Bioresource and Agricultural Engineering Commons^™

Evaluating Ventilation Rates Based On New Heat And Moisture Production Data For Swine Production, Yanxi Lu, Morgan D. Hayes, John P. Stinn, Tami M. Brown-Brandl, Hongwei Xin

Biosystems and Agricultural Engineering Faculty Publications

Heat and moisture production (HMP) rates of animals are used for calculation of ventilation rate (VR) in animal housing. New swine HMP data revealed considerable differences from previously reported data. This project determined new design VRs and evaluated differences from previously recommended VRs. The swine production stages evaluated included gestation, farrowing, nursery, growing, and finishing. The ranges of ambient temperature and ambient relative humidity (RH) evaluated for VR were -25°C to 15°C in 10°C increments and 15% to 75% in 15% increments, respectively. Indoor set points for temperature and RH were, respectively, 15°C, 20°C, 25°C and 60%, 70%, 80% for …

Evaluation Of Flocculation, Sedimentation, And Filtration For Dewatering Of Scenedesmus Algae, Nicholas A. Rhea, Jack Groppo, Czarena Crofcheck

Biosystems and Agricultural Engineering Faculty Publications

Algae can be used as a feedstock for agricultural fertilizers, livestock and poultry feeds, anaerobic digestion, and biofuel production. For each end product, the requirements for moisture content (or solids content) vary, such that a desirable water removal strategy needs to be adaptable to varying levels of water removal. Flocculation, sedimentation, and filtration were evaluated as possible strategies for thickening and dewatering of algae. The goal of this study was to validate that algae cells treated by such means could be processed by vacuum belt filters and to determine the conditions under which the solids content could be increased to …

Effects Of Biochar Treatment Of Municipal Biosolids And Horse Manure On Quality Of Runoff From Fescue Plots, Rachel Williams, Dwayne R. Edwards

Biosystems and Agricultural Engineering Faculty Publications

Land-applied horse manure and municipal biosolids can increase nutrient and bacteria concentrations in runoff. Biochar has been demonstrated to have beneficial impacts on nutrient retention and runoff quality when used to treat other land-applied organic soil amendments (e.g., poultry manure). The objective of this study was to evaluate the effects of biochar addition to horse manure and municipal biosolids on runoff concentrations of nutrients and fecal coliforms. Biochar was added at 5% to 8% (wet basis) to horse manure and biosolids that were applied to 2.4 m x 6.1 m fescue plots followed by application of simulated rainfall (102 mm …

Geopolymerization Of Coal Ash To Produce Cementless Binders, Hamid Akbari, Robert Mensah-Biney, Jonathan Simms

Coal Combustion and Gasification Products Journal Archive

The main objective of this study was to evaluate geopolymer concrete made from coal combustion by-products, disposed of in landfills, as a potential substitute for the ordinary Portland cement (OPC), which is responsible for 5-8% of the total CO2 emissions in the world. In this study, a coal fly ash sample from the Carolinas was used in a chemical process known as geopolymerization to produce a “geopolymer” binder. The developed geopolymer binder could competently substitute the OPC binder in regular concrete applications. An experimental design program was conducted to optimize parameters of the geopolymerization affecting the strength of the final …

Groundwater Monitoring And Data Analysis Under The Coal Combustion Residuals Rule, Bruce Hensel

Coal Combustion and Gasification Products Journal Archive

No abstract provided.

Ponded And Landfilled Fly Ash As A Source Of Rare Earth Elements From A Kentucky Power Plant, James C. Hower, John G. Groppo, Kevin R. Henke, Uschi M. Graham, Madison M. Hood, Prakash Joshi, Dorin V. Preda

Coal Combustion and Gasification Products Journal Archive

Twenty samples, with one composite sample built out of the 20 individual samples, of ponded ash were collected at a Kentucky power plant. The coal feed throughout the history of the power plant was central eastern Kentucky low- to moderate-S high volatile A bituminous coal. The pond was in the process of being excavated, with the ash moved to a landfill on another company property. In spite of the long history of the pond and the expected variation in coal supply, and perhaps because of the mixing due to the excavation, there is little variation in ash-basis rare earth elements …

