Open Access. Powered by Scholars. Published by Universities.®

Food Processing Commons™

Open Access. Powered by Scholars. Published by Universities.®

Food Biotechnology

Institution
Keyword
Publication Year
Publication
Publication Type

Articles 4981 - 5010 of 5042

Full-Text Articles in Food Processing

Research On Antibacterial Effect Of Eucalyptus Extracts Combined With Oxacillin Against Mrsa, Cui Haiying, Zhang Xuejing, Zhou Hui, Zhao Chengting, Li Wei, Lin Lin Feb 2015

Research On Antibacterial Effect Of Eucalyptus Extracts Combined With Oxacillin Against Mrsa, Cui Haiying, Zhang Xuejing, Zhou Hui, Zhao Chengting, Li Wei, Lin Lin

Food and Machinery

Ethanol and water are used respectively to extract the active ingredients of eucalyptus leaves. Then it was researched on the inhibitory effect of the active ingredients on MRSA, and compared the inhibitory effect of the oxacillin with and without eucalyptus extracts addition. The results shows that, the ethanol extract of eucalyptus presents a minimum inhibitory concentration(MIC)from 1 g/L to 5 g/L for MRSA, and the water extract is from 2~10 g/L. With 0.2 g/L of ethanol extract of eucalyptus added, the oxacillin can reduce the MIC of the MRSA from 62.5～250 mg/L to 7.8～31.3 mg/L, and the MIC for all …

Go to article

Study On Antibacterial Activity Of Phenol Hydroxyl From N-Aryl Schiff Cos Derivatives, Han Yongping, Gong Ping, Li Keyi Feb 2015

Study On Antibacterial Activity Of Phenol Hydroxyl From N-Aryl Schiff Cos Derivatives, Han Yongping, Gong Ping, Li Keyi

Food and Machinery

The N-aryl Chitooligosaccharides (COS) derivatives were firstly synthesized with Benzaldehyde, salicylal and 3,4-two hydroxy benzaldehyde, subsequently was quaternized to enhance its water solubility.The chemical structures of all COS derivatives were characterized by ATR-FTIR or 1H NMR. The antibacterial studies of these COS derivatives were carried out by the inhibition zone diameters methods against E.coli, S.aurueus and P.aeruginosa bacteria. The antibacterial activity results showed N-3,4-two hydroxy benzaldehyde Schiff’s base COS > N-salicylal Schiff’s base COS > N- Benzaldehyde Schiff’s base COS> COS. In comparison to the COS derivatives chemical structure, it was found that the phenol hydroxyl group from N-aryl Schiff COS …

Go to article

Study On Isolation, Purification, Composition And Immulogical Characterics Of Ganoderma Lucidum Body Polysaccharides, Yang Hui, Dai Jun, Chen Shangwei, Zhu Song Feb 2015

Study On Isolation, Purification, Composition And Immulogical Characterics Of Ganoderma Lucidum Body Polysaccharides, Yang Hui, Dai Jun, Chen Shangwei, Zhu Song

Food and Machinery

Two water-soluble polysaccharide fractions named as GLPD2 and GLPD2were isolated and purified from the same Ganoderma Lucidum body which was collected from Jiangxi province. The GPC and SEC-LLS results indicated that GLPD1 and GLPD2 were high purity, moreover, their molecule weights could both reach above 5×106. Their primary structural features and conformational properties were characterized by infrared spectrometry and SEC-LLS. The data obtained indicated that GLPD1 and GLPD2 may both be β-glucan configuration with pyran glucan groups. What's more, conformational analysis detected by SEC-LLS showed that GLPD1 and GLPD2 had rather tight structure with high degree of branch. However, PMP-HPLC …

Go to article

Study On Preparation Of Body Wall Hydrolysate Of Starfish Asterina Pectinifera And Antioxidant Activity Detection, Li Yubo, Ji Xiaolin, Liu Shan, Zha Yue, Xin Qiuyan, Qi Hang Feb 2015

Study On Preparation Of Body Wall Hydrolysate Of Starfish Asterina Pectinifera And Antioxidant Activity Detection, Li Yubo, Ji Xiaolin, Liu Shan, Zha Yue, Xin Qiuyan, Qi Hang

