Bioresource and Agricultural Engineering Commons^™

Error Analysis Of Stored Grain Inventory Determination, Aaron P. Turner, Michael D. Montross, Joshua J. Jackson, Samuel G. Mcneill, Mark E. Casada, Josephine M. Boac, Rumela Bhadra, Ronaldo G. Maghirang, Sidney A. Thompson

Biosystems and Agricultural Engineering Faculty Publications

Estimation of the quantity of stored grain is important for crop insurance, financial statements, and inventory control. Traditionally, the height of grain has been measured using weighted tape measures, and the volume is subsequently computed using standard geometric shapes (cylinders and cones) along with visual correction of the grain surface. Field measurements by four trained USDA Farm Service Agency and crop insurance agents on older farm-sized bins (8.2 to 11.0 m, or 27 to 36 ft, in diameter) resulted in standard deviations between 0.02 and 0.30 m for the equivalent height when the grain surface was not level. The largest …

Correlating Bulk Density (With Dockage) And Test Weight (Without Dockage) For Wheat Samples, Rumela Bhadra, Mark E. Casada, Josephine M. Boac, Aaron P. Turner, Sidney A. Thompson, Michael D. Montross, Ronaldo G. Maghirang, Samuel G. Mcneill

Biosystems and Agricultural Engineering Faculty Publications

In grain bins, the compaction of stored grain is caused by the overbearing pressure of the bulk material in the bin. To predict the amount of grain in the bin, compaction values must be determined based on the average bulk density (BD) of the stored material. However, BD is determined following the Federal Grain Inspection Service (FGIS) guidelines for measuring test weight (TW), which require that dockage be removed prior to measuring wheat TW. Thus, this creates a problem for predicting grain compaction and conducting inventory studies, because the average BD of the grain in a bin for these calculations …

As-Applied Estimation Of Volumetric Flow Rate From A Single Sprayer Nozzle Series Using Water-Sensitive Spray Cards, Michael P. Sama, John T. Evans, Aaron P. Turner, Surya Saket Dasika

Biosystems and Agricultural Engineering Faculty Publications

The objective of this study was to test the feasibility of using coverage measurements from water-sensitive spray cards to estimate the volumetric flow rate at an individual sprayer nozzle. TeeJet VisiFlow Even Flat Spray Tips were selected due to their uniform distribution of coverage. Spray distribution for each nozzle was validated using a spray patternator table with 2.5 cm sampling widths. A rotary test fixture translated water-sensitive spray cards through the spray dispersion (water at ambient conditions) at a constant angular velocity and a radius of 1.2 m. The test fixture measured volumetric flow and pressure at the nozzle and …

A Review Of Non-Destructive Methods For Detection Of Insect Infestation In Fruits And Vegetables, Nader Ekramirad, Akinbode A. Adedeji, Reza Alimardani

Biosystems and Agricultural Engineering Faculty Publications

Insect damage in fruits and vegetables cause major production and economic losses in the agriculture and food industry worldwide. Monitoring of internal quality and detection of insect infestation in fruits and vegetables is critical for sustainable agriculture. Early detection of an infestation in fruits can facilitate the control of insects and the quarantine operations through proper post-harvest management strategies and can improve productivity. The present review recognizes the need for developing a rapid, cost-effective, and reliable insect infestation monitoring system that would lead to advancements in agriculture and food industry. In this paper, an overview of non-destructive detection insect damages …

Nozzle Sensor For In-System Chemical Concentration Monitoring, Joseph S. Dvorak, Timothy S. Stombaugh, Yongbo Wan

Biosystems and Agricultural Engineering Faculty Publications

Chemical concentration is a vital parameter for determining appropriate chemical application. This study describes the design and testing of a sensor that attempted to monitor concentration of chemicals upstream from each nozzle body. The sensor is based on an LED and photodiode pair. Its ability to detect chemical concentration within the main carrier was tested with a 2,4-D formulation, a glyphosate formulation, and a powdered Acid Blue 9 dye. The liquid herbicide formulations of glyphosate and 2,4-D were tested across common application concentrations of 0% to 12.5% by volume. The powdered dye produced a much stronger effect on the sensor …

