Food Science Commons^™

Texture And Microstructure Of Soybean Curd (Tofu) As Affected By Different Coagulants, J. M. Deman, L. Deman, S. Gupta

Food Structure

The coagulating properties of five coagulants and the nature of the curd obtained from soymilk was investigated . Viscosity changes during coagulation were studied using a Namctrc Vibrating Sphere Viscometer and texture measurements were made by compression and computer assisted analysis. pH and amount of solids in the whey were determined. The microstructure of the tofu was examined by sca nning electron microscopy. It was observed that CaCI2.2H20 and MgCI2.6H20 coagulaled the milk in stantl y while CaS04 .1/2H20. glucono delta l a~tonc (GOL) and MgS04 .7H20 acted comparatively slowly. The t exture of the curd was greatly influenced by …

Mucilage In Yellow Mustard (Brassica Hirta) Seeds, I. R. Siddiqui, S. H. Yiu, J. D. Jones, M. Kalab

Food Structure

Release of mucilage from yellow mustard (brassica hirta, also known as Sinapis alba) seed coats (hulls) was studied by optical and scanning electron microscopy. Micrographs were obtained of the mucilage which had exuded from briefly moistened seeds and dried subsequently in the form of small droplets on the seed surface.

The mucilage collected from the seed surface and mucilage isolated on a larger scale from seed hulls was hydrolyzed with sulfuric acid and the hydrolyzates were analyzed for sugar composition. Galactose, glucose, and galacturonic acid were found to be major components and mannose, arabinose, xylose, and rhamnose were minor components. …

Mechanical Properties Of Cheese, Cheese Analogues And Protein Gels In Relation To Composition And Microstructure, M. L. Green, K. R. Langley, R. J. Marshall, B. E. Brooker, A. Willis, J. F. V. Vincent

Food Structure

Samples of commercial Cheddar cheese, experimental Cheddar cheeses made from heated, ultrafiltration-concentrated mllks, processed cheese analogues and whey protein gels of defined composition were examined microscopically and some fracture and deformation properties were determined. Surfaces of cheese prepared by critical point drying and those examined frozen were comparable in microstructure. As the concentration factor of the milk used for experimental c heesemaking increased, the cheese became more resistant to reversible deformation, the work required to cut with a wire or break wf th a hammer increased and the microstructure showed that the protein matrix was coarser. The force to deform …

Relationship Between Microstructure And Susceptibility To Syneresis In Yoghurt Made From Reconstituted Nonfat Dry Milk, V. R. Harwalkar, Miloslav Kalab

Food Structure

Increase in the density of protein matrices i n yoghurt samples conta ining 10 to 30% total milk sol ids was studied by scanning electron micros copy and was corr e lated with a decrease in syneresis. Casein particles which formed chains and clusters in the protein matrix were largest in the 10% total solids yoghurt and their dimensions were decreased as the total solids contents were increased. This observation was confirmed by transmission electron microscopy of thin sections. An attempt has been made to explain the discrepancy between results on syneresis obtained by a drainage and a centrifugation method …

Ultrastructural Studies On The Cultivation Processes And Growth And Development Of The Cultivated Mushroom Agaricus Bisporus, D. A. Wood, G. D. Craig, P. T. Atkey, R. J. Newsam, K. Gull

Food Structure

Scanning electron microscopy (SEM) , transmission electron microscopy and light microscopy have been used to study various processes in the cultivation of the edible mushroom Agaricus bisporus . Mushrooms are cultured on composted wheat straw. The microbial degradation processes during composting have been visualised by TEM and SEM and correlated with microbiological studies . Various modes of attack by the microorganisms on the plant cell walls can be seen. Most rapid degradation occurred on the cuticle and phloem and spread to other cell types. Microbial attack was found to be nonuniform between tissue types and individual cells. The mycelium of …

Thermal Analysis Microscopy For The Study Of Phase Changes In Fats, J. M. Deman, A. N. Mostafa, A. K. Smith

Food Structure

An investigation was carried out using the Mettler FPBOO Thermosystem to study polymorphic transitions of several monoacid triglycerides and hydrogenated Canola oil. The system includes a central processing unit connected with a thermal microscopy hot stage that allows the measurement of heat flow to the scrnple . Scanning electron microscopy was also used to examine the same samples after osmium tetroxide fixation . The results obtained relate phase transitions occurring during heating and cooling with the morphology of the various crystal structures.

