Catalysis and Reaction Engineering Commons^™

Synthesis And Investigation Of Tungsten–Copper Oxide Composites For Enhanced Photocatalytic Applications, Janak Paudel, John Nichols

Research and Creative Works Expo

No abstract provided.

Development Of A Metal-Based Catalyst For The Ammonia Dehydrogenation Reaction, Othman Mohammed Abdullah Al-Amodi

Thesis/ Dissertation Defenses

Developing cost-effective and active catalysts that would replace noble metals is desirable for the ammonia decomposition reaction. Hence, this thesis focuses on the development and evaluation of a 10Ni/0.75TiO2-0.25CeO2 catalyst for ammonia decomposition, a promising route to carbon-free hydrogen production. The system parameters investigated include the effect of reaction temperature (550, 650, and 750°C) and the catalyst mass (100, 200, and 300 mg) on the performance of the ammonia decomposition process. The primary objective of this work is to investigate how catalyst composition and metal-support interactions influence activity, hydrogen production, and ammonia conversion. Catalysts were prepared by the incipient wetness …

Identification Of Proximal And Isolated Aluminum Heteroatoms In Zeolites By Infrared Spectroscopy, Melanie A. Brunet Torres, Philip Kester, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

High demand for energy production and limited fossil fuel reserves are two factors that motivate intense research for new alternative energy resources. While we are still far from completely moving to renewable energy solutions, a new solution that replaces crude oil and coal with shale gas is currently under investigation. For this modern technology, new zeolite catalysts need to be developed for the conversion of light hydrocarbons gases to liquid transportation fuels. These catalysts are of special interest in the production of liquid fuels since they exhibit high reaction rates, molecular sieving properties and selectivity behavior. In this work, the …

Platinum-Gallium (Pt-Ga) Intermetallic Alloys For Propane Dehydrogenation, Brittany K. Roopnarine, Nicole J. Libretto, Johnny Zhuchen, Zhenwei Wu, Evan Wegener, Griffin Canning, Abhaya K. Datye, Jeffrey T. Miller

The Summer Undergraduate Research Fellowship (SURF) Symposium

Natural gas is a source of energy for the United States. The Center for Innovative Strategic Transformation of Alkane Resources (CISTAR) plans to use shale gas extracted from shale rock formations as a bridge fuel to replace coal and oil while the US transitions to renewable energy like solar and wind. After methane, the largest components in shale gas are light alkanes such as ethane and propane. These can be catalytically converted to olefins, which can be further reacted to produce fuels, for example. Olefins from alkanes can be accomplished by dehydrogenation by promoted platinum alloys. This study compares the …

Investigation Of The Effects Of Solid-State Treatments On The Structure And Mobility Of Copper In Zeolites, Jiayang Wu, Laura Wilcox, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

Zeolites are microporous, aluminosilicate catalysts that play an important role in industrial applications as well as studies for the fundamental understanding of catalysts for emerging reactions of interest. The introduction of aluminum into the zeolite lattice introduces a negative charge on the framework that can be balanced with extra-framework cations. The control of the aluminum distribution and the choice of charge balancing cations allows for the ability to tailor the active sites to facilitate a desired reaction. This research focuses on studying copper active sites in zeolites. Copper oxide was used as a copper precursor to introduce copper ions in …

Computational Catalysis: Creating A User-Friendly Tool For Research And Education, Kevin P. Greenman, Peilin Liao

The Summer Undergraduate Research Fellowship (SURF) Symposium

Catalysis is used in a significant portion of production processes in the industrialized world, including most processing of chemicals and fuels. This makes maximizing the efficiency of catalysts a high priority. However, the immense number of candidates for new catalysts precludes the possibility of testing all of them by experiments. Density functional theory (DFT) has been widely and successfully used to calculate material properties relevant to catalysis and to screen promising candidates for experimental testing, but there currently exists no publicly- available, user-friendly tool for performing these DFT calculations. This work details the development of such a tool for nanoHUB.org …

Scaling Relationships Across Chemically Related Adsorbates For Fast Screening Of Alloy Catalysts For Propane Dehydrogenation, Anne Esther Serban, Ranga Rohit Seemakurthi, Brandon C. Bukowski, Jeffrey Greeley

The Summer Undergraduate Research Fellowship (SURF) Symposium

A catalyst is a material which speeds up the rate of a specific reaction. A reaction that is of significant importance to the chemical industry is the selective transformations of light alkanes (ethane, propane), which are largely available in shale gas, to olefins. These olefins can then be converted into higher-value chemicals, materials, and fuels. However, there are several undesired reactions that take place alongside the main dehydrogenation reaction, so a catalyst of high selectivity is desired. Apart from the industrially used PtSn catalyst, work by our experimental collaborators has shown that various other Pt and Pd alloys (In, Zn) …

What Happens To Nox Emissions Of Vw Diesel Cars When Water/Methanol Injection Is Used?, Andrew Croxell

ASA Multidisciplinary Research Symposium

Volkswagen has come under fire for their "Clean Diesel" automobiles that were found to emit too much NOx (Oxides of Nitrogen) when driven on the street. Since NOx is created by high temperature combustion events, the addition of a water/methanol injection system was tested on a VW diesel vehicle to identify if it could cool combustion temperatures and thus reduce NOx to an acceptable specification.

