Food Science Commons^™

Product Morphology Of Fatty Products, I. Heertje, M. Leunis, W. J.M. Van Zeyl, E. Berends

Food Structure

In order to relate composition, processing and product properties of fat spreads, a proper description of the microstructure of these products is required . A technique for the observation of the three-dimensional product structure has been developed which allows free observation of the solid crystalline matrix by removing the liquid oil phase from a fat spread with a solvent system. To perform the different preparation steps required in a reproducible and efficient way, a special sample holder was constructed. Application of preformed sintered bronze elements allows free penetration of the organic solvents. In general, reproducible results are obtained with retention …

The Microstructure And Rehydration Properties Of The Phoenix Oyster Mushroom (Pleurotus Sajor Caju) Dried By Three Alternative Processes, Brigitte Li-Shing-Tat, Pavel Jelen

Food Structure

The aim of this investigation was to observe the effects of three drying methods on the microstructure and rehydration properties of the Phoenix Oyster mushroom. Mushrooms were dried at 55C by air-, freeze- and vacuum-drying pilot plant processes. At the microstructural level, the hyphae of the air-dried samples were more flattened and collapsed than the vacuum - and freeze dried samples. The Basidia were distorted by all three treatments to a certain extent, but there seemed to be less damage on the gill surface of the vacuum-dried samples. Appearance, rehydration time and capacity were similar for freeze- and vacuum-dried mushrooms; …

The Microstructure Of The Hen's Egg Shell - A Short Review, R. M. G. Hamilton

Food Structure

The structure of the hen's egg shell can be divided into five separate layers . The Innermost layer consists of two distinct membranes known as the inner and outer shell membranes. These membranes are compos ed of networks of protein/polysaccharide fibres and are =70 mm thick. Attached to the outer fibres of the outer membrane are polycrystals of calcite (calcium carbonate) which extend outward in an inverse conical manner until the cones from several sites of crystal i nit iation fuse together. The fibre/ crystal attachment sites, known as basal caps, and the cones form the mammillary knobs layer which …

Observations On The Microstructure And Rheology Of Ovalbumin Gels, I. Heertje, F. S.M. Kleef

Food Structure

Understanding the gelation behaviour of proteins is of importance in order to be able to influence the properties of many food systems and it may lead to proposals for product or process improvement . In this context the formation of heat-set ovdl bumin gels. in different media , has been studied by microstrucmral. rheological and conformational observations. An oval bumin/ water geL prepared at pH 5, shows a granular. inhomogeneous microstructure. At this pH the re are both many interand intramolecu lar interactions. and network formation occurs via aggregates of folded, globular protein chains. On the other hand , gels …

Structural Characteristics Of Eleusine Corocana (Finger Millet) Using Scanning Electron And Fluorescence Microscopy, C. M. Mcdonough, L. W. Rooney, C. F. Earp

Food Structure

The objective of this study was to document the microstructure of finger millet wlth scanning electron and fluorescence microscopies. Finger millet is an utricle which is spheri ca 1 and about 1 . 5 ITlT1 in diameter. The membranous peri carp of finger millet was loosely associated with the seed at maturity. Beneath the loose pericarp wa s a five-layered testa that varied from red to purple in color. The outer layer was the only testa layer that autofl uoresced, suggesting the presence of phenolic acids, i .e., ferulic acid. The aleurone layer was beneath the testa , and was …

Texture And Microstructure Of Soybean Curd (Tofu) As Affected By Different Coagulants, J. M. Deman, L. Deman, S. Gupta

Food Structure

The coagulating properties of five coagulants and the nature of the curd obtained from soymilk was investigated . Viscosity changes during coagulation were studied using a Namctrc Vibrating Sphere Viscometer and texture measurements were made by compression and computer assisted analysis. pH and amount of solids in the whey were determined. The microstructure of the tofu was examined by sca nning electron microscopy. It was observed that CaCI2.2H20 and MgCI2.6H20 coagulaled the milk in stantl y while CaS04 .1/2H20. glucono delta l a~tonc (GOL) and MgS04 .7H20 acted comparatively slowly. The t exture of the curd was greatly influenced by …

