Chemical Engineering Commons^™

Identifying, Monitoring, Quantifying And Converting Algae To Bio-Fuels In Bio-Reactors, Alice C. Jernigan

Graduate Theses and Dissertations

Growing algae as a source for bio-fuels has become an area of interest due to concerns about global warming and the reliability and ecology of the production of fossil fuels. Dried algae harvested from a pilot water quality improvement technology at the Rockaway Wastewater Treatment Facility in New York were examined as a source of carbohydrates and lipids for the production of bio-fuels in bio-reactors. The length of storage time, storage conditions, sugar and lipid extraction processes, and fuel production were studied. The results show that if the algae is stored dry (0.015 g/g algae even after a year in …

Comparing Virus Ultrafiltration Of Bacteriophages With Filtration Of Minute Virus Of Mice, Kent Smith

Graduate Theses and Dissertations

Industrial production of protein therapeutics demand rigorous testing and clearance of viruses. The U.S. Food and Drug Administration dictate the purity of pharmaceuticals with regards to viral contamination. As this testing is time consuming and expensive using mammalian cells and viruses, bacteriophages may provide a faster and cheaper alternative for membrane filtration processes. We used ultrafiltration membranes to filter protein solutions with viruses. Two bacteriophages were tested against membranes with two different pore sizes. These membranes were then tested by inverting the membrane's orientation. Flux measurements and log virus removal data were taken. Flux and log virus removal were seen …

Fabrication And Analysis Of Soy Flour Filled Polyethylene Fibers, Ozgun Ozdemir, Sam Lukubira, Amod Ogale, Paul Dawson

Graduate Research and Discovery Symposium (GRADS)

Fibers composed of soy flour (soy) and linear low density polyethylene (PE) were produced by melt spinning method. The mixing time of soy flour and PE was adjusted to get better dispersion of soy flour inside the matrix. The inclusion of soy decreased tensile modulus by 35% and tensile strength by 30% of the fibers compared with 950 MPa and 43 MPa, respectively, for PE fibers. Strain to failure for soy-PE fibers was 292% where PE fibers have strain to failure at 513%. Tensile properties of soy-PE fibers are comparable to those of pure PE. Even washing did not deteriorated …

In-Package Nonthermal Plasma Degradation Of Pesticides On Fresh Produce, N. Misra, Shashi Pankaj, Tony Walsh, Finbarr O'Regan, Paula Bourke, Patrick J. Cullen

Articles

In-package nonthermal plasma (NTP) technology is a novel technology for the decontamination of foods and biological materials. This study presents the first report on the potential of the technology for the degradation of pesticide residues. A cocktail of pesticides, namely Azoxystrobin, Cyprodinil, Fludioxonil and Pyriproxyfen was tested on strawberries. The concentrations of these pesticides were monitored in priori and post- plasma treatment using GC-MS/MS. An applied voltage and time dependent degradation of the pesticides was observed for treatment voltages of 60, 70 and 80 kV and treatment durations ranging from 1 to 5 min, followed by 24 h in-pack storage. …

Design Of Functional Dendrimer Nanocarriers And Their Formulations In Propellant-Based Inhalers For Pulmonary Drug Delivery, Lin Yang

Wayne State University Dissertations

This Dissertation focuses on addressing two of the major challenges in developing pressurized metered dose inhalers for pulmonary drug / gene delivery to and through the lungs. First challenge is to design biocompatible moieties for the steric stabilization of suspension formulations in HFO-based propellants. Using a combination of tools including ab initio calculation, molecular dynamics simulation and high pressure tensiometry, potential fluorocarbon-philic moieties were systematically screened. Surfactants with those chemistries as tail fragments were studied at the HFO|H2O interface for their ability to lower the interfacial tension at HFO|H2O interface. Selected surfactants were further optimized for surfactant balance by altering …

Effects Of Sodium Hydroxide Pretreatment On Structural Components Of Biomass, Alicia A. Modenbach, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

Pretreatment is a unit operation in the conversion of biomass to valuable products that utilizes various combinations of conditions, including chemicals, heat, pressure, and time, to reduce the recalcitrance of lignocellulose. Many such pretreatments have been developed over the years, as the operating conditions can be adapted so that lignocellulose is modified in ways unique to each pretreatment. By tailoring pretreatment conditions to achieve these modifications, the types of final products produced can be controlled. The purpose of this review is to provide a consolidated source of information for sodium hydroxide effects on lignocellulose. The structural characteristics of lignocellulose and …

