Chemical Engineering Commons^™

Electrocoagulation: A Promising Method To Treat And Reuse Mineral Processing Wastewater With High Cod, Gaogui Jing, Shuai Ren, Yuesheng Gao, Wei Sun, Zhiyong Gao

Michigan Tech Publications, Part 1

Mineral processing wastewater contains large amounts of reagents which can lead to severe environmental problems, such as high chemical oxygen demand (COD). Inspired by the wastewater treatment in such industries as those of textiles, food, and petrochemistry, in the present work, electrocoagulation (EC) is applied for the first time to explore its feasibility in the treatment of wastewater with an initial COD of 424.29 mg/L from a Pb/Zn sulfide mineral flotation plant and its effect on water reuse. Typical parameters, such as anode materials, current density, initial pH, and additives, were characterized to evaluate the performance of the EC method. …

Radio Frequency Studies Of Soot Loading And Ammonia Storage On A Diesel Particulate Filter With A Scr Catalyst Coating, Shreyans Sethia

Dissertations, Master's Theses and Master's Reports

The radio frequency (RF) measurement technique has been shown to be a viable method for measurement of the amount of soot loaded onto DPF’s ^[1] and the amount of NH₃ stored on SCR catalysts ^[2]. In one of the configurations, a microwave resonant cavity is formed by the metal can encasing the enclosed catalyst. Two metal probes acting as antennas are placed on either side of the catalyst. Power transmitted between the antennas is monitored as the frequency of the signal is swept. At certain frequencies, resonance is achieved. Measurements of the resonance frequencies, amplitude at resonance, and …

Systems Analysis For Sustainability Assessment Of Biogas And Bio-Ch4 Production From Food Waste And Dairy Manure Mixtures In The Us, Sharath Kumar Ankathi

Dissertations, Master's Theses and Master's Reports

The purpose of the dissertation is to relate systems analysis for bioenergy to identify optimum configurations for improved scenarios and to make better decisions in a systems perspective.

Chapter 1 is a review of the literature to identify the state of the knowledge in terms of systems analysis for anaerobic digestion (AD) bioenergy systems. The key outcomes from this review showed that anaerobic digestion of mixtures of food waste and animal manure has great potential to achieve economic and environmental benefits compared to other treatments of organic waste materials, such as landfilling or conventional manure management.

Chapter 2 focuses on …

Detection And Thermal Stabilization Of Virus Based On Surface Properties, Xue Mi

Dissertations, Master's Theses and Master's Reports

Viral diseases take the lives of millions of people each year. The most effective methods to prevent viral disease outbreak are viral detection to reduce contact with viral pathogens and vaccines to prevent disease. To reduce the costs of the detection of viruses and improve vaccine formulation, we explored viral surface properties. The properties we have focused on are viral hydrophobicity and surface charge using chemical force microscopy (CFM). CFM is a single-particle technique that measures the adhesion force of a functionalized atomic force microscopy (AFM) probe, and in this study, a virus covalently bound to a surface. The non-enveloped …

Lipemia Levels Analysis From Human Blood Samples, Zainab Ibrahim Alshoug

Dissertations, Master's Theses and Master's Reports

Worldwide, an estimated 31% of people who die each year have a cardiovascular disease (CVD), an all-encompassing group of diseases and conditions of the heart or blood vasculature. Access to portable, user-friendly tools to test lipid levels accurately and efficiently, without requiring large volume blood draws, will help improve access to wellness management by reducing costs and facilitating early screening and monitoring of CVD thus improving outcomes. Point of care micro or millifluidic chips to test biofluids that are integrated into detection units are an attractive measurement tool because of their potential for ease of use by patients at home …

Innovative Sustainable Wood Preservatives From Pulp And Paper Industry Byproduct, Raisa Carmen Andeme Ela

Dissertations, Master's Theses and Master's Reports

In the modern forest industry, the need for bio-based, renewable, and environmentally-benign wood preservatives is increasing. Preservatives are used to prevent or limit decay and there has been an increasing interest in developing wood preservatives from renewable materials. To support the need for bio-based, environmentally-friendly preservatives, this work employed kraft lignin as a raw material to produce a novel bio-based wood preservative.

