Civil and Environmental Engineering Commons^™

Sensitivity Analysis Of Aashto's 2002 Flexible And Rigid Pavement Design Methods, Sanjay Shahji

Electronic Theses and Dissertations

Over the years pavement design has been based on empirical equations developed from the American Association of State Highway Transportation Officials (AASHTO) road tests. The various editions of the AASHTO pavement design guide have served well for several decades; nevertheless many serious limitations existed for their continued use as the nation's primary pavement design procedure. For example, the traffic loads and truck sizes have increased over the years, the AASHTO design equations were derived based on the climatic conditions present at the Road Tests site, and the issue of aging materials was not addressed in the design. To overcome these …

Cumberland Gap Tunnel Pavement Problem, Brad Rister

Kentucky Transportation Center Research Report

Ground Penetrating Radar was used to verify voids beneath the concrete roadway located at the Cumberland Gap Tunnel, in Middelsboro, KY. Preliminary results indicate that several void areas reside beneath the north and southbound tunnel.

Development Of A Frost Heave Test Apparatus, Russell David Lay

Theses and Dissertations

Frost heave damage to roadways costs millions of dollars every year. The need for an improved understanding of the fundamental mechanisms associated with frost heave and methods for efficiently improving frost-susceptible materials prompted the Department of Civil and Environmental Engineering at Brigham Young University (BYU) to undertake a project to design, construct, and verify the functionality of a new frost heave testing apparatus. Frost heave research has been carried out for more than 75 years. The equipment used to conduct this testing has advanced in accuracy and utility over the years. To establish a background in past and current frost …

Pavement/Sub-Grade Condition Assessment I-65 Approximate Milepost 97.5 To 102.5 (Transition From Asphalt To Concrete) To (Ky 313 Overpass), Brad Rister, Clark Graves

Kentucky Transportation Center Research Report

This report summarizes the condition assessment of the pavement structure on I-65 between 97.5 to 102.5. Three types of equipment were used to evaluate the present condition of the pavement: falling weight deflectormeter, ground penetrating radar, and coring machine, Results indicated that durability of the existing concrete surface appears to be the most detrimental problem encountered in this survey. Load-transfer across transverse joint appear to be in acceptable ranges. Limited areas were identified to have less than four inches of D.G.A. beneath the concrete pavement. These areas have also been experiencing the most differential settlement. In addition several areas are …

Interaction Between Micro-Cracking, Cracking, And Reduced Durability Of Concrete: Developing Methods For Considering Cumulative Damage In Life-Cycle Modeling, Zhifu Yang, W. Jason Weiss, J. Olek

JTRP Technical Reports

It is becoming increasingly popular to utilize numerical simulation models to predict the long-term performance of concrete pavements and structures. The majority of these models have been developed using laboratory test data that considers concrete in an uncracked state. While uncracked concrete exists as the best case scenario, frequent cracking occurs in real structures that could have a profound impact on life cycle performance. Cracks from several sources may accumulate and interact thereby accelerating the deterioration of concrete. For example, the distributed cracking caused by freeze/thaw damage can substantially increases the rate of water absorption and reduces the load carrying …

Detection And Evaluation Of Exisiting Pavement System With Brick Base, Karishma Desai

Electronic Theses and Dissertations

At the turn of the century, the City of Orlando initiated the "Neighborhood Horizon Program." This program involved local citizens to help improve their community resources by engaging in a process of planning where the problems associated with the communities were identified. Many residents favored to bring back the brick roads that were overlaid with asphalt concrete to provided better transportation in the mid 1900s. With majority of the neighborhood streets already bricked, removing asphalt ensured safety, served as a technique for slowing traffic, and added to the historical integrity. Since there were no official documentations available that stated the …

Initial Study For Cost-Effectiveness Of Joint/Crack Sealing, Chuanxin Fang, Khaled A. Galal, David R. Ward, John E. Haddock

