Environmental Education Commons^™

Wpływ Instalacji Termicznego Przekształcania Odpadów Komunalnych Na Jakość Powietrza, Robert Oleniacz

Robert Oleniacz

At the turn of 2015/2016 it is planned to launch in Poland a few new municipal solid waste incineration plants. This type activities causes usually concerns of the local community due to their potential negative impact on air quality. Are these fears are, however, justified? The article describes allowable air emissions for new waste incinerators, the actual emissions that occur from such installations, and the current state of knowledge about their impact on air pollution.English title: The impact of installations of municipal solid waste thermal treatment on air quality.

Energetyczne Wykorzystanie Stałych Paliw Wtórnych Z Odpadów (Srf) Na Przykładzie Instalacji Współspalania Paliw W Cementowni Chełm, Magdalena Kasietczuk, Robert Oleniacz

Robert Oleniacz

The paper presents the use of Solid Recovered Fuels (SRF) in Chelm Cement Plant (Poland). These types of fuels are produced from non-hazardous waste and can be used for energy recovery in waste co-combustion plants. They are much cheaper compared to primary fuels, so their use in the process of cement clinker burning brings evident economic benefits. Chelm cement plant owned by the CEMEX company is a leader in the use of alternative fuels in Poland. In the years 2005-2011 the amount of co-combustion of alternative fuels in the cement had risen from 107 to 318 thousand tons, and their …

Produkcja Stałego Paliwa Wtórnego Na Przykładzie Przedsiębiorstwa Usług Komunalnych „Empol” Sp. Z O.O. / Production Of Solid Waste-Derived Fuel - A Case Study Of The Enterprise Of Municipal Services "Empol" Llc, Robert Oleniacz, Leszek Rataj, Monika Wyrostek

Robert Oleniacz

The work presents activities of the Enterprise of Municipal Services "Empol" Sp. z o.o. based in Tylmanowa (Małopolska Province, Poland) and the interrelated technological lines for sorting of waste and production of alternative fuels (refuse derived fuels - RDFs) started in 2009 in the Special Economic Zone in Gorlice. The paper also discusses properties of the produced RDFs and their typical applications.

Problem Niekontrolowanego Spalania Odpadów I Pozostałości Roślinnych W Obszarze Wiejskim Na Wybranym Przykładzie, Robert Oleniacz, Barbara Bacik

Robert Oleniacz

This paper presents the results of surveys on the problem of uncontrolled burning of waste in domestic stoves and boilers for central heating and open burning of plant residues in rural areas. The questionnaires were conducted among the inhabitants of one of Polish village (Łąkta Dolna), located in the Malopolska province, in the submontane area. The study comprised 80.2% of all households. As is clear from conducted surveys waste were burned in more than 80% of surveyed houses and more than half of respondents admitted to the open burning of plant residues. The percentage of people burning waste and plant …

Pomiary Liczby I Wielkości Cząstek Aerozoli W Powietrzu Miejskim Z Wykorzystaniem Metody Optoelektronicznej, Marek Bogacki, Robert Oleniacz, Marian Mazur, Monika Dziugieł

Robert Oleniacz

In the paper some measurement results of number and size for aerosols particles suspended in air achieved using infrared particle sizer IPS-P (Kamika Instruments) with isokinetic air sampling method were presented. In IPS-P analyzer, with measuring range from 0,4 to 300 μm, is applied optical/electronic measurement method which is determined by dimensions of measurement space by aerosols particles motions in a parallel radiation beam. The research was conducted on the roof of four-storey building in Krakow for various meteorological conditions. Results achieved for measured parameters were analysed in terms of selected meteorological factors influence.

English title: Number and size measurements …

Uncontrolled Combustion Of Household Wastes And Vegetation Remains In A Rural Community – Questionnaire Results, Robert Oleniacz, Anna Tomkowicz

Robert Oleniacz

Uncontrolled combustion of household wastes and vegetation remains makes a serious problem referring to the emission of many substances polluting atmosphere, including polychlorinated dibenzo-p-dioxins and dibenzofurans. Combustion of post-use wastes or garbage and burning grasses are also seen as one of the causes of air pollution in larger and larger number of communities in Poland. The awareness of the Polish society referring to this problem and related appearance of different air pollutants, including dioxins and furans, has still been low. It was studied in one of Polish rural communities, based on the results of the questionnaires. In the questionnaire studies …

Dobór Systemu Oczyszczania Gazów Odlotowych Ze Spalania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The flue gas cleaning system is usually one of the most costly elements of the installation to the incineration of hazardous waste. Adapting the system to the actual needs could therefore bring obvious economic benefits.

The paper presents the method of the preselection of the configuration of the cleaning system based on knowledge of the level of concentration of selected components of the raw exhaust gas (sulfur dioxide, hydrogen chloride, hydrogen fluoride, total dust, mercury, cadmium and thallium, and other heavy metals). Twelve examples of flue-gas cleaning systems were proposed and extreme concentration values of the substances in the raw …

Oczyszczanie Gazów Odlotowych Ze Spalania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

Flue gas cleaning system is a very important part of each hazardous waste incineration plant. Air pollutant emission limit values permissible for this process in Member States of the European Union are so rigorous that the installation designers there are forced to use very effective and of course expensive solutions. In the paper a review of methods and systems used to the treatment of flue gases from hazardous waste incineration is presented. This can be particularly useful in the face of the adaptation of existing waste incineration plant operating in Poland with European Union requirements.