Rare Earth Element Distribution In Fly Ash Derived From The Fire Clay Coal, Kentucky, Madison M. Hood, Ross K. Taggart, Ryan C. Smith, Heileen Hsu-Kim, Kevin R. Henke, Uschi Graham, John G. Groppo, Jason M. Unrine, James C. Hower

Coal Combustion and Gasification Products Journal Archive

Fly ash was collected from individual mechanical and electrostatic precipitator (ESP) hoppers at a 130-MW pulverized-coal utility unit burning a southeastern Kentucky moderate- to high-S Pennsylvanian Fire Clay coal. The fly ash particle size is generally similar within each row of the mechanical and ESP hoppers, with the mean particle diameter decreasing from >36 μmin the mechanical hoppers to 6 μm in the last ESP row. Rare earth element (REE)–bearing phases occur within fine minerals and, possibly, as part of the fly ash glass phase. Transmission electron microscopy was used to identify Y-Ce-Nd-La–bearing regions within a glassy matrix. Y- and …

The Relative Impact Framework For Evaluating Coal Combustion Residual Surface Impoundment Closure Options: Applications And Lessons Learned, Ari S. Lewis, Andrew B. Bittner

Coal Combustion and Gasification Products Journal Archive

In response to the U.S. Environmental Protection Agency’s new rule regarding the disposal of coal combustion residuals (CCRs), many utilities need to re-examine their waste disposal practices and make decisions regarding if and how unlined surface impoundments (SIs) should be closed. The two primary options for closing SIs are in-place closure, with capping and engineering controls, and excavation of the CCR for transport to and re-disposal in a lined landfill. To help inform closure option decisions, we supported the Electric Power Research Institute’s development of a practical, science-based decision framework that comprehensively evaluates the potential impacts to human health and …

Stored Grain Volume Measurement Using A Low Density Point Cloud, Aaron P. Turner, Joshua J. Jackson, Nicole K. Koeninger, Samuel G. Mcneill, Michael D. Montross, Mark E. Casada, Josephine M. Boac, Rumela Bhadra, Ronaldo G. Maghirang, Sidney A. Thompson

Biosystems and Agricultural Engineering Faculty Publications

This technical note presents the development of a new apparatus and data processing method to accurately estimate the volume of stored grain in a bin. Specifically, it was developed to account for the variability in surface topography that can occur in large diameter bins when partially unloaded. This was accomplished using a laser distance meter to create a low density point cloud, from which a surface was interpolated using ArcMap geoprocessing tools. The manually controlled and portable system was designed to hold the laser distance meter and provided a common reference point. The data from the laser distance meter was …

Fourth-Generation Fan Assessment Numeration System (Fans) Design And Performance Specifications, Michael P. Sama, George B. Day, Laura M. Pepple, Richard S. Gates

Biosystems and Agricultural Engineering Faculty Publications

The Fan Assessment Numeration System (FANS) is a measurement device for generating ventilation fan performance curves. Three different-sized FANS currently exist for assessing ventilation fans commonly used in poultry and livestock housing systems. All FANS consist of an array of anemometers inside an aluminum shroud that traverse the inlet or outlet of a ventilation fan. The FANS design has been updated several times since its inception and is currently in its fourth-generation (G4). The current design iteration (FANS-G4) is reported in this article with an emphasis on the hardware and software control, data acquisition systems, and operational reliability. Six FANS-G4 …

A Method For Reflectance Index Wavelength Selection From Moisture-Controlled Soil And Crop Residue Samples, Ali Hamidisepehr, Michael P. Sama, Aaron P. Turner, Ole O. Wendroth