Ultrastructural Ultilization Of Plants By Herbivores, L. H. Harbers

Food Structure

Study of the patterns of ruminal digestion of forages enhances the nutritional knowledge of how specific plant tissues are digested and adds its own dimension by characterizing the specific cells and the complex interactions of ruminal microflora with those tissues. A common pattern of digestibility exists for mono- and dicotyledon leaves: mesophyll and phloem are degraded readily, and sclerenchyma slowly, whereas cuticle and the remaining vascular tissues are rarely utilized . Digestion of stems is limited to parenchymal tissues in monocotyledons and to cortex and parenchyma in dicotyledons. Epidermal silica and cuticle are undigestible and restrict microbial entrance. Calcium oxalate …

Scanning Electron Microscopic Study Of Rockfish Preserved At Either Ambient Temperature Or By Isothermal Freeze-Fixation, L. E. Lampila, V. Mohr, D. S. Reid

Food Structure

Fresh rockfish (Bocaccio, Sebastus paucispinis) fillets were blast frozen and stored at either -5 °C or -20 °C for 60 days . At defined sampling intervals, speci mens were removed and chemically fixed at either ambient temperature or isothermally, at the respective storage temperatures (-5 °C or -20°C) . The results indicated that isothermally freeze - fixed specimens showed a degree of crushing and/or distortion of the muscle fiber, the deposition of presumed ice crystals in the cell membrane, the multi-dimensionality of connective tissue and the preservation of fine detail . In specimens fixed at ambient temperatures , structura l …

Seed Microstructure: Review Of Water Imbibition In Legumes, Barry G. Swanson, Joe S. Hughes, H. Paul Rasmussen

Food Structure

Scanning electron microscopy (SEM) is an invaluable tool for studying foods and food products. SEM has been particularly va luable in the study of seed microstructure and the ro le of microstructure in water imbibition by legumes. Controversy continues to surround the causes of hard ness in legumes as addi tional research revea ls differences between legumes that imbibe water and legumes that fail to imbibe water. SEM observation of the microstructural changes occurring in legumes during water imbibition ofkrs a better undcrstandi ng of d i ffc rcnces that ex ist betwee n hard and normal beans. Structural changes …

Particle Structure In Spray-Dried Whole Milk And In Instant Skim Milk Powder As Related To Lactose Crystallization, Zenichi Saito

Food Structure

The structure of instant skim milk and whole milk powders was studied by scanning electron microscopy with special respect to lactose crystallization during storage. X-ray diffraction analysis was used to confirm the crystallization. Some samples were ashed in a plasma asher and the residues were also examined by scanning electron microscopy. The structures of instant skim milk and whole milk powder particles were well-preserved after the ashing procedure.

The crystallization of ~X-Iactose hydrate occurred in instant skim milk and whole milk powders according to moisture uptake. In instant skim milk powder, ~X-Iactose hydrate crystals were observed on the particle surface. …

Ultrastructural Study Of Yam Tuber As Related To Postharvest Hardness, L. Sealy, S. Renaudin, D. J. Gallant, B. Bouchet, J. M. Brillouet

Food Structure

Usually, parenchyma cell walls of monocotyledons do not develop secondary walls; however a few days after harvesting, the yam tuber of Dioscorea dumetorum starts to harden. Two or three weeks Iater, hardness is so pronounced that the tubers cannot be eaten, even after a long cooking time.

Cytochemical studies using autofluorescence or some fluorescent dyes, such as phloroglucinol hydrochloride showed that the thin, and flexible cell walls of parenchyma tubers very quickly became fully lignified after harvesting. Ultrastructura 1 stud ies of the hardened ce 11 wa 11 s showed very thick secondary wa 11 s and very deep pit …

Rheological And Ultrastructural Studies Of Wheat Kernel Behaviour Under Compression As A Function Of Water Content, A. Al Saleh, D. J. Gallant

Food Structure

The rhea logical behaviour of two wheat varieties (Triticum durum), cultivated at different sites, was studied by INSTRON* as a function of water content. Patterns of crushed grains were investigated by scanning electron microscopy . The apparent modulus of elasticity of the wheat grains was apparently re 1 a ted to their vitreosity. The mealy grain generally had an apparent modulus of elasticity lower than that of the vitreous one and the modulus appeared to be related to the air spaces in mealy endosperm. Humidification favoured the conversion of vitreous endosperm to the mealy state. Grain morphology and particularly the …