For the first project, a statistical design of experiments approach in Minitab® was used to study how fractionation process variables during acid precipitation of lignin influence the lignin mass yield and characteristics. After precipitating lignin from black liquor, …

Investigation Of The Stability Of Liquid And Air Films By Synchronized Tri-Wavelength Reflection Interferometry Microscope, Yuesheng Gao

Dissertations, Master's Theses and Master's Reports

Liquid films are widely involved in many processes, such as froth flotation, oil extraction, foam/bubble stabilization, etc. In the meantime, air films are commonly seen in diverse fields like dust control, ink print, coating industry, and so on. Stabilities of these liquid/air films are of great importance to improve the processes. As more and more researchers are paying increasing attention to liquid/air films, tremendous efforts have been made to explore the properties of the films. On the one hand, some theoretical models have also been well developed in recent decades. State-of-the-art technologies, such as AFM, SFA, and RICM, have also …

Continuous Viral Vaccine Manufacturing And Viral Detection Strategies, Dylan G. Turpeinen

Dissertations, Master's Theses and Master's Reports

Viruses are responsible for many human diseases that lead to suffering and death. Acquired immunodeficiency syndrome (AIDS), influenza, and coronavirus disease 2019 (COVID-19) have claimed the lives of millions of people. Two methods have been created to reduce the suffering caused by these diseases. The first is the manufacturing of vaccines that prevent disease and the second is the development of virus detection tests that lead to treatment. The work summarized in this dissertation discusses the development of a continuous virus purification process using an aqueous two-phase system for use in vaccine manufacturing. Additionally, two novel virus detection methods were …

Role Of Flocculation And Dispersion In Pelletization Of Iron Ore, Victor J. Claremboux

Dissertations, Master's Theses and Master's Reports

Traditional modeling of iron ore pellet strength utilizes micromechanical models such as Rumpf’s equation, which correlate attractive forces and pellet properties into an average expected pellet strength. These models combine with repulsive forces within pellets to predict that pellet strength decreases with the introduction of these forces. However, naïvely applying Rumpf’s equation readily leads to incorrect predictions about the resulting behavior. Pellets created with strong repulsive forces arising from dispersion conditions are observed to be significantly stronger overall than pellets formed in the absence of dispersants. A new model is required to understand and predict the effects of these additives …

Virus-Like Particle Vaccine Manufacturing From Yeast, Ananya Ananya

Dissertations, Master's Theses and Master's Reports

Influenza virus has an intrinsic nature to undergo mutations. Hence, there have been struggles to combat this disease since the time when the worst influenza pandemic first hit in 1918. Vaccines have proved to be effective in controlling the spread of the influenza A virus by providing herd immunity. However, the contemporary design of influenza A virus based on egg and cell-culture is not efficient in tackling influenza A virus transformation. Virus-like particles (VLPs) have established themselves as a potental platform for future vaccine candidates. VLPs have all the credentials to supplant contemporary vaccine designs without compromising on immunogenicity. For …

Mechanisms Of Pathogen Inactivation In Wastewater And Pharmaceutical Applications, Christa L. Meingast

Dissertations, Master's Theses and Master's Reports

Infectious diseases are a significant threat to public health. Though society enacts practices to prevent the spread of these dangerous diseases, challenges remain. Therefore, continual advancements in treatment and prevention are required. Wastewater treatment and viral clearance in pharmaceutical applications are two key health measures that prevent the spread of infections.