Food and Machinery

Hydrolysate was extracted from starfish Asterina pectinifera, the starfish Asterina pectiniferas were hydrolyzed with pepsin, neutrase and trypsin under their optimal conditions to obtain the hydrolysate, and the antioxidant activity of hydrolysate was detected by using electron spin resonance(ESR) spectroscopy The results indicated that the DPPH radical and hydroxyl radical scavenged ability increased with the increasing concentration of hydrolysate; at the concentration of 20 mg/mL, the clearance rate of pepsin group, neutrase group and trypsin group on DPPH radical were(5225±014)%, (6830±037)% and (4627±047)% respectively, and the rate of hydroxyl radical were(7261±017)%, (8182±079)% and (5677±028)% respectively.

Go to article

Antioxidant Activity Of Hydrolysate From Corn Glutelin By Protamex, Liu Yue, Liu Xiaolan, Zheng Xiqun, Zhou Limin Feb 2015

Antioxidant Activity Of Hydrolysate From Corn Glutelin By Protamex, Liu Yue, Liu Xiaolan, Zheng Xiqun, Zhou Limin

Food and Machinery

The molecular weight distribution and antioxidative activities of corn glutelin hydrolysate by Protamex during hydrolysis process, corn glutelin as raw material, were investigated. The results showed that the highest antioxidant activities was exhibited at the hydrolysis time of 120 min, with molecular weight distribution among 6 511.51~307.32 Da and peptides component 94.36%. DPPH radical scavenging activity, superoxide anion scavenging activity, hydroxyl radical scavenging activity, reducing power and Fe2+-chelating activity of hydrolysate were 58.86%, 82.64%, 37.21%, 0.236 and 29.92%, respectively.

Go to article

Identification Andoptimization Of Fermentation Conditions For Symbiotic And Epiphyte Bacterium Dnc2 From Strongylocentrotus Intermedius, Li Zhen, Zhang Fuyun, Li Wei, Zhao Yu, Lu Hang Feb 2015

Identification Andoptimization Of Fermentation Conditions For Symbiotic And Epiphyte Bacterium Dnc2 From Strongylocentrotus Intermedius, Li Zhen, Zhang Fuyun, Li Wei, Zhao Yu, Lu Hang

Food and Machinery

To explore the Symbiotic and Epiphyte bacterium DNC2 from Strongylocentrotus intermedius, the morphological, biochemical and physiological characteristics of the strain were researched and the 16S rDNA sequences of it were analyzed. The univariate experiment and orthogonal test of L16(45) were carried out to optimize the fermentation conditions for antibacterial activity. Symbiotic and Epiphyte bacterium DNC2 was identified as Bacillus subtilis. The optimal fermentation conditions were obtained as fermentation at 35 ℃ for 120 h with initial pH 9, and the optimum fermentation medium was determined as beef extract 0.3% and peptone 0.6%. The optimized …

Go to article

Study On Antitumor Activities Of Five Kinds Of Wild Edible Mushrooms In Changbai Mountain, Li Xue, Li Pengfei, Li Xiaodong, Yu Ting, Jin Qiankun, Cui Chengbi Feb 2015

Study On Antitumor Activities Of Five Kinds Of Wild Edible Mushrooms In Changbai Mountain, Li Xue, Li Pengfei, Li Xiaodong, Yu Ting, Jin Qiankun, Cui Chengbi

Food and Machinery

To study the anti-tumor activities of wild edible mushrooms of the Changbai Mountain, the experiment selected Ganoderma Lucidum, Inonotus Obliquus, Phellinus, Hericium Erinaceus, Lentinula Edodes five kinds of Changbai Mountain wild edible mushrooms as materials, the experiment was divided into in vitro and in vivo study. The inhibition effect of tumor cells was tested by MTT method, and the inhibition ratio of mouse sarcoma S-180 was calculated in vivo study. The results showed that Ganoderma Lucidum has the highest inhibition ratio on the HeLa and HepG2 cell lines. Phellinus has the highest inhibition rate on MCF-7 cell line, Hericium Erinaceus …

Go to article

Analysis Of Nutritional And Bioactive Components Of Solid-State Fermented Substrate Of Isaria Cicadae, Yu Shijun, Chai Xinyi, Fan Meizhen Feb 2015

