Mechanical Engineering Commons^™

Electric Bus Systems. A Case Study And Optimization Study, Florida Solar Energy Center, Nan Qin

FSEC Energy Research Center®

Pure electric buses (EBs) offer an alternative fuel for the nation's transit bus systems. To evaluate EBs in a transit setting, this project investigated the five electric bus fleet of the StarMetro transit system of the city of Tallahassee, FL. For the study, the implementing strategy, route distances and timings, charging times, fuel economies, impact of chargers, and maintenance and operational characteristics were analyzed. The results were compared to a baseline five diesel bus fleet. The results showed that even with a four-fold improvement in fuel efficiency, the operational costs of electric buses were only 10% lower than that for …

Fuel Cell Vehicle Technologies Final Report, Florida Solar Energy Center, Nan Qin

FSEC Energy Research Center®

Fuel cell electric vehicles (FCEVs) use hydrogen as fuel and exhaust only water and heat. They provide driving ranges and fueling times comparable to gasoline vehicles. Despite the advantages, FCEVs have been in and out of the spot light of the auto industry for the past several decades. As FCEVs finally moved from concept demonstration to commercialization in 2015, it is critical to analyze the opportunities and challenges this technology brings. This project placed emphasis on four areas: (1) Analysis of the development of FCEVs from a historic and technology point of view; (2) analysis of hydrogen fueling station infrastructure …

Assessing The Sunguide® And Steward Databases, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

This report is a final research report for Assessing the SunGuide® and STEWARD Databases project of the Electric Vehicle Transportation Center (EVTC) at the University of Central Florida (UCF). The Electric Vehicle Transportation Center is a University Transportation Center funded by the Research and Innovative Technology Administration of the U.S. Department of Transportation. The EVTC is a research and education center whose projects prepare the U.S. transportation system for the influx of electric vehicles into a sustainable transportation network and investigate the opportunity these vehicles present to enhance electric grid modernization efforts. The EVTC is led by UCF's Florida Solar …

Pv-Driven Heat Pump Water Heater Final Report, Florida Solar Energy Center, Carlos Colon

FSEC Energy Research Center®

As part of the effort towards zero energy buildings and high efficiency water heating systems, the Florida Solar Energy Center (FSEC) working under contract with the National Renewable Energy laboratories (NREL) has successfully completed a demonstration of a photovoltaic heat pump water heater (PV-HPWH) concept. The system integrates two 310Wp solar photovoltaics (PV) modules and grid tied micro-inverters with a commercially available 50-gallon HPWH. The project showcases innovative strategies for distributed PV thermal systems that limit grid interaction and provide increased thermal energy storage. The system utilizes a custom appliance control module (ACM) interface to vary thermostat settings (115 °F …

Electric Vehicle Charging Technologies Analysis And Standards, Florida Solar Energy Center, J. Doug Kettles

FSEC Energy Research Center®

This project has evaluated the technologies and standards associated with Electric Vehicle Service Equipment (EVSE) and the related infrastructure, and the major cost issue related to electric vehicle (EV) charging -- the cost of utility power. The technology assessment report evaluated safety standards for infrastructure, highway and vehicles and the barriers and challenges of deploying an expanded network of EV charging stations. The report also made recommendations to help standardize and expedite EVSE infrastructure and charging network deployment.

Cost Effectiveness Of Energy Efficiency And On-Site Photovoltaic Power For 2015 International Energy Conservation Code Eri (Energy Rating Index) Compliance, Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

EnergyGauge® USA v.5.1 is used to simulate the energy use of one-story, three bedroom, 2000 ft², single-family, frame homes in sixteen representative U.S. climates comprising all eight IECC climate zones. The energy use of the Section R406.2 minimum efficiency home (the Baseline Home) is compared against the energy use of homes complying with the prescriptive requirements of Section R402 of the 2015 IECC and against homes complying with the Section R406 Energy Rating Index (ERI) Compliance Alternative. The improvement cost and energy savings of the improved homes relative to the Baseline Home are then used to determine the cost effectiveness …