A low-cost, low-technology biosolids treatment process was developed to improve wastewater treatment by collecting key information on storage temperature, ammonia, volatile solids, moisture content, pH, and pathogen inactivation in biosolids over long-term storage at two wastewater treatment plants located in northern climates of the United States. Inactivation of pathogens …

Towards Efficient Water Treatment: Mechanism Of Colloidal Fouling Of Ultrafiltration Membranes, Ikenna Henry Ozofor

Dissertations, Master's Theses and Master's Reports

This research study first reviewed challenges of conventional and membrane separation systems for water treatment. Though membrane separation systems appeared superior to the conventional counterparts for water and wastewater treatment, wider applications of membrane systems have been limited by some factors, most notably is membrane fouling. Experimental studies were therefore conducted to achieve the goal of this research, which is to investigate how feed properties affect fouling of ultrafiltration (UF) membranes by colloids.

Feed salinity, pH, and nanoparticle concentration were the variables studied to unravel how different UF membranes are fouled by model silica colloids (with average diameter of 25nm). …

Virus Purification Framework And Enhancement In Aqueous Two-Phase System, Pratik Umesh Joshi

Dissertations, Master's Theses and Master's Reports

Viral infections regularly pose detrimental health risks to humans. Preventing viral infections through global immunization requires the production of large doses of vaccines. The increasing demand for vaccines, especially during pandemics such as COVID-19, has challenged current manufacturing strategy to develop advanced unit operations with high throughput capability. Over the decade, the upstream processing responsible for synthesizing viral products in cell cultures has shown significant success in yielding high titers of viruses and virus-like particles. The progress in the upstream stage has now shifted the bottleneck to the downstream processing (DSP). Overlooked for decades, the DSP responsible for viral product …

Antibacterial Properties Of Mussel-Inspired Polydopamine Coatings Prepared By A Simple Two-Step Shaking-Assisted Method, Pegah Kord Fooroshani, Elizabeth Polega, Kevin Thomson, Mohammad Saleh Akram Bhuiyan, Rattapol Pinnaratip, Mikhail Trought, Chito E. Kendrick, Yuesheng Gao, Kathryn Perrine, Lei Pan, Bruce P. Lee

Michigan Tech Publications, Part 1

A simple two-step, shaking-assisted polydopamine (PDA) coating technique was used to impart polypropylene (PP) mesh with antimicrobial properties. In this modified method, a relatively large concentration of dopamine (20 mg ml⁻¹) was first used to create a stable PDA primer layer, while the second step utilized a significantly lower concentration of dopamine (2 mg ml⁻¹) to promote the formation and deposition of large aggregates of PDA nanoparticles. Gentle shaking (70 rpm) was employed to increase the deposition of PDA nanoparticle aggregates and the formation of a thicker PDA coating with nano-scaled surface roughness (RMS = 110 …

Integration Of Pretreatment With Simultaneous Counter-Current Extraction Of Energy Sorghum For High-Titer Mixed Sugar Production, Daniel L. Williams, Rebecca Ong, John E. Mullet, David B. Hodge

Michigan Tech Publications, Part 1

Sorghum (Sorghum bicolor L. Moench) offers substantial potential as a feedstock for the production of sugar-derived biofuels and biochemical products from cell wall polysaccharides (i. e., cellulose and hemicelluloses) and water-extractable sugars (i.e., glucose, fructose, sucrose, and starch). A number of preprocessing schemes can be envisioned that involve processes such as sugar extraction, pretreatment, and densification that could be employed in decentralized, regional-scale biomass processing depots. In this work, an energy sorghum exhibiting a combination of high biomass productivity and high sugar accumulation was evaluated for its potential for integration into several potential biomass preprocessing schemes. This included counter-current …

Towards Sustainable Production Of Chemicals And Fuels From The Fast Pyrolysis Of Waste Polyolefin Plastics, Ulises Gracida Alvarez