Carbon Dioxide Adsorption Studies On Fly Ash Zeolites, Denitza Zgureva

Coal Combustion and Gasification Products Journal Archive

In this study, the potential of fly ash zeolites (FAZ) Linde (LTA) and faujasite (FAU) to adsorb carbon dioxide (CO2) was investigated in view of the results of implementation in postcombustion carbon-capture technologies. Adsorption isotherms of selected samples were measured at 273.15 K by a Micromeritics Tristar II 3020 surface analyzer. The highest adsorption capacity was obtained for FAZ with a FAU structure synthesized by a two-stage fusion hydrothermal process from fly ash (FA) that was composed of 65 wt% amorphous components. The adsorption capacity for this sample reached a value of 136.40 mg CO2/g FAZ at atmospheric pressure, a …

Analysis Of Scientific Investigations Related To Reclamation Of Surface Mining Control And Reclamation Act Permitted Coal Mines With Coal Combustion By-Products, Kimery C. Vories

Coal Combustion and Gasification Products Journal Archive

In the United states, the placement of coal combustion by-products (CCBs) (i.e., fly ash, bottom ash, boiler slag, flue gas desulfurization material, and fluidized bed combustion material) in coal mines has been an area of controversy. Federal and state governments, universities, the National Energy Technology Laboratory, and industrial research organizations have taken an active role in encouraging and promoting technological advances, research, and technology transfer related to the use of CCBs at coal mines. CCBs have been placed at Surface Mining Control and Reclamation Act of 1977 (SMCRA) permitted mines since 1977 to serve the following purposes: (1) a seal …

Coal Ash By-Product From Shanxi Province, China, For The Production Of Portland–Calcium Sulfoaluminate, Tristana Y. Duvallet, Thomas L. Robl, Kevin R. Henke, Yongmin Zhou, David Harris

Coal Combustion and Gasification Products Journal Archive

Twenty bulk samples were collected from ponded coal combustion ash in Shanxi Province, China, as part of an investigation of their beneficiation potential. The samples were shipped to the University of Kentucky, where they were chemically analyzed. The samples were highly consistent in chemistry, falling within the ASTM C-618 class F compositional range. The particle size of the ponded ash was relatively coarse, with only ,7% by weight on average, falling below 200 mesh (75 mm) particle size. The bulk of the material (.80%) was within 50 by 200 mesh (equivalent to 300 by 75 mm). X-ray diffraction investigation combined …

Effect Of Coal Fly Ash Leachate On The Bioluminescence Intensity Of Vibrio Fischeri, Shiro Ikeda, Irena Kostova, Hideaki Sekine, Yoshika Sekine

Coal Combustion and Gasification Products Journal Archive

Coal fly ash is a residue of coal-fired thermoelectric power plants (TPPs) and is mostly dumped in ash ponds or landfill sites, even though it potentially contains significant amounts of water-soluble hazardous contaminants. Bioassay using the bioluminescent bacterium *Vibrio fischeri* is known to be applicable for assessing the short-term and sublethal toxicity of complex mixtures without the need for precise chemical characterization. However, this type of bioassay is potentially adversely influenced by the pH-induced protein denaturation of cells. Because coal fly ash leachates often have alkaline or acidic properties, when applying the *V. fischeri*-based bioassay to the samples, we need …

Influence Of Coal-Fired Power Plant Emissions Regulations And Consequent Engineering Controls And Coal-Supply Modifications On Fly Ash Chemistry And Petrology: Examples From Kentucky Power Plants, Madison M. Hood, John G. Groppo, Michelle N. Johnston, James C. Hower, Herek L. Clack, Diego S. De Medeiros, Silvio R. Taffarel, Cesar M.N.L. Cutruneo, Luis F.O. Silva

