Mechanical Engineering Commons^™

Phased Retrofits In Existing Homes In Florida Phase Ii: Shallow Plus Retrofits [Revised], Florida Solar Energy Center, Karen Sutherland

FSEC Energy Research Center®

The U.S. Department of Energy Building America team Partnership for Improved Residential Construction is collaborating with Florida Power & Light Company (FPL) to conduct a phased residential energy-efficiency retrofit program. This research seeks to determine the impacts on annual energy reductions from the installation of advanced residential technologies. Earlier project work involving the application of two levels of retrofit, shallow and deep, found average savings of 9% and 38%, respectively. Whole-house demand reduction among the deep retrofit homes averaged 39% during FPL's peak summer hour. These savings levels approach the Building America program goals of reducing whole-house energy use of …

Energy-Efficient Management Of Mechanical Ventilation And Relative Humidity In Hot-Humid Climates, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

The U.S. Department of Energy's Building America research team Building America Partnership for Improved Residential Construction conducted this research project to gain data and insight into these issues. The project focused on energy-efficient management of mechanical ventilation and RH during the cooling season. It consisted of eight test configurations. A particular focus evaluated how well a ductless seasonal energy-efficiency ratio (SEER) 21.5 mini-split heat pump (MSHP) could perform as the primary cooling system without a dehumidifier for supplemental dehumidification in a continuously mechanically ventilated house.

Ev Workplace Charging Energy Use And Cost Case Study, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

Efforts to increase the availability of plug-in electric vehicle (PEV) charging stations have focused on expanding public charging stations, promoting charging at the workplace and using charging stations as a shopping incentive for retail stores. This report examines the costs and energy uses to provide the charging service. Rapidly charging a PEV requires expensive electric equipment and can lead to high operating costs due to electrical demand charges. This project presents results from a detailed case study for 5 PEV chargers where the charger electricity costs are a part of a facilities electric bill. Also presented are options for minimizing …

Evaluation Of The Impact Of Slab Foundation Heat Transfer On Heating And Cooling In Florida, Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

The U.S. Department of Energy's Building America Partnership for Improved Residential Construction (BA-PIRC) performed experiments in the Florida Solar Energy Center's Flexible Residential Test Facility intended to assess for the first time (1) how slab-on-grade construction influences interior cooling in a cooling-dominated climate and (2) how the difference in a carpeted versus uncarpeted building might influence heating and cooling energy use.

Final Report: Cooling Seasonal Energy And Peak Demand Impacts Of Improved Duct Insulation On Fixed-Capacity (Seer 13) And Variable-Capacity (Seer 22) Heat Pumps, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

Previous phase 1, 2, and 3 research identified that duct conductive losses to an attic environment imposed greater relative energy losses for the variable-capacity systems compared to the fixed-capacity systems (Cummings and Withers 2011) because of the longer dwell time of conditioned air in the ducts. The purpose of the Phase 4 experiments reported here was to see if duct R-value enhancement would benefit the overall operating efficiency of the variable-capacity system relatively more than the fixed-capacity system. The current Phase 4 experiments (the primary focus of this report) found that this was a secondary effect.

Flexible Residential Test Facility: Impact Of Infiltration And Ventilation On Measured Cooling Season Energy And Moisture Levels (2016), Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

Originally published in January 2014, this revision of the report clarifies and corrects references to Standard 62.2 as the 2013 version (62.2-2013), and it corrects the total CFM requirement for the subject buildings under the standard. Further, two plots have been updated to distinguish between the mechanical CFM and the total CFM required for the subject buildings under Standard 62.2-2013.

Minimum Conditions For Visible Mold Growth, G. A. Tsongas, Frank Riordan

Mechanical and Materials Engineering Faculty Publications and Presentations

Considerable confusion and misunderstanding exists over the conditions required for visible mold growth at a surface in buildings. That is evident in papers and articles authored by engineers and other scientists, including various ASHRAE, ASTM and Canada Mortgage Housing Corporation publications. One of the major problems is that many HVAC engineers, building scientists, practitioners and others believe there exists a single critical value of the relative humidity (RH) of the indoor or ambient air well away from surfaces, below which mold will not grow on surfaces. However, that is not the case. The purpose of this article is to clarify …

Florida Rural Small Business Energy Assistance Collaborative Cumulative Report Ending July 31, 2016, Florida Solar Energy Center, Janet Mcilvaine