Dissertations, Master's Theses and Master's Reports

The increasing amount of plastic waste (PW) generation has become an important concern due to the leveled-off recycling rates. Therefore, governmental agencies around the world, including state governments in the United States, have proposed initiatives to minimize the amount of PW that is landfilled and encourage recycling or energy recovery. Circular economy is a strategy that attempts on reusing PW to produce new polymers while avoiding its disposal and the use of virgin material. Chemical recycling raises an interesting technology prospect due to the potential reduction of pollutant emissions and the establishment of a circular economy through the production of …

Exploring The Role And Impact Of Microscale Phenomena On Electrode, Microdevice, And Cellular Function, Sanaz Habibi

Dissertations, Master's Theses and Master's Reports

Microfluidic technologies enable the development of portable devices to perform multiple high-resolution unit operations with small sample and reagent volumes, low fabrication cost, facile operation, and quick response times. Microfluidic platforms are expected to effectively interpret both wanted and unwanted phenomena; however, a comprehensive evaluation of the unwanted phenomena has not been appropriately investigated in the literature. This work explored an attenuative evaluation of unwanted phenomena, also called here as secondary phenomena, in a unique approach.

Upon electric field utilization within microfluidic devices, electrode miniaturization improves device sensitivity. However, electrodes in contact with medium solution can yield byproducts that can …

Enhanced Anticancer Activity Of 5'-Dfur-Pcl-Mpeg Polymeric Prodrug Micelles Encapsulating Chemotherapeutic Drugs, Alicia J. Sawdon, Jun Zhang, Xutu Wang, Ching-An Peng

Department of Chemical Engineering Publications

The compound 5’-deoxy-5-fluorouridine (5’-DFUR) is a prodrug of the anti-tumor drug 5-fluorouracil (5-FU). Thymidine phosphorylase (TP) is an enzyme that can convert 5’-DFUR to its active form 5-FU and the expression of TP is upregulated in various cancer cells. In this study, 5’-DFUR associated with amphiphilic copolymer poly(ε-caprolactone)-methoxy poly(ethylene glycol) (5’-DFUR-PCL-MPEG) was synthesized, characterized, and self-assembled into functional polymeric micelles. To demonstrate that the prodrug 5’-DFUR could convert into cytotoxic 5-fluorouracil (5-FU) by endogenous TP, HT-29 colorectal cancer cells were treated with 5’-DFUR-PCL-MPEG polymeric micelles for various time periods. Chemotherapeutic drugs doxorubicin (DOX) and 7-ethyl-10-hydroxycamptothecin (SN-38) were also encapsulated separately …

Reverse Flotation Separation Of Fluorite From Calcite: A Novel Reagent Scheme, Jianjun Wang, Zihan Zhou, Yuesheng Gao, Wei Sun, Yuehua Hu, Zhiyong Gao

Michigan Tech Publications, Part 1

Fluorite (CaF₂), as an important strategic mineral source, is usually separated from calcite by the common froth flotation method, but this separation is still not selective enough. The development of a selective collector and/or depressant is the key to achieving high selective separation. 1-Hydroxyethylidene-1,1-diphosphonic acid (HEDP or H₄L) is widely used as an environmentally friendly water treatment reagent due to its low cost and excellent anti-scaling performance in an aqueous solution. In this study, a novel reagent scheme was developed using HEDP as a fluorite depressant and sodium oleate (NaOL) as a calcite collector for the …

Diverse Lignocellulosic Feedstocks Can Achieve High Field‐Scale Ethanol Yields While Providing Flexibility For The Biorefinery And Landscape‐Level Environmental Benefits, Yaoping Zhang, Lawrence G. Oates, Jose Serate, Dan Xie, Edward Pohlman, Yury Bukhman, Rebecca Garlock Ong, Et Al.

