Bioresource and Agricultural Engineering Commons^™

Development Of A Finite-Element Stored Grain Ecosystem Model, Michael D. Montross, Dirk E. Maier, Kamyar Haghighi

Biosystems and Agricultural Engineering Faculty Publications

An axisymmetric finite–element model was developed that predicts the heat, mass, and momentum transfer that occurred in upright corrugated steel storage structures due to conduction, diffusion, and natural convection using realistic boundary conditions. Weather data that included hourly total solar radiation, wind speed, ambient temperature, and relative humidity were used to model the temperature, moisture content, dry matter loss, and maize weevil development during storage with no aeration, and with ambient and chilled aeration. Periods of aeration were simulated assuming a uniform airflow rate through the grain mass. Heat and mass balances were used to calculate the temperature and absolute …

Validation Of A Finite-Element Stored Grain Ecosystem Model, Michael D. Montross, Dirk E. Maier, Kamyar Haghighi

Biosystems and Agricultural Engineering Faculty Publications

An axisymmetric finite–element model was validated with respect to predicting the heat, mass, and momentum transfer that occurred in upright corrugated–steel storage bins due to conduction, diffusion, and natural convection using realistic boundary conditions. Hourly weather data that included hourly total solar radiation, wind speed, ambient temperature, and relative humidity were used to model the corn temperature and moisture content during storage with no aeration, and with ambient and chilled aeration. Periods of aeration were simulated assuming a uniform airflow rate through the grain mass. Sixteen bins with a capacity of 11.7 t each and instrumented with temperature cables were …

A Reduced–Cost Mechanized System For Handling And Curing Mechanically–Harvested Burley Tobacco, Greg A. Camenisch, Larry G. Wells, Timothy D. Smith, George A. Duncan

Biosystems and Agricultural Engineering Faculty Publications

An experimental system was tested in which mechanically harvested burley tobacco plants placed onto steel slotted receivers were retrieved from a field, transported to a field curing structure, and placed onto the structure for air curing by a single worker. The system consisted of a tractor–towed, trailer mechanism that engaged and hoisted loads of approximately 360 burley plants of approximately 1 Mg mass. Ten slotted steel rails, 3.05 m long, holding 36 notched plants were placed onto parallel wooden beams suspended at a height of 2.13 m by wooden posts set in the ground. Burley tobacco was cured in this …

A Portable Rainfall Simulator For Plot–Scale Runoff Studies, J. Byron Humphry, Tommy C. Daniel, Dwayne R. Edwards, Andrew N. Sharpley

Biosystems and Agricultural Engineering Faculty Publications

Rainfall simulators have a long history of successful use in both laboratory and field investigations. Many plot–scale simulators, however, have been difficult to operate and transport in the field, especially in remote locations where water or electricity is unavailable. This article describes a new rainfall simulator that is relatively easy to operate and transport to and from the field while maintaining critical intensity, distribution, and energy characteristics of natural rainfall. The simulator frame is constructed from lightweight aluminum pipe with a single 50 WSQ nozzle centered at a height of 3 m (9.8 ft). An operating nozzle pressure of 28 …

Friction Of Wheat: Grain-On-Grain And On Corrugated Steel, Marek Molenda, Jozef Horabik, I. Joe Ross, Michael D. Montross

Biosystems and Agricultural Engineering Faculty Publications

Coefficients of friction of wheat for grain–on–grain and on galvanized corrugated steel sheet were investigated using a modified direct shear apparatus. Tests were conducted under a normal pressure of 20.7 kPa using soft red winter wheat at a moisture content of 11.2% (w.b.) and an uncompressed bulk density of 740 kg/m³. Three consolidation procedures and three methods of deposition of grain in the test chamber were used. Test results of grain–on–grain friction showed that consolidation procedure markedly influenced the force–displacement relationship, while its influence on the coefficients of friction were small. Shearing to peak strength as a consolidation …

Review Of: Eat Your Genes: How Genetically Modified Food Is Entering Our Diet (Stephen Nottingham Ed.), Natalie Duval

RISK: Health, Safety & Environment (1990-2002)

Review of the book: "Eat Your Genes: How Genetically Modified Food Is Entering Our Diet," by Stephen Nottingham, (St. Martin's Press 1999). Introduction, Glossary, Bibliography, Index. ISBN 1-85649-578-7 [212 pp. $17.95. Softbound, St. Martin's Press, Inc., New York, NY 10010].

