Bioresource and Agricultural Engineering Commons^™

Methane Production By A Packed-Bed Anaerobic Digester Fed Dairy Barn Flush Water, Sean Richard Thomson

Master's Theses

Packed-bed digesters are an alternative to covered lagoon digesters for methane production and anaerobic treatment of dilute wastewaters such as dairy barn flush water. The physical media of packed-beds retain biofilms, often allowing increased treatment rates. Previous studies have evaluated several types of media for digestion of dilute wastewaters, but cost and media fouling have setback commercial development. A major operational cost has been effluent recirculation pumping.

In the present effort, a novel approach to anaerobic digestion of flush dairy water was developed at pilot-scale: broken walnut shells were used as a low-cost packed-bed medium and effluent recirculation was replaced …

Economic Impacts Of Increased Corporate Average Fuel Economy (Cafe) Standards, Ann K. Hunter-Pirtle

Department of Agricultural Economics: Dissertations, Theses, and Student Research

The Renewable Fuel Standard (RFS) mandates that U.S. transportation fuel producers blend specific volumes of ethanol and other biofuels with fossil fuels to spur U.S. biofuel production and to minimize foreign oil imports. Ethanol is more corrosive to auto engines than gasoline, and although vehicles manufactured since 2001 are approved to use up to a 15% ethanol blend (E15) (Naylor & Falcon, 2011), E10 is much more widely available. Ethanol producers therefore face a so-called blend wall at 10 percent—a maximum amount of ethanol that is usable domestically based on the demand for gasoline.

Meanwhile, gasoline demand in the U.S. …

Infiltration And Runoff Parameters For Tilled And No-Till Row Crops, Andrew J. Volkmer

Department of Agricultural and Biological Systems Engineering: Dissertations, Theses, and Student Research

Infiltration and runoff are hydrologic processes that effect the amount of water available to plants, for groundwater recharge, and for stream flow. No-till planting (NT) is a management practice used to reduce soil erosion, increase water infiltration, and reduce soil water evaporation, and can have great impact on infiltration and runoff. An investigation was conducted to determine the impact of NT on infiltration and runoff when compared to tilled conditions.

Runoff and precipitation data was gathered from sites at Fillmore County, NE, Phelps County, NE, the USDA-ARS North Appalachian Experimental Watersheds (NAEW) near Coshocton, OH, and the Lennoxville Research Station …

A Case Study Of Changing Cropping Diversity And Agricultural Risk In The Doulthabad Mandal Of Telangana State In India, Srikanth Kondabolu

School of Natural Resources: Dissertations, Theses, and Student Research

The Doulthabad^[1] Mandal is a hot semi-arid agro-ecological sub-region (Rao et al. 2006) located in Mahbubnagar District on the North Telangana Plateau in the state of Telangana. Agriculture is the main occupation in this region, which is populated mostly with small and marginal farmers. This study uses the time period from 1971 to 2004 to study the variation in cropping pattern diversity and distribution of rainfall during the monsoons and understand the implications on production risk in agriculture. Quantitative methods were used in determining the changes in rainfall while qualitative methods were used to study cropping system changes. The …

Development Of A Public Education Website: Building Bridges Over Water, Angelina Mckee

Agricultural Education and Communication

Website created by Angelina McKee to educate the public about water resource issues. Water is the basic unit of life, water resources are the basis for what societies and ecosystems are founded upon. Water shortages and droughts are more prevalent in our ever-changing world. It is no shock that there are discrepancies between various stockholders on either sides of the dry riverbed. This senior project resulted in the development of a website that addresses global water resources, water use in California, water conservation, and water allocation. The website informs the public on water resources and related issues and will hopefully …

Affluent Populations And Their Effect On Biological Diversity Through The Consumption Of Meat, Electronics, And Motor Vehicles, Melody Flores

