Food Processing Commons^™

Aromatic Amino Acid Catabolism By Lactobacillus Spp.: Biochemistry And Contribution To Cheese Flavor Development, Sanjay Gummalla

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Amino acids derived from the degradation of casein in cheese serve as precursors for the generation of desirable and undesirable flavor compounds. Microbial degradation of aromatic amino acids is associated with the formation of aroma compounds that impart putrid-fecal, barny-utensil, and floral off-flavors in cheese, but pathways for their production had not been established. This study investigated Tyr and Phe catabolism by Lactobacillus casei and Lactobacillus helveticus cheese flavor adjuncts under simulated Cheddar cheese-ripening conditions (pH 5.2, 4% NaCl, 15°C, no sugar). Enzyme assays of cell-free extracts and micellar electrokinetic capillary chromatography of supernatants indicated that L. casei and L. …

Studies On The Formation Of Dna-Cationic Lipid Composite Films And Dna Hybridization In The Composites, Murali Sastry, Vidya Ramakrishnan, Mrunalini Pattarkine, Krishna N. Ganesh

Faculty Works

The formation of composite films of double-stranded DNA and cationic lipid molecules (octadecylamine, ODA) and the hybridization of complementary single-stranded DNA molecules in such composite films are demonstrated. The immobilization of DNA is accomplished by simple immersion of a thermally evaporated ODA film in the DNA solution at close to physiological pH. The entrapment of the DNA molecules in the cationic lipid film is dominated by attractive electrostatic interaction between the negatively charged phosphate backbone of the DNA molecules and the protonated amine molecules in the thermally evaporated film and has been quantified using quartz crystal microgravimetry (QCM). Fluorescence studies …

Biochemistry And Application Of Exopolysaccharide Production In Mozzarella Cheese Starter Cultures, Brent Petersen

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

This study sought to investigate the role of the C₅₅ undecaprenol lipid carrier in the production of exopolysaccharide (EPS), the effect of exopolysaccharide producing (EPS⁺) starter cultures on the viscosity of Mozzarella cheese whey, and the possible protective characteristics of capsular EPS against freezing and freeze drying. Efforts to investigate the role of the lipid carrier in EPS production employed pAMbacA, a plasmid that encodes an enterococcallipid kinase that confers bacitracin resistance by increasing intracellular levels of undecaprenol phosphate lipid carrier. Unfortunately, this avenue of study was thwarted by the inability to demonstrate bacA …

Cationic Surfactant Mediated Hybridization And Hydrophobization Of Dna Molecules At The Liquid/Liquid Interface And Their Phase Transfer, Murali Sastry, Ashavani Kumar, Mrunalini Pattarkine, Vidya Ramakrishnan, Krishna N. Ganesh

Faculty Works

Hybridization of complementary oligonucleotides mediated by a cationic surfactant at the water/hexane interface leads to hydrophobic, double-helical DNA which may be readily phase transferred to the organic phase and cast into thin films on solid substrates.

Hybridization Of Dna By Sequential Immobilization Of Oligonucleotides At The Air-Water Interface, Murali Sastry, Vidya Ramakrishnan, Mrunalini Pattarkine, Anand Gole, K. N. Ganesh

Faculty Works

The hybridization of DNA by sequential electrostatic and hydrogen-bonding immobilization of single-stranded complementary oligonucleotides at the air-water interface with cationic Langmuir monolayers is demonstrated. The complexation of the single-stranded DNA molecules with octadecylamine (ODA) Langmuir monolayers was followed in time by monitoring the pressure-area isotherms. A large (and slow) expansion of the ODA monolayer was observed during each stage of complexation in the following sequence: primary single-stranded DNA followed by complementary single-stranded DNA followed by the intercalator, ethidium bromide. Langmuir-Blodgett (LB) films of the ODA-DNA complex were formed on different substrates and characterized using quartz-crystal microgravimetry (QCM), Fourier transform infrared …

Prediction Of Rice Sensory Texture Attributes Using Spectral Stress Strain Analysis And Jack-Knife Model Optimization, Marura Lenjo, Jean-Francois Meullenet

Discovery, The Student Journal of Dale Bumpers College of Agricultural, Food and Life Sciences

Sensory texture characteristics of cooked rice were predicted using an extrusion test and a novel multivariate analysis method. Eleven sensory texture characteristics were evaluated via a trained descriptive panel and predicted for force/deformation spectra with partial least squares regression. Only four sensory attributes—adhesion to lips (Rcal = 0.83), cohesion of bolus (Rcal = 0.78), cohesiveness (Rcal = 0.69), and hardness (Rcal = 0.72)—were successfully predicted from instrumental measurements.

