefficient R²>0.998. The average recoveries of three abietic acid compounds were experiments, the average recovery rate was 87.8%~98.5% with relative standard deviations （RSDs, n=6） of 1.99%~6.71%, at …

Variable Structure Intelligent Control For Mango Drying With Air Source Heat Pump, Guo Xiaoxuan, Guo Min, Han Shuai, Sun Leping

Food and Machinery

Objective: To improve the energy efficiency of mango drying in the air source heat pump system so as to save energy. Methods: The process of drying mangoes was subdivided, and a variable structure control was used to adjust the temperature and humidity of drying room intelligently and dynamically to improve energy efficiency. Each drying process stage was divided into three parts, namely far away from the conversion point, near the conversion point, and closing to the conversion point. For the first two parts, a constrained nonlinear autoregressive neural network (NARX) with external inputs was used to intelligently adjust the temperature …

Effects Of Tea Polysaccharide On The Properties Of Sodium Alginate/Starch/Tea Powder Composite Membrane, Chen Long, Chen Hui, Zhu Jing, Liu Chengyang, Wang Qing

Food and Machinery

Objective: This study aimed to develop a green and environment-friendly sodium alginate/starch/tea powder composite membrane. Methods: Tea polysaccharides with different mass fractions were added to the sodium alginate/starch/tea powder composite film to investigate the influence of tea polysaccharides on the properties of sodium alginate/starch/tea powder composite film. Therefore, full infrared barrier, color difference, water solubility, water vapor permeability, tensile strength, elongation at break, thickness, water content, free radical clearance and bacteriostasis were measured. Results: A strong interaction between tea polysaccharides and sodium alginate were found. The composite film with tea polysaccharide content of 5% exhibited the best comprehensive performance. The …

The Effects Of Pea Peptides On The Quality Of Set Yogurt, Chen Yangling, Mo Haoran, Jiao Ye, Cui Bo, Fang Yong, Chen Xiuwen, Yang Jinjie, Cheng Yunhui

Food and Machinery

Objective: This study aimed to reduce the setting time of yogurt, improve the texture of yogurt and evaluate the effect of pea peptides on the quality of coagulated yogurt. Methods: Different amounts（0, 0.50%, 0.75%, 1.00%, 1.25%, 1.50%）of pea peptides were added into milk powder to prepare pea peptide yogurt, and then the setting time, titer acidity, and texture properties of the yogurt were investigated. Results: The results showed that when the amount of pea peptides added was less than or equal to 1.25%, the yogurt setting time could be significantly shortened. When the amount of pea peptide added was 1%, …

Determination Of Mandipropamid Residues In Cucumber By Uplc-Ms, Zhang Zhouli, Li Dong, Luo Si, Luo Xingyu, Yong Ping, Yi Da

Food and Machinery

Objective： To establish a detecting method for mandipropamid residues in cucumber by UPLC-MS coupled with the positive ions mods of MRM. Methods： The cucumber samples were was extracted by ultrasonic acetonitrile and then were purified by dispersed solid phase extraction (QuEChERS). Cucumber solution diluted with ultrapure water, and filtered by 0.22 μm water phase. Then 0.1% formic acid water (A) and acetonitrile (B) were used as mobile phase for isocratic elution. Results： The results showed that a good linearity was obtained for the standard curve of the method, its correlation was high, R²=0.999 8. Its detection limit was …

Preparation Of Chitosan/Bentonite Composites By Impingement Flow-Hydraulic Cavitation And Its Application, Wang Ning, Huang Chengdu, Pang Xi, Huang Yongchun

Food and Machinery

Objective: In order to solve the problem that the preparation of chitosan/montmorillonite composites by traditional mechanical stirring was time-consuming and not conducive to scale-up production. Methods: Chitosan/montmorillonite composites were prepared by impinging stream hydrodynamic cavitation, the effects of four factors, namely chitosan dosage, chitosan molecular weight, reaction time and reaction temperature on the organic ignition loss were investigated, and then the optimum method of preparation was optimized by using the L₉（3⁴） orthogonal test. The structure of the composite was characterized by scanning electron microscopy, infrared spectroscopy, X-ray diffraction and Specific surface analyzer. Results: The optimal solution …

Modeling Analysis And Protection Study Of Vertical And Horizontal Vibrations In Hami Melon Logistics Packages, Zhang Lianwen, Xie Xiaoding, Wu Yuzhu, Zhang Chao, Gao Jia, Xu Bin

Food and Machinery

Objective: Optimized cushioning packaging. Methods: Taking Hami melon and its packaging as the research object, conducted sweep frequency vibration test on 5-layer stacked packaging, measured the natural frequency, maximum power Spectral density and peak acceleration of the vertical and horizontal vibration of each layer of packaging, and established the relational model between the maximum power spectral density, peak acceleration and stacking layer. Results: The higher the packaging, the larger the maximum power spectral density and peak acceleration in both vertical and horizontal directions. The maximum power spectral density and peak acceleration in the vertical direction of the same layer of …