Department of Chemical Engineering Publications

Increasing the diversity of lignocellulosic feedstocks accepted by a regional biorefinery has the potential to improve the environmental footprint of the facility; harvest,storage, and transportation logistics; and biorefinery economics. However, feedstocks can vary widely in terms of their biomass yields and quality characteristics (chemical composition, moisture content, etc.). To investigate how the diversity of potential biofuel cropping systems and feedstock supply might affect process and field‐scale ethanol yields, we processed and experimentally quantified ethanol production from five different herbaceous feedstocks: two annuals (corn stover and energy sorghum) and three perennials (switchgrass, miscanthus, and mixed prairie). The feedstocks werepretreated using ammonia …

Methods And Systems For Identifying A Particle Using Dielectrophoresis, Adrienne Minerick, Jeana Collins, Kaela M. Leonard, Tayloria N.G. Adams

Michigan Tech Patents

A system for identifying a particle. The system includes a microfluidic device; a microelectrode array including a plurality of electrodes, the microelectrode array disposed within the microfluidic device; a plurality of particles suspended in a solution and delivered to the microelectrode array using the microfluidic device; a signal generator operatively coupled to the microelectrode array; a particle detector adjacent to the microelectrode array; and a controller in operative communication with the signal generator and the particle detector. The controller is configured to apply an oscillating voltage signal to the microelectrode array between a low frequency and a high frequency at …

Selective Flocculation Separation Of Fine Hematite From Quartz Using A Novel Grafted Copolymer Flocculant, Jinxia Zhang, Weiguang Sun, Zhiyong Gao, Fusheng Niu, Long Wang, Yawei Zhao, Yuesheng Gao

Michigan Tech Publications, Part 1

Beneficiation of ultrafine mineral particles (typically with an average size less than 20 µm) remains a critical problem for the mineral processing industry. Selective flocculation technique has been found to show great potential to tackle this problem, whose success mainly depends on the selective adsorption of a flocculant on the target mineral particles. In this work, a novel copolymer flocculant was synthesized by grafting starch and acrylamide, which for the first time, was employed in the flocculation separation of fine hematite from quartz. The composites of the grafted copolymer flocculant (GCF) were characterized by Fourier transform infrared spectroscopy (FTIR) and …

2017-2018 Che Newsletter, Department Of Chemical Engineering, Michigan Technological University

Department of Chemical Engineering Newsletters

Table of Contents

• Department
• Convocation
• Student News
• Faculty
• Alumni & Friends

Investigation On The Potential Of A Co2 Capture System, Downstream Of The Aftertreatment System For A Heavy-Duty Engine Application, Murchana Pathak

Dissertations, Master's Theses and Master's Reports

The transportation sector accounts for the second largest source of CO₂ emissions after power generation. New Corporate Average Fuel Economy (CAFE) regulations are focusing on improving energy through reduced fuel consumption and greenhouse gas emissions. This work investigates the potential of a CO₂ capture system downstream of an aftertreatment system for a heavy-duty engine application. Amine absorption has been described as one of the most effective ways to capture CO₂ from the exhaust for point sources. Therefore, using thermal-swing absorption process with potassium carbonate (K₂CO₃) as the absorbent liquid, a process was analyzed …

Effects Of Co-Product Uses On Environmental And Economic Sustainability Of Hydrocarbon Biofuel From One- And Two-Step Pyrolysis Of Poplar, Daniel G. Kulas

Dissertations, Master's Theses and Master's Reports

This study investigated the environmental and economic sustainability of liquid hydrocarbon biofuel production via fast pyrolysis of poplar biomass through two pathways: a one-step pathway that converted poplar via fast pyrolysis only, and a twostep pathway that includes a torrefaction step prior to fast pyrolysis. Optimization of these fast pyrolysis-based biofuel processes were investigated through heat integration and alternative uses of the co-product biochar, which can be sold as an energy source to displace coal, soil amendment or processed into activated carbon. The impacts of optimization on the cost of hydrocarbon biofuel production as well as the environmental impacts were …

