Chemical Engineering Commons^™

Water Absorption Enhancement Of Sodium Poly Acrylate And Poly(2-Acrylamido-2-Methylpropane Sulphonic Acid) Based Hydrogel Mixtures, Sohair A. Darwish, Ibrahim M. Ibrahim, Nasser Y. Mostafa, Mostafa A. Radwan, Mohamed A. Sadek, Hany A. Elazab

Chemical and Biochemical Engineering Faculty Research & Creative Works

Introduction: Hydrogels are hydrophilic polymers which are cross-linked to form three-dimensional structures, which can absorb, swell and retain huge amounts of water or aqueous fluids. Objective: This paper reports the preparation and characterization of Poly (2-Acrylamido-2-Methylpropane Sulphonic Acid) (PAMPS) hydrogel with different crosslinking intensities. Methodology: 2-Acrylamido-2-methylpropane sulfonic acid (AMPS) monomer was purchased from Alfa Aesar Company as reagent grade. It was used as received (>98% purity) without any further purification. PAMPS hydrogel was prepared by free radical crosslinking solution polymerization of AMPS in water at room temperature under a nitrogen blanket in cylindrical glass tubes. The characteristics of the …

Better Heat And Power Integration Of An Existing Gas-Oil Plant In Egypt Through Revamping The Design And Organic Rankine Cycle, Mamdouh A. Gadalla, Alaa Elmasry, Ibrahim Alhajri, Fatma H. Ashour, Hany A. Elazab

Chemical and Biochemical Engineering Faculty Research & Creative Works

Objective: The current study aims mainly to Maximize Condensate Recovery (NGLs), focusing on a gas processing train of Gas-Oil Separation Plant (GOSP) located in Egypt with a capacity of 4,230 kmole/h. Methods: The research study accounts for the constraint of Reid Vapor Pressure (RVP) specification, which makes the storage in floating roof tanks is of a great risk. The study proposes the installation of the cryogenic train that recovers condensates (C4+). This train comprises of compression unit, expansion unit, three-phase separators and a re-boiled absorber. The problem of RVP will no longer exist because of the re-boiled absorber achieving RVP …

Equilibrium And Kinetic Study On The Biosorption Of Trypan Blue From Aqueous Solutions Using Avocado Seed Powder, Tamer T. El-Idreesy, Omar Khoshala, Amin Firouzi, Hany A. Elazab

Chemical and Biochemical Engineering Faculty Research & Creative Works

This research aims to investigate the removal of trypan blue dye from aqueous solutions by employing ground avocado seeds powder, a low-cost biowaste adsorbent (biosorbent), under various experimental conditions. The effect of contact time, initial dye concentration, and adsorbent dose on dye removal were studied. The experimental kinetic data were fitted to pseudo-first order and pseudo-second-order kinetic models. Results imply that adsorption of trypan blue on the avocado seed adsorbent nicely followed the pseudo-second-order kinetic model. Equilibrium isotherms were analyzed by Langmuir and Freundlich isotherms, where Langmuir isotherm described the isotherm data with a high-correlation coefficient (R2=0.9948) closer to unity, …

Synthesis Of Uio-66 Metal Organic Frameworks, Nicholas Johnston, Larissa Lagria

Summer Community of Scholars Posters (RCEU and HCR Combined Programs)

No abstract provided.

Brownian Dynamics Of Interacting Anisotropic Magnetic Nanoparticles, Daniel Duke

Summer Community of Scholars Posters (RCEU and HCR Combined Programs)

No abstract provided.

Temporal Understanding Of The Conversion Of Normal Synovial Fibroblasts Into Osteoarthritic Fibroblasts, Danielle Mcdowell

Summer Community of Scholars Posters (RCEU and HCR Combined Programs)

No abstract provided.

The Effect Of Surface Topography On The Deposition Of Colloids, Mikhail Ramirez

Summer Community of Scholars Posters (RCEU and HCR Combined Programs)

No abstract provided.