Changes In Quality And Flavor Of Frozen Semi-Dried Pomfret Under Simulated Logistics And Transportation Conditions, Duan Rubi, He Yanfu, Qiu Dan, Xia Guanghua, Li Yongcheng

Food and Machinery

Objective: This study aimed to investigate the changes in quality and flavor of semi-dried gold pomfret during the thawing process of logistics transportation. Methods: The logistics transportation process of frozen semi-dried gold pomfret was simulated at different temperatures. The thawing-loss rate, changes in myofibrillar protein conformation, physical and chemical indexes of protein, lipid oxidation and changes in flavor substances were determined. Results: The protein and lipid oxidation degrees of pomfret were significantly increased with the extension of transport time (P＜0.05). The oxidation degree was (P＜0.05) more significant as the temperature increased. During this process, protein aggregation …

Analysis On Quality In Three Kinds Of Basal Tea Of Noval-Jasmine Tea Beverage, Zhang Fen, Chen Jiaxian, Yuan Dongyin, Zhang Xuhao, Wen Lixiang

Food and Machinery

Objective: This study aimed to explore the quality features of basal tea of noval-jasmine tea. Methods: Taking three kinds of basal tea（Fujian Xianghao, Yunnan Maojian, Sichuan Xiangming）of noval-jasmine tea beverage scenting tea dhool from Fujian, Yunnan and Sichuan as the research objects, the quality of the base tea including main biochemical components, taste, aroma were analyzed by electronic tongue, solid phase microextraction combined with gas chromatography-mass spectrometry (GC-MS), sensory evaluation and chemical analysis. Results: Water extracts of three kinds of basal tea was 49.40%~51.40%, tea polyphenols was 18.00%~23.20%, caffeine was 3.20%~4.30%, free amino acid was 3.32%~3.50%. The main biochemical components …

Study On The Effect Of Ultrasonic Aging Of Crude Baijiu After Second Distillation, Zhang Yingying, Chen Xuepeng, Yu Yougui, Tan Wenjun, Wu Jinlan, Dai Shan, Zheng Qing

Food and Machinery

Objective: Accelerated manmade aging of base liquor after heavy distillation. Methods: A single factor experimental design method was adopted based on the study of impurity removal in second distillation of Luzhou-flavor crude Baijiu. The changes in the content of total acids and total esters in the liquor were used as indicators to preliminarily explore the effect of ultrasonic treatment conditions on the crude Baijiu. Results: The results showed that: among the three single factors of ultrasonic treatment power, temperature and time, there were varying degrees of differences between the levels of each individual factor; At an ultrasonic frequency of 45 …

Effects Of Electrical Stimulation On Water-Soluble Flavor Compounds In Beef Semimembranosus Muscle, Chelsie Beebe

Theses and Dissertations

This study examined the effects of electrical stimulation on water-soluble flavor compounds in beef semimembranosus muscle, collected immediately after exsanguination (PRE), immediately after stimulation (POST), and 24 h postmortem (H24) from both stimulated (ES) and non-stimulated (CON) carcasses. Short-chained peptides were greater in ES at H24 (P = 0.007). Glutamic acid concentration was above its taste threshold (0.044 mmol/kg) and was less in ES at PRE and POST by 0.030 mmol/kg (P ≤ 0.028) but was similar in both ES and CON by H24 (P = 0.142). Lysine, a Strecker amino acid, was greater in ES at H24 by 0.138 …

Effects Of Wet Aging On Water-Soluble Flavor Compounds, Descriptive Flavor, Consumer Acceptability, And Willingness-To-Pay Of Beef Longissimus Lumborum Steaks, Shangshang Wang

Theses and Dissertations

This study examined the effects of wet aging on water-soluble flavor compounds, descriptive flavor, consumer acceptability, and willingness-to-pay of beef strip steaks. Twenty USDA Select boneless beef loins (NAMP #180) were dorsally divided into four equal portions, which were randomized to receive either 0, 7, 14, or 21 d of wet aging. Short-chained peptide concentration increased from 4.11 mg/g on d 0 to 5.12 mg/g on d 7 (P = 0.011) and subsequently increased to 7.14 mg/g on d 21 (P < 0.001). Cooked beef contained 1.85 mg/g less short-chained peptides than raw beef (P < 0.001). Wet aging for 21 d increased the concentrations of amino acids, which are precursors for the Maillard reaction, including methionine, threonine, cystine, serine, tryptophan, and phenylalanine (P < 0.001). Wet aging decreased the nucleotide concentrations (P ≤ 0.003) and increased hypoxanthine concentration, a compound that imparts bitter flavor (P …

Investigation Of Physicochemical Properties, Nutritional Status, And Volatile Compounds Profiling Of Four Underutilized Spices Of Cameroon Origin, Stève Djiazet, Digambar Kavitake, Ramasamy Ravi, Laurette B. Mezajoug Kenfack, Ragu Pullakhandam, Bethala L.A. Prabhavathi Devi, Clergé Tchiégang, G. Bhanuprakash Reddy, Prathapkumar Halady Shetty