FSEC Energy Research Center®

The U.S. Department of Agriculture's (USDA) Rural Development initiative reaches out to communities across America with many programs (http://www.rd.usda.gov/programs-services/all-programs). USDA's Rural Energy for America Program (REAP) offers grants and loan guarantees for energy efficiency improvements and renewable energy systems to agriculture operations and qualifying rural small businesses. USDA has awarded the University of Central Florida a grant to provide a limited number of subsidized Energy Audits to eligible businesses in Florida in support of USDA Rural Development (USDA-RD) Grant and Loan programs for rural small businesses. The ultimate goal of the energy audits is to increase participation in …

Cost Effectiveness Of Energy Efficiency And On-Site Photovoltaic Power For 2015 Iecc Energy Rating Index (Eri) Compliance (Draft), Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

EnergyGauge® USA v.5.1 is used to simulate the energy use of one-story, three-bedroom, 2000 ft² , single-family, frame homes in sixteen representative U.S. climates comprising all eight IECC climate zones. The energy use of the Section R406.2 minimum efficiency home (the Baseline Home) is compared against the energy use of homes complying with the prescriptive requirements of Section R402 of the 2015 IECC and against homes complying with the Section R406 Energy Rating Index (ERI) Compliance Alternative. The improvement cost and energy savings of the improved homes relative to the Baseline Home are then used to determine the cost …

Evaluating The Economic Impacts Of The Legislatively Delayed Provisions Of The 5th Edition (2014) Florida Building Code (Final Report), Florida Solar Energy Center, Robin Vieira

FSEC Energy Research Center®

This research provides an assessment of the potential economic impacts of implementing three legislatively delayed requirements of the Florida Building Code, 5th Edition (2014): 1) residential air leakage testing, 2) residential whole-house mechanical ventilation, and 3) two fire service access elevators for applicable buildings.

Comprehensive Modeling Of Optimal Paths To Reach Nearly Zero Energy Buildings (Nzebs) For New Constructions In Europe, Florida Solar Energy Center, Delia D'Agostino

FSEC Energy Research Center®

As established by the recast of the European Union (EU) Directive on Energy Performance of Buildings (EPBD), all new buildings have to be nearly zero energy buildings (nZEBs) by the end of 2020. However, reaching this result considering cost-optimality is still an open challenge. Balancing renewable power generation with energy efficiency to reach the nZEB target is a key goal of all EU Member States. We describe results obtained from the modeling of nZEBs for new constructions in Europe using the energy performance software EnergyPlus. The model performs hourly sequential simulations showing how to best achieve nearly zero energy home …

Phased Retrofits In Existing Homes In Florida Phase I: Shallow And Deep Retrofits (February 2016), Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

The U.S. Department of Energy's Building America research team Building America Partnership for Improved Residential Construction is collaborating with Florida Power & Light (FPL) to conduct a phased residential energy-efficiency retrofit program. This research seeks to establish impacts on annual energy and peak energy reductions from the technologies applied at two levels of retrofit--shallow and deep--with savings levels that approach the Building America program goal of reducing whole-house energy use by 40%.

Relationship Between The Home Energy Score (Hes) And The Home Energy Rating System (Hers), Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

A significant cohort of approximately 2,900 registered home energy ratings using the REM/Rate HERS software tool, as reported to RESNET, are subjected to statistical analysis by the Dillon Group, Inc. The statistical analysis determines the distribution of HES results as a function of home energy efficiency as measured by the minimum standards of the 2009 IECC and by EPA’s ENERGY STAR program.

In addition, a parametric simulation analysis is conducted by the Florida Solar Energy Center using EnergyGauge® USA version 5.0, a RESNET-accredited HERS software tool, to determine the relationship between HES scores and the HERS Index. The parametric analysis …

Why Doesn't 25 Years Of An Evolving Energy Code Make More Of A Difference?, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

This paper was presented at the 2015 Behavior, Energy and Climate Change Conference (BECC). New and more stringent building energy codes are implemented with the assumption and expectation that significant energy conservation will occur. While simulation and various analysis methodologies may be reasonably sound at estimating the energy impact, the actual impact is largely dependent upon new code enforcement and occupant behavior. This work is based upon the research question: Do homes built to a newer energy code deliver measurable energy savings compared to homes built to a much earlier energy code? This residential research study was focused on comparing …

Simulating The Energy Performance Of A Foam Roof System, Florida Solar Energy Center, Jeffrey Sonne

FSEC Energy Research Center®

Annual residential simulations were run in 13 US cities to determine the energy savings of using an insulated foam tile roof in retrofit applications where ceiling insulation was only R-11 or R-19. Variations included leaving the attic vented and sealing the attic space.