Information Architecture For A Chemical Modeling Knowledge Graph, Adam R. Luxon

Theses and Dissertations

Machine learning models for chemical property predictions are high dimension design challenges spanning multiple disciplines. Free and open-source software libraries have streamlined the model implementation process, but the design complexity remains. In order better navigate and understand the machine learning design space, model information needs to be organized and contextualized. In this work, instances of chemical property models and their associated parameters were stored in a Neo4j property graph database. Machine learning model instances were created with permutations of dataset, learning algorithm, molecular featurization, data scaling, data splitting, hyperparameters, and hyperparameter optimization techniques. The resulting graph contains over 83,000 nodes …

Nature-Inspired Material Strategies Towards Functional Devices, Sayantan Pradhan

Theses and Dissertations

Naturally sourced, renewable biomaterials possess outstanding advantages for a multitude of biomedical applications owing to their biodegradability, biocompatibility, and excellent mechanical properties. Of interest in this dissertation are silk (protein) and chitin (polysaccharide) biopolymers for the fabrication of functional biodevices. One of the major challenges restricting these materials beyond their traditional usage as passive substrate materials is the ability to combine them with high-resolution fabrication techniques. Initial research work is directed towards the fabrication of micropatterned, flexible 2D substrates of silk fibroin and chitin using bench-top photolithographic techniques. Research is focused on imparting electrochemical properties to silk proteins using conducting …

Continuous Preparation And Application Of Novel Heterogeneous Catalysis, Michael B. Burkholder

Theses and Dissertations

Transition metal heterogeneous catalysts are widely used across many chemical industries to reduce waste and emissions and reduce production time while increasing rate. The prevalence of these materials results from the complex relationship between metal nanoparticles and supports affecting final catalytic performance. Rational catalyst synthesis describes the ability to precisely engineer structures through controlled preparation. Novel materials and continuous processing represent a promising approach for rational catalyst synthesis.

The application of these catalysts in continuous, multiphase processes, such as cross-coupling reactions, oxidation chemistry, and nitroreduction processes, are paramount to developing new commercial routes for high-value products. Pd/G catalysts synthesized by …

Applied Machine Learning In Extrusion-Based Bioprinting, Shuyu Tian

Theses and Dissertations

Optimization of extrusion-based bioprinting (EBB) parameters have been systematically conducted through experimentation. However, the process is time and resource-intensive and not easily translatable across different laboratories. A machine learning (ML) approach to EBB parameter optimization can accelerate this process for laboratories across the field through training using data collected from published literature. In this work, regression-based and classification-based ML models were investigated for their abilities to predict printing outcomes of cell viability and filament diameter for cell-containing alginate and gelatin composite hydrogels. Regression-based models were investigated for their ability to predict suitable extrusion pressure given desired cell viability when keeping …

Kinetics Study Of The Hydrodeoxygenation Of Xylitol Over A ReoX-Pd/Ceo2 Catalyst, Blake Macqueen, Michael Royko, Bradie S. Crandall, Andreas Heyden, Yomaira J. Pagán-Torres, Jochen A. Lauterbach

Faculty Publications

In this study, we elucidate the reaction kinetics for the simultaneous hydrodeoxygenation of xylitol to 1,2-dideoxypentitol and 1,2,5-pentanetriol over a ReOx-Pd/CeO2 (2.0 weight% Re, 0.30 weight% Pd) catalyst. The reaction was determined to be a zero-order reaction with respect to xylitol. The activation energy was elucidated through an Arrhenius relationship as well as non-Arrhenius kinetics. The Arrhenius relationship was investigated at 150–170◦ C and a constant H2 pressure of 10 bar resulting in an activation energy of 48.7 ± 10.5 kJ/mol. The investigation of non-Arrhenius kinetics was conducted at 120–170◦ C and a sub-Arrhenius relation was elucidated with activation energy …

Development Of An Injectable Methylcellulose Hydrogel System For Nucleus Pulposus Repair And Regeneration, Nada A. Haq-Siddiqi

Dissertations and Theses

Low back pain is the most common cause of disability in the world and is often caused by degeneration or injury of the intervertebral disc (IVD). The IVD is a complex, fibrocartilaginous tissue that allows for the wide range of spinal mobility. Disc degeneration is a progressive condition believed to begin in the central, gelatinous nucleus pulposus (NP) region of the tissue, for which there are few preventative therapies. Current therapeutic strategies include pain management and exercise, or surgical intervention such as spinal fusion, none of which address the underlying cause of degeneration. With an increasingly aging population, the socioeconomic …

Development Of Light Actuated Chemical Delivery Platform On A 2-D Array Of Micropore Structure, Hojjat Rostami Azmand, Hojjat Rostami Azmand