Coal Combustion and Gasification Products Journal Archive

The chemistry and petrology of fly ash are controlled by a number of factors: (1) chemistry of the feed coal (and added fuels, such as petroleum coke, tires, biomass, etc.), (2) particle size of the fuel feed (controlled by pulverized fuel vs. cyclone combustion, maintenance of pulverizers, etc.), (3) design of the boiler and pollution-control system, and (4) temperature of the flue gas at the collection point. In general, for any electrostatic precipitator or baghouse system, the concentrations of volatile trace elements in fly ash will increase with a drop in the flue gas temperature and a decrease in the …

Object Detection For Agricultural And Construction Environments Using An Ultrasonic Sensor, Joseph S. Dvorak, Marvin L. Stone, Kelvin P. Self

Biosystems and Agricultural Engineering Faculty Publications

This study tested an ultrasonic sensor‘s ability to detect several objects commonly encountered in outdoor agricultural or construction environments: a water jug, a sheet of oriented strand board (OSB), a metal fence post, a human model, a wooden fence post, a Dracaena plant, a juniper plant, and a dog model. Tests were performed with each target object at distances from 0.01 to 3 m. Five tests were performed with each object at each location, and the sensor‘s ability to detect the object during each test was categorized as "undetected," "intermittent," "incorrect distance," "good." Rigid objects that presented a larger surface …

Recalibration Methodology To Compensate For Changing Fluid Properties In An Individual Nozzle Direct Injection System, Joe D. Luck, Scott A. Shearer, Brian D. Luck, Michael P. Sama

Biosystems and Agricultural Engineering Faculty Publications

Limited advancement of direct injection pesticide application systems has been made in recent years, which has hindered further commercialization of this technology. One approach to solving the lag and mixing issues typically associated with injection-based systems is high-pressure individual nozzle injection. However, accurate monitoring of the chemical concentrate flow rate can pose a challenge due to the high pressure, low flow, and changing viscosities of the fluid. A methodology was developed for recalibrating high-pressure chemical concentrate injectors to compensate for fluid property variations and evaluate the performance of this technique for operating injectors in an open-loop configuration. Specific objectives were …

Monitoring Yogurt Culture Fermentation And Predicting Fermentation Endpoint With Fluorescence Spectroscopy, Timothey P. Mains, Frederick Alan Payne, Michael P. Sama

Biosystems and Agricultural Engineering Faculty Publications

Determination of the endpoint of yogurt culture fermentation is a process parameter that could benefit from automation. The feasibility of using a fluorescence sensor technology based on 280 nm excitation and 350 nm emission to predict the endpoint of yogurt culture fermentation was investigated and compared with the endpoint prediction from a near-infrared (880 nm) light backscatter sensor. Yogurt cultures with three levels of milk solids (8%, 10%, and 12%) and three temperatures (40°C, 43°C, and 46°C) were tested with three replications in a 3 x 3 factorial design (n = 27). Prediction models were developed for each optical measurement …

Wetlands And Coastal Systems: Protecting And Restoring Valuable Ecosystems, Carmen T. Agouridis, Kyle R. Douglas-Mankin, Anna C. Linhoss, Aaron R. Mittelstet

Biosystems and Agricultural Engineering Faculty Publications

Wetlands and coastal systems are unique, highly productive, and often threatened landscapes that provide a host of services to both humans and the environment. This article introduces a five-article Wetlands and Coastal Systems Special Collection that evolved from a featured session at the 2015 ASABE Annual International Meeting in New Orleans, Louisiana. The Collection provides perspectives on tools and techniques for enhancing the protection and restoration of wetlands and coastal systems with emphasis on vegetation, hydrology, water quality, and planning. Topics span the Florida Everglades (two articles) and Virginia floodplain (one article) wetland systems and include remote sensing (one article) …

Hybrid Diesel-Electric Drivetrain For Small Agricultural Field Machines, Joseph Jackson, Joseph S. Dvorak