Analysis Of Nutritional And Bioactive Components Of Solid-State Fermented Substrate Of Isaria Cicadae, Yu Shijun, Chai Xinyi, Fan Meizhen

Food and Machinery

In the present work, the nutritional and bioactive components of the solid-state fermented substrate of I. cicadae were studied. And the results indicated that the contents of protein, total sugar and fat acid were 16.17%, 38.87% and 1.43%, respectively. The unsaturated fat acid content was 1.18%. The amino acid profile was analyzed and lysine was the first restrictive amino acid in the FAO/WHO model. The contents of vitamin E and C were 1 833 mg/kg and 239 mg/kg, respectively. Furthermore, the fermented substrate contained adenosine, mannitol and polysaccharide. This work provided basic information for the further development of Fermented Substrate …

Go to article

Study On Subcritical Extraction Of Ginger Oil, Chang Dawei, Sun Jiaojiao, Liu Shuxing Feb 2015

Study On Subcritical Extraction Of Ginger Oil, Chang Dawei, Sun Jiaojiao, Liu Shuxing

Food and Machinery

The gingers were selected as raw material and the optimum extract conditions of essential oil of ginger were studied by using subcritical extraction technology. The essential oil of ginger from the methods of subcritical extraction and hydro-distillation were compared. The 1, 1, 1, 2-tetrafluoroethane was used as the extraction agent. The optimum conditions of subcritical extraction were as follows: the materials granularity was 60 mesh；subcritical extraction time was 1.5 hours and extraction temperature was 30～40 ℃. Under the conditions, the extraction ratio of ginger essential oil was about 3.14%. The essential oil components were analyzed by GC—MS. α-curcumene and zingiberene …

Go to article

Preparation Of Flavor Compounds From Volvariella Volvacea By Microwave-Composite Enzyme Synergistic Extraction, Jie Guangchuan, Chen Hongjie, Li Bijin Feb 2015

Preparation Of Flavor Compounds From Volvariella Volvacea By Microwave-Composite Enzyme Synergistic Extraction, Jie Guangchuan, Chen Hongjie, Li Bijin

Food and Machinery

First, hydrolyzing the Volvariella volvacea by mlti-enzyme complex hydrolysis technology, and then using microwave technology to hydrolyze, using orthogonal design method to determine the optimum extraction process of the Volvariella volvacea with microwave-enzymatic hydrolysis technology and the extract amount of α-Amino nitrogen as observing indexes and the optimum extraction process were as followed: hydrolysis time 120 min, hydrolysis temperature 55 ℃, edible fungus hydrolase No.1 to No. 2 dosage 1∶2(m∶m), initial pH 5.5, microwave power 800 W, microwave temperature 70 ℃, microwave time 10 min. The content of α-amino nitrogen in the orthogonal experiments of microwave-assisted extraction under mlti-enzyme was …

Go to article

Optimizationon Extracting Technology Of Total Flavonoids From Ginkgo Biloba Leaves By Ultrasonic-Assisted Method, Du Ruoyuan, Xie Jing, Wang Ting, Che Xu, Lan Weiqing Feb 2015

Optimizationon Extracting Technology Of Total Flavonoids From Ginkgo Biloba Leaves By Ultrasonic-Assisted Method, Du Ruoyuan, Xie Jing, Wang Ting, Che Xu, Lan Weiqing

Food and Machinery

Objective to optimize the technology for extracting process of total flavonoids from Ginkgo biloba leaves. Methods Based on the single factor experiments for ethanol concentration, solid-liquid ratio and extracting time, orthogonal experiment L9 (33) was designed to optimize the ethanol extracting conditions of total flavonoids by ultrasonic-assisted method. Results the optimal technology for extracting conditions of total flavonoids was as followed: with 60% ethanol concentration, 1∶50 (m∶V) solid-liquid ratio and 30 min of extracting time. Conclusion According to the results of variance analysis, ethanol concentration (P<0.01) had the greatest influence on yield of total flavonoids, followed by solid-liquid ratio (P<0.05), extracting time was the minimal influence (P>0.05). Under these conditions, the yield of total flavonoids was 8.075 …