Implications Of Electric Vehicle Penetration On State And Federal Highway Revenues, Florida Solar Energy Center, Kevin Schleith

FSEC Energy Research Center®

This report summarizes the results of research conducted to determine if current and near future electric vehicle (EV) sales will have an impact on motor fuel tax revenues as part of the Federal Highway Trust Fund (HTF). Gasoline and diesel fuel taxes account for $31.1 billion or about 87% of the HTF. The project results were accomplished by conducting a review of existing industry and government reports that detail fuel tax revenues and an analysis of EV sales from 2010 through 2016. Results show, that as of January 2017, the lost fuel tax revenue from EV sales of 560,000 vehicles …

Electric Vehicle Life Cycle Cost Analysis, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

This project compared total life cycle costs of battery electric vehicles (BEV), plug-in hybrid electric vehicles (PHEV), hybrid electric vehicles (HEV), and vehicles with internal combustion engines (ICE). The analysis considered capital and operating costs in order to present an equal comparison of differing vehicles. The analysis also included photovoltaic (PV) and workplace charging options. The overall goal was to define the total vehicle cost of ownership over 5, 10, 15, and 20 year life expectancies. The developed life cycle cost computer program will allow any individual to compare life cycle costs of any vehicle.

Comparative Performance Of Two Ventilation Strategies In A Hot-Humid Climate, Florida Solar Energy Center, Sarah Widder

FSEC Energy Research Center®

ASHRAE Standard 62.2, 'Ventilation and Indoor Air Quality in Low-Rise Buildings,' is the most commonly referenced residential ventilation standard in the United States. It is currently required by ENERGY STAR Version 3 (V3), the 2012 International Energy Conservation Code, the U.S. Department of Energy's Zero Energy Ready Home Program, many state weatherization programs, and many other home performance programs. The standard calls for ventilation levels that are perceived by some builders and contractors to cause indoor moisture issues in hot-humid climates unless mitigated by supplemental dehumidification systems, which increase overall energy consumption. Therefore, many high-performance home builders in a hot-humid …

Economic Impacts Of Electric Vehicle Adoption, Florida Solar Energy Center, Makena Coffman

FSEC Energy Research Center®

The objective of the Economic Impacts of Electric Vehicle Adoption research project was to examine the predicted levels of electric vehicle (EV) adoption, to analyze the life cycle costs of EVs compared to internal combustion engine vehicles and to evaluate EV impacts on GHG emissions for Hawaii. The results were presented in three publications. The first report evaluated EV penetration rates and provided an assessment of expected EV penetration over time. The research also assessed factors that affect EVs adoption, including regulatory mechanisms. The results estimated there will be 140,000 EVs on the road in Hawaii by the year 2040 …

Florida Rural Small Business Energy Assistance Collaborative Cumulative Report Ending December 31, 2016, Florida Solar Energy Center, Janet Mcilvaine

FSEC Energy Research Center®

The U.S. Department of Agriculture's (USDA) Rural Development initiative reaches out to communities across America with many programs (http://www.rd.usda.gov/programs-services/all-programs). USDA's Rural Energy for America Program (REAP) offers grants and loan guarantees for energy efficiency improvements and renewable energy systems to agriculture operations and qualifying rural small businesses. USDA has awarded the University of Central Florida a grant to provide a limited number of subsidized Energy Audits to eligible businesses in Florida in support of USDA Rural Development (USDA-RD) Grant and Loan programs for rural small businesses. The ultimate goal of the energy audits is to increase participation in REAP. Audits …

Phased Retrofits In Existing Homes In Florida Phase Ii: Shallow Plus Retrofits [Revised], Florida Solar Energy Center, Karen Sutherland