English title: Cleaning of flue …

Pesticide Waste Incineration In The Wet Process Cement Kiln, Marian Mazur, Robert Oleniacz, Marek Bogacki, Stanisław Słupek

Robert Oleniacz

The presentation discusses the problem of pesticide wastes in Poland that have been accumulated underground in concrete graveyards or bunkers. Their progressive unsealing poses a significant health risk to people due to groundwater, soil and air pollution. There are not many of professional hazardous waste incineration plants in Poland, therefore, the paper proposes the use of cement kiln for thermal treatment of such waste. Polish cement industry is interested in utilization of various wastes (e.g. in the capacity of alternative fuels) in the process connected with the cement clinker production in rotary kilns. High temperatures existing in cement kilns (ca. …

Spopielanie Odpadów Medycznych W Systemie Purotherm-Pyrolise – Zmienność Składu Spalin I Emisji Zanieczyszczeń W Cyklu Załadowczym, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The paper presents selected effects of the cyclical nature of the two-stage process of medical waste incineration on the variation of concentrations of basic constituents and selected gaseous pollutants (NOx, CO, SO2, H2S and HCl) in flue gas discharged from the process. The study included the installation working in the Purotherm-Pyrolise system (waste gasification and gas afterburning) with actual yields of 100-150 kg/h. The phases of the process varied in dynamic and direction changes of the flue-gas composition and the levels of air pollutant emissions were separated and described for these phases. They can be very important for the organization …

Pirolityczne Metody Utylizacji Odpadów Niebezpiecznych - Przykładowe Rozwiązania I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

The paper presents the pyrolysis and gasification processes of organic matter and the main directions of their use for the thermal disposal of hazardous waste. Used for this purpose the basic technical solutions are discussed with regard to existing and new technologies. Given the fact that the pyrolytic methods in Poland were primarily used for the incineration of medical waste, most attention was paid to a facility designated for such waste disposal. The problem of air pollutant emissions from this type of installation and some operating guidelines was also presented on the basis of the literature analyses and own research. …

Zastosowanie Procesów Pirolizy I Zgazowania Do Termicznej Utylizacji Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents characteristic of pyrolysis and gasification processes and main trends to their application for the waste thermal treatment. Selected examples of the applications and course of these processes as well as sorts of their final products is here also discussed.

English title: The use of pyrolysis and gasification processes to waste thermal utilization.

Spalanie Odpadów W Procesie Skojarzonym Z Produkcją Klinkieru Cementowego - Problem Emisji Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

The paper presents a review of emissions of main gaseous pollutants (including acidic constituents), some organic compounds (including dioxins and furans), particulates and heavy metals from cement kilns burning waste fuels.

A widely employed method to reduce the cost of cement production is the substitution of traditional fuels used in cement kilns with alternative and waste-derived fuels. Cement industry offers the most acceptable method of waste (especially hazardous waste) thermal treatment and disposal at much lower cost than commercial incinerators. Characteristic for cement kilns high temperatures and long residence time of exhaust gas ensure almost complete destruction of organic compounds …

Spalanie Odpadów Niebezpiecznych W Piecach Cementowych. Część 1. Informacje Podstawowe, Robert Oleniacz

Robert Oleniacz

A widely employed method of reducing cement production costs is the substitution of traditional fuels with alternative and waste-derived fuels to heat the cement kiln. Cement industry offers the most acceptable method of hazardous waste incineration and co-combustion with significantly lower cost in comparison to incinerators. The high temperatures and long residence times inherent in the operation of cement kilns ensure the almost complete destruction of the organic compounds introduced together with waste fuels. This part of the article presents general characteristic of sort of waste incinerated in cement kilns, way of their charging, advantages and limitations of waste co-combustion …

Piece Cementowe - Konkurencja Dla Spalarni Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents the advantages of cement kilns and the possibility of their use for thermal waste utilization. The most common types of waste incinerated in these kilns and the possible degree of replacing traditional fuels with waste fuels have also been characterized. The work also discusses the problem of air pollutant emissions from the process of waste co-incineration in cement kilns. Attention has been paid to the possible increase in the use of Polish cement industry in the waste management, system, especially in the field of energy recovery from solid municipal waste, waste tires and waste from the refinery …

Spalanie Odpadów Poszpitalnych I Farmaceutycznych W Piecu Obrotowym / Incineration Of Hospital And Pharmaceutical Wastes In A Rotary Kiln Incinerator, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The paper presents selected results of research on hospital and pharmaceutical waste incineration in a full-scale rotary kiln with variable loads of the kiln. As part of these studies measurements of air pollutant concentrations in flue gases and leaching tests of solid combustion products were carried out. Based on these studies, the maximum dose of hospital and pharmaceutical waste was proposed in the mixture with industrial wastes, which does not cause excessive air emissions. The average emission factors for the waste mixture loading were also determined.

Spalarnia Odpadów Lobbe W Dąbrowie Górniczej, Marian Mazur, Robert Oleniacz, Ryszard Januszek

Robert Oleniacz

This paper is a general characteristic of the industrial and hazardous waste incineration plant which was operated in Dąbrowa Górnicza (Poland) in the 90. The waste incineration plant is based on two incinerators - a rotary kiln and a multiple hearth furnace. Levels of selected air pollutant emissions presented in the work allow to assess the potential impact of this facility on air quality.

English title: The LOBBE incineration plant in Dąbrowa Górnicza.

Monitoring Zanieczyszczeń Powietrza Wokół Elektrowni "Jaworzno Iii", Marian Mazur, Robert Oleniacz, Marek Bogacki, Ryszard Kozakiewicz

Robert Oleniacz

The article presents the concept of system of monitoring of air pollution around the Power Plant "Jaworzno III" in Jaworzno (Poland), whose objective is to evaluate the impact of this object on air quality. This system is based on a few measuring points and a mobile station should also allow for the assessment of ecological effects associated with the use of low-emission burners in power boilers (reduction of NOx emission) and run the wet installation of flue gas desulfurization (reduction of SO2 emission). An additional aim of the measurements is to identify the possible effects of a changes in the …