Biosystems and Agricultural Engineering Faculty Publications

Reflectance indices are a method for reducing the dimensionality of spectral measurements used to quantify material properties. Choosing the optimal wavelengths for developing an index based on a given material and property of interest is made difficult by the large number of wavelengths typically available to choose from and the lack of homogeneity when remotely sensing agricultural materials. This study aimed to determine the feasibility of using a low-cost method for sensing the moisture content of background materials in traditional crop remote sensing. Moisture-controlled soil and wheat stalk residue samples were measured at varying heights using a reflectance probe connected …

Evaluating A New Shade For Feedlot Cattle Performance And Heat Stress, Morgan D. Hayes, Tami M. Brown-Brandl, Roger A. Eigenberg, Larry A. Kuehn, R. Mark Thallman

Biosystems and Agricultural Engineering Faculty Publications

Heat stress in cattle results in decreased feed intake, lower daily gain, and potentially death in susceptible animals under intense conditions. A study was carried out during the summer of 2013 at the USDA-ARS U.S. Meat Animal Research Center feedlot evaluating the impact of shade on environmental conditions and cattle performance. A novel two-tiered shade was used in half of the 14 pens, each holding 30 animals. The shades were designed to reduce solar heat load by 40% to 60% and to provide traveling shade across the pen, providing varied amounts of shade area as well as varied solar reduction …

Equilibrium Moisture Content Of Kabuli, Chickpea, Black Sesame, And White Sesame Seeds, Paul R. Armstrong, Elizabeth B. Maghirang, Bhadriraju Subramanyam, Samuel G. Mcneill

Biosystems and Agricultural Engineering Faculty Publications

Sesame and chickpea are important crops in Ethiopia because both are major export crops that generate much revenue for both small farmers and the country as a whole. However, there is a lack of information about the fundamental equilibrium moisture content (EMC) relationships among these crops, which would help facilitate better monitoring and storage. Therefore, EMC adsorption and desorption prediction models based on temperature (T) and relative humidity (RH) were developed for the modified Chung-Pfost and modified Henderson models for Kabuli chickpea (KC), black sesame (BS), and white sesame (WS) seeds. The samples for conducting the adsorption and desorption tests …

Toward Biochemical Conversion Of Lignocellulose On-Farm: Pretreatment And Hydrolysis Of Corn Stover In Situ, Alicia A. Modenbach, Sue E. Nokes, Michael D. Montross, Barbara L. Knutson

Biosystems and Agricultural Engineering Faculty Publications

High-solids lignocellulosic pretreatment using NaOH followed by high-solids enzymatic hydrolysis was evaluated for an on-farm biochemical conversion process. Increasing the solids loadings for these processes has the potential for increasing glucose concentrations and downstream ethanol production; however, sequential processing at high-solids loading similar to an on-farm cellulose conversion system has not been studied. This research quantified the effects of high-solids pretreatment with NaOH and subsequent high-solids enzymatic hydrolysis on cellulose conversion. As expected, conversion efficiency was reduced; however, the highest glucose concentration (40.2 g L^-1), and therefore the highest potential ethanol concentration, resulted from the high-solids combined pretreatment …

Impact Of Climate Change On Extreme Hydrological Events In The Kentucky River Basin, Somsubhra Chattopadhyay

Theses and Dissertations--Biosystems and Agricultural Engineering

Anthropogenic activities including urbanization, rapid industrialization, deforestation and burning of fossil fuels are broadly agreed on as primary causes for ongoing climate change. Scientists agree that climate change over the next century will continue to impact water resources with serious implications including storm surge flooding and a sea level rise projected for North America. To date, the majority of climate change studies conducted across the globe have been for large-sized watersheds; more attention is required to assess the impact of climate change on smaller watersheds, which can help to better frame sustainable water management strategies.