Honors College Theses

The human has caused a far greater impact on the planet's biodiversity than any other species in existence, due to the impact of population, afflluence, and technology. This thesis will argue the importance of biological diversity and how affluent populations are reducing biodiversity through the consumption of meat, electronics, and motor vehicles. Aldo Leopold's "The Land Ethic" and Herman Daly's "The Impossibility Theorem", among others, create a rubric evaluating human activities and provide alternative views on economic impossibilities. Consumption is reviewed from an ecocentric perspective, a holistic outlook placing emphasis on the ecosystem. The reader will become cognizant of their …

Physical And Chemical Attributes Of A Genetically Modified Fruit Pectin, Carl Patrick Littrell

Open Access Theses

Pectin is an important polymer used in the food industry as a thickening and gelling agent. Though pectin is ubiquitous in plants, chemical and structural differences among pectin molecules prevent most from being viable for industrial use. Enzymes found naturally in fruit cell walls during the ripening process impair many desirable attributes of fruit pectins, rendering them unsuitable for industrial applications. Pectin methylesterase (PME) is one such enzyme whose expression can be altered during ripening through the use of recombinant genetic engineering. Reduction in levels of PME results in increased degree of methylation and molecular size of pectin, greatly increasing …

Differences In Carbon Dioxide Evolution From Samples Of Shelled Corn Subjected To Various Storage Treatments, Cininta Alp Pertiwi

Open Access Theses

Shelled corn was collected from two sources - commercial grain elevators and corn harvested from Purdue University farms and then frozen until tested. Using a carbon dioxide (CO₂) test kit manufactured by Woods End Laboratories, CO₂ evolution measurements were conducted on shelled corn from both sources, after the samples were re-wetted to approximately 21% moisture content, placed in a 473 ml glass jar, and incubated at room temperature for 72 hours. The CO₂ test kit uses a gel that changes color in response to a change in the level of CO₂ in the surrounding air. …

Project Proposal And Development Plan For A New Security Gate At Swanton Pacific Ranch, K. Morgan Perry

Agricultural Education and Communication

The purpose of this project was to develop a prototype gate for Cal Poly’s Swanton Pacific Ranch in Santa Cruz, CA. Swanton Pacific Ranch requested that the author design and build a 21’x5’ single-retractable gate for Swanton Pacific Ranch to help decrease the security issues that have recently arisen at the facility. The design and format of this project are focused towards the desires and goals set forth by Swanton Pacific Ranch and the Operations Manager, Steve Auten in order to obtain a certain outcome. This project provides an outline of what needs to be done in order to produce …

Overcoming India’S Food Security Challenges: The Role Of Intellectual Property Management And Technology Transfer Capacity Building, Stanley Kowalski, Aarushi Gupta, Ifica Mehra

Law Faculty Scholarship

The growth of the Indian economy after Independence has had little impact on the food security of the country. The paper analyses the development of advanced crop varieties through the use of agricultural technologies (hereinafter "agbiotech") within the technology transfer system, a framework which comprises of the interactions of intellectual property rights law and agricultural research and development in India. Through this, the author argues that agricultural innovation in India is failing due to the absence of connections within the technology transfer system and advocates for the creation of a national program aimed at advancing IP and tech-transfer capacity in …

Fate Of Antimicrobials And Antimicrobial Resistance Genes In Simulated Swine Manure Storage, Stacey R. Joy, Xu Li, Daniel D. Snow, John Gilley, Bryan L. Woodbury, Shannon L. Bartelt-Hunt

School of Natural Resources: Faculty Publications

The behavior of three antibiotics (bacitracin, chlortetracycline, and tylosin) and two classes of antibiotic resistance genes (ARGs), tet and erm, were monitored in swine manure slurry under anaerobic conditions. First-order decay rates were determined for each antibiotic with half-lives ranging from1 day (chlortetracycline) to 10 days (tylosin). ARGs were monitored in the swine manure slurry, and losses of approximately 1 to 3 orders of magnitude in relative abundance were observed during the 40 day storage period. First-order degradation profiles were observed for chlortetracycline and its corresponding resistance genes, tet(X) and tet(Q). Tylosin was degraded to approximately 10% …