Microstructural Changes In Maturing Seeds Of The Common Bean (Phaseolus Vulgaris L.), Joe S. Hughes, Barry G. Swanson

Food Structure

Seeds of Phaseolus vulgaris L. beans were collected at weekly intervals throughout maturation and examined by scanning electron microscopy (SEM). No major structural changes were observed on the surface of the seed coat during the seven week study period. A cross-sectional examination of the seed coat revealed a substantial increase in thickness of the parenchyma cell layer in young seeds followed by a dramatic decrease in thickness as the seed approached maturity. In the cotyledons, the diameter of the storage cells and starch granules increased over time, with distinct protein bodies becoming visible only in the later stages of maturity. …

Rheological And Scanning Electron Microscopic Examination Of Skim Milk Gels Obtained By Fermenting With Ropy And Non-Ropy Strains Of Lactic Acid Bacteria, S. M. Schellhaass, H. A. Morris

Food Structure

Physical and rheological parameters of skim milk gels fermented with slime producing (ropy) cultures and non-ropy cultures were compared. The skim milk gels were made from steamed reconstituted nonfat dry milk inoculated with 2% of a single strain starter culture and incubated at 32, 37, and 45°C until pH 4. 5 + 0.05 was attained.

Skim milk gels fermented by slime-producing strains of Streptococcus thermophilus, Streptococcus cremoris, and Lactobacillus bulgaricus exhibited similar rheological and physical characteristics. Electron micrographs of the ropy skim milk cultures showed that slime produced by the organisms was associated with the cell surface as well as …

Crystal Morphology Of Cocoa Butter, D. M. Manning, P. S. Dimick

Food Structure

The multiple melting points of triglycerides have been known and studied for more than a century by numerous workers. The ability of fat to undergo polymorphic changes is important mainly due to its effect on product texture and appearance. Polymorphic resolidification during storage of cocoa butter into higher melting forms can destroy the smooth glossy appearance of a confectionery product. This manuscript will review the polymorphic characteristics and composition of cocoa butter from Theobroma cacao. A discussion of common fat behavior relative to tempering and bloom formation will be included. Scanning electron microscopy and polarized light microscopy aided in visually …

Properties Of Calcium Caseinates With Disparate Performance In Imitation Cheese, K. Fleming, R. Jenness, H. A. Morris, R. Schmidt

Food Structure

Two commercial lots of calcium caseinate preparations differing in performance imitation cheese were analyzed for various characteristics. A imitation process cheese manufacturing classified the caseinates as good or poor based on appearances of the finished cheese, emulsification of fat, oiling-off during sheeting and melting properties. The sample which exhibited good functional properties in imitation cheese, had slightly higher calcium (16.4 mg/g protein), non-casein protein (2.87%) and y-casein contents, a higher formal titre (8.95 mg free amino N/g protein), lower water absorption (138 mg/100 g protein), and lower stability to added calcium (8.0 min) than did the other sample (14.6 mg/g, …

Seed Structure And Composition Of Potential New Crops, D. W. Irving, R. Beckler

Food Structure

Prosopis , Ol neya , and Amaranthus have potenti a l economic value as food or feed crops fo r a rid /semi- arid r egions. Ma ture seeds of these genera we r e examined using scanning e l ec tron and fluoresce nce microscopy to define a natomy and localize s t or age s truc tures in cells . Pro t ein bodies, some co nt a ini ng phytin inc lu sions , were l oca li zed in the embryos of five Prosopi s s peci es . Prosopis chilensis wa s the only one …

Microstructure Of Set-Style Yoghurt Manufactured From Cow's Milk Fortified By Various Methods, A. Y. Tamime, M. Kalab, G. Davies

Food Structure

Five different batches of skim milk were prepared and fortified by the addition of skim milk powder (SMP) or sodium caseinate (Na-cn) or by concentration using a vacuum evaporator (EV), ultrafiltration (UF), or reverse osmosis (RO) to contain similar levels of protein (5.0-5.5%). Yoghurts were made by inoculating the milks with one of 3 commercial yoghurt starter cultures and by incubating the mixes at 42°C for 2.5 h. The following factors were found in this study to affect firmness of the yoghurts: (a) Lactic acid production (acidity) - Yoghurts containing 1.02% of lactic acid or more (pH 4.54 or less) …