Go to article

Optimization On Ultrasonic Extraction Technology Of Tannin From Gallnut, Li Qianyun, Zhang Shuangling, Zhou Guoyan Feb 2015

Optimization On Ultrasonic Extraction Technology Of Tannin From Gallnut, Li Qianyun, Zhang Shuangling, Zhou Guoyan

Food and Machinery

Gallic tannins have extensive bioactivities functions，including antioxidant，antitumor and anticancer. In order to investigate the extraction technology of Chinese gallnut tannin by ultrasonic, the effect factors，including the volume fraction of HCl , the volume fraction of ethanol, ultrasonic temperature and the ratio of material were optimized through orthogonal tests L9（34）on the basis of single factor experiment . The result showed the optimal extracting conditions were as follows: hydrochloric acid volume fraction 1.0%, ethanol volume fraction 50%, ultrasonic temperature 40 ℃, the ratio of material to liquid was 1∶30(m∶V). Under the optimal conditions，the extraction rate of Chinese gallnut …

Go to article

Purification Of Polyphenols From Walnut Peel By Macroporous Resin Adsorption, Li Qiong, Chen Kai, Chen Yanqin, Li Huanrong Feb 2015

Purification Of Polyphenols From Walnut Peel By Macroporous Resin Adsorption, Li Qiong, Chen Kai, Chen Yanqin, Li Huanrong

Food and Machinery

A method for separation and purification of polyphenols from Walnut peel with macroporous resins. The results as follows: five kinds of macroporous resins were selected, AB-8 resin was considered as suitable material to purify and separate the Walnut peel polyphenols. The optimum conditions were concentration of feed 3.0 mg/mL at pH 4.0, and the volume of polyphenols sample 100 mL, flowing rate 2.0 mL/min, elute ethanol concentration 30%, ethanol at pH 6.0, elute volume 250 mL, elution rate 2.0 mL/min. After eluted with AB-8 resin, the polyphenols purity reach 36.36%, which is approximately 4.8 times higher than the previous7.65%.

Go to article

Research On Fermentation Technology For Buckwheat Sweet Rice Wine By Tan-Fan Method, Wan Ping, Liu Hong, Tang Ling, Long Jianbing, Peng Lianxin Feb 2015

Research On Fermentation Technology For Buckwheat Sweet Rice Wine By Tan-Fan Method, Wan Ping, Liu Hong, Tang Ling, Long Jianbing, Peng Lianxin

Food and Machinery

With buckwheat rice and glutinous rice(1∶1) as raw material, and the optimum were determined through single factor test and orthogonal test fermentation technology for buckwheat sweet rice wine by tan-fan method as follow: the use level of jiuyao was 0.4%; the use level of the wheat starter was 5%; the add liquor alcohol content 45%vol, the use level of liquor: the raw material for 1∶1(V∶m), fermentation temperature 30 ℃, the primary fermentation time 11 d. Under the above condition, the produced buckwheat sweet rice wine, after storage had mellow taste and lubrication and special styles and it was yellow in …

Go to article

Preparation Of Salted Eggs With Low Salt, Su He, Yang Ruijin, Zhao Wei, Hua Xiao, Zhang Wenbin Feb 2015

Preparation Of Salted Eggs With Low Salt, Su He, Yang Ruijin, Zhao Wei, Hua Xiao, Zhang Wenbin

Food and Machinery

A two stage brining method for preparing salted eggs with low salt was investigated. The moisture and salt content of the egg white and egg yolk in the process of brining were measured. The oil-off ratio of the yolk of the salted eggs was measured, and the sensory quality of the salted eggs was comprehensively evaluated.The results showed that, when the two stage briningprocess in which duck eggs were preserved with 19% salt solution firstly,then switched to a low concentration of 3.5% salt solution was applied, the salt content of the salted egg white was 3.64%, 51.21% lower than the …

Go to article

Optimization Of Liquid Culture Medium For Fermenting Mycelial Flavone In Phellinus Igniarius, Xu Qian Feb 2015

Optimization Of Liquid Culture Medium For Fermenting Mycelial Flavone In Phellinus Igniarius, Xu Qian