Fiber Optic Sensor Response To High Levels Of Fat In Cream, Czarena L. Crofcheck, Frederick A. Payne, Clair L. Hicks, M. Pinar Mengüç, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

A light backscatter technique using optical fibers to deliver and receive light was investigated for measuring the milkfat content of unhomogenized cream. Light backscatter through cream at wavelengths of 450 to 900 nm was measured for fiber separation distances from 2 to 6.5 mm and for cream containing 10 to ~40 weight percent (wt%) milkfat. Unhomogenized cream (~40 wt% milkfat) was mixed with skim milk (~0.05 wt% milkfat) to yield samples with five different milkfat levels. Three optical response models were tested for correlation with milkfat content: one using the light intensity measurement at a single separation distance, the second …

Monitoring Subsurface Drainage Flow At Remote Locations, Stephen R. Workman, Stephen F. Higgins, Scott A. Shearer

Biosystems and Agricultural Engineering Faculty Publications

Laboratory evaluations and field results are presented for a slotted weir used to measure discharge from subsurface drains. The head–discharge curve for the vertical slot is a simple power function with an exponent of 1.5. There was excellent agreement (r² > 0.99 and 1:1 slope) between predicted and observed discharge in laboratory testing of 12 test weirs representing five slot widths. The primary advantages of the vertical slot weir are its simplicity, ease of maintenance, and ability to measure small flow rates. Disadvantages include a tendency for the slot to close a small amount over time as a result of …

Evaluation Of Residual Chlorothalonil Levels On Processing Tomato Foliage Using The Tom-Cast Spray Program, Jane M. Patterson, Sue E. Nokes, Mark A. Bennett, Richard E. Riedel

Biosystems and Agricultural Engineering Faculty Publications

Field tomatoes were sprayed with chlorothalonil on a fixed–interval spray program and a TOM–CAST spray program with disease severity value threshold of 18. Foliage samples from upper and lower canopy layers were collected prior to spray re–applications. Chlorothalonil residue data were compared to the chlorothalonil efficacy threshold (1.2 μg/cm²). Using a seven–day interval program, eight of the nine and seven of the nine spray intervals had chlorothalonil residues above the critical level for the upper and lower canopy layers, respectively. Using the TOM–CAST program, four of the five spray intervals had chlorothalonil residues above the critical level for …

Influence Of Inoculum Size On Phytase Production And Growth In Solid-State Fermentation By Aspergillus Niger, Chundakkadu Krishna, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

Solid–state fermentation is experiencing renewed interest for industrial enzyme production. Previous studies on the effects of fungal inoculum size on product yield have focused on spore inoculum. However, some organisms require vegetative inocula. This study investigated the effects of initial inoculum colony age, vegetative inoculum size, and duration of fermentation on the production of fungal biomass and phytase in solid–state fermentation using Aspergillus niger grown on wheat bran and soy meal. Initial inocula from 7– and 14–day–old potato dextrose agar (PDA) plates were used to study the effect of inoculum colony age in liquid culture and its further influence on …

Studies On The Formation Of Dna-Cationic Lipid Composite Films And Dna Hybridization In The Composites, Murali Sastry, Vidya Ramakrishnan, Mrunalini Pattarkine, Krishna N. Ganesh

Faculty Works

The formation of composite films of double-stranded DNA and cationic lipid molecules (octadecylamine, ODA) and the hybridization of complementary single-stranded DNA molecules in such composite films are demonstrated. The immobilization of DNA is accomplished by simple immersion of a thermally evaporated ODA film in the DNA solution at close to physiological pH. The entrapment of the DNA molecules in the cationic lipid film is dominated by attractive electrostatic interaction between the negatively charged phosphate backbone of the DNA molecules and the protonated amine molecules in the thermally evaporated film and has been quantified using quartz crystal microgravimetry (QCM). Fluorescence studies …

Cationic Surfactant Mediated Hybridization And Hydrophobization Of Dna Molecules At The Liquid/Liquid Interface And Their Phase Transfer, Murali Sastry, Ashavani Kumar, Mrunalini Pattarkine, Vidya Ramakrishnan, Krishna N. Ganesh

Faculty Works

Hybridization of complementary oligonucleotides mediated by a cationic surfactant at the water/hexane interface leads to hydrophobic, double-helical DNA which may be readily phase transferred to the organic phase and cast into thin films on solid substrates.