JTRP Technical Reports

The sealing and resealing of joints and cracks in PCC, HMA, and composite pavements is assumed to be an important component of pavement maintenance. Recently this practice has been challenged by research indicating that sealing may not be cost-effective. The Indiana Department of Transportation currently spends approximately four million dollars annually to perform joint/crack sealing. The primary objective of the research presented in this report is to investigate the costeffectiveness of joint/crack sealing in relation to pavement performance. The results of a mail survey showed that most states, including Indiana, do not have quantitative justification for sealing policies, nor do …

Influence Of Curing Conditions On Strength Properties And Maturity Development Of Concrete, Scott Andrew Newbolds, Jan Olek

JTRP Technical Reports

In this study, the results of both laboratory studies and a field study, conducted to evaluate the effects of different curing conditions on the strength properties and maturity development of pavement concrete, are presented. Further, a laboratory study was performed to evaluate the maturity concept in relation to the degree of hydration of cement. Concrete specimens, beams and cylinders, were prepared in the field study. The specimens in the field were cured in one of four curing conditions: lime bath, sandpit, air, or by temperature match curing. Specimens were tested for flexural strength and compressive strength, respectively. The temperature of …

Concrete Overlay As A Rehabilitation Option For Distressed Asphalt Pavements, Sudarshan Rajan, J. Olek

JTRP Technical Reports

Ultra-thin Whitetopping (UTW) involves placing a very thin concrete overlay 50 mm to 100 mm thick (2”-4”) on the milled surface of a distressed asphalt pavement. To investigate the performance of UTW placed over a flexible pavement subjected to slow and heavy moving wheel loads, whitetopping mixes were placed over a milled pavement surface in the Accelerated Pavement Testing (APT) facility of the Indiana Department of Transportation (INDOT) Research Division in West Lafayette Indiana in the fall of 1999. The UTW installation experiment consisted of four test ‘lanes’ of two different thicknesses; each utilizing plain and fiber reinforced concrete. The …

Seasonal And Spatial Variation Of Subgrade Response, Mustaque Hossain, Stefan Romanoschi, Andrew J. Gisi

Civil Engineering Faculty Publications - Archive

Temperature, subgrade moisture content, and Falling Weight Defleetometer (FWD)-deflection data were collected monthly on four asphalt pavement test sections in Kansas for a year. The subgrade moduli were baekealeulated using the elastic layer theory. It was found that for almost all sites, the monthly variation in subgrade moisture content was not very significant over the seasons. The patterns of subgrade response, in terms of subgrade moduli versus time, simulated sine-shaped forms signifying a possible temperature effect. Higher variabilities across the site were associated with the extreme temperature conditions, usually very low or high average pavement temperatures. In all cases, the …

Pavement Design Guide: A Short Course, Kentucky Transportation Center

Kentucky Transportation Center Research Report

The purpose of this short course is to provide information to the registered engineer (with no previous background in pavement design or pavement technology) on the structural design of pavements. Included in this course is a summary of background information on the materials used in pavement construction and on the history and evolution of pavement design. Included with this course is an updated Design Guide or catalog to be used for designing new pavements in Kentucky. The intent of the guide or catalog is to provide the road\\ a) designer with a simplified, straightforward methodology for developing structural designs of …

Development Of A 3-D Finite Element Program For Pavement Analysis, Volume 3: Appendix 3, Tatsaba Nilaward, Chiang Shih, Thomas D. White, E. C. Ting

JTRP Technical Reports

A three dimensional finite element program is developed for the analysis of pavement systems. An explicit approach of the finite element analysis is adopted. This approach results in a vector formulation of the equation of motion. Large displacement is considered through the use of a co-rotational approach which considers small deformations and large rotations of the elements. For the convenience of application a two dimensional finite element program is also developed. An eight-node isoperimetric solid element is used for the three dimensional analysis, and a four-node element for the two dimensional analysis. Loading conditions are verified for static ramp and …

Development Of A 3-D Finite Element Program For Pavement Analysis, Volume 2: Appendix 2, Tatsaba Nilaward, Chiang Shih, Thomas D. White, E. C. Ting