Food and Machinery

Objective Phellinus igniarius is a kind of rare medicinal fungi, its flavone can be used as medicine. This research was to optimize liquid culture medium for flavone fermention.Methods Taking the mycelia flavone yield of Phellinus igniarius as index, the liquid culture medium was optimized with L9(34) orthogonal test. Results The optimal medium for high flavone yield established was A3B3C2D2: corn flour 3%+ wheat bran 7%, peptone 2%, KH2PO4 0.10%, MgSO4 0.15%, mycelia flavone yield of Phellinus igniarius was 212.35 mg/L. Conclusion Liquid culture medium …

Go to article

Optimization On Two Kinds Of Extraction Process For Sterol In Sesame Oil Deodorizer Distillate, Ma Suhuan, Wang Xuede, Li Menghua Feb 2015

Optimization On Two Kinds Of Extraction Process For Sterol In Sesame Oil Deodorizer Distillate, Ma Suhuan, Wang Xuede, Li Menghua

Food and Machinery

Explored the sesame oil deodorization distillate of two extraction methods of phytosterols. On the basis of single factor experiment with orthogonal experiment optimization for the solvent to extract for optimum process conditions were as followed, saponification time 3.5 h, saponification temperature 80 ℃, alkaline quantity 8.5 mL/0.5 g, and thetotal sterol content is 8.42%; Supercritical method to extract the best conditions were as followed: CO2 flow 20 L/h, 3 h extraction time, extraction pressure 25 MPa, extraction temperature 50 ℃, and thesterol extraction rate is 73.25%. Compared two methods of supercritical CO2 extraction method, the superior is better than the …

Go to article

Optimization On Conditions Of Protease Hydrolysis For Whey Protein, Sun Yang, Qian Fang, Zhao Lei, Liu Xiaohui, Mu Guangqing Feb 2015

Optimization On Conditions Of Protease Hydrolysis For Whey Protein, Sun Yang, Qian Fang, Zhao Lei, Liu Xiaohui, Mu Guangqing

Food and Machinery

With quadratic regression orthogonal rotational combination design, the conditions of whey protein enzyme hydrolysis were optimized. Established the orthogonal regression model which is about the degree of hydrolysis to three factors of temperature, time, enzyme dosage. Experiments showed under the conditions of temperature of 57 ℃, enzyme dosage of 8 214 U/g protein and hydrolysis time of 114 minutes, the degree of hydrolysis was the maximum, of 11.72%, which basically consistent with the model value.

Go to article

Effect Of Different Temperature Air Drying Conditions On Quality Of Thompson Seedless Grapes, Meng Yang, Liu Fengjuan, Wang Yuhong, Zhu Chunli, Huang Wenshu, Feng Zuoshan Feb 2015

Effect Of Different Temperature Air Drying Conditions On Quality Of Thompson Seedless Grapes, Meng Yang, Liu Fengjuan, Wang Yuhong, Zhu Chunli, Huang Wenshu, Feng Zuoshan

Food and Machinery

The effects of different temperatures on grape quality were studied by hot air drying, taken Turpan Thompson seedless grapes as material, which was treated by dry-promoter agent, and dried by hot air drying in 30 ℃, 35 ℃, 40 ℃, 45 ℃, respectively. The results showed that: in the process of drying seedless white grapes, the contents of ascorbic acid, titratable acidity, total phenol decreased, while browning was raised. Comprehensive comparison, hot air drying in 40 ℃ can prepare raisin better quality.

Go to article

Effect Of Modified Starch On Stability Of Maize Beverage, Li Shaohua, Long Jiaoyan, Sijun Na, Wuguang Hui, Gao Yuanjun Feb 2015

Effect Of Modified Starch On Stability Of Maize Beverage, Li Shaohua, Long Jiaoyan, Sijun Na, Wuguang Hui, Gao Yuanjun

Food and Machinery

In order to improve the stability of maize beverage, modified starch is added as the stabilizer. Investigations have been made to study the impact of three kinds of modified starches with one-factor and orthogonal experiment. Results showed that the maize beverage can be improved with 0.8% hydroxypropyl composite modified starch, 0.8% cassava modified starch and 0.6% hydroxypropyl octenylsuccinate esterification starch, and lowered centrifugal sedimentation. The order of the impact of these three modified starches from high to low is: hydroxypropyl composite modified starch, hydroxypropyl octenylsuccinate esterification starch and cassava modified starch.