In the first of three …

Fractionation And Characterization Of Lignin Streams From Genetically Engineered Switchgrass, Enshi Liu

Theses and Dissertations--Biosystems and Agricultural Engineering

Development of biomass feedstocks with desirable traits for cost-effective conversion is one of the main focus areas in biofuels research. As suggested by techno-economic analyses, the success of a lignocellulose-based biorefinery largely relies on the utilization of lignin to generate value-added products, i.e. fuels and chemicals. The fate of lignin and its structural/compositional changes during pretreatment have received increasing attention; however, the effect of genetic modification on the fractionation, depolymerization and catalytic upgrading of lignin from genetically engineered plants is not well understood. This study aims to fractionate and characterize the lignin streams from a wild-type and two genetically engineered …

Relative Cross Track Error Calculations In Asabe/Iso 12188-2:2012 And Power/Energy Analysis Using A 20 Hp Tractor On A Fully Electric Drivetrain, Joseph D. Rounsaville

Theses and Dissertations--Biosystems and Agricultural Engineering

ASABE/ISO Standard 12188-2 provides test procedures for positioning and guidance systems in agricultural vehicles during straight and level travel. The standard provides excellent descriptions of test procedures, however it does not provide detail on methods to carry out the calculations necessary to calculate relative cross-track error (XTE), which is the primary measurement used to judge accuracy of the system. The standard was used to estimate the guidance accuracy of a relatively low-accuracy vehicle at 1.25 and 0.5 m s^-1. At 1.25 m s^-1, a nearest point calculation overestimated mean XTE by 0.8 cm, or 8.2%. The …

Using The Vehicle Routing Problem (Vrp) To Provide Logistics Solutions In Agriculture, Hasan Seyyedhasani

Theses and Dissertations--Biosystems and Agricultural Engineering

Agricultural producers consider utilizing multiple machines to reduce field completion times for improving effective field capacity. Using a number of smaller machines rather than a single big machine also has benefits such as sustainability via less compaction risk, redundancy in the event of an equipment failure, and more flexibility in machinery management. However, machinery management is complicated due to logistics issues.

In this work, the allocation and ordering of field paths among a number of available machines have been transformed into a solvable Vehicle Routing Problem (VRP). A basic heuristic algorithm (a modified form of the Clarke-Wright algorithm) and a …

Capture And Recycle Of Industrial Co2 Emissions Using Mircoalgae, Michael H. Wilson, Daniel T. Mohler, John G. Groppo, Thomas E. Grubbs, Stephanie Kesner, E. Molly Frazar, Aubrey Shea, Czarena L. Crofcheck, Mark Crocker

Center for Applied Energy Research Faculty and Staff Publications

A novel cyclic flow photobioreactor (PBR) for the capture and recycle of CO₂ using microalgae was designed and deployed at a coal-fired power plant (Duke Energy’s East Bend Station). The PBR was operated continuously during the period May–September 2015, during which algae productivity of typically 0.1–0.2 g/(L day) was obtained. Maximum CO₂ capture efficiency was achieved during peak sunlight hours, the largest recorded CO₂ emission reduction corresponding to a value of 81 % (using a sparge time of 5 s/min). On average, CO₂ capture efficiency during daylight hours was 44 %. The PBR at East Bend …

The Confounding Effects Of Particle Size And Substrate Bulk Density On Phanerochaete Chrysosporium Pretreatment On Panicum Virgatum, Amanda N. Hickman, Sue E. Nokes, William S. Sympson, Mathew J. Ruwaya, Michael D. Montross, Barbara L. Knutson

Biosystems and Agricultural Engineering Faculty Publications

Phanerochaete chrysosporium treatment is less effective as a biological pretreatment on feedstock with larger particle sizes. We hypothesized that the improved effectiveness of the pretreatment when smaller particle sizes are used may be due to the inherently higher bulk density with smaller particle sizes. The effects of substrate bulk density and particle size on the efficacy of P. chrysosporium pretreatment of switchgrass (Panicum virgatum) was tested experimentally. Phanerochaete chrysosporium was grown on senesced switchgrass (2 different particle sizes) with various bulk densities. In all treatments, the fungal-pretreated samples released more glucose during enzymatic saccharification than the control sample. …

Physicochemical And Functional Properties Of Extruded Sorghum‐Based Bean Analog, Akinbode A. Adedeji, Michael V. Joseph, Brian Platter, Sajid Alavi