JTRP Technical Reports

A three dimensional finite element program is developed for the analysis of pavement systems. An explicit approach of the finite element analysis is adopted. This approach results in a vector formulation of the equation of motion. Large displacement is considered through the use of a co-rotational approach which considers small deformations and large rotations of the elements. For the convenience of application a two dimensional finite element program is also developed. An eight-node isoperimetric solid element is used for the three dimensional analysis, and a four-node element for the two dimensional analysis. Loading conditions are verified for static ramp and …

Development Of A 3-D Finite Element Program For Pavement Analysis, Volume I: Introduction And Appendix 1, Tatsaba Nilaward, Chiang Shih, Thomas D. White, E. C. Ting

JTRP Technical Reports

A three dimensional finite element program is developed for the analysis of pavement systems. An explicit approach of the finite element analysis is adopted. This approach results in a vector formulation of the equation of motion. Large displacement is considered through the use of a co-rotational approach which considers small deformations and large rotations of the elements. For the convenience of application a two dimensional finite element program is also developed. An eight-node ¶metric solid element is used for the three dimensional analysis, and a four-node element for the two dimensional analysis. Loading conditions are verified for static ramp and …

Summary Of Results Of 1995 Field Evaluations Of Long Life Pavement Marking Materials, Kentucky Transportation Center

Kentucky Transportation Center Research Report

This report completes the summary of the results of data collected as part of the 1995 field and laboratory evaluations of pavement marking materials for the National Transportation Product Evaluation Program (NTPEP). A previous report summarized the data for the first year after placement of these materials (AASHTO's National Transportation Product Evaluation Program, Report 96, NTPEP 121, October 1996). Data for the second year for the long life pavement marking materials are given in this report.

Remediation Of Hazardous Effluent Emitted From Beneath Newly Constructed Road Systems And Clogging Of Underdrain Systems, Ronald Fred Wukasch, Adil Siddiqui

JTRP Technical Reports

The Indiana Department of Transportation uses recycled concrete pavement as aggregate for the construction of highways. The effluent from these pavements has a high pH. The high pH effluent can cause clogging of drains and vegetative kill around the outlet. This project looks into the source of the effluent water, its chemical composition and the approximate duration the problem can be expected to persist. The project also investigates possible methods for reduction of the problem in future installation. The approximate additional cost of these solutions and the problems associated with them are discussed as well.

Summary Of Results Of 1993 Field And Laboratory Evaluations Of Pavement Marking Materials, Kentucky Transportation Center

Kentucky Transportation Center Research Report

This report summarizes the results of data collected as part of the 1993 field and laboratory evaluations of pavement marking materials for the SASHTO Regional Test Facility. The report is divided into two volumes. The first volume presents the field evaluations while the laboratory tests results are given in the second volume. The purpose of the Regional Test Facility (RTF) is to minimize the amount of field and laboratory research testing of specific types of materials. This is accomplished by combining efforts in an organized manner to reduce the monetary and man-hour requirements of both the states and industry. A …

Impacts Of The Extended-Weight Coal Haul Road System (Interim Report), Joseph D. Crabtree, Jerry G. Pigman, John A. Deacon, Kenneth R. Agent

Kentucky Transportation Center Research Report

The Extended-Weight Coal Haul Road System, created by Kentucky's Legislature in 1986, consists of all roads which carry over 50,000 tons of coal in a calendar year. Trucks hauling coal on this system are authorized to exceed normal weight limits through the payment of an annual decal fee. A research study was initiated in July of 1992 to analyze the impacts of the extended-weight system. This interim report, prepared after one year of a three-year study, describes the analyses performed thus far and presents preliminary findings, recommendations, and a discussion of future work.