Growth Of Clostridium Sporogenes Pa3679 In A Vacuum-Packaged Meat-Vegetable Product, Julie M. Racz

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Clostridium sporogenes PA 3679 spores were inoculated into a meat-vegetable mixture before extrusion, cooking, and vacuum packaging into "stewsticks" to simulate Clostridium botulinum growth. The experiment was a 3 x 5 x 2 x 3 factorial which determined the influence of pH, water activity, initial spore load, and storage period on spore survival. Spore levels decreased throughout storage for all treatments. Spore levels decreased linearly (P = 0.02) as water activity increased, in samples that were heated to kill vegetative cells and activate spores. Other significant interactions of heat-treated samples were observed with inoculum level (P < 0.01) and storage time (P < 0.01). Spore levels in stored products were also significantly affected by water activity * inoculum level (P = 0.03), pH * time, water activity * time (P = 0.01), inoculum level * time (P < 0.01), and water activity * inoculum levels * time (P < 0.01). The interaction between pH * water activity * time tended towards significance (P = 0.06). Most probable number estimates in nonheated samples accounted for naturally occurring viable cells and spores, and added spores and were significantly affected by the main effects of inoculum level (P < 0.01) and time (P < 0.01). The two-way interactions of water activity * inoculum level (P = 0.04), pH * inoculum level (P < 0.01), water activity * time (P < 0.01), and three-way interaction of pH * inoculum level * time (P = 0.03) were significant. Spore levels approached 10², or less …

Influence Of Commercial Starter Media On Biochemical Characteristics Of Lactococcus Lactus, Norman Bart Devries

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Five strains of Lactococcus lactis were inoculated individually into six commercial bulk set growth media, 11% non-fat dry milk (NDM), and Elliker's broth. After growth in each medium the strains were tested for rate of acid production, and activities of proteinase, aminopeptidase, and lipase/esterase. Growth in commercial starter media significantly influenced acid production rate (P = 0.040), aminopeptidase activity (P < 0.0001), and lipase/esterase activity (P < 0.0001) .

For selected strain/media combinations, the duration of induced aminopeptidase and lipase/esterase activity was followed. The chosen strains were grown in selected commercial bulk set media, reinoculated into 11% NDM, and enzyme activity was examined for five successive …

Influence Of Stress Treatments On The Resistance Of Lactococcus Lactis To Freezing And Freeze-Drying, Chan Lin

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

This study investigated the effect of cold, heat, or osmotic shock treatment on the resistance of L. lactis subsp. cremoris MM160 and MM310 and Lactococcus lactis subsp. lactis MM210 and FG2 cheese starter bacteria to freezing and freeze-drying. The ability to withstand freezing at -60°C for 24 h was variable among lactococci, but resistance to this treatment was significantly improved (P < 0.05) in most strains by a 2-h cold shock at l0°C or a 25-min heat shock at 39°C (L. lactis subsp. cremoris) or 42°C (L. lactis subsp. lactis). Stress treatments that improved lactococcal freeze resistance were also found to significantly (P < 0.05) enhance the resistance of most strains to lyophilization. Increased resistance to freezing or lyophilization was not detected when stress treatments were performed in broth that contained erythromycin, which indicated stress-inducible proteins were involved in cell protection. Membrane fatty acid analysis of stress-treated cells suggested that enhanced resistance to freezing and lyophilization may be related to heat or cold shock-induced changes in cell membrane composition. Heat-shocked cells had a higher 19:0 cyclopropane fatty acid content than did control cells, and cold-shocked cells contained a lower ratio of saturated to unsaturated fatty acids. Other factors must also be involved in cell protection, however, because similar changes in membrane composition were also detected in strains whose resistance to freezing and lyophilization was not improved by heat or cold shock.

Tryptophan Catabolism By Lactobacillus Spp. : Biochemistry And Implications On Flavor Development In Reduced-Fat Cheddar Cheese, Sanjay Gummalla

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Amino acids derived from the degradation of casein in cheese serve as precursors for the generation of key flavor compounds. Microbial degradation of tryptophan (Trp) is thought to promote formation of aromatic compounds that impart putrid fecal or unclean flavors in cheese, but pathways for their production have not been established. This study investigated tryptophan catabolism by Lactobacillus casei LC301 and LC202 and Lactobacillus helveticus CNRZ32 and LH212 cheese flavor adjuncts in carbohydrate starvation (pH 6.5, 30 or 37°C, no sugar) and cheese-like conditions (pH 5.2, 4% NaCl, 15°C, no sugar). Enzyme assays of cell-free extracts revealed both species of …

Effect Of Ph, Fat Level, And Various Browning Agents On Composition, Color, Texture, And Sensory Characteristics Of Dark-Cutting Beef Patties, Igor V. Moiseev

