Catalysis and Reaction Engineering | Open Access Articles

Size-Controlled Large-Diameter And Few-Walled Carbon Nanotube Catalysts For Oxygen Reduction, Xianliang Wang, Qing Li, Hengyu Pan, Ye Lin, Yujie Ke, Haiyang Sheng, Mark T. Swihart, Gang Wu

Faculty Publications

We demonstrate a new strategy for tuning the size of large-diameter and few-walled nitrogen-doped carbon nanotubes (N-CNTs) from 50 to 150 nm by varying the transition metal (TM = Fe, Co, Ni or Mn) used to catalyze graphitization of dicyandiamide. Fe yielded the largest tubes, followed by Co and Ni, while Mn produced a clot-like carbon morphology. We show that morphology is correlated with electrocatalytic activity for the oxygen reduction reaction (ORR). A clear trend of Fe > Co > Ni > Mn for the ORR catalytic activity was observed, in both alkaline media and more demanding acidic media. The Fe-derived N-CNTs exhibited …

Go to article

Enhancing Grain Boundary Ionic Conductivity In Mixed Ionic–Electronic Conductors, Ye Lin, Shumin Fang, Dong Su, Kyle S. Brinkman, Fanglin Chen

Faculty Publications

Mixed ionic–electronic conductors are widely used in devices for energy conversion and storage. Grain boundaries in these materials have nanoscale spatial dimensions, which can generate substantial resistance to ionic transport due to dopant segregation. Here, we report the concept of targeted phase formation in a Ce0.8Gd0.2O2−δ–CoFe2O4 composite that serves to enhance the grain boundary ionic conductivity. Using transmission electron microscopy and spectroscopy approaches, we probe the grain boundary charge distribution and chemical environments altered by the phase reaction between the two constituents. The formation of an emergent phase successfully avoids segregation of the Gd dopant and depletion of oxygen vacancies …

Go to article

Investigating The Stability Of Eliposomes At Elevated Temperatures, Ghaleb A. Husseini, William G. Pitt, Marjan Javadi

Faculty Publications

eLiposomes encapsulate a perfluorocarbon nanoemulsion droplet inside a liposome. Ultrasound is then used as a trigger mechanism to vaporize the perfluorocarbon, break the liposome, and release the desired drug to the tumor tissue. The purpose of this research is to show that eLiposomes synthesized using perfluoropentane are stable above the normal boiling point of the perfluoropentane and at body temperature and thus has potential for use in vivo. Experiments involving the release of fluorescent calcein molecules were performed on eLiposomes to measure the release of calcein at various temperatures in the absence of ultrasound. Results showed that eLiposomes are stable …

Go to article

Influence Of Crystal Structure On The Electrochemical Performance Of A-Site-Deficient Sr 1-Xnb 0.1 Co 0.9 O 3-Δ Perovskite Cathodes, Yinlong Zhu, Ye Lin, Xuan Shen, Jaka Sunarso, Wei Zhou, Shanshan Jiang, Dong Su, Fanglin Chen, Zongping Shao

Faculty Publications

The creation of A-site cation defects within a perovskite oxide can substantially alter the structure and properties of its stoichiometric analogue. In this work, we demonstrate that by vacating 2 and 5% of A-site cations from SrNb_0.1Co_0.9O_3−δ (SNC1.00) perovskites (Sr_1−sNb_0.1Co_0.9O_3−δ, s = 0.02 and 0.05; denoted as SNC0.98 and SNC0.95, respectively), a Jahn–Teller (JT) distortion with varying extents takes place, leading to the formation of a modified crystal lattice within a the perovskite framework. Electrical conductivity, electrochemical performance, chemical compatibility and microstructure of Sr …

Go to article

Phase Transitions Of Perfluorocarbon Nanoemulsion Induced With Ultrasound: A Mathematical Model, William G. Pitt, Ram N. Singh, Krystian X. Perez, Ghaleb A. Husseini, Daniel R. Jack