Ultrasound Assisted Hydration Of Navy Beans (Phaseolus Vulgaris), N. Misra

Articles

The use of ultrasound to enhance the transport phenomena in food processes has been well recognised in recent times. The objective of this study was to evaluate the effect of sonication on hydration rate and pasting profile of navy beans. The hydration kinetics for control and ultrasound assisted soaking was mathematically described using mechanistic (Fickian diffusion) and empirical (Peleg’s equation, Weibull model and First Order equation) models. Ultrasound enhanced the rate of hydration which was evident from the plot of kinetic data and model parameters. The effective diffusivities for water transport without and with ultrasound application were estimated to be …

Virus Purification, Detection And Removal, Khrupa Saagar Vijayaragavan

Dissertations, Master's Theses and Master's Reports - Open

The biopharmaceutical industry has a growing demand and an increasing need to improve the current virus purification technologies, especially as more and more vaccines are produced from cell-culture derived virus particles. Downstream purification strategies can be expensive and account for 70% of the overall manufacturing costs. The economic pressure and purification processes can be particularly challenging when the virus to be purified is small, as in our model virus, porcine parvovirus (PPV). Our efforts are focused on designing an easy, economical, scalable and efficient system for virus purification, and we focused on aqueous two-phase systems. Industry acceptable standards for virus …

Enzyme Optimization For Lignocellulose Hydrolysis Using Mechanistic Modeling, Adam S. Marlowe

Dissertations, Master's Theses and Master's Reports - Open

A novel mechanistic model for the saccharification of cellulose and hemicellulose is utilized to predict the products of hydrolysis over a range of enzyme loadings and times. The mechanistic model considers the morphology of the substrate and the kinetics of enzymes to optimize enzyme concentrations for the enzymatic hydrolysis of cellulose and hemicellulose simultaneously. Substrates are modeled based on their fraction of accessible sites, glucan content, xylan content, and degree of polymerizations. This enzyme optimization model takes into account the kinetics of six core enzymes for lignocellulose hydrolysis: endoglucanase I (EG1), cellobiohydrolase I (CBH1), cellobiohydrolase II (CBH2), and endo-xylanase (EX) …

Nanometer-Scale Membrane Electrode Systems For Active Protein Separation, Enzyme Immobilization And Cellular Electroporation, Zhiqiang Chen

Theses and Dissertations--Chemical and Materials Engineering

Automated and continuous processes are the future trends in downstream protein purification. A functionalized nanometer-scale membrane electrode system, mimicking the function of cell wall transporters, can selectively capture genetically modified proteins and subsequently pump them through the system under programmed voltage pulses. Numerical study of the two-step pulse pumping cycles coupled with experimental His-GFP releasing study reveals the optimal 14s/1s pumping/repel pulse pumping condition at 10 mM bulk imidazole concentration in the permeate side. A separation factor for GFP: BSA of 9.7 was achieved with observed GFP electrophoretic mobility of 3.1×10^-6 cm² s^-1 V^-1 at 10 …

Information In Biological Systems And The Fluctuation Theorem, Yaşar Demirel

Department of Chemical and Biomolecular Engineering: Faculty Publications

Some critical trends in information theory, its role in living systems and utilization in fluctuation theory are discussed. The mutual information of thermodynamic coupling is incorporated into the generalized fluctuation theorem by using information theory and nonequilibrium thermodynamics. Thermodynamically coupled dissipative structures in living systems are capable of degrading more energy, and processing complex information through developmental and environmental constraints. The generalized fluctuation theorem can quantify the hysteresis observed in the amount of the irreversible work in nonequilibrium regimes in the presence of information and thermodynamic coupling.

Non-Mass Transfer Limited Crystal Growth, Ryan J. Smyth, Caitlin Schram, Stephen P. Beaudoin

The Summer Undergraduate Research Fellowship (SURF) Symposium

There are many different active pharmaceutical ingredients (APIs) that have been discovered in research labs all around the world that can be used to treat and cure patients with a variety of different ailments. The challenge with these APIs in treatments is that they are not soluble in water, thus they low absorption into the blood stream (bio-availability). The key to making these APIs more bio-available is to understand how they grow as crystals and drop out of the aqueous solutions. One of the ways these APIs were made more bio-available is to render them amorphous and suspend them in …

An Analysis Of The Impact Of Storage Temperature, Moisture Content & Duration Upon The Chemical Components & Bioprocessing Of Lignocellulosic Biomass, Arun Athmanathan

Open Access Dissertations

The successful utilization of lignocellulosic biomass as a feedstock for fuels and chemicals necessitates storage for 2-6 months. It is correspondingly important to understand the impact of storage parameters - moisture concentration, temperature and duration - on biomass quality.