Go to article

Study On Stability Of Rice Beverage, Guo Jieli, Lu Shengmin, Xing Jianrong, Chen Jianbing, Tu Kang Feb 2015

Study On Stability Of Rice Beverage, Guo Jieli, Lu Shengmin, Xing Jianrong, Chen Jianbing, Tu Kang

Food and Machinery

Eleven kinds of different stabilizers and emulsifiers were applied to the research on the stability of rice beverage. Among which, four kinds with better stability effect were selected and used in the orthogonal test to improve the stability of rice beverage. The results indicated that the rice beverage had the highest stability with its precipitation rate 0.87% only and without stratification occurred after 3 weeks at room temperature when the amount of pectin, xanthan gum and monoglyceride were added 0.60%, 0.165% and 0.60% respectively. In addition, xanthan gum and pectin had significant（P<0.01 and P<0.05, respectively）, while monoglyceride and Span 40 did not have significant（P>0.05）effect on the stability of rice beverage. Comparatively, …

Go to article

Preparation Of Germinated Soybean Milk With Household Soymilk Machine, Jin Zixin, Yang Ruijin, Zhu Shengbo, Liu Xinjuan, Zhang Wenbin Feb 2015

Preparation Of Germinated Soybean Milk With Household Soymilk Machine, Jin Zixin, Yang Ruijin, Zhu Shengbo, Liu Xinjuan, Zhang Wenbin

Food and Machinery

The objectives of this study were to optimize pulverizing and boiling process for germinated soybean milk. Pulverizing temperature and boiling time were explored through single-factor experiments and the optimal temperature was figured out as 70 ℃ and boiling time as 4 min.With optimized process, content of γ-aminobutyric acid, total freeamino acids, essential freeamino acids in the germinated soybean based milk were 1.36 mg/100 g, 0.455 g/100 g, and 0.219 g/100 g, respectively. Compared with dry soybean milk, the above contents were 3.68, 1.34, 8.87 folds increased respectively. Despite that the trypsin inhibitor activity (TIA) was 1.27 times that of dry …

Go to article

Optimization On Technology Of Potato Yogurt, Wu Jianmin, Liu Shaojun, Shao Songlin Feb 2015

Optimization On Technology Of Potato Yogurt, Wu Jianmin, Liu Shaojun, Shao Songlin

Food and Machinery

To reseach technology of the potato yogurt，the technology and formulation of potato yogurt inoculation of the ferment,fermentation time,temperature and other parameters were studied. The optimum technological conditions of potato yogurt were optimized.The optimum formulation was as followed: potato juice to milk 20∶70(V∶V), sugar 4%(m/V), Starter cultures 8%（V/V）, ferment time 6 h.

Go to article

Processing Technology Of Rosa Sterilis Yoghourt Buccal Tablets, Yan Xiaoyue, Liu Xing, Li Yongfu, Chen Qinfang, Zhong Yaoguang, Wang Zhengwu Feb 2015

Processing Technology Of Rosa Sterilis Yoghourt Buccal Tablets, Yan Xiaoyue, Liu Xing, Li Yongfu, Chen Qinfang, Zhong Yaoguang, Wang Zhengwu

Food and Machinery

Rosa sterilis, sericin peptides and skim milk were used as raw materials to produce yoghourt buccal tablets of the ratio of raw materials and preparation conditions, which could enrich yoghourt buccal tablets varieties in the market and improve their nutritional value. The results showed that the optimal co-fermentation time was 4 hours, the best ratio of Rosa sterilis, xylitol and dried skim milk 2∶5∶10 and the content of magnesium stearate 2%. The yoghourt buccal tablets were nutritive and suitable sour and sweet, rich in yogurt flavor and the fruital of Rosa sterilis, whose nutritional and hygienic indexes could meet the …

Go to article

Development Andchallenge Of 3d Print In The Food Industry, Li Guangling Feb 2015

Development Andchallenge Of 3d Print In The Food Industry, Li Guangling

Food and Machinery

With the rapid development of 3D printing technology, its applications expand into the field of architecture, industrial design and orthopedic from the traditional mold manufacturing. The cost reduction is benefited from the development of opening hardware technology. In the food industry, 3D food printing will have a profound impact on shortage of food supply, individual needs. But there are also many challenges in material limitations, taste, safety, cost and psychological disorders which 3D food printing must face.