Dissertations and Theses

Localized chemical delivery plays an essential role in the fundamental information transfers within biological systems. Thus, the ability to mimic the natural chemical signal modulation would provide significant contributions to understand the functional signaling pathway of biological cells and develop new prosthetic devices for neurological disorders. In this paper, we demonstrate a light-controlled hydrogel platform that can be used for localized chemical delivery in a high spatial resolution. By utilizing the photothermal behavior of graphene-hydrogel composites confined within micron-sized fluidic channels, patterned light illumination creates the parallel and independent actuation of chemical release in a group of fluidic ports. The …

Adsorption Kinetics And Phase Behavior Of Particles Adsorbed At An Interface, Shaghayegh Darjani

Dissertations and Theses

The ability to predict the adsorption dynamic, phase behavior, and surface pressure of a monolayer of adsorbed particles in two-dimensional systems are key aspects of many current research areas. Examples include phase transitions in amphiphilic monolayers, emulsion stability due to particle adsorption at interfaces, and melting at an interface.

In this thesis, a new approach for deriving the equation of state for a two-dimensional lattice gas is proposed, based on arguments similar to those used in the derivation of the Langmuir-Szyszkowski equation of state for localized adsorption. This work aims to predict the adsorption kinetics and phase behavior of a …

A New Mathematical Theory For The Dynamics Of Large Tumor Populations, A Potential Mechanism For Cancer Dormancy & Recurrence And Experimental Observation Of Melanoma Progression In Zebrafish, Adeyinka A. Lesi

Dissertations and Theses

Cancer, a family of over a hundred disease varieties, results in 600,000 deaths in the U.S. alone. Yet, improvements in imaging technology to detect disease earlier, pharmaceutical developments to shrink or eliminate tumors, and modeling of biological interactions to guide treatment have prevented millions of deaths. Cancer patients with initially similar disease can experience vastly different outcomes, including sustained recovery, refractory disease or, remarkably, recurrence years after apparently successful treatment. The current understanding of such recurrences is that they depend on the random occurrence of critical mutations. Clearly, these biological changes appear to be sufficient for recurrence, but are they …

Molecular To Macroscopic Understanding Of Chloroaluminate Anion Intercalation In Rechargeable Aluminum-Graphite Batteries, Jeffrey Xu

Dissertations and Theses

Today’s global energy challenges pose an urgent need to electrify transportation and better store intermittent renewable energy sources (e.g., solar and wind energy). For such large-scale battery applications, aluminum batteries are a promising “beyond lithium-ion” technology due to the high volumetric capacity, earth abundance, low-cost, and inherent safety of aluminum metal. However, there are very few compatible positive electrode materials that exhibit high energy density and cycling stability, in part due to the challenges of electrochemically intercalating highly charged Al³⁺ cations. Recently, graphite has been demonstrated as a promising positive electrode material in non-aqueous rechargeable aluminum batteries, which store …

Molecular-Level Understanding Of Ionic & Electronic Charge Storage Mechanisms In Rechargeable Aluminum Batteries Using Sold-State Nmr, Ankur Lahanu Jadhav

Dissertations and Theses

Rechargeable aluminum-ion batteries are safe and low-cost alternatives to traditional lithium-ion batteries due to the high volumetric capacity (8040 mAh/cm³) of aluminum. However, very few electrode materials have shown reversible aluminum ion intercalation. Intercalation Al³⁺ ions in these structures leads to poor capacity retention, mainly due to slow solid-state diffusion of the highly charged tri-valent aluminum ions within these crystalline structures. In 2015, aluminum ions were shown to reversibly intercalate/de-intercalate into the Chevrel Mo₆S₈ phase, though the intercalation mechanism is not well understood. Alternatively, molecular chloroaluminate ions within the ionic liquid electrolyte have also …

Investigating The Effect Of Electrolyte Concentration And Charging Protocol On Materials Utilization In Rechargeable Zinc Manganese Dioxide Batteries, Snehal H. Kolhekar

Dissertations and Theses

Achieving a highly cyclable, high energy density battery with MnO₂ cathodes encounters many obstacles. Chief among these is the inability of the widely-used γ-MnO₂ polymorph to retain its structural integrity when cycled to near full one-electron discharge capacity, which is about 280mAh/g for commercially available electrolytic manganese dioxide (EMD). In this one-electron range, discharge occurs by proton insertion producing Mn⁺³ which then reverts to γ-MnO₂ on charging. In the first part of the thesis, we investigate the root cause of failure of MnO₂ cathodes under deep cycling in the one-electron discharge range and establish a …