Modeling The Aqueous-Phase Copper Ion-Exchange Behavior Onto Ssz-13 Zeolites, Brian N. Bayer, Rajamani Gounder, Trevor M. Lardinois

The Summer Undergraduate Research Fellowship (SURF) Symposium

Copper-exchanged zeolites are utilized as catalysts for the selective catalytic reduction of nitrogen oxides, which are atmospheric pollutants found in diesel engine exhaust. The total amount of copper ions and the types of copper species (Cu(II) or Cu(II)OH) exchanged onto a zeolite can be varied. Copper is exchanged onto SSZ-13 (an aluminosilicate zeolite with the chabazite topology) during a process known as aqueous ion exchange, where the zeolite is mixed in a copper-containing solution. The distribution of copper on SSZ-13 is influenced by exchange conditions, including the molarity, temperature, and pH of the copper solution. The effect of exchange conditions …

Numerical Simulation On The Combustion Characteristic Of Iron Ore Sintering With Flue Gas Recirculation, Gan Wang, Zhi Wen, Guofeng Lou, Ruifeng Dou, Xunliang Liu, Fuyong Su, Sizong Zhang

The 8th International Conference on Physical and Numerical Simulation of Materials Processing

No abstract provided.

Study Of Poisoning Mechanism Of Hg And As On V2o5–Wo3/Tio2 Scr De-Nox Catalysts, Qingcai Liu, Ming Kong, Lu Yao, Shan Ren, Jian Yang

The 8th International Conference on Physical and Numerical Simulation of Materials Processing

No abstract provided.

Hydrophobic Zeolites For Applications In Adsorption And Catalysis, Zige Huang, Michael Cordon, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

Lewis acidic zeolites such as Sn-Beta are commonly studied for use as selective catalysts for glucose isomerization to fructose in liquid water. Glucose to fructose isomerization is a critical reaction for lignocellulosic biomass upgrading, which converts abundant and renewable feedstocks into commercially desirable fuels and chemicals.

Industrial applications require catalysts that maintain optimal reactivity over long time scales, yet at typical reaction temperatures, Lewis acidic Beta zeolites are known to deactivate in liquid water through poorly understood mechanisms. Recent work in our group has shown that interactions between water and Sn-Beta zeolites can cause leaching of active Sn sites from …

Quantification And Characterization Of Aluminum Distributions In Commercial Beta And Mordenite Zeolites By Cobalt Exchange, Rebecca L. Reitzel, Claire T. Nimlos, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

The aluminum distribution throughout the zeolite framework determines the structural, ion-exchange and catalytic properties of the zeolite. Several methods have been proposed to control the Al distribution, but in order to accurately assess these methods a procedure is needed to quantify Al distribution in various zeolite frameworks. Co²⁺ ions exchange onto the zeolite framework at Al pairs, and atomic absorbance spectroscopy (AAS) can be used to quantify the number of exchanged Co²⁺ ions and, in turn, the overall number of Al pairs. Each framework exhibits differences in pore size and channel configuration which affect the equilibrium conditions needed …

Pt-Cu Catalysts For Catalytic Dehydrogenation Of Alkanes For Energy Production, Zixue Ma, Zhenwei Wu, Jeffrey T. Miller

The Summer Undergraduate Research Fellowship (SURF) Symposium

More active, selective and stable catalysts are in demand to increase the yields of olefins production from light alkane dehydrogenation. Cu was reported to promote Pt catalysts and Pt-Cu catalysts has been shown to achieve increased olefin selectivity and decreased deactivation rate. Pt-Cu catalysts with different Pt:Cu molar ratios may have different crystal structure and performance. This study seeks to understand of the promotion effect of Cu on Pt alkane dehydrogenation catalysts. Four different Pt-Cu catalysts with different atomic ratios were prepared and tested for propane dehydrogenation at 550℃. Synchrotron in situ X-ray diffraction and X-ray absorption spectroscopy are used …

Determining Glucose Isomerization Mechanisms On Lewis Acidic Beta Zeolites Using Isotropic Tracer Studies And 1h Nmr, Jacklyn N. Hall, Michael J. Cordon, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

Biofuels synthesized from biomass sources are becoming necessary for sustainable production due to their significantly lower net CO₂ production than fuels synthesized from fossil-based carbon sources such as petroleum. Catalytic pathways for the primary biomass-to-biofuels reaction pathway include the isomerization of glucose to fructose, which can be catalyzed by either Lewis acids or bases. Isolated metal atoms and metal oxide particles on Beta zeolites serve as active sites that catalyze this reaction through a Lewis acid 1,2-intramolecular hydride shift or by a Lewis base proton transfer mechanism, respectively. The Lewis acid mechanism has proven to have higher fructose selectivity …