Molecular Biogeochemistry Of A Poor Fen, Zhimin Song

Dissertations, Master's Theses and Master's Reports

Variations in climate may rapidly change the carbon balance of peatlands and increase greenhouse gas emissions through accelerated decomposition of peat and dissolved organic matter (DOM). In this study, porewater samples were collected monthly from May to October in 2017 to study the effects of plant functional groups (PFGs) on DOM, dissolved inorganic and organic nitrogen through the season in a poor fen with replicate plots dominated by different PFGs in Nestoria, Michigan, USA (46.34˚N 88.16˚W). The composition of the peat porewater showed strong statistical significance with plot type and season.The observed PFG and season impact on the composition of …

Reverse Insulator Dielectrophoresis: Utilizing Droplet Microenvironments For Discerning Molecular Expressions On Cell Surfaces, Jeana Collins

Dissertations, Master's Theses and Master's Reports

Lab-on-a-chip (LOC) technologies enable the development of portable analysis devices that use small sample and reagent volumes, allow for multiple unit operations, and couple with detectors to achieve high resolution and sensitivity, while having small footprints, low cost, short analysis times, and portability. Droplet microfluidics is a subset of LOCs with the unique benefit of enabling parallel analysis since each droplet can be utilized as an isolated microenvironment. This work explored adaptation of droplet microfluidics into a unique, previously unexplored application where the water/oil interface was harnessed to bend electric field lines within individual droplets for insulator dielectrophoretic (iDEP) characterizations. …

Investigation Of Mechanical, Electrical, And Thermal Properties Of Particulate/Fiber/Polymer Composites, Julie Tomasi

Dissertations, Master's Theses and Master's Reports

Composites have many applications due to their high strength to weight ratio, chemical resistance, and the ability to tune properties like electrical resistivity (ER). In this work, polyetheretherketone (PEEK) and cycloaliphatic epoxy (CE) composites with different fillers were studied. PEEK composites contained up to 10 wt% Akzo Nobel Ketjenblack carbon black (CB), up to 15 wt% Asbury Carbons TC307 graphene nanoplatelets (GNP), up to 30 wt% Solvay carbon fiber (CF), and combinations of the three carbons. Formulations were developed for electrostatic dissipative and electrically conductive applications. The most conductive formulation was 7.5 wt% CB/30 wt% CF/PEEK, which had an electrical …

Identification Of Developmental Stage And Anatomical Fraction Contributions To Cell Wall Recalcitrance In Switchgrass, Jacob D. Crowe, Nicholas Feringa, Sivakumar Pattathil, Brian Merritt, Cliff Foster, Dayna Dines, Rebecca Ong, David B. Hodge

Department of Chemical Engineering Publications

Background

Heterogeneity within herbaceous biomass can present important challenges for processing feedstocks to cellulosic biofuels. Alterations to cell wall composition and organization during plant growth represent major contributions to heterogeneity within a single species or cultivar. To address this challenge, the focus of this study was to characterize the relationship between composition and properties of the plant cell wall and cell wall response to deconstruction by NaOH pretreatment and enzymatic hydrolysis for anatomical fractions (stem internodes, leaf sheaths, and leaf blades) within switchgrass at various tissue maturities as assessed by differing internode.

Results

Substantial differences in both cell wall composition …

Heat Transfer Analysis In A Paddle Reactor For Biomass Fast Pyrolyis, Ankith Ullal

Dissertations, Master's Theses and Master's Reports

Heat transfer analysis was performed on a novel auger reactor for biomass fast pyrolysis. As part of this analysis, correlations for specific heat capacity and heat transfer coefficients for biomass (sawdust) and sand (used as heat transfer medium) were developed. For sand, the heat transfer coefficient followed a power law distribution with reactor fill level and temperature. For raw biomass, the heat transfer coefficient also showed similar dependence on fill level, but was independent of temperature up to 300°C. These correlations were used in a one dimensional heat transfer model developed to calculate the heating time and heating rate of …