FSEC Energy Research Center®

The U.S. Department of Energy Building America team Partnership for Improved Residential Construction is collaborating with Florida Power & Light Company (FPL) to conduct a phased residential energy-efficiency retrofit program. This research seeks to determine the impacts on annual energy reductions from the installation of advanced residential technologies. Earlier project work involving the application of two levels of retrofit, shallow and deep, found average savings of 9% and 38%, respectively. Whole-house demand reduction among the deep retrofit homes averaged 39% during FPL's peak summer hour. These savings levels approach the Building America program goals of reducing whole-house energy use of …

Energy-Efficient Management Of Mechanical Ventilation And Relative Humidity In Hot-Humid Climates, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

The U.S. Department of Energy's Building America research team Building America Partnership for Improved Residential Construction conducted this research project to gain data and insight into these issues. The project focused on energy-efficient management of mechanical ventilation and RH during the cooling season. It consisted of eight test configurations. A particular focus evaluated how well a ductless seasonal energy-efficiency ratio (SEER) 21.5 mini-split heat pump (MSHP) could perform as the primary cooling system without a dehumidifier for supplemental dehumidification in a continuously mechanically ventilated house.

Effect Of Ducted Hpwh On Space-Conditioning And Water Heating Energy Use - Central Florida Lab Home, Florida Solar Energy Center, Carlos Colon

FSEC Energy Research Center®

The purpose of this research is to investigate the impact of ducted heat pump water heaters (HPWHs) on space-conditioning and water heating energy use in residential applications. Two identical HPWHs, each with a capacity of 60 gal, were tested side by side at the Flexible Residential Test Facility (FRTF) laboratories on the Florida Solar Energy Center (FSEC) campus in Cocoa, Florida. The FRTF's residential buildings feature the same square footage (1,535 ft2 ), orientation, and envelope characteristics; currently, the only difference between them is the finished floor material. The east FRTF building is furnished with standard carpet flooring, whereas the …

Ev Workplace Charging Energy Use And Cost Case Study, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

Efforts to increase the availability of plug-in electric vehicle (PEV) charging stations have focused on expanding public charging stations, promoting charging at the workplace and using charging stations as a shopping incentive for retail stores. This report examines the costs and energy uses to provide the charging service. Rapidly charging a PEV requires expensive electric equipment and can lead to high operating costs due to electrical demand charges. This project presents results from a detailed case study for 5 PEV chargers where the charger electricity costs are a part of a facilities electric bill. Also presented are options for minimizing …

Comparison Of The Modes And Mechanisms Of Degradation Of Experimental C-Si Pv Modules With Various Encapsulants, October 2016, Florida Solar Energy Center, Neelkanth Dhere

FSEC Energy Research Center®

Seven modules with different encapsulants, provided by the National Renewable Energy Laboratory (NREL), were installed at the Florida Solar Energy Center (FSEC) outdoor test facility for long-term durability testing in the hot and humid climate of Florida. Along with the modules, NREL also provided corresponding load resistors, junction boxes, and module connections. The modules were installed at latitude tilt, on a south facing rack on March 20, 2014.During project different types of tests such as visual inspection in environmental conditions and infrared imaging and I-V characterization were carried out on the seven module

Cost Analysis Of Workplace Charging For Electric Vehicles, Florida Solar Energy Center, Richard Raustad

FSEC Energy Research Center®

This report examines the life-cycle costs associated with the operation of electric vehicle supply equipment (EVSE) and the impact that plug-in electric vehicle (PEV) charging may have on commercial building electricity cost. This study assumed that a utility electric meter was attached to each charging station and that 10 kWh of energy was required to replenish the energy consumed during a typical 35-mile daily work commute. Through a life-cycle assessment of typical EVSE equipment, including first cost and maintenance and operating costs, it was found that AC Level 1 or 2 workplace charging can be similar to or lower in …

Lennar Ventures Power Purchase Agreement Analysis, Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