Biosystems and Agricultural Engineering Faculty Publications

In this project, a series electric drivetrain sized for small agricultural machinery was developed and tested. Electric drives have noted benefits in simplicity, controllability, integration with other electronics such as those that provide autonomous action, and in efficiency over a wide operating range. Their biggest drawback for agricultural use is the limited capacity of electrical energy storage. A series hybrid drivetrain provides a method to overcome these capacity constraints through the use of chemical energy storage. The series hybrid drivetrain in this research was designed using well-established components. It consisted of a diesel-electric generator, a lead acid battery pack, a …

Using Wii Technology And Experiential Learning To Teach Newtonian Mechanics To Rural Middle School Students, Joseph S. Dvorak, Tanya C. Franke-Dvorak, Shane Neel

Biosystems and Agricultural Engineering Faculty Publications

This study looked at the effects of an experiential learning activity using the accelerometer in the Wii Remote to teach basic concepts of Newtonian mechanics, e.g., acceleration, to middle school students in a rural school district. A major prerequisite for students at the mid-level in biosystems engineering programs is that they have a good knowledge of basic science, including physics. Education in these concepts must begin before college, such as at the middle school level. Improvements in science education are vitally necessary to achieve essential learning outcomes for middle school students in the U.S. and to prepare these students for …

Effects Of Chemical Amendments To Swine Manure On Runoff Quality, Elizabeth L. Bullock, Dwayne R. Edwards, Phillip A. Moore Jr., Richard S. Gates

Biosystems and Agricultural Engineering Faculty Publications

Land-applied swine manure can be an environmental concern when runoff losses of manure constituents occur. The use of chemical amendments to mitigate these losses has been investigated for poultry litter, but materials such as swine manure have received less attention in this context, particularly at the plot scale or larger. The objective of this experiment was to evaluate the impacts of aluminum sulfate (alum; Al₂(SO₄)₃), aluminum chloride (AlCl₃), and ferric chloride (FeCl₃) addition on runoff of selected constituents of land-applied swine manure. Manure was collected from feeder pigs fed a …

Methods For Calculating Relative Cross-Track Error For Asabe/Iso Standard 12188-2 From Discrete Measurements, Joseph D. Rounsaville, Joseph S. Dvorak, Timothy S. Stombaugh

Biosystems and Agricultural Engineering Faculty Publications

ASABE/ISO Standard 12188-2 provides test procedures for positioning and guidance systems in agricultural vehicles during straight and level travel. While the standard provides excellent descriptions of test procedures, it does not provide detail on methods to carry out the calculations necessary to calculate relative cross-track error (XTE), which is the primary error statistic used to judge accuracy. Given the travel speed and sampling constraints provided by the standard, the difference between a method based on nearest points or one based on path interpolation could hypothetically be as large as 25 cm. In this project, the standard was used to estimate …

Effectiveness Of Biochar Addition In Reducing Concentrations Of Selected Nutrients And Bacteria In Runoff, Rachel Williams

Theses and Dissertations--Biosystems and Agricultural Engineering

Land application and storage of horse manure and municipal sludge can increase nutrient and bacteria concentrations in runoff. Biochar increases soil nutrient retention when used as a soil amendment. The objectives of this study were to determine if biochar, when mixed with horse manure or sludge, affects runoff concentrations of total Kjehldahl nitrogen (TKN), ammonia-nitrogen (NH3-N), nitrate (NO3-N), total phosphorus (TP), dissolved phosphorus (DP), total suspended solids (TSS), chemical oxygen demand (COD), and fecal coliforms (FC). Horse manure and sludge were applied to 2.4 x 6.1 m fescue plots (six each), with three plots of each material amended with 5-8% …

Evaluation Of Flocculation, Sedimentation, And Filtration For Dewatering Of Algal Biomass, Nicholas A. Rhea

Theses and Dissertations--Biosystems and Agricultural Engineering

Algae can be used as a feedstock for agricultural fertilizers, livestock/poultry feeds, anaerobic digestion, and biofuel production. Regardless of the end product, water removal is necessary and difficult to do cost effectively. For each product the requirements for moisture content (or solids content) vary, such that a desirable water removal strategy would need to be adaptable to varying levels of water removal. Flocculation, with sedimentation and drying was evaluated as a possible strategy for algae dewatering. Anionic and nonionic flocculants are known to be ineffective at flocculating algal culture, which was confirmed for this case by electro-osmotic flow testing of …

Recirculating Calcium Hydroxide Solution: A Practical Choice For On-Farm High Solids Lignocellulose Pretreatment, William S. Sympson Jr.