Faculty Publications

While ultrasound has been used in many medical and industrial applications, only recently has research been done on phase transformations induced by ultrasound. This paper presents a numerical model and the predicted results of the phase transformation of a spherical nanosized droplet of perfluorocarbon in water. Such a model has applications in acoustic droplet vaporization, the generation of gas bubbles for medical imaging, therapeutic delivery and other biomedical applications. The formation of a gas phase and the subsequent bubble dynamics were studied as a function of acoustic parameters, such as frequency and amplitude, and of the physical aspects of the …

Go to article

Self-Healing Catalysts: Co3O4 Nanorods For Fischer-Tropsch Synthesis, Cun Wen, Darrius D. Dunbar, Xin Zhang, Jochen A. Lauterbach, Jason R. Hattrick-Simpers

Faculty Publications

We combine kinetic and spectroscopic data to demonstrate the concept of a self-healing catalyst, which effectively eliminates the need for catalyst regeneration. The observed self-healing is triggered by controlling the crystallographic orientation at the catalyst surface.

Go to article

One-Step Production Of Long-Chain Hydrocarbons From Waste-Biomass-Derived Chemicals Using Bi-Functional Heterogeneous Catalysts, Cun Wen, Elizabeth A. Barrow, Jason R. Hattrick-Simpers, Jochen A. Lauterbach

Faculty Publications

n this study, we demonstrate the production of long-chain hydrocarbons (C₈₊) from 2-methylfuran (2MF) and butanal in a single step reactive process by utilizing a bi-functional catalyst with both acid and metallic sites. Our approach utilizes a solid acid for the hydroalkylation function and as a support as well as a transition metal as hydrodeoxygenation catalyst. A series of solid acids was screened, among which MCM-41 demonstrated the best combination of activity and stability. Platinum nanoparticles were then incorporated into the MCM-41. The Pt/MCM-41 catalyst showed 96% yield for C₈₊ hydrocarbons and the catalytic performance was stable …

Go to article

Solid Oxide Fuel Cells With Both High Voltage And Power Output By Utilizing Beneficial Interfacial Reaction, Chao Su, Zongping Shao, Ye Lin, Yuzhou Wu, Huanting Wang

Faculty Publications

An intriguing cell concept by applying proton-conducting oxide as the ionic conducting phase in the anode and taking advantage of beneficial interfacial reaction between anode and electrolyte is proposed to successfully achieve both high open circuit voltage (OCV) and power output for SOFCs with thin-film samarium doped ceria (SDC) electrolyte at temperatures higher than 600 °C. The fuel cells were fabricated by conventional route without introducing an additional processing step. A very thin and dense interfacial layer (2–3 μm) with compositional gradient was created by in situ reaction between anode and electrolyte although the anode substrate had high surface roughness …

Go to article

Investigation Of Carbon Corrosion Resistance Of Cnt Containing Electrode, Diana Larrabee, William A. Rigdon, Eli Mcpherson, Joshua Sightler, Xinyu Huang

Faculty Publications

Carbon support corrosion is one of the major degradation mechanisms of polymer electrolyte membrane (PEM) fuel cell. Carbon oxidation occurs in PEM electrode and is accelerated at high potential created by adverse operating conditions and improper distribution of reactants and products [1, 2, 3]. Carbon corrosion can lead to the thinning of the electrode layer and severe performance degradation. The detailed mechanisms of carbon support corrosion induced performance loss are still not fully understood; it is believed that the following events contribute to the decay: (1) structural collapse of the porous electrode due to the loss of carbon; (2) carbon …

Go to article

Application Of Electrospinning Technique In The Fabrication Of A Composite Electrode For Pemfc, Joshua Sightler, Eli Mcpherson, William A. Rigdon, Xinyu Huang

Faculty Publications

The Pt/C catalysts were mixed with carbon nanotube (CNT), Nafion™ dispersion and a fiber former, polymer poly-acrylic acid (PAA), to form an ink. The ink was deposited onto aluminum foil attached to a rotating collector via an electrospinning process. The ink composition, mixing procedure, and the E-spin parameters were studied for producing a uniform nanofiber mat on the aluminum substrate. The fiber-mat containing active catalyst ingredients was heat treated and decal transferred onto a Nafion membrane to form a membrane electrode assembly (MEA).