Agricultural and Environmental Sciences Faculty Research

In this study, four underutilized spices (fruit and ulb of Aframomum sulcatum, fruit of Xylopia africana, and bark of Hypodaphnis zenkeri) were analyzed for their physical properties, nutrients composition, and profile of volatile compounds using standard analytical methods. The protein, fat, sugar, and dietary fiber contents were analyzed. The spices were revealed to be a good source of essential amino acids and fatty acids including pentadecanoic acid. Several minerals (Mn, Mg, Ca, Fe, and K) of nutritional importance were found at various proportions. Electronic nose analysis revealed the presence of fifty-six different compounds, belonging to ten major classes (phenylpropenes, acids, …

Analysis Of The Potential Of Rice And Corn In Supporting Food Availability, Luh Pastiniasih, Ketut Sumantra, Ni Putu Pandawani, Putu Edi Yastika

The Philippine Agricultural Scientist

A region’s agricultural sector plays a strategic role in fulfilling its food needs with ideal nutrition. The potential of cereal commodities, specifically rice and corn, was identified based on the production level and competitiveness by district in Buleleng Regency, Indonesia. The regency’s potential to provide and support food security was also determined through a quantitative descriptive analysis of the Location Quotient (LQ), Shift Share Analysis (SSA), Localization Coefficients, and Levels of Food Availability by utilizing secondary data on cereal commodity production and population numbers over the course of 10 yr (2012–2021). Results showed that Sawan, Seririt, and Sukasada districts were …

The Effects Of Sous Vide Cooking And Cysteine Proteases On Instrumental And Sensory Textural Properties Of Lower Value Cuts Of Beef, Ian Smith

All Theses

Sous vide cooking has the potential to increase the value of lower quality cuts of beef. Understanding the textural properties following a cook-chill sous vide process is crucial to maximizing this potential. The use of enzymes may further increase the value of these products if able to positively alter the texture of the final product.

The first research objective was to use instrumental texture analysis to evaluate potential relationships between enzymatic treatments and sous vide processing time of lower value cuts of beef. Three cuts were evaluated: infraspinatus (top blade), semitendinosus (eye of round), and beef tongue. Infraspinatus and semitendinosus …

Development Of An Intact Mass Spectrometry Method For The Detection And Differentiation Of Major Bovine Milk Proteins, Emily F. Harley-Dowell

Department of Food Science and Technology: Dissertations, Theses, and Student Research

The authentication of products with claims regarding protein sources or compositions is a challenge for traditional analytical methods, which generally lack the required specificity whole protein analysis can provide. For example, the establishment of milk as “A2” is achieved through genetic testing of cows before milk production, with no methods to authenticate milk products themselves. Establishment of A2 milk is completed through genetic testing of the cows before milk production, but with no methods to authenticate the milk products themselves. Intact protein mass spectrometry (MS) has the potential to directly authenticate protein products, including specific proteoform claims. The development of …

Effect Of Storage Temperatures And Home Refrigeration Systems On The Shelf Life Of Frozen Desserts, Natalie Sinclair

All Theses

The effect of storage temperature over 12 weeks was studied using dairy and non-dairy frozen desserts. Research was conducted to determine if higher freezer temperatures affect frozen dessert quality to reduce energy use associated with lower freezer temperatures. Samples were analyzed for ice crystal pore size using micrographs, grittiness by a trained sensory panel and weight loss during storage. Ice crystal size was determined using scanning electron microscopy and grittiness was measured on a 5-point ranking scale, with 1 being least gritty and 5 being most gritty. Weight loss was determined by measuring sample weights before and after the 12-week …

Nutritional-Environmental Trade-Offs In Potato Storage And Processing For A Sustainable Healthy Diet, Aubin Payne, Ebenezer M. Kwofie, Prince Agyemang, Jamie Baum

Biological and Agricultural Engineering Faculty Publications and Presentations

Over the last decade, poor diets and limited access to nutritious foods have been critical drivers of micronutrient deficiency in human health. However, food fortification at an industrialized scale in developed countries has helped eliminate deficiency-related diseases. In developing countries, fortified foods and biofortified materials have been delivered to nutrient-deficient communities. While these strategies have produced significant and acclaimed results, reports from the Food and Agricultural Organization suggest that over a quarter of the world’s population suffers from micronutrient deficiency. This implies that there are still declines in micronutrients in food products at different nodes along the food value chain …

Controlling Salmonella: Strategies For Feed, The Farm, And The Processing Plant, Tomi Obe, Timothy Boltz, Mike Kogut, Steven C. Ricke, Lasheda A. Brooks, Ken Macklin, Ashley Peterson

Poultry Science Faculty Publications and Presentations

Controlling Salmonella in poultry is an ongoing food safety measure and while significant progress has been made, there is a need to continue to evaluate different strategies that include understanding Salmonella-poultry interaction, Salmonella-microbiota interactions, Salmonella genetics and response to adverse conditions, and preharvest and postharvest parameters that enable persistence. The purpose of this symposium is to discuss different strategies to consider from feed milling to the farm to the processing environment. This Poultry Science Association symposium paper is divided into 5 different sections that covers 1) immunological aspects of Salmonella control, 2) application of Salmonella genetics for targeted …