As aerobic storage is the most viable large-scale solution, aerobic storage experiments were carried out with three projected bioenergy feedstocks - sweet sorghum (Sorghum bicolor) bagasse, corn (Zea mays) stover and switchgrass (Panicum virgatum). Stored samples of each were examined for dry matter loss and composition change to develop a material balance around carbohydrates and lignin.

A mean dry matter loss …

Algae To Propellants: Biosynthesis Of 1,2-Propanediol From Algal Derived Sugars, Lauren Rachelle Merriman

Graduate Theses and Dissertations

Propylene glycol dinitrate (PGDN) is an important component used in the formulation of energetic materials. A renewable, environmentally-friendly and effective production technique for the production of 1,2-propanediol, an important precursor to PGDN, is desired. While fermentation of 1,2-propanediol has been achieved, it suffers from major limitations such as expensive feed sugars and relatively low yields. It is hypothesized that algae sugars could serve as a feedstock for the microbial synthesis of 1,2-propanediol, thereby reducing production costs and enhancing sustainability.

Algal biomass produced from an Algal Turf Scrubber® has proven to have significant potential as a source of fermentable materials. However, …

Kinetics Of Tomato Peroxidase Inactivation By Atmospheric Pressure Cold Plasma Based On Dielectric Barrier Discharge, Patrick J. Cullen, Shashi Pankaj, N. Misra

Articles

Atmospheric pressure cold plasma technology is an emerging nonthermal food technology for microbiological decontamination of food and bio-materials. This study demonstrates the applicability of in-package cold plasma technology as a novel means to inactivation of enzymes. The kinetics of inactivation of tomato peroxidase as a model enzyme was studied at 30, 40 and 50kV, for up to 5’ of atmospheric air dielectric barrier discharge plasma treatments. The enzyme activity was found to decrease with both treatment time and voltage, the former variable exhibiting a more pronounced effect. Kinetic models viz. first-order, Weibull and logistic models were fitted to the experimentally …

Bio-Separation Process Improvement Via Genomic Manipulation: Development Of Novel Strains For Use In Immobilized Metal Affinity Chromatography (Imac), Ryan Curtis Haley

Graduate Theses and Dissertations

The dissertation is comprised of three parts. Part I describes proteomic analysis of native bacterial proteins from Escherichia coli (E.coli) that bind during Immobilized Metal Affinity Chromatography (IMAC). Part II describes the value in exploiting proteome based data as a tool toward the design an E. coli expression strain that is particularly useful when Immobilized Metal Affinity Chromatography is employed as the initial capture step of a homologous protein purification process. Part III describes a methodology of chromosomal mapping of all contaminant gene products.

The objective of Part I was to identify all E. coli proteins that bind to Co(II), …

Expression, Production, And Purification Of Novel Therapeutic Proteins, Mckinzie Shea Fruchtl

Graduate Theses and Dissertations

Interest in the production of recombinant proteins consisting of collagen binding domain (CBD) fused to a bioactive material has increased due to the targeting/attachment capabilities of CBD. For example, CBD fusions can be applied to the reversing of bone density loss and the repair of the eardrum, specifically, by choosing an appropriate fusion partner (parathyroid hormone or epidermal growth factor). The production of CBD fusions was examined using batch and fed-batch culturing of Escherichia coli to express the fusion proteins, and affinity chromatography to isolate the final product.

Different medium formulations, feeding strategies, and induction methods were tested in order …

Multiscale Modeling Of Enzyme-Catalyzed Methanol Production By Particulate Methane Monooxygenase, Katherine K. Bearden

Doctoral Dissertations

In this work, the conversion of methane to methanol by the particulate Methane Monooxygenase (pMMO) enzyme is investigated using a multi-scale modeling approach. This enzyme participates in carbon cycling and aids in the removal of harmful atmospheric methane, converting it to methanol. The interaction between pMMO and a neighboring enzyme that is present in the same organism is studied, and the unknown pMMO active site is elucidated and tested for methane oxidation towards the production of methanol.