Biosystems and Agricultural Engineering Faculty Publications

The objective of this study was to develop and evaluate the physicochemical and functional properties of a bean like product made from cold extrusion of sorghum, soy and wheat flours. Formulated samples comprised of sorghum (25–70%), wheat (0–35%) and soy (30–50%) flours. The degree of gelatinization ranged from 54.1 to 93.6%. Pasting curves showed minimal starch damage with peak and final viscosities in the range of 456.0–1138.5 and 297–584 cP, respectively. Textural properties of the extrudates were significantly impacted by starch content and cooking time. There was significant cooking loss due to poor binding properties of the extrudates. Cooking the …

On-Farm Integrated High-Solids Processing System For Biomass, Sue E. Nokes, Bert C. Lynn, Stephen E. Rankin, Barbara L. Knutson, Michael D. Montross, Michael D. Flythe

Biosystems and Agricultural Engineering Faculty Patents

A method for on-farm processing a biomass feedstock into a useful industrial chemicals includes the steps of (a) delignifying the biomass feedstock to produce a delignified biomass, (b) subjecting the deliguified biomass to cellulase production, (c) subjecting the deliguified biomass with attached cellulase to simultaneous cellulolytic and solventogenic reactions to produce useful industrial chemicals (d) collecting and separating the useful industrial chemical from the fermentation broth and (e) collecting the fermentation residues.

Mobile Device-Based Location Services Accuracy, Hasan Seyyedhasani, Joseph S. Dvorak, Michael P. Sama, Tim S. Stombaugh

Biosystems and Agricultural Engineering Faculty Publications

The objective of this study was to characterize the expected position accuracy when using popular mobile devices for location-based agricultural decision-making activities. This study utilized Android-based Nexus 7 tablets and tested the operation of the three location services available on this system in a 24-h fixed location test and a shorter duration multiple location field test. In the 24-h test, the “network” location system had a measured error of 37.19 m while reporting an accuracy of 55.56 m. The “gps” location system had a measured error of 2.57 m and a reported accuracy of 3.20 m. Multiple tests were conducted …

Wet Grain Delivery Advice: A Previously Impossible Extension Challenge Solved Through App Technology, Joseph S. Dvorak, Sam Mcneill, Clint Hardy

Biosystems and Agricultural Engineering Faculty Publications

The delivery of wet grain during harvest is a complex and constantly changing problem about which Extension professionals have been unable to offer more than general advice. By capitalizing on important characteristics of mobile devices, a new app enables producers to fully benefit from detailed information universities have generated on grain drying and costs associated with delivery of grain to different locales. Development of such an app demonstrates the power of apps and mobile devices in allowing Extension to deliver previously unattainable services to its clientele.

Application Of Recycled Media And Algae-Based Anaerobic Digestate In Scenedesmus Cultivation, Xinyi E, Czarena Crofcheck, Mark Crocker

Biosystems and Agricultural Engineering Faculty Publications

To make large-algae cultivation systems sustainable, commercial fertilizer inputs should be minimized. One means of achieving this is to maximize the recycle of nutrients used in algae cultivation. In addition to recycling nutrient-containing water from algae harvesting and dewatering, after harvesting algal biomass can be used as a substrate for anaerobic digestion, which can then generate mineralized nutrients to be used for further cultivation. In this study, the effect of recycling media and using mineralized nutrients during Scenedesmus cultivation was investigated. The recycled media proved to be able to support cell growth with nutrient replenishment, and it could be recycled …

Long-Term Trend Analysis Of Precipitation And Air Temperature For Kentucky, United States, Somsubhra Chattopadhyay, Dwayne R. Edwards