Submerged And Solid-State Phytase Fermentation By Aspergillus Niger: Effects Of Agitation And Medium Viscosity On Phytase Production, Fungal Morphology And Inoculum Performance, Maria Papagianni, Sue E. Nokes, Keith Filer

Biosystems and Agricultural Engineering Faculty Publications

Qualitative relationships between agitation levels and medium viscosity, Aspergillus niger morphology and phytase production were investigated in submerged and solid-state fermentations. Overall phytase production increased with increasing shaker speeds from 150 to 300 rpm, although specific growth rates and phytase production rates were higher at 150 rpm for 72 h from inoculation. Fungal morphology was greatly influenced by agitation with the morphological forms of small pellets and entangled mycelia predominating at 150 rpm, while the free filamentous form was obtained at 300 rpm. Upon inoculation of SSF, increased productivities were obtained from inocula grown at 150 rpm. A shift towards …

Improving Irrigation For Ord Sugar Cane, Jim Engelke, Joe Sherrard, Gae Plunkett, Tim Triglone

Journal of the Department of Agriculture, Western Australia, Series 4

Major changes are underway in irrigation practices for the Ord sugar industry as it moves to implement recent findings on improving irrigation efficiency and managing rising groundwater. Significant improvement in efficiency is expected by more accurately matching water application with crop water requirements and by minimising drainage losses through improved water application techniques.

Based on findings from this work, drying off may not be an appropriate strategy for the ORIA as a means of improving crop sucrose content, but could allow for some reduction in water use towards the end of the crop cycle without adversely impacting on sucrose yield. …

Non–Water–Stressed Baseline As A Tool For Dynamic Control Of A Misting System For Propagation Of Poinsettias, Sérgio Zolnier, Richard S. Gates, Robert G. Anderson, Sue E. Nokes, George A. Duncan

Biosystems and Agricultural Engineering Faculty Publications

A technique is presented for dynamically adjusting misting intervals during propagation of vegetative cuttings. A crop setpoint temperature for activation of misting was defined by a "non-water-stressed baseline" concept, using infrared thermometry to acquire canopy temperature for plant feedback. The critical crop setpoint temperature was calculated from instantaneous values of air temperature, incident radiation, and air vapor pressure deficit (VPD_air). Misting was activated when the actual crop temperature exceeded the critical crop setpoint temperature. The dynamic control was shown to have the potential to reduce the amount of applied water from 9 to 12 times during low levels …

Hybridization Of Dna By Sequential Immobilization Of Oligonucleotides At The Air-Water Interface, Murali Sastry, Vidya Ramakrishnan, Mrunalini Pattarkine, Anand Gole, K. N. Ganesh

Faculty Works

The hybridization of DNA by sequential electrostatic and hydrogen-bonding immobilization of single-stranded complementary oligonucleotides at the air-water interface with cationic Langmuir monolayers is demonstrated. The complexation of the single-stranded DNA molecules with octadecylamine (ODA) Langmuir monolayers was followed in time by monitoring the pressure-area isotherms. A large (and slow) expansion of the ODA monolayer was observed during each stage of complexation in the following sequence: primary single-stranded DNA followed by complementary single-stranded DNA followed by the intercalator, ethidium bromide. Langmuir-Blodgett (LB) films of the ODA-DNA complex were formed on different substrates and characterized using quartz-crystal microgravimetry (QCM), Fourier transform infrared …

Proposed Design Modifications To Reduce Risk Of Operating Rotary Field Mowers, Katie L. White, Larry G. Wells, Scott A. Shearer, Larry R. Piercy

Biosystems and Agricultural Engineering Faculty Publications

The primary objective of this project was to reduce risk of injury associated with operating a rotary mower driven by a tractor power take-off (PTO) by developing and evaluating design improvements and determining their economic feasibility. Researchers have concluded that alteration of machinery design has a greater impact on the reduction of accidents than safety training. Implementation of an Operator Presence Sensing System (OPSS) and removal of the PTO are the two injury-reducing, engineering modifications evaluated by this research. Hydraulic power allows this to occur by providing dynamic braking, few moving parts (removal of the PTO), and controllable power. A …

Reconditioning Corn And Soybeans To Optimal Processing Moisture Contents, Michael D. Montross, Dirk E. Maier