Fundamental knowledge of pMMO's mechanism is not fully understood. Understanding how this enzyme works in nature will provide information towards designing efficient synthetic …

How Atomic Level Interactions Drive Membrane Fusion: Insights From Molecular Dynamics Simulations, Navendu Bhatnagar

Wayne State University Dissertations

This project is focused on identifying the role of key players in the membrane fusion process at the atomic level with the use of molecular dynamics simulations. Membrane fusion of apposed bilayers is one of the most fundamental and frequently occurring biological phenomena in living organisms. It is an essential step in several cellular processes such as neuronal exocytosis, sperm fusion with oocytes and intracellular fusion of organelles to name a few. Membrane fusion is a frequent process in a living organism but is still not fully understood at the atomic level in terms of the role of various factors …

Polymeric Nanocarriers And Their Oral Inhalation Formulations For The Regional Delivery Of Nucleic Acids To The Lungs, Denise Santos Conti

Wayne State University Dissertations

Gene therapy has attracted attention in the fields of medicine, pharmacy, and bionanotechnology due to the potential for treating a large number of medically relevant diseases. Oral inhalation (OI) is a promising route for the administration of therapeutics, including small molecules and biomacromolecules, such as nucleotides, peptides, and proteins, to (locally) and through (systemically) the lungs. The use of OI is especially attractive for the delivery of nucleic acids as it provides a direct and non-invasive route for targeting the lungs. Pressurized metered-dose inhalers (pMDIs), are the most commonly used OI in treatment of lung diseases and are thus promising …

Modeling Of Biorefinery Supply Chain Economic Performance With Discrete Event Simulation, Joseph S. Amundson

Theses and Dissertations--Manufacturing Systems Engineering

As competition for fossil fuels accelerates, alternative sources of chemicals, fuels, and energy production become more appealing to researchers and the layman. Among the candidates to fill this growing niche is lignocellulosic biomass. Many researchers have examined supply chain design and optimization for biofuel and bioenergy production throughout the years. However, these models often fail to capture the variability and uncertainty inherent to the biomass supply chain. Multiple factors with high degrees of stochasticity can have major impacts on the performance of a biorefinery: weather, biomass quality, feedstock availability, and market demand for products are just a few. To begin …

Engineering Novel Terpene Production Platforms In The Yeast Saccharomyces Cerevisiae, Xun Zhuang

Theses and Dissertations--Plant and Soil Sciences

The chemical diversity and biological activities of terpene and terpenoids have served in the development of new flavors, fragrances, medicines and pesticides. While terpenes are made predominantly by plants and microbes in small amounts and as components of complex mixtures, chemical synthesis of terpenes remains technically challenging, costly and inefficient. In this dissertation, methods to create new yeast lines possessing a dispensable mevalonate biosynthetic pathway wherein carbon flux can be diverted to build any chemical class of terpene product are described. The ability of this line to generate diterpenes was next investigated. Using a 5.5 L fed bath fermentation system, …

Synthesis Of 4-Azidocoumarins And Their Use In Copper-Catalyzed Azide-Alkyne Cycloaddition Reactions, Anthony J. Netsuri

Dissertations and Theses

Triazole-containing compounds have shown great biological activity ranging from antiviral, antibacterial, to anticancer, to name a few. Coumarin derivatives have also shown interesting biological activities. The combination of these bioactive compounds appears to have great promise for new and future medicines. In this work, various 4-azido-coumarins were synthesized via the transformation of the 4-hydroxy derivatives to 4-benzotriazolyloxy coumarins by reaction with the peptide coupling agent (benzotriazol-1-yloxy)tris-(dimethylamino)phosphonium hexafluorophosphate (BOP), and 1,8-diazabicycloundec-7-ene (DBU) as the base, in tetrahydrofuran (THF) solvent. The 4-benzotriazolyloxy coumarins were converted to the 4-azidocoumarins by reaction with sodium azide (NaN3), and the overall process was simplified to a …

Computational Prediction Of The Sporulation Network In Clostridium Thermocellum, Changyi Jiang

Dissertations, Master's Theses and Master's Reports - Open

Sporulation is a process in which some bacteria divide asymmetrically to form tough protective endospores, which help them to survive in a hazardous environment for a quite long time. The factors which can trigger this process are diverse. Heat, radiation, chemicals and lacking of nutrition can all lead to the formation of endospores. This phenomenon will lead to low productivity during industrial production. However, the sporulation mechanism in a spore-forming bacterium, Clostridium theromcellum, is still unclear. Therefore, if a regulation network of sporulation can be built, we may figure out ways to inhibit this process. In this study, a …

Ultrasound For Improved Crystallisation In Food Processing, N. Misra, Navneet Deora, Brijesh Tiwari, Patrick J. Cullen