Theses and Dissertations--Biosystems and Agricultural Engineering

Pretreatment is a necessary step in the utilization of lignocellulosic biomass for biochemical conversion to higher value products. There are multiple chemical choices for industrial settings, however on-farm choices are constrained to near ambient conditions with minimal specialized equipment, training, and limited waste disposal. Calcium hydroxide (lime) is suitable for on-farm use. This work presents the novel idea of pretreating biomass by recirculating a filtered, saturated lime solution in an up-flow, high solids (14-16% w/w) configuration at ambient conditions. In this system, lime solids were efficiently consumed, post-pretreatment washing of substrate did not significantly improve glucose yields, and energy and …

Heat And Mass Transfer In Baled Switchgrass For Storage And Bioconversion Applications, Drew F. Schiavone

Theses and Dissertations--Biosystems and Agricultural Engineering

The temperature and moisture content of biomass feedstocks both play a critical role in minimizing storage and transportation costs, achieving effective bioconversion, and developing relevant postharvest quality models. Hence, this study characterizes the heat and mass transfer occurring within baled switchgrass through the development of a mathematical model describing the relevant thermal and physical properties of this specific substrate. This mathematical model accounts for the effect of internal heat generation and temperature-induced free convection within the material in order to improve prediction accuracy. Inclusion of these terms is considered novel in terms of similar biomass models.

Two disparate length scales, …

Long-Term Effects Of Forestry Best Management Practices On Hydrology And Water Chemistry In Three Appalchian Headwater Catchments, Kameryn I. Wright

Theses and Dissertations--Biosystems and Agricultural Engineering

In 1982, a study was initiated in the Field Branch watershed, in the University of Kentucky’s Robinson Forest, to evaluate forestry best management practice (BMP) effectiveness after intensive harvesting. The study utilized a paired watershed approach on three adjacent Field Branch subcatchments. One subcatchment was left as the control, one had BMPs implemented (including a 50-ft undisturbed buffer along the stream), and one was clear-cut to the stream’s banks without the use of BMPs (i.e. logger’s choice). Prior research has shown that logging can negatively impact watershed functions by altering stream hydrology, geomorphology, water quality, and instream habitat. Thus, the …

Induction Of Cellulase In High Solids Cultivation Of Trichoderma Reesei For Enhanced Enzymatic Hydrolysis Of Lignocellulose, Danielle Empson

Theses and Dissertations--Biosystems and Agricultural Engineering

This project aimed investigated cellulase in-situ production for large-scale on-farm production of lignocellulosic biofuel. Cellulase activity and glucose released by T. reesei with corn stover and wheat bran as co-substrates for solid state cultivation (SSC) were examined. Co-cultivation has previously increased T. reesei cellulase, but corn stover and wheat bran have not been co-cultivated (Dhillon, Oberoi et al. 2011). This work compared cellulase activity and glucose concentration of corn stover co-cultivated with 0-40% wheat bran in high solids. Samples with at least 20% wheat bran exhibited increased cellulase activity. However, the average glucose concentration without wheat bran was 3.29 g/L …

Development Of Regional And Hydraulic Geometry Curves For The Eastern Kentucky Coalfields, Ashlan Berry