Biosystems and Agricultural Engineering Faculty Publications

Experimental trials were carried out to evaluate the technical feasibility of reconditioning overly dry corn and soybeans to optimal market and processing moisture contents. Data obtained from experimental trials were used to validate an aeration simulation model. This model was used to evaluate the feasibility of reconditioning soybeans and corn. Reconditioning of grain was feasible at low airflow rates (0.11 m³ min^–1 t^–1) over a six-month period when an automatic aeration controller was used. Using downflow aeration and monthly unloading of the bin allowed for the greatest net economic gain. Predicted reconditioning in Des Moines, Iowa, …

Environmental Guidelines For New And Existing Piggeries, A Latto, John Noonan, R. J. Taylor

Bulletins 4000 -

These guidelines apply to the management of Western Australia piggeries in Western Australia, including intensive Growing pigs under intensive conditions where the and extensive operations, straw-based housing and animals spend their entire life cycle indoors, is an combinations of these (otherwise referred to as semi- important part of the Western Australian and intensive housing).

Simulated Performance Of Conventional High-Temperature Drying, Dryeration, And Combination Drying Of Shelled Corn With Automatic Conditioning, Michael D. Montross, Dirk E. Maier

Biosystems and Agricultural Engineering Faculty Publications

Combination drying, based on computer simulation, was evaluated as an alternative drying technique to traditional high-temperature drying and dryeration. Simulation models of high-temperature crossflow drying and in-bin drying and conditioning were used to evaluate the performance of conventional crossflow drying and full-heat crossflow drying followed by dryeration or natural-air drying for Indianapolis, Indiana, and Des Moines, Iowa. Energy costs from propane, electricity, moisture shrink below the market moisture content, and dry matter loss were estimated to find the total average drying cost over 29 years. Dryeration and combination drying reduced the total drying cost by approximately 10% compared to conventional …

Evaporation Reduction Potential In An Undisturbed Soil Irrigated With Surface Drip And Sand Tube Irrigation, Masoud Meshkat, Richard C. Warner, Stephen R. Workman

Biosystems and Agricultural Engineering Faculty Publications

The efficiency of drip irrigation is highly dependent on evaporation losses occurring from the constantly saturated soil beneath emitters. Advent of subsurface drip irrigation is in part an approach to curb this inefficiency. An irrigation method, Sand Tube Irrigation (STI), is proposed to increase the efficiency of “Normal” surface applied drip Irrigation (NI method) on permanent tree crops without the need for burying the irrigation tubing. The sand tube consists of removing a soil core beneath the emitter and filling the void with coarse sand. A weighing lysimeter was constructed in the laboratory and instrumented to directly measure temporal evaporation …

Light Backscatter Of Milk Products For Transition Sensing Using Optical Fibers, Frederick A. Payne, Czarena L. Crofcheck, Sue E. Nokes, Klat C. Kang

Biosystems and Agricultural Engineering Faculty Publications

Transition sensors are needed, particularly in the dairy industry, for detecting transitions in pipe flow systems from product-to-water or product-to-product (such as from chocolate to vanilla ice cream mix). Transition information is used to automatically sequence valves to minimize product waste. Optical fibers were used to measure light backscatter between 400 and 950 nm as a function of milk concentration in water and milkfat concentration in milk. The normalized response (100% for product and 0% for water) as a function of product concentration in water was approximately logarithmic for skim milk between 400 and 900 nm and approximately linear for …

Optimization Of Solid-State Fermentation Parameters For The Production Of Xylanase By Trichoderma Longibrachiatum On Wheat Bran In A Forced Aeration System, Elizabeth R. Ridder, Sue E. Nokes, Barbara L. Knutson

Biosystems and Agricultural Engineering Faculty Publications

The effect of aeration on the production of xylanase by Trichoderma longibrachiatum on wheat bran in a solid-state fermentation (SSF) system has not been investigated. This study was conducted to investigate the interactive effects of aeration, initial moisture content of the substrate, and depth of the substrate on xylanase activity produced in a tray fermenter. The experiment was conducted as a split plot experiment with factorial treatments and three replications of each treatment combination. The whole plot treatment was aeration rate (0, 2.9, 5.7 L/min/kg bran). Initial moisture content (45, 55, 65% w.b.) and depth of substrate (1.0 and 2.5 …

Runoff From Fescue Plots Treated With Trimec, Cristopher G. Moss, Dwayne R. Edwards, Stephen R. Workman, R. Michael Williams

Biosystems and Agricultural Engineering Faculty Publications

Runoff of herbicides can promote adverse impacts in receiving waters. The objective of this study was to assess the effects of rainfall delay, herbicide application rate, rainfall intensity, and pre-application rainfall on runoff of TRIMEC (a combination of 2,4-D, dicamba, and mecoprop), a herbicide that is commonly used in central Kentucky. The levels of rainfall delay were 0, 2, and 4 d following application; and the levels of herbicide application rate were 0, 0.5, 1 and 2 times the recommended rate. Simulated rainfall was applied at intensities of 64, 102, and 140 mm h^-1; and the depths of …

Pesticide Residue Regulation: Analysis Of Food Quality Protection Act Implementation, Linda-Jo Schierow

RISK: Health, Safety & Environment (1990-2002)

Dr. Schierow discusses the effects of a recent statute on food safety.