Articles

Within the food industry, controlling crystallisation is a key factor governing food structure, texture and consumer appeal, with some foods requiring the promotion of crystallisation in a controlled manner (e.g. chocolate) and others a check (e.g. in honey). Sonocrystallisation is the application of ultrasound energy to control the nucleation of a crystallisation process. The use of power ultrasound provides a non-invasive approach to producing crystals with desired properties. Sonocrystallisation facilitates process control, primarily by modulating crystal size distribution and morphology. This paper details the governing mechanisms of sonocrystallisation. Proven and potential applications of the process in foods, including chocolates, honey, …

Novel Copper (Ii) Mediated Transfection Nano-Systems And Biological Properties Of Pyridinium Surfactants, Sarit Pal

Open Access Theses & Dissertations

Efficacy of gene therapy is relied upon the improvement of gene delivery vectors into mammalian cells. Although viral-based polynucleotide carriers are still considered as the most common method for gene delivery but the cost effectiveness, nonspecific lethal immune response has evoked the renaissance of non-viral synthetic delivery systems. An initial discovery by Felgnar et al showed Cationic Liposomes (CLs) (having an overall positive charge) when mixed with DNA to form CL-DNA complexes can enhance the transfer of polynucleotides into cells followed by its expression. Presently, a flurry of experimental works is taking place for the better understanding of structural characterization …

Capillary And Microchip Electrophoresis For The Monitoring Of Disease Causing Amyloid Proteins, Elizabeth Nancy Pryor

Graduate Theses and Dissertations

The detection of oligomers and aggregates formed by two amyloid proteins, insulin and amyloid-beta (AB), is of particular importance due to the role which these species play in Diabetes and Alzheimer's disease, respectively. However, existing techniques are limited in the ability to detect insulin and AB; oligomers due to the fact that these early aggregates are transient, present at low concentrations, and difficult to isolate. Improvements must be made to existing techniques or alternative techniques must be explored in order to identify and quantify the size of these oligomeric and aggregate species without disrupting their structure.

Capillary and microchip electrophoresis …

Inactivation Of Bacterial Opportunistic Skin Pathogens By Nonthermal Dc-Operated Afterglow Atmospheric Plasma, L. C. Heller, C. M. Edelblute, A. M. Mattson, X. Hao, J. F. Kolb

Bioelectrics Publications

AIMS: Multidrug-resistant opportunistic pathogens are clinically significant and require the development of new antimicrobial methods. In this study, Acinetobacter baumannii, Pseudomonas aeruginosa and Staphylococcus aureus cells were exposed to atmospheric plasma on agar plates and in vitro on porcine skin for the purpose of testing bacterial inactivation.

METHODS AND RESULTS: Microbial inactivation at varying exposure durations was tested using a nonthermal plasma jet generated with a DC voltage from ambient air. The observed reduction in colony forming units was quantified as log₁₀ reductions.

CONCLUSIONS: Direct plasma exposure significantly inactivated seeded bacterial cells by approx. 6 log_{10 …}

Rat Brain Pro-Oxidant Effects Of Peripherally Administered 5 Nm Ceria 30 Days After Exposure, Sarita S. Hardas, Rukhsana Sultana, Govind Warrier, Mo Dan, Rebecca L. Florence, Peng Wu, Eric A. Grulke, Michael T. Tseng, Jason M. Unrine, Uschi M. Graham, Robert A. Yokel, D. Allan Butterfield

Chemistry Faculty Publications

The objective of this study was to determine the residual pro-or anti-oxidant effects in rat brain 30 days after systemic administration of a 5 nm citrate-stabilized ceria dispersion. A ∼4% aqueous ceria dispersion was iv-infused (0 or 85 mg/kg) into rats which were terminated 30 days later. Ceria concentration, localization, and chemical speciation in the brain was assessed by inductively coupled plasma mass spectrometry (ICP-MS), light and electron microscopy (EM), and electron energy loss spectroscopy (EELS), respectively. Pro- or anti-oxidant effects were evaluated by measuring levels of protein carbonyls (PC), 3-nitrotyrosine (3NT), and protein-bound-4-hydroxy-2-trans-nonenal (HNE) in the hippocampus, cortex, and …

Peptoid Based Slide Coatings For Disease Detection Via Elisa Microarray Analysis, Melissa Lea Hebert

Graduate Theses and Dissertations

Poly-N-substituted glycines (peptoids) are a very versatile family of synthetic molecules that can be customized for any number of applications. In this study, we chose to use peptoids as a foundation for sandwich ELISA microarray analysis with a long term goal of creating an early detection device for complex diseases such as cancer. The peptoids were designed to self-assemble into microspheres to be used in coatings on the surface of the microarray substrates to increase the surface area available for antibody attachment. This increased antibody density would lead to an increase in the microarray analysis sensitivity and dynamic range. Studies …