Perovskite Thin Films Annealed In Supercritical Fluids For Efficient Solar Cells, Gilbert Annohene

Theses and Dissertations

In the field of photovoltaics, scientists and researchers are working fervently to produce a combination of efficient, stable, low cost and scalable devices. Methylammonium lead trihalide perovskite has attracted intense interest due to its high photovoltaic performance, low cost, and ease of manufacture. Their high absorption coefficient, tunable bandgap, low-temperature processing, and abundant elemental constituent provide innumerable advantages over other thin film absorber materials. Since the perovskite film is the most important in the device, morphology, crystallization, compositional and interface engineering have been explored to boost its performance and stability. High temperatures necessary for crystallization of organic-inorganic hybrid perovskite films …

An Experimental Study Investigating The Impact Of Miscible And Immiscible Nitrogen Injection On Asphaltene Instability In Nano Shale Pore Structure, Mukhtar Elturki, Abdulmohsin Imqam

Geosciences and Geological and Petroleum Engineering Faculty Research & Creative Works

Miscible gas injection has become the most used enhanced oil recovery (EOR) method in the oil and gas industry. The deposition and precipitation of asphaltene during the gas injection process is one of the problems during the oil production process. The asphaltene can deposit and plug the pores, which reduces the permeability in a reservoir; thus, decreasing the oil recovery and increasing the production costs. This research investigates the nitrogen (N2) miscible and immiscible pressure injections on asphaltene instability in shale pore structures. First, a slim tube was used to determine the minimum miscibility pressure (MMP) of N2 to ensure …

Prediction Of Equivalent Liquid Permeability From Gas Permeability Measurements: A Recurrent Neural Network Approach, Husam Alkinani, Abo Taleb Al-Hameedi, Shari Dunn-Norman

Geosciences and Geological and Petroleum Engineering Faculty Research & Creative Works

One of the most vital reservoir properties is permeability. It is usually measured using core samples with two major measurement methods: using gas or using liquid. The purpose of this work is to use a data-driven recurrent neural network model to estimate the equivalent liquid permeability based on gas permeability. By using this model, the equivalent liquid permeability can be predicted for the permeability of core samples with rich clay minerals measured using gas (or any core sample that is measured using gas). This will give an alternative way to the currently used method (Klinkenberg method). Core sample data measurements …

Will Carbon Dioxide Injection In Shale Reservoirs Produce From The Shale Matrix, Natural Fractures, Or Hydraulic Fractures?, Sherif Fakher, Youssef Elgahawy, Hesham Abdelaal, Abdulmohsin Imqam

Geosciences and Geological and Petroleum Engineering Faculty Research & Creative Works

Enhanced oil recovery (EOR) in shale reservoirs has been recently shown to increase oil recovery significantly from this unconventional oil and gas source. One of the most studied EOR methods in shale reservoirs is gas injection, with a focus on carbon Dioxide (CO₂) mainly due to the ability to both enhance oil recovery and store the CO₂ in the formation. Even though several shale plays have reported an increase in oil recovery using CO₂ injection, in some cases this method failed severely. This research attempts to investigate the ability of the CO₂ to mobilize crude …

Optimization Of Gelatin-Based Cellular Coating Of Msc For Myocardial Infarction Therapy, Kara Amelle Davis

Theses and Dissertations--Chemical and Materials Engineering

Cardiovascular disease remains the number one threat to American lives. During an acute myocardial infarction (AMI), blood flow is blocked and results in the formation of scar tissue. As the body’s immune system responds, inflammatory signaling causes an increase in both scar tissue size and the patient’s risk for further chronic heart failure. In order to reduce the risk of continued heart disease inflammatory signaling must be reduced. Stem cell therapies have the ability to alter the immune system’s pro-inflammatory signal. However, stem cell retention is limited due to blood flow shear. Gelatin methacrylate (GelMA) based coatings have been shown …

Assessment Of A Decentralized Solution For Waste Plastic Management In Developing Regions, Chandniben Ashishkumar Joshi