Analyses in this report are based on: …

Summary Of Results Of 1992 Field And Laboratory Evaluations Of Pavement Marking Materials, Kentucky Transportation Center

Kentucky Transportation Center Research Report

This report summarizes the results of data collected as part of the 1992 field and laboratory evaluations of pavement marking materials for the SASHTO Regional Test Facility. The report is divided into two volumes. The first volume presents the field evaluations while the laboratory tests results are given in the second volume. The purpose of the Regional Test Facility (RTF) is to minimize the amount of field and laboratory research testing of specific types of materials. This is accomplished by combining efforts in an organized manner to reduce the monetary and man-hour requirements of both the states and industry. A …

Kentucky Rock Asphalt (Kyrock) Road Surfacing Material: Preliminary Investigation, Jerry G. Rose

Kentucky Transportation Center Research Report

This report documents a preliminary investigation of Kentucky Rock Asphalt (Kyrock) - as a road surfacing material. The indigenous bituminous impregnated sandstone was widely used as a premium quality skid resistant surfacing material during the first half of this century. Redevelopment efforts gained momentum during the 1960's, but for the last twenty years interest has waned.

Laboratory tests were conducted on the Kyrock to determine its applicability in bituminous surface mixes by blending Kyrock with virgin materials in a similar manner as adding recycled asphalt pavement. The findings indicated it was feasible to blend Kyrock and a continuation proposal was …

Value Of Research, Kentucky Transportation Center

Kentucky Transportation Center Research Report

Transportation research in Kentucky has been ongoing since 1914. The Road Materials Testing Laboratory was established that year at the University of Kentucky. Operation of the laboratory commenced in 1915 under the guidance of Professor D.V. Terrell who later became Dean of the College of Engineering. Dean Terrell often noted that the purpose of research was not to save money but to make it go farther. Public funding was never sufficient to accomplish all that various agency personnel considered essential nor that which the public deemed necessary and research was conducted most often for the purpose of gaining more for …

Summary Of Results Of 1990 Field And Laboratory Evaluations Of Pavement Marking Materials (Sashto Regional Test Facility), Kentucky Transportation Center

Kentucky Transportation Center Research Report

This report summarizes the results of data collected as part of the 1990 field and laboratory evaluations of pavement marking materials for the SASHTO Regional Test Facility. The purpose of the Regional Test Facility (RTF) is to minimize the amount of field and laboratory research testing of specific types of materials. This is accomplished by combining efforts in an organized manner to reduce the monetary and man-hour requirements of both the states and industry. A RTF for the twelve SASHTO states was approved at the 1988 SASHTO convention. The twelve SASHTO states are Alabama, Arkansas, Florida, Georgia, Kentucky, Louisiana, Mississippi, …

Summary Of Results Of 1989 Field And Laboratory Evaluations Of Pavement Marking Materials, Kentucky Transportation Center

Kentucky Transportation Center Research Report

This report summarizes the results of data collected as part of the field and laboratory evaluations of pavement marking materials for the SASHTO Regional Test Facility. The purpose of the Regional Test Facility (RTF) is to minimize the amount of field and laboratory research testing of specific types of materials. This is accomplished by combining efforts in an organized manner to reduce the monetary and man-hour requirements of both the states and industry. A RTF for the twelve SASHTO states was approved at the 1988 SASHTO convention. The twelve SASHTO states are Alabama, Arkansas, Florida, Georgia, Kentucky, Louisiana, Mississippi, North …

Preliminary Engineering, Monitoring Of Construction, And Initial Performance Evaluation: Use Of Ponded Fly Ash In Highway Road Base, David Q. Hunsucker, R. Clark Graves

Kentucky Transportation Center Research Report

This report summarizes findings of laboratory and field trial evaluations of ponded fly ash used as a component In a stabilized aggregate base course. Ponded fly ash is the fine portion of pond ash which is a by-product of a coal burning process and Is disposed by sluicing to a disposal pond.