Investigation Of The Effectiveness And Failure Rates Of Whole-House Mechanical Ventilation Systems In Florida, Florida Solar Energy Center, Jeffrey Sonne

FSEC Energy Research Center®

This report presents the results of a field investigation of the effectiveness and failure rates of whole-house mechanical ventilation systems installed in Florida homes over the last 15 years. The report includes homeowner survey and ventilation system testing results and code modification recommendations based on study findings.

Cooling And Heating Season Impacts Of Right-Sizing Of Fixed- And Variable-Capacity Heat Pumps With Attic And Indoor Ductwork, Florida Solar Energy Center, James Cummings

FSEC Energy Research Center®

The U.S. Department of Energy's research team Building America Partnership for Advanced Residential Construction implemented two phases of experiments to examine the cooling and heating seasonal and peak demand performance of a variable-capacity 2-ton SEER 22 heat pump versus a 3-ton variable-capacity SEER 21 heat pump with attic ducts and indoor ducts. The experiments also compared the cooling and heating seasonal and peak demand performance of 2-ton versus 3-ton fixed-capacity SEER 13 heat pumps with attic ducts and indoor ducts.

Developing Exhaust Air Energy Recovery Credits For The Florida Energy Code, Florida Solar Energy Center, Bereket Nigusse

FSEC Energy Research Center®

Energy Recovery Ventilator (ERV) or Heat Recovery Ventilator (HRV) devices recover energy from building's exhaust air to precondition outdoor air. Energy savings of ERV/HRV devices were determined for various commercial buildings in Florida climate using whole building energy simulation tool. The annual HVAC energy percent savings due to ERV/HRV device were calculated from HVAC energy use of a standard reference building without and with ERV/HRV device using EnergyPlus. The annual HVAC energy savings potential (ERV Credits) will be used for code compliance calculation when a compliance software does not have ERV modeling capability. The ERV/HRV credits were reported by building …

Maximum Energy Efficiency Cost Effectiveness In New Home Construction, Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

EnergyGauge® USA (v.4.0.00) is used to examine the cost effectiveness of high performance homes that are improved to significantly exceed the minimum requirements of the 2015 IECC. The objective of the study is to determine the maximum level of energy efficiency that can be considered cost effective to the consumer. For these purposes, it is the cost effectiveness of the entire package of measures that is considered by the analysis rather than the cost effectiveness of individual measures. Optimization and rank ordering of the individual improvement measures in the package is not considered by the analysis.

One-story 2,000 ft^{2 …}

Phased Retrofits In Existing Homes In Florida Phase I: Shallow And Deep Retrofits, Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

The U.S. Department of Energy (DOE) Building America program, in collaboration with Florida Power & Light (FPL), is conducting a phased residential energy-efficiency retrofit program. This research seeks to establish impacts on annual energy and peak energy reductions from the technologies applied at two levels of retrofit ' shallow and deep, with savings levels approaching the Building America program goals of reducing whole-house energy use by 40%. Under the Phased Deep Retrofit (PDR) project, we have installed phased, energy-efficiency retrofits in a sample of 56 existing, all-electric homes. End-use savings and economic evaluation results from the phased measure packages and …

Achieving Challenge Home In Affordable Housing In The Hot-Humid Climate, Florida Solar Energy Center, David Beal

FSEC Energy Research Center®

The Building America Partnership for Improved Residential Construction (BA-PIRC) worked with two affordable housing builders who pursued and achieved CH certification. Both builders needed very few changes to reach CH; however, both were already certifying homes under the ENERGY STAR® for Homes Standard v.3.1. Habitat for Humanity affiliates’ mortgage terms are 0% interest over a 30-year mortgage to qualified buyers. To improve relevance of the study to the general homebuilding community, the cost-effectiveness calculations herein are based on a code-minimum reference rather than the builders’ standard practice (ENERGY STAR), and projected first year cash flow is provided for both the …

Cost Effectiveness Of 2015 Iecc Compliance Using The Hers Index, Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

The EnergyGauge HERS software tool is used to examine the 2012 IECC Standard Reference Design (IECC SRD) configuration for three-bedroom, one-story 2000 ft² and three-bedroom, two-story 2,400 ft² single-family homes in sixteen representative U.S. cities. The energy use of the 2012 SRD homes is compared against the energy use of homes complying with the 2015 IECC using the ERI compliance method. HERS simulations for each home are conducted for both a best case home orientation and a worst case home orientation. Improvements to the 2012 IECC SRD homes are made such that the HERS Index for the homes …