Theses and Dissertations--Chemical and Materials Engineering

Rapid population growth, urbanization and availability of pre-packaged consumer goods have led to increased generation and consumption of plastic – so much so that it has become ubiquitous in the environment. An affordable, durable, and lightweight material of construction, plastic is used in innumerable products in every country on earth. However, this explosion of consumption coupled with the material’s significantly low degradability have led to serious plastic accumulation challenges, which are now an imminent threat to terrestrial and marine species globally. These challenges are especially acute in developing countries, where capital and infrastructure constraints, poor governmental regulation and lack of …

Interactions Of Lignin Dimers With Engineered Surfaces And Model Cell Membranes For Design Of Lignin-Based Materials, Mahsa Moradipour

Theses and Dissertations--Chemical and Materials Engineering

Capitalizing on byproducts of industrial and agricultural economies is among the utmost goals of sustainability. Of particular interest for commercial upgrading is lignin, a phenolic biopolymer found in the cell walls of plants which is the second most abundant biopolymer on Earth after cellulose. Due to its heterogeneous structure, deconstructing lignin to selected small molecules for use as chemicals or advanced materials has been elusive. This work capitalizes on a “bottom up” approach to the synthesis of lignin oligomers of known bond chemistry to better understand their interfacial interactions.

The potential pharmacological mechanism of lignin deconstruction components and their toxicological …

Downhole Water Drainage From A Gas Reservoir For Water Dumpflood In An Underlying Oil Reservoir, Htet Myet Zin Naing

Chulalongkorn University Theses and Dissertations (Chula ETD)

For wells drilled in a bottom water-drive gas reservoir, water coning may lead to a considerable amount of water production which diminishes the gas recovery. If the gas reservoir has an oil reservoir underneath, a method called “Downhole Water Drain for Water Dumpflood” (DWDDF) can be performed to drain water from the aquifer underneath the gas reservoir and dump it into the oil reservoir to perform waterflooding. DWDDF technique can help increase gas production from the upper gas reservoir and oil production from the lower reservoir at the same time. In this study, a simple reservoir model having common rock …

Quality Control Of Chemical Grade Calcium Carbonate From Lopburi Limestone Deposit In Thailand, Pimpichcha Teawpanich

Chulalongkorn University Theses and Dissertations (Chula ETD)

Calcium carbonate (CaCO3) is naturally produced from calcite, limestone, chalk, and marble. It is being used as raw material in various industries (e.g., cement, plastic, paint, paper, and pharmaceutical industries). The low-grade CaCO3 samples obtained from a calcite plant at Khoktum Sub-district, Muang Lopburi District, Lopburi Province, Thailand were used in this study. These samples contain more than 98% of CaCO3 while Fe2O3 contents are higher than 0.1% and increased after finished the process. Because of this problem, the products could not be sold since lower Fe2O3 contents are required (e.g., ≤0.05% for filler grade and ≤ 0.1% for animal …

Effects Of Clay Minerals On Oil Recovery Mechanism In Low Salinity Waterflooding In Shaly-Sandstone Formation, Tri Yudha Putra

Chulalongkorn University Theses and Dissertations (Chula ETD)

Low Salinity Waterflooding (LSWF) is one of Enhanced Oil Recovery (EOR) techniques that are often mentioned nowadays. Several studies showed that injecting low salinity water leads to Multi-component Ion Exchange (MIE) which is one of oil recovery mechanisms provided by this technique. This study was performed to investigate the effects of specific clay mineral in rock and ion in injected water. First, representative clays were analytically tested to ensure their mineral compositions and the selected representative clays were tested by filtration with different water formulations to identify ionic capacities in MIE for each clay. Results obtained from filtration test and …

Sustainable Two-Step Minlp Heat Exchanger Network Synthesis With Practical Detailed Design, Thanawat Boonvaerojkul

Chulalongkorn University Theses and Dissertations (Chula ETD)

Due to sustainable development that focuses on energy conservation, decreasing emissions and environmental effect, the research of heat exchanger network synthesis (HENS) is still necessary and challenging. Most academic studies in the subject of HENS aim on reducing total annual cost (TAC) through optimal topology design without the detailed design costs of each heat exchanger in the network, resulting in conceptual HEN designs. Hence, the detailed design of shell and tube heat exchangers is recalculated for TAC and corrected area costs, including the pumping costs from overall pressure drop of heat exchangers. For a shell and tube heat exchanger, its …