An analysis was performed to determine the cost-effectiveness of photovoltaic (PV) system Power Purchase Agreements for prototype homes in 13 United States climate locations. EnergyGauge® USA v.5.1 software was used to simulate the energy use of one-story, three-bedroom, 2000 ft² , single-family, frame prototype homes in thirteen representative U.S. climates comprising six IECC climate zones. The same software was used to simulate the power production of PV systems designed to provide approximately 75% of the annual electric energy required by the prototype homes. The net present value (NPV) of the photovoltaic PPA was then calculated as the difference in …

Evaluation Of The Impact Of Slab Foundation Heat Transfer On Heating And Cooling In Florida, Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

The U.S. Department of Energy's Building America Partnership for Improved Residential Construction (BA-PIRC) performed experiments in the Florida Solar Energy Center's Flexible Residential Test Facility intended to assess for the first time (1) how slab-on-grade construction influences interior cooling in a cooling-dominated climate and (2) how the difference in a carpeted versus uncarpeted building might influence heating and cooling energy use.

Final Report: Cooling Seasonal Energy And Peak Demand Impacts Of Improved Duct Insulation On Fixed-Capacity (Seer 13) And Variable-Capacity (Seer 22) Heat Pumps, Florida Solar Energy Center, Charles Withers, Jr.

FSEC Energy Research Center®

Previous phase 1, 2, and 3 research identified that duct conductive losses to an attic environment imposed greater relative energy losses for the variable-capacity systems compared to the fixed-capacity systems (Cummings and Withers 2011) because of the longer dwell time of conditioned air in the ducts. The purpose of the Phase 4 experiments reported here was to see if duct R-value enhancement would benefit the overall operating efficiency of the variable-capacity system relatively more than the fixed-capacity system. The current Phase 4 experiments (the primary focus of this report) found that this was a secondary effect.

Flexible Residential Test Facility: Impact Of Infiltration And Ventilation On Measured Cooling Season Energy And Moisture Levels (2016), Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

Originally published in January 2014, this revision of the report clarifies and corrects references to Standard 62.2 as the 2013 version (62.2-2013), and it corrects the total CFM requirement for the subject buildings under the standard. Further, two plots have been updated to distinguish between the mechanical CFM and the total CFM required for the subject buildings under Standard 62.2-2013.

Florida Rural Small Business Energy Assistance Collaborative Cumulative Report Ending July 31, 2016, Florida Solar Energy Center, Janet Mcilvaine

FSEC Energy Research Center®

The U.S. Department of Agriculture's (USDA) Rural Development initiative reaches out to communities across America with many programs (http://www.rd.usda.gov/programs-services/all-programs). USDA's Rural Energy for America Program (REAP) offers grants and loan guarantees for energy efficiency improvements and renewable energy systems to agriculture operations and qualifying rural small businesses. USDA has awarded the University of Central Florida a grant to provide a limited number of subsidized Energy Audits to eligible businesses in Florida in support of USDA Rural Development (USDA-RD) Grant and Loan programs for rural small businesses. The ultimate goal of the energy audits is to increase participation in …

Cost Effectiveness Of Energy Efficiency And On-Site Photovoltaic Power For 2015 Iecc Energy Rating Index (Eri) Compliance (Draft), Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

EnergyGauge® USA v.5.1 is used to simulate the energy use of one-story, three-bedroom, 2000 ft² , single-family, frame homes in sixteen representative U.S. climates comprising all eight IECC climate zones. The energy use of the Section R406.2 minimum efficiency home (the Baseline Home) is compared against the energy use of homes complying with the prescriptive requirements of Section R402 of the 2015 IECC and against homes complying with the Section R406 Energy Rating Index (ERI) Compliance Alternative. The improvement cost and energy savings of the improved homes relative to the Baseline Home are then used to determine the cost …

2015 Electric Vehicle Market Summary And Barriers, Florida Solar Energy Center, David L. Block

FSEC Energy Research Center®

The object of this research report is to present the current market status of plug-in-electric vehicles (PEVs) and to predict their future penetration within the world and U.S. markets. The sales values for 2015 show that China leads in yearly sales at 214,283 (triple increase for 2014) followed by Western Europe at 184,500 vehicles sold. The U.S. is third at 115,262 followed by Japan at 46,339 vehicles. These four countries comprise 95% of the global sales market. The world total of EV sales for 2015 is estimated to be 565,668 up from 315,519 in 2014. This data also shows that …