Platinum-Bismuth Bimetallic Catalysts: Synthesis, Characterization And Applications, Jose A. Saucedo Jr, Yang Xiao, Arvind Varma

The Summer Undergraduate Research Fellowship (SURF) Symposium

Bimetallic catalysts have been explored and shown to exhibit unique characteristics which are not present in monometallic catalysts. Platinum is well known as an effective catalyst for oxidation and reduction reactions, and it can be made more effective when bismuth is introduced as a promotor. Thus, the effectiveness of the Pt-Bi catalyst was demonstrated in prior work. What is not clear, however, is the mechanism behind the catalyst function; why addition of bismuth to platinum decreases deactivation and increases selectivity, and how effective would the Pt-Bi catalyst be in deoxygenation reactions? In this work, the effectiveness of different variations of …

Catalysis In Petroleum Coking, Robert Khakimov, Anya Heinimann, Enrico Martinez, Hyun-Tae Hwang

The Summer Undergraduate Research Fellowship (SURF) Symposium

The petroleum industry is challenged with the processing of present heavy crudes caused by high composition of sulfur and metals, which lead to a higher yield of unfavorable bottom product as vacuum residue. Vacuum residue is the least valuable fraction of four, such as saturates, aromatics, resins and asphaltenes. However, it can be upgraded to recover more valuable products such as light hydrocarbons. The Delayed Coking process is going to be used to transform the vacuum residue at different experimental conditions. First of all, the behavior of the vacuum residue needs to be analyzed with no additions in feedstock. Secondly, …

The Catalysis Of Delayed Petroleum Coking, Anya M. Heinimann, Robert Khakimov, Hyun-Tae Hwang, Enrico N. Martinez

The Summer Undergraduate Research Fellowship (SURF) Symposium

Due to the decreasing crude oil quality (heavier crudes and increasing contaminant concentrations) methods for upgrading residues from the refining process, such as coking, are becoming increasingly important. Delayed coking, a method by which residues are thermally cracked (large heavy molecules broken into smaller lighter molecules), produces liquid products and solid coke which can both be sold for further profit. In order to increase the amount of liquid products produced since they are the most value added product of the coking process catalysts (platinum on 0.5% alumina and nickel (skeletal),molybdenum promoted (1 wt%)) were tested to see how they would …

Synthesis And Characterization Of Microporous And Mesoporous Catalysts For Shale Gas Upgrading, Danesh Contractor, Ravi Joshi, Rajamani Gounder

The Summer Undergraduate Research Fellowship (SURF) Symposium

The petroleum industry is gradually shifting from using naphtha to ethane as its feedstock and new ethane steam crackers are being built. Using ethane as a feedstock produces more ethene and less co-products such as propene, aromatics and C4 alkenes. Thus, the shift in feedstock will reduce the availability of these co-products. Developing methods for the interconversion of alkenes, and specifically using ethene as a reactant, can solve this problem.

This project focuses on synthesis and characterization of zeolites with the BEA framework topology, and their nickel exchanged versions as potential ethene dimerization catalysts. In future work, these materials will …

The Role Of Surface Area In Catalytic Gasification Of Biomass, Elizabeth A. Wachs, Nitish Kumar, Indraneel Sircar, Prithviraja Basak, Jay P. Gore Phd

The Summer Undergraduate Research Fellowship (SURF) Symposium

Gasification of biomass has the potential to provide a carbon-negative source of liquid fuels. The current limited use of gasification is due in part to the high temperatures necessary to achieve high conversion levels. These temperatures can be lowered by the use of catalysts, but the mechanisms by which catalysts affect the reaction rate are not fully understood. Here, the structural component of potassium carbonate’s role in the gasification process was examined. Samples of pinewood sawdust were impregnated with potassium carbonate, then pyrolyzed with N2 in a fixed bed reactor at 750°C (heater thermocouple reading). Half of the char was …

Experimental Study Of Co2 Recycling Using Metal-Oxide Enhanced Coconut Char Gasification: Catalytic Effect Of Potassium Carbonate On Gasification, Mengqi Gao, Indraneel Sircar, Jay P. Gore

The Summer Undergraduate Research Fellowship (SURF) Symposium

Biomass gasification is an important process in the production of bio-derived fuels and renewable energy. Biomass gasification with CO₂ is an endothermic process requiring high temperatures, resulting in low process-efficiency. Metals found in the ash in biomass feedstock have shown rate-promoting effects on the C-CO₂ reaction and have motivated the study of low-temperature catalytic gasification. The present study investigates the catalytic effects of potassium (K) on the biomass gasification reactivity of a coconut-derived char (>99.9% carbon) within the temperature range of 600 – 1000 ^oC. A wet-impregnation technique is used to prepare K-treated chars. Gasification of …