Go to article

A Novel Laboratory Course On Advanced Chemical Engineering Experiments, Jochen A. Lauterbach, S. White, X. Lui, G. M. Bodner, W. N. Delgass

Faculty Publications

The chemical engineering curriculum in the United States has trained generations of technical experts who have successfully optimized chemical processes and products once they entered the chemical industry. The U.S. chemical industry, however, has entered a critical stage in which it must be able to create new and differentiated value through technical innovations that arc essential for long-term survival. This innovation process will require new skills that go far beyond the traditional expertise for the optimization of tasks possessed by young chemical engineers. The innovators must be able to identify new opportunities, explore the boundaries of technology, evaluate critical issues, …

Go to article

Oxygen Reduction On Silver In 6.5 Molar Caustic Soda Solution, Prosper K. Adanuvor, Ralph E. White

Faculty Publications

No abstract provided.

Go to article

Catalysis and Reaction Engineering Commons^™

Full-Text Articles in Catalysis and Reaction Engineering

Size-Controlled Large-Diameter And Few-Walled Carbon Nanotube Catalysts For Oxygen Reduction, Xianliang Wang, Qing Li, Hengyu Pan, Ye Lin, Yujie Ke, Haiyang Sheng, Mark T. Swihart, Gang Wu

Faculty Publications

Enhancing Grain Boundary Ionic Conductivity In Mixed Ionic–Electronic Conductors, Ye Lin, Shumin Fang, Dong Su, Kyle S. Brinkman, Fanglin Chen

Faculty Publications

Investigating The Stability Of Eliposomes At Elevated Temperatures, Ghaleb A. Husseini, William G. Pitt, Marjan Javadi

Faculty Publications

Influence Of Crystal Structure On The Electrochemical Performance Of A-Site-Deficient Sr 1-Xnb 0.1 Co 0.9 O 3-Δ Perovskite Cathodes, Yinlong Zhu, Ye Lin, Xuan Shen, Jaka Sunarso, Wei Zhou, Shanshan Jiang, Dong Su, Fanglin Chen, Zongping Shao

Faculty Publications

Phase Transitions Of Perfluorocarbon Nanoemulsion Induced With Ultrasound: A Mathematical Model, William G. Pitt, Ram N. Singh, Krystian X. Perez, Ghaleb A. Husseini, Daniel R. Jack

Faculty Publications

Self-Healing Catalysts: Co3O4 Nanorods For Fischer-Tropsch Synthesis, Cun Wen, Darrius D. Dunbar, Xin Zhang, Jochen A. Lauterbach, Jason R. Hattrick-Simpers

Faculty Publications

One-Step Production Of Long-Chain Hydrocarbons From Waste-Biomass-Derived Chemicals Using Bi-Functional Heterogeneous Catalysts, Cun Wen, Elizabeth A. Barrow, Jason R. Hattrick-Simpers, Jochen A. Lauterbach

Faculty Publications

Solid Oxide Fuel Cells With Both High Voltage And Power Output By Utilizing Beneficial Interfacial Reaction, Chao Su, Zongping Shao, Ye Lin, Yuzhou Wu, Huanting Wang

Faculty Publications

Investigation Of Carbon Corrosion Resistance Of Cnt Containing Electrode, Diana Larrabee, William A. Rigdon, Eli Mcpherson, Joshua Sightler, Xinyu Huang

Faculty Publications

Application Of Electrospinning Technique In The Fabrication Of A Composite Electrode For Pemfc, Joshua Sightler, Eli Mcpherson, William A. Rigdon, Xinyu Huang

Faculty Publications

A Novel Laboratory Course On Advanced Chemical Engineering Experiments, Jochen A. Lauterbach, S. White, X. Lui, G. M. Bodner, W. N. Delgass

Faculty Publications

Oxygen Reduction On Silver In 6.5 Molar Caustic Soda Solution, Prosper K. Adanuvor, Ralph E. White

Faculty Publications