Investigation Of Potential Benefits Of Revising Exception 1 Under Florida Building Code, Energy Conservation, Section 101.4.7.1.1 Duct Sealing Upon Equipment Replacement, Florida Solar Energy Center, Janet Mcilvaine

FSEC Energy Research Center®

Section 101.4.7.1.1, Duct sealing upon equipment replacement (Mandatory), of the 2012 Supplement to the Florida Building Code, Energy Conservation went into effect briefly in 2013. The new section required sealing of accessible ducts at the time of HVAC equipment replacement. Exception #1 however, eliminates the requirement for ducts in conditioned space, and by doing so, effectively eliminates the sealing requirement for building cavities in conditioned space that are used as air distribution paths. However, test results show that these building cavities are often connected to adjacent unconditioned spaces, in effect they are not really in the conditioned space because they …

Initial Testing Of A Unitary Hvac System Advanced Control Module, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

Testing of a unitary HVAC system advanced control module and the results.

Assessment Of Energy Efficient Methods Of Indoor Humidity Control For Florida Building Commission Research, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

This research project was conducted with the primary objective to identify approaches and technologies which can achieve energy-efficient latent cooling in light of code requirements that may increase overall ventilation rates in new Florida homes. This report covers the work of two primary efforts of completing a literature review and testing a few space conditioning methods in a mechanically ventilated building. Results from a literature review provide a list of various approaches to managing the latent load in homes with emphasis on energy efficiency and cost-effectiveness. In addition to a literature review, controlled experiments using four different approaches to space …

A Review Of Home Airtightness And Ventilation Approaches For Florida Building Commission Research, Florida Solar Energy Center, Jeffrey Sonne

FSEC Energy Research Center®

This research project was conducted with the primary objectives of 1) providing a literature review, examination of experimental data, and calculations of energy impacts of using or not using various types of ventilation systems and 2) developing alternative approaches to achieving acceptable levels of ventilation while avoiding the risks associated with super-tight home enclosures and potential mechanical system failures. The report includes discussions of pertinent airtightness and mechanical ventilation topics and provides recommended ventilation practices for Florida.

Flexible Residential Test Facility: Impact Of Infiltration And Ventilation On Measured Cooling Season Energy And Moisture Levels, Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

Air infiltration and ventilation in residential buildings is a very large part of the heating loads, but empirical data regarding the impact on space cooling has been lacking. Moreover, there has been little data on how building tightness might relate to building interior moisture levels in homes in a hot and humid climate. To address this need, BA-PIRC has conducted research to assess the moisture and cooling load impacts of airtightness and mechanical ventilation in two identical laboratory homes in the hot-humid climate over the cooling season.

Technical And Business Solutions For Zero Net-Energy Ready And Zero Net-Energy Homes In The Hot Humid Climate, Florida Solar Energy Center, Eric Martin

FSEC Energy Research Center®

The Department of Energy's Challenge Home program provides a standardized platform for application and marketing of Building America innovations in new residential construction and is intended to facilitate delivery of zero net-energy ready and zero net-energy homes that also meet goals for durability, quality, affordability, and comfort. The Building America Partnership for Improved Residential Construction, one of the Building America research team leads, has partnered with several builders in the hot-humid climate, as they work through the process of adopting Challenge Home. This paper serves to identify viable technical pathways to meeting the Challenge Home criteria in this region and …

Energy And Peak Power Reduction From Air Misting Products Applied To Commercial Condensing Units In Hot And Humid Climates, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

A proprietary research project was conducted to evaluate the potential annual and peak energy reduction resulting from the addition of a water misting system applied to supermarket condenser coils in the Florida Power and Light service territory. Tests were performed to evaluate the performance of a mist system under various outdoor conditions over an eight-month period in a hot and humid climate zone. The project measured an average of 2.8% percentage energy savings and average 3.2% utility peak demand reduction. The report discusses why hot and humid climates can expect much lower savings compared to hot and arid climates. One …

Comparative Performance Analysis: Hers Index Score Dependencies Related To Home Geometries And Operating Assumptions, Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

EnergyGauge USA v.3.1.02 is used examine the impact of geometry and operating conditions on comparative simulation analysis techniques that are used to evaluate home energy performance with respect to a standardized reference case. A cohort of homes is simulated using the HERS Index scoring system in 15 U.S. cities that are representative of the 8 International Energy Conservation Code (IECC) climate zones. All of the homes are configured to have the thermal envelope characteristics specified by Table R402.1.1 of the 2012 IECC. All homes are also configured to meet all other mandatory requirements of the 2012 IECC, including 75% high …