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Extra lean (3.3% fat) and lean (20.0% fat) hamburgers in three pH groups (≤ 6.0; 6.01-6.49; 6.50-6.92) were evaluated for cooking-temperature profile, total process lethality, and physical properties after cooking to 71°C by double-side frying on an electric grill. Neither cooking-temperature profile nor cooking time was affected by hamburger fat content or pH. Double-side frying to 71.1°C internal temperature was adequate for more than 6-log destruction of viable E. coli O157:H7 and Salmonella at the geometrical center of extra lean and lean hamburgers. The coldest spot was on the circumferential surface, as indicated by the presence of a red ring …

Anion Induced Blue To Purple Transition In Bacteriorhodopsin, Mrunalini Pattarkine, Anil K. Singh

Faculty Works

Purple membrane (PM, λ" role="presentation">λmax" role="presentation">max 570 nm) of H. halobium on treatment with sulphuric acid changes its colour to blue (λ" role="presentation">λmax" role="presentation">max 608 nm). The purple chromophore can be regenerated from the blue chromophore by exogeneous addition of anions such as CI−" role="presentation">− and HPO42−" role="presentation">2−4. Chloride ion is found to be more effective than the dibasic phosphate ion in regenerating the purple chromophore. Nevertheless, one thing common to the anion regeneration is that both CI−" role="presentation">− and HPO42−" role="presentation">2−4 show marked pH effect. At pH 1.0 the efficiency of …

Microbiological And Sensory Effects Of Milk Processed For Extended Shelf Life And The Development Of Rapid Methods To Quantitate Spores And Lipase Activity, Michael R. Blake

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

The initial aim of this work was to evaluate processing conditions for extended shelf life (ESL) milk to have a shelf life at refrigeration temperature of 60 d. Milk was processed on a pilot-scale ultra-high-temperature processing plant and evaluated for microbial and sensory quality over 60 d at 7°C storage. Results of this study showed that lower process temperatures were preferable to minimize cooked flavors and that the minimum safe processing temperature was 134°C for 4 s as determined by the destruction of bacterial spores in the processed milk.

Consumer preference panel results indicated that consumers preferred milk processed at …

Uht Milk : Expanding The Market, Caroline Love, Ian Bell, Martin Robertson

Journal of the Department of Agriculture, Western Australia, Series 4

An increase in the export of UHT (Ultra Heat Treated) milk to Asian markets is potentially worth millions of dollars to the dairy inmdustry. This increase however, relies on the shelf life of UHT products being extended to nine months. Spoilage of UHT milk can be caused by bacterial spores which originate on-farm and are resistant to processing. Expansion in the UHT market therefore relies on a continued reduction in the number of these spores getting into raw milk. Caroline Love, Ian Bell and Martin Robertson report on the sources of spores entering milk on-farm and the control methods available.

Anaerobic Treatment Of Whey Permeate Using Upflow Sludge Blanket Bioreactors, Seokhwan Hwang

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Whey permeate was anaerobically digested in laboratory scale upflow anaerobic sludge blanket reactors. Nine hydraulic retention times between 5 and 0.2 days were examined with a fixed influent concentration of 10.6 ± 0.2 g COD/L.

Chemical oxygen demand removal efficiency ranged from 99.0 to 18.9% and maximum production rate of methane gas was 2.67 L/L/day at a hydraulic loading rate of 12.97 kg COD/m³/day. About 70% of the chemical oxygen demand removed was converted to methane.

Both the nonlinear least square method with 95% confidence interval and linear regression were used to evaluate kinetic coefficients. The maximum substrate …

Effects Of Potassium Lactate, Encapsulated Citric Acid And Storage Temperature On Microbial Growth And Shelf Life Of Pork Sticks, Yen-Kan Su

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

A new product, pork sticks, was developed. Optimum shelf life and safety were major concerns associated with this product. Potassium lactate (3%) or citric acid (0.5%, 0.56%, 0.60% or 0.66%) was added to pork sticks to determine their effects on microbial growth, sensory evaluation, and shelf life when stored frozen (-20°C), refrigerated (2°C), or at room temperature (22°C). Two raw materials, pork blade meat (shoulder meat; 91% lean, 9% fat) and regular 80:20 pork trim (80% lean, 20% fat) were used. The consumer panel preferred lean pork sticks made from blade meat over high-fat pork sticks made from regular 80:20 …

Purification And Immunological Reactivity Of Commercial Microbial Milk Clotting Enzyme Preparations, Chima I. Osuala

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Commercial microbial milk clotting enzyme preparations were purified by immunoaffinity chromatography using purified antibody covalently coupled to porous glass beads as the column matrix. Commercial enzyme preparation diluted in 1 mM sodium acetate buffer at pH 5.0 was then biospecifically adsorbed to the column matrix by end-over-end mixing of the glass-antibody complex in the enzyme solution for 12 h at 5°C. The antibody bound enzyme adsorbed glass beads were soaked in .2 M glycine or ethanolarnine at pH 7.0 to block uncoupled reactive sites on the matrix. Following this, the column was washed with 1 mM sodium acetate …