Theses and Dissertations--Biosystems and Agricultural Engineering

Regional curves and hydraulic geometry curves relate bankfull channel dimensions to drainage area and bankfull discharge, respectively. These curves are used in the natural channel design process to help identify bankfull and to estimate bankfull dimensions of the design channel. Nineteen streams were surveyed to determine their bankfull parameters (cross-sectional area, width, mean depth, discharge, slope, and Manning’s n), along with 27 streams previously surveyed in other studies. The data were used to create regional and hydraulic geometry curves for three hydrologic landscape regions (HLR 9, HLR 11, and HLR 16, individually) in the Eastern Kentucky Coalfields (EKC) as well …

Automated Solid-Substrate Cultivation Of The Anaerobic Bacterium Clostridium Thermocellum, Mathew J. Ruwaya

Theses and Dissertations--Biosystems and Agricultural Engineering

The organism Clostridium thermocellum grows on cellulosic substrates and produces ethanol, acetate, lactate, formic acid, and CO₂. The organic acids produced alter the growth environment in which the bacteria grows and ultimately inhibit bacterial growth. One method which has been used successfully to maintain the system at acceptable growth conditions is to intermittently flush out the spent media and metabolic products and replace with new fermentation media. Our goal was to design and build an automated system that will automatically flush the spent media from the growing culture and resupply new media without manual intervention. An automated control …

Development And Preliminary Evaluation Of A Spray Deposition Sensing System For Improving Pesticide Application, Melissa A. Kesterson, Joe D. Luck, Michael P. Sama

Biosystems and Agricultural Engineering Faculty Publications

An electronic, resistance-based sensor array and data acquisition system was developed to measure spray deposition from hydraulic nozzles. The sensor surface consisted of several parallel tin plated copper traces of varying widths with varying gap widths. The system contained an embedded microprocessor to monitor output voltage corresponding to spray deposition every second. In addition, a wireless module was used to transmit the voltage values to a remote laptop. Tests were conducted in two stages to evaluate the performance of the sensor array in an attempt to quantify the spray deposition. Initial tests utilized manual droplet placement on the sensor surface …

Scalable Control Architecture For Variable-Rate Turn Compensation, Michael P. Sama, Joe D. Luck, Timothy S. Stombaugh

Biosystems and Agricultural Engineering Faculty Publications

The objective of this study was to determine if a CAN bus could be used to implement variable-rate turn compensation in a manner that is scalable by encoding application rates for an entire implement into a single data message. A variable-rate turn compensation test fixture was developed that used a CAN bus to communicate application rates to 16 individual nodes using a 2-byte data message (80-bit extended identifier CAN messages). The system assumed that the physical structure of an implement was linear and that the control nodes were equally spaced. Application rates for the outer-most nodes were broadcasted and the …

Creating A National Coalition To Address Tractor Overturn Fatalities., Pamela J. Tinc, Paul D. Ayers, John J. May, Mark A. Purschwitz, Julie A. Sorensen

Biosystems and Agricultural Engineering Faculty Publications

Tractor overturns continue to be the leading cause of death on U.S. farms. While rollover protective structures (ROPS) are effective in preventing these fatalities, they are underutilized due to a number of barriers. Past programs in the U.S. and abroad have targeted this area of agricultural safety; however, a national program is not yet in place for U.S. farmers. This study seeks to build a national partnership to address tractor overturn fatalities by increasing the number of tractors with ROPS. A diverse, multisector steering committee has been organized and is working together using Whole System in a Room methods. This …

Multistage Concentration Of Cenospheres In Fly Ash Using The Inverted Reflux Classifier, A. Kiani, J. Zhou, K.P. Galvin

Coal Combustion and Gasification Products Journal Archive

Cenospheres are one of the most valuable components found in the fly ash waste of coal-fired power stations, consisting of hollow, aluminosilicate spherical shells and offering very low bulk density, high strength, and high thermal resistance. Although wet processing methods offer the best prospect for achieving recovery and concentration of the cenospheres, significant impediments remain for achieving satisfactory economics. This work was concerned with the recovery and concentration of cenospheres from fly ash using a novel system, the inverted reflux classifier (IRC), covering single and multistage processing. The system consists of a series of parallel inclined channels mounted underneath an …