Biosystems and Agricultural Engineering Faculty Publications

Variation in quantities such as precipitation and temperature is often assessed by detecting and characterizing trends in available meteorological data. The objective of this study was to determine the long-term trends in annual precipitation and mean annual air temperature for the state of Kentucky. Non-parametric statistical tests were applied to homogenized and (as needed) pre-whitened annual series of precipitation and mean air temperature during 1950–2010. Significant trends in annual precipitation were detected (both positive, averaging 4.1 mm/year) for only two of the 60 precipitation-homogenous weather stations (Calloway and Carlisle counties in rural western Kentucky). Only three of the 42 temperature-homogenous …

Switchgrass (Panicum Virgatum) Fermentation By Clostridium Thermocellum And Clostridium Saccharoperbutylacetonicum Sequential Culture In A Continuous Flow Reactor, Noelia M. Elia, Sue E. Nokes, Michael D. Flythe

Biosystems and Agricultural Engineering Faculty Publications

The study was conducted to evaluate fermentation by Clostridium thermocellum and C. saccharoperbutylacetonicum in a continuous-flow, high-solids reactor. Liquid medium was continuously flowed through switchgrass (2 mm particle size) at one of three flow rates: 83.33 mL h⁻¹ (2 L d⁻¹), 41.66 mL h⁻¹ (1 L d⁻¹), and 20.833 mL h⁻¹ (0.5 L d⁻¹). The cellulolytic phase was initiated by culturing C. thermocellum (63 °C, 24 h). The temperature was decreased (35) and C. saccharoperbutylacetonicum was inoculated. When metabolism decreased (96 h), the temperature was increased (63 °C; 24 h) …

Characteristics And Composition Of Magnetic Concentrates Of Bottom Ash Samples From Two Types Of Thermal Power Plants In Odisha, India, Subir Kumar Das

Coal Combustion and Gasification Products Journal Archive

Aluminosilicate bottom ash samples were examined from a thermal power plant in Talcher (sample NT-BA) and in Sambalpur (sample HR-BA), Odisha, India, to determine magnetic particle morphology, internal structure, mineralogy, mineral chemistry, ash fusion temperature, chemical composition, and leaching characteristics. The Talcher plant has adopted pulverized coal combustion, whereas the Sambalpur plant uses circulating fluidized bed combustion boiler technology. For NT-BA, most magnetic particles were ideal solid spheres (ferrospheres) with diverse morphological features (smooth, granular, dendritic and skeletal, porous, spotted, polygonal, and hollow [magnetite cenospheres]). For HR-BA, magnetic particles were subspherical, oval, and angular and showed widely varying surface morphologies, …

Distribution Of Uranium And Other Radionuclides In Coal And Coal Combustion Products, With Discussion Of Occurrences Of Combustion Products In Kentucky Power Plants, James C. Hower, Shifeng Dai, Greta Eskenazy

Coal Combustion and Gasification Products Journal Archive

Uranium and thorium are part of the mineral assemblages within coals. Uranium can also occur in organic associations, particularly in low-rank coals. While the average U concentration in coals is 2.9 ppm for low-rank coals and 1.9 ppm for bituminous and higher rank coals, high concentrations are known from certain low-rank and thin coals and from coals in areas associated with U mineralization. No high-U coals are mined for power production in the United States. Uranium and Th in coal combustion products are found in amounts more or less in proportion to their concentrations in the feed coal. Not being …

Modeling The Compressibility Behavior Of Hard Red Wheat Varieties, Aaron P. Turner, Michael D. Montross, Samuel G. Mcneill, Michael P. Sama, Mark E. Casada, Josephine M. Boac, Rumela Bhadra, Ronaldo G. Maghirang, Sidney A. Thompson

Biosystems and Agricultural Engineering Faculty Publications

The bulk density of grain in a storage structure varies vertically and horizontally due to the overburden pressure created by the cumulative weight of the overlying material. As the overburden pressure increases, the stored material compacts. This compaction is believed to be caused by rearrangement of kernels along with higher intergranular stress between particles, leading to kernel deformation. This compaction is of primary concern when estimating the amount of grain in a storage structure. In this comprehensive study, confined uniaxial compression tests were conducted on 27 different samples of hard red winter wheat, at three moisture levels, over the range …