Go to article

Off-Gas Analysis In Fermented Foods Industry, Dong Kewu, Li Lu Feb 2015

Off-Gas Analysis In Fermented Foods Industry, Dong Kewu, Li Lu

Food and Machinery

Off-gas analysis plays an important role in the production of fermented foods. It is noninvasive and enables on-line process monitoring of the physiological status of the fermentation, including growth kinetics and substrate consumption. It also helps determine the optimum point to halt the process for maximum yield. Two kinds of analytical method，as well as the applications in fermented food such as amino acid, organic acid, enzymes and so on were introduced. Process mass spectrometer will be potentially used in various of fermented food production fields, which can monitor several fermenters simultaneously with long-term good stability and high-precision.

Go to article

Research Status And Progress Of Ultra-Low Temperature Refrigeration Plant, Guo Yaojun, Xie Jing, Zhu Shixin, Wang Jinfeng, Tang Yuanrui Feb 2015

Research Status And Progress Of Ultra-Low Temperature Refrigeration Plant, Guo Yaojun, Xie Jing, Zhu Shixin, Wang Jinfeng, Tang Yuanrui

Food and Machinery

Ultralow temperature of －40 ℃～－80 ℃ is mainly used in the fields such as food processing, petrochemical industry, biological pharmacy and scientific experiments. The ultralow temperature refrigeration system and the research progress with refrigerant and compressor were introduced. Based on the comparison with the current research at home and abroad. the future development of ultra-low temperature refrigeration unit can be optimized from the auto-cascade refrigeration system, and the natural refrigerants as a substitute can also be concerned, further studies for the compressor inverter technology and other aspects of CO2 compressors’ performance.

Go to article

Advances In Heat And Mass Transfer Models Of Microwave Freeze-Drying, Yan Shasha, Duan Xu, Ren Guangyue, Liu Wei Feb 2015

Advances In Heat And Mass Transfer Models Of Microwave Freeze-Drying, Yan Shasha, Duan Xu, Ren Guangyue, Liu Wei

Food and Machinery

Microwave freeze-drying is a rapid dehydration technique that can be applied to certain foods, particularly to seafoods, and fruits and vegetables. MFD involves much less drying time and energy consumption than conventional freeze-drying methods, and also improves product quality. The article presents the principles of microwave freeze-drying, the research progress of heat and mass transfer mathematical simulation at home and abroad, the detection technology online, and the dielectric properties of materials taken into account in the drying process simulation. After analyzing the problems, the trend of numerical simulation of freeze-drying is predicted.

Go to article

Research Progress Of Health Functions Of Wheat Bran, Du Zhenya, Chen Fusheng, Bu Guanhao Feb 2015

Research Progress Of Health Functions Of Wheat Bran, Du Zhenya, Chen Fusheng, Bu Guanhao

Food and Machinery

As one of the important dietary fiber source, wheat bran contains various active polysaccharides, phenolic compounds and others physiologically active substances, which plays an important role in human health. Mainly introduced and prospected the function of wheat bran in relieving constipation, colon cancer, diabetes and other.

Go to article

Application Of Calcium In Fruit And Vegetable Industry, Yu Hongguo, Chen Fusheng, Lai Shaojuan, Zhang Lifen Feb 2015

Application Of Calcium In Fruit And Vegetable Industry, Yu Hongguo, Chen Fusheng, Lai Shaojuan, Zhang Lifen

Food and Machinery

As an important fruit elements of the cell wall, calcium is also an important component of the plasma membrane.It plays an important role for the growth and development of fruits and vegetables, and also involved in regulating a variety of physiological processes, improve fruit quality. In the production and processing,spraying calcium fertilizer before harvest can improve the quality of fruits and vegetables; postharvest calcium treatment can also prolong its storage period, maintain good quality, reduce the loss of fruits and vegetables after the harvest.

Go to article

First Prev Next Last