A Simple Procedure For The Preparation Of Stirred Yoghurt For Scanning Electron Microscopy, Paula Allan-Wojtas, Miloslav Kalab

Food Structure

Stirred yoghurt is aspirated into agar gel tubes having 1.2 mm interior diameter, fixed in glutaraldehyde , dehydrated in ethanol freeze - fractured under liquid nitrogen and critical-point dried. Agar gel encapsulation protects the sample and prevents it from disintegration during the preparative steps. Scanning electron microscopy of the mounted fragments reveals the corpuscular microstructure of this type of yoghurt which develops due to stirring and pumping of the product during manufacture.

Ultrastructural Studies Of Raw And Processed Tissue Of The Major Cultivated Mushroom, Agaricus Bisporus, E. M. Jasinki, B. Stemberger, R. Walsh, A. Kilara

Food Structure

Commercial mushroom processors currently lose approximately 30 percent of the mushroom weight due to shrinkage during processing (blanching and canning) , resulting in substantial economic losses . Microscopy was used to assess the extent and type of chemical and structural changes induced by processing mushrooms and causing shrinkage. Scanning electron microscopy revealed that the processing operations including vacuum hydration , blanching , and thermal treatment do not damage the integrity of the tissue. Light microscopy revealed that the morphology of the tissue, shape and spacing of cells, appear similar for raw and processed mushroom tissue . However, the intra ce …

Ultrastructural Aspects Of Spun Pea And Fababean Proteins, D. J. Gallant, B. Bouchet, J. Culioli

Food Structure

The ultrastructure of pea and fababean spun proteins has been studied by SEM and TEM as a function of dope pH and washing bath salt concentrations. The textural properties {mechanical resistance, moisture content) and diameter of the fibres have been determined.

Spinning was only possible when dope pH was higher than 11. An increase in dope pH from 11.5 to 13 induced a shear strength increase whereas the moisture content and the diameter of the fibres decreased . The structure of the fibres became more compact and changed from an aggregate of spherical particles to a tridimensional network. When dope …

Infection Of Oriental Mustard By Nematospora: A Fluorescence And Scanning Electron Microscope Study, Richard A. Holley, Beverley E. Phipps-Todd, Suk H. Yiu

Food Structure

Fluorescence light microscopy and scanning electron microscopy were used to study penetration by the yeast Nematospora caryli through the seed coat and into the embryonic tissues of oriental mustard seed (Brasslca iuncea).

Infection of the seed was associated with its physical injury; however, it was evident that the yeast was capable of successfully invading healthy plant cells. The pathological process was followed in parallel using both the above types of microscopy. Foci of yeast infection on the seed coat outer surface were characterized by swelling of the infected epidermal cells. Nematospora hyphae were seen in the lumina of the seed …

The Structure Of Fresh Desiccated Coconut, J. F. Heathcock, J. A. Chapman

Food Structure

Light and electron microscopy have been used to study the structure of fresh coconut endosperm tissue and the changes which have occurred when this has been processed to the desiccated form. In fresh tissue, a marked gradation of cell size , shape and contents exists between inner and outer endosperm regions. Adjacent to the brown testa, cells are rigid, compact and lipid-filled while those cells lining the central water-filled cavity have thin, easily deformed cell walls and contain little lipid . Desiccated coconut be ing derived from fresh tissue, is similar in morphology but moisture is reduced from 50% to …

Electron Microscopy Of Milk And Milk Products: Problems And Possibilities, D. G. Schmidt

Food Structure

Milk and dairy products have frequently been studied by transmission- and scanning electron microscopy. The specimen preparation procedure may considerably influence the final result, and formation of artefacts is frequently observed. In this respect, formation of ice crystals during cryofixation is a well-known phenomenon. But dehydration, to an extent such as is required for embedding procedures, also appears to be harmful to dairy products. Micrographs of thin sections of plastic- embedded samples of casein submicelles show threadlike material, whereas in freeze-etched specimens only spherical particles are found. Similar observations are made when samples of cheese and of concentrated milk are …