The Application Of Light And Scanning Electron Microscopy During Flour Milling And Wheat Processing, R. Moss

Food Structure

Light and scanning electron microscopy have been employed as part of an on-going study on the effect of the milling system on flour composition and quality. Examples are given of some areas where microscopy has been particularly useful in understanding the functional changes that take place during milling or the subsequent processing of the flour . The use of heavy reduction roll pressures was shown to modify gluten protein quality as well as produce the desired increase in starch damage. The use of in-line impact machines not only disrupted flaked flour particles but also fragmented wheat germ and allowed it …

Microstructure Of Spray-Dried And Freeze-Dried Microalgal Powders, L. P. Lin

Food Structure

Chiarella and Spirulina algae were spray-dried and freezedried under several different conditions, and the morphological changes induced were studied by scanning electron microscopy. The internal structure of the particles (granules) was revealed by cryofracturing. The cellular composition of the two algae, method of drying, cell concentration, feed conditions, temperature, and drying times all affected the external morphology of the resulting powders. In the case of spray-drying, at a temperature of 160 °C for 6 sec, the particles shrunk or collapsed; if the drying time was over 10 sec at 160 °C, similar results were observed. The cell concentration affected the …

Microstructural Changes In Winged Bean And Soybean During Fermentation Into Miso, K. Saio, H. Suzuki, T. Kobayashi, M. Namikawa

Food Structure

Miso was prepared from winged bean, being substituted for soybean. Microstructural changes of winged bean miso at various stages of the manufacturing processes were studied by means of light and transmission electron microscopies. Soybean was also studied for comparison.

After steaming , winged bean and soybean cells were shrunken and intracellular spaces enlarged and cell wall structure was degraded, showing layered structures and aggregated lumps in intraspaces between cell walls during fermentation into misc . At the end of the fermentation , the PAS reaction with cell walls almost disappeared. Surprisingly the thick cel l walls of winged bean degraded …

Image Analysis Of Morphological Changes In Wiener Batters During Chopping And Cooking, A. G. Kempton, S. Trupp

Food Structure

Histological changes in wiener batters during chopping and cooking have often been illustrated with "representative" fields . The practice of selecting representative fields ignores variation and leads to word descriptions that cannot be correlated with numerical scores for functional or sensory tests . If wieners are regarded as a multi-component system, objectivity can be achieved by selecting many fields for each sample according to a rigid sampling plan. Image analysis quantified parameters of both the fat and protein components . The reduction in size of fat globules during chopping of a commercial formulation, for example, was a function of area …

Structure And Properties Of The Particulate Constituents Of Human Milk. A Review., M. Ruegg, B. Blanc

Food Structure

Milk contains different types of colloidal or coarsely dispersed particles, such as casein micelles, membrane fragments, fat globules and cells. The fat globules are composed of subpopulations of differently sized particles. In contrast to COW 1S milk, the overall average diameter (dys), increases with advancing lactation from about 1.8 ~min colostrum to 4.0 ~min mature milk. Membrane materials originating from the milk fat globule membrane, plasma membrane, secretory vesicles and other sources can be found in milk serum. These particles have also been called lipoprotein particles. Their size ranges from about 10 - 400 nm. New results concerning the structure …

Microstructure And Rheology Of Process Cheese, Abdelaziz Hassan Rayan

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Four batches of pasteurized process cheese were prepared from the same Cheddar cheese by cooking to 82C in the presence of sodium citrate, disodium phosphate, tetrasodium pyrophosphate or sodium aluminum phosphate. Each batch contained the same moisture (40.6%) and emulsifying salt concentration (2.5%). The process cheese was sampled for microstructural and rheological examination after 0, 5, 10, 20 and 40 min in the cooker at 82C.

Even though each emulsifying salt affected the physical properties of the process cheese differently, the cheese generally became firmer, stiffer, more elastic and less meltable as cooking time increased from 0 to 40 min. …