Evaluating The Economic Impacts Of The Legislatively Delayed Provisions Of The 5th Edition (2014) Florida Building Code (Final Report), Florida Solar Energy Center, Robin Vieira

FSEC Energy Research Center®

This research provides an assessment of the potential economic impacts of implementing three legislatively delayed requirements of the Florida Building Code, 5th Edition (2014): 1) residential air leakage testing, 2) residential whole-house mechanical ventilation, and 3) two fire service access elevators for applicable buildings.

Automated, Autonomous And Connected Vehicle Technology Assessment, Florida Solar Energy Center, David L. Block

FSEC Energy Research Center®

The U.S. Department of Transportation (USDOT) and almost every state DOT are showing extreme interest in the application of automated and connected vehicles (ACV). This combined application can significantly reduce crashes, energy consumption, pollution and the costs of congestion which in turn will offer a fundamental change to the U.S. transportation network and system. The objective of this technology assessment project is to evaluate the vehicle technologies, actions, laws and policies that are now in place and to assess their future usage. The assessment also evaluates the highest level of automated vehicles called autonomous or self-driving vehicles. In fact, autonomous …

Comprehensive Modeling Of Optimal Paths To Reach Nearly Zero Energy Buildings (Nzebs) For New Constructions In Europe, Florida Solar Energy Center, Delia D'Agostino

FSEC Energy Research Center®

As established by the recast of the European Union (EU) Directive on Energy Performance of Buildings (EPBD), all new buildings have to be nearly zero energy buildings (nZEBs) by the end of 2020. However, reaching this result considering cost-optimality is still an open challenge. Balancing renewable power generation with energy efficiency to reach the nZEB target is a key goal of all EU Member States. We describe results obtained from the modeling of nZEBs for new constructions in Europe using the energy performance software EnergyPlus. The model performs hourly sequential simulations showing how to best achieve nearly zero energy home …

Phased Retrofits In Existing Homes In Florida Phase I: Shallow And Deep Retrofits (February 2016), Florida Solar Energy Center, Danny Parker

FSEC Energy Research Center®

The U.S. Department of Energy's Building America research team Building America Partnership for Improved Residential Construction is collaborating with Florida Power & Light (FPL) to conduct a phased residential energy-efficiency retrofit program. This research seeks to establish impacts on annual energy and peak energy reductions from the technologies applied at two levels of retrofit--shallow and deep--with savings levels that approach the Building America program goal of reducing whole-house energy use by 40%.

Relationship Between The Home Energy Score (Hes) And The Home Energy Rating System (Hers), Florida Solar Energy Center, Philip W. Fairey

FSEC Energy Research Center®

A significant cohort of approximately 2,900 registered home energy ratings using the REM/Rate HERS software tool, as reported to RESNET, are subjected to statistical analysis by the Dillon Group, Inc. The statistical analysis determines the distribution of HES results as a function of home energy efficiency as measured by the minimum standards of the 2009 IECC and by EPA’s ENERGY STAR program.

In addition, a parametric simulation analysis is conducted by the Florida Solar Energy Center using EnergyGauge® USA version 5.0, a RESNET-accredited HERS software tool, to determine the relationship between HES scores and the HERS Index. The parametric analysis …

Implications Of Electric Vehicles On Gasoline Tax Revenues, Florida Solar Energy Center, Kevin Schleith

FSEC Energy Research Center®

This report summarizes the results of research conducted to determine if current and near future EV sales will have an impact on gasoline (gas) tax revenues as part of the Federal Highway Trust Fund (HTF). Gasoline taxes account for $31.1 billion or about 87% of the HTF. The project results were accomplished through a review of existing industry and government reports that detail fuel tax revenues and through analysis of EV sales from 2010 to 2015.