Modeling Surface And Subsurface Pesticide Transport Under Three Field Conditions Using Przm-3 And Gleams, Robert W. Malone, Richard C. Warner, Stephen R. Workman, Matt E. Byers

Biosystems and Agricultural Engineering Faculty Publications

Contaminant transport models should be evaluated over a wide range of conditions to determine their limitations. The models PRZM and GLEAMS have been evaluated many times, but few studies are available in which predicted movement in runoff and percolate were simultaneously evaluated against field data. Studies of this type are essential because pesticide leaching and runoff are mutually dependent processes. For this reason, PRZM-3 and GLEAMS were evaluated for their ability to predict metribuzin concentrations in runoff, sediment, subsurface soil, and pan lysimeters under three field conditions (yard waste compost amended, no-till, and conventional-till) on a Lowell silt loam soil. …

Predicting The Cutting Time Of Cottage Cheese Using Backscatter Measurements, Czarena L. Crofcheck, Frederick A. Payne, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

An automated system for monitoring culture growth and determining coagulum cutting time is needed for cottage cheese manufacturing. A light backscatter measurement system was designed and installed in a local cottage cheese manufacturing plant. A cutting time prediction algorithm was developed using parameters generated from the backscatter profile. The cutting time prediction algorithm, T_cut = T_max + β₂ S, used two time-based parameters generated from the backscatter profile (T_max and S) and one operator selected parameter, β₂, to predict the coagulum cutting time, Tcut. The standard error of prediction for the algorithm was 6.4 …

A Case Study Of Bioengineering In America: Profits, Risks And Standards Of Value In The Commercialization Of Monsanto Company's Newleaf Potato, Bridget Lyons, Teresa Ralabate, Nadhim Frangul

WCBT Faculty Publications

Last year, approximately 45 million acres of American farmland were planted with crops that had been genetically engineered to either produce their own pesticides, or withstand herbicides. The long and short-term effects of this biotechnology on humans and the environment, are being studied, but remain unknown. Leading the way in the field of bioengineered crops is the Missouri-based Monsanto Company. Monsanto believes that current agricultural practices are inconsistent with sustainable development. The NewLeaf potato is one of three products Monsanto has created to feed the growing world population. The genetically engineered crop produces, in every cell of the plant, a …

Comparison Of Water And Temperature Distribution Profiles Under Sand Tube Irrigation, Masoud Meshkat, Richard C. Warner, Stephen R. Workman

Biosystems and Agricultural Engineering Faculty Publications

Drip irrigation is one of the most efficient systems in delivering water to the plant root zone. Research has shown that the saturated, or nearly saturated, surface beneath the emitter may increase evaporation thereby reducing the irrigation efficiency. To increase the efficiency of surface applied drip irrigation on permanent tree crops a sand tube irrigation (STI) method was developed and tested. The sand tube method consists of removing a soil core beneath the emitter and filling the void with coarse sand. A weighing lysimeter was designed and instrumented to directly measure temporal evaporation during irrigation and for a period of …

Optimization Of Solid-State Fermentation Parameters For The Production Of Xylanase By Trichoderma Longibrachiatum On Wheat Bran, Elizabeth R. Ridder, Sue E. Nokes, Barbara L. Knutson

Biosystems and Agricultural Engineering Faculty Publications

Solid-state fermentation has the potential to produce inexpensive enzymes for use in high-volume industrial applications. Process parameters such as substrate moisture content and length of fermentation can have a significant effect on the amount and timing of enzyme production. This study was conducted in two stages, a screening stage and an optimization stage, to determine the effects of moisture content of the substrate, surfactant addition upon inoculation, depth of the substrate, and duration of fermentation on xylanase activity produced by Trichoderma longibrachiatum. Screening fermentations were conducted at 25°C, 50 and 75% wet basis moisture content (w.b.), 0.0 and 0.2% …