Three stabilized aggregate base mixtures containing various proportions of dense graded aggregate, ponded fly ash, and hydrated lime were evaluated In the laboratory relative to maximum dry density, optimum moisture content, and unconfined compressive strength. The mixture that was selected for field trial evaluation had the highest unconfined …

Pavement Inspection Derbyshire Estates, R. Clark Graves, David L. Allen

Kentucky Transportation Center Research Report

The subject project was constructed in the fall of 1988. Soon after construction, the pavement began to deteriorate. Areas of alligator cracking were observed along with extensive rutting and pushing of the asphaltic concrete. Distresses occurred soon after the roadway was completed. Personnel of the Jefferson Co. Public Works Department requested that Kentucky Transportation Center (KTC) personnel make a preliminary inspection.

Kentucky Transportation Center (KTC) personnel conducted preliminary tests at the site on July 11, 1989. Results of tests were outlined in a letter to Schimpeler-Corradino Associates, on July 19, 1989. After review, of those results, Schimpeler-Corradino principals requested that …

Pavement Evaluation Elkhorn Drive, R. Clark Graves

Kentucky Transportation Center Research Report

The Lexington-Fayette Urban County Government requested that the Kentucky Transportation Center perform a pavement evaluation and overlay design for Elkhorn Drive. This pavement section consisted of 3 inches of asphaltic concrete and 8 inches of dense graded aggregate. A visual inspection during testing revealed several areas of severe alligator cracking along with some areas of transverse cracking.

Demonstration Project No. 59: The Use Of Fly Ash In Highway Construction, Fayette County, Kentucky, David Q. Hunsucker, Gary W. Sharpe

Kentucky Transportation Center Research Report

This report summarizes preliminary site investigations, design criteria and procedures, construction criteria and procedures, and results of initial and final evaluations of an experimental road base utilizing lime kiln dust, fly ash and aggregate. Observed performance has been satisfactory. Compressive strength evaluations indicate exceptional early strength and continued strength gain of the pozzolanic base. Back calculation of specific elastic layer moduli indicate that the moduli of the pozzolanic base material is most likely within a range of 500,000 to 1,000,000 psi.

Based upon observations to date, treated bases enhance overall pavement performance and their use should be continued. It is …

Implementation Of A Pavement Management Program In Lexington-Fayette County, Kentucky, Gary W. Sharpe, Robert C. Deen, Ronald R. Sewell

Kentucky Transportation Center Research Report

Lexington, in central Kentucky, is the second largest city in the state. Local government is by a mayor and council of elected representatives from twelve districts and three at-large representatives. The Department of Public Works headed by a Commissioner, who reports to the mayor and city-county council, administers the streets and roads system.

The street and road network in Lexington consists of approximately 720 centerline miles. Approximately 100 miles are rural in nature and 620 miles are urban. Approximately 95 percent are bituminous surfaced roads; a majority of the remainder is constructed of portland cement concrete.

Increasing costs for constructing …

Evaluation Of A Full-Depth Asphaltic Concrete Pavement, Herbert F. Southgate, Gary W. Sharpe, Mark Anderson

Kentucky Transportation Center Research Report

This study was initiated to verify a newly-developed set of design curves for full-depth asphaltic concrete pavements. Quality control during construction was checked using nuclear density testers, Benkelman beams, and a Road Rater. During the course of this study, an analysis system (predicated upon the elastic theory model) was developed to interpret the dynamic deflections as measured by the Road Rater. The thickness design curves were verified by elastic theory and deflection testing within the accuracy of construction variations.

Measured rut depths were analyzed in terms of potential rut depth resulting from consolidation under traffic due to lack of obtaining …

Materials Characterization And Economic Considerations Of Cold-Mix Recycled Asphalt Pavements, Luis Humberto Castedo-Franco

Indiana Local Technical Assistance Program (LTAP) Publications

Recycling of asphalt pavements has become a common rehabilitation and maintenance process since the mid 1970s. The state of the art of designing and constructing pavements composed of recycled materials has now advanced to a point where recycling is considered as an alternative to conventional procedures for most paving projects. An in-depth evaluation of cold-mix recycling techniques was undertaken and the findings are presented in this report. The variability of the existing materials found in city streets and county roads throughout the State of Indiana was evaluated by means of laboratory test procedures. The data obtained from these experiments were …