Effects Of Sodium Hydroxide Pretreatment On Structural Components Of Biomass, Alicia A. Modenbach, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

Pretreatment is a unit operation in the conversion of biomass to valuable products that utilizes various combinations of conditions, including chemicals, heat, pressure, and time, to reduce the recalcitrance of lignocellulose. Many such pretreatments have been developed over the years, as the operating conditions can be adapted so that lignocellulose is modified in ways unique to each pretreatment. By tailoring pretreatment conditions to achieve these modifications, the types of final products produced can be controlled. The purpose of this review is to provide a consolidated source of information for sodium hydroxide effects on lignocellulose. The structural characteristics of lignocellulose and …

Implementing Green Roofs On Movie Theaters And Shopping Centers: Business Cases In Profitable Sustainability, Ryan J. Miller

Pomona Senior Theses

This thesis presents the business case for installing green roofs on movie theaters and shopping centers. These businesses can then derive increased profits from the environmental benefits of reduced energy use and increased stormwater retention. After presenting the basic design and benefits of a green roof, the thesis develops stand-alone business plans for a movie theater and shopping center. The author finds that green roofs are a profitable sustainability solution for the commercial enterprise.

Design And Use Of An Adjustable Clearance Flailing Knife Biomass Shredder To Mechanically Increase Particle Surface Area, Shawn Gregory Ehlers

Open Access Theses

A flailing knife shredder was designed and tested as an alternative to a hammermill for processing biomass. The machine was comprised of two cylinders with four rungs, each with five free-swinging blades. Each of the two cylinders had adjustable clearance hoods and variable speed drives. Energy usage, output characteristics and device capacities were compared with corn stover processed at moisture contents (MC) of 10%, 35% and 50% wet basis (WB). The hammermill produced a more uniform particle size distribution in comparison to the shredder. Accessibility, indicated by conductivity index, to plant constituents, revealed that the method of treatment was not-significant …

2013-2014 Kentucky & Tennessee Tobacco Production Guide, Kenneth W. Seebold, Robert C. Pearce, William A. Bailey, Lowell P. Bush, Jonathan D. Green, Robert D. Miller, Laura A. Powers, William M. Snell, Lee H. Townsend, Mark Purschwitz, Larry G. Wells, John H. Wilhoit, Margarita Velandia, Steve Bost, Gene Burgess, Frank Hale, Darrell Hensley, Paul Denton, Neil Rhodes

Agriculture and Natural Resources Publications

Tobacco growers in Kentucky and Tennessee have faced many challenges during the past two years, including weather, labor availability, and rising production costs. However, there have been opportunities as well. Some buying stations have closed or moved, but new buyers have come into the market and contract volumes have been stable overall. Good quality burley tobacco is in relatively short supply, and this has offered opportunities to those who have been able to overcome weather and labor challenges and produce good crops. These changes have had different impacts in different regions of both states, based largely on where buying stations …

Effect Of Anaerobic Dairy Manure Co-Digestion And Effluent Solid Separation On Volatile Fatty Acids During Manure Storage, Laura Page

Open Access Theses

Volatile fatty acids (VFA) are among the most abundant organic compounds found in animal manure and act as important intermediates in the production of methane under anaerobic digestion (AD). However, VFA also contribute to odor emissions from manure. Anaerobic digestion and separation of solids may help to reduce odor pollution during manure storage and subsequent land application by reducing VFA concentrations.

Little information about the characteristics and concentrations of VFA in dairy manure related to AD is available. This thesis presents the results of VFA production during two three-month storage studies of dairy manure collected from four different sources on …

Estimation Of Watershed Nitrate Loads On Drained Agricultural Lands, Yan Jiang

Open Access Theses

Estimation of nutrient load is critical for many applications in water quality management; however, infrequent data monitoring and measurement error could raise considerable uncertainty in the load estimations. The objectives of this study were to quantify the overall uncertainty in annual nitrate-N load estimates, and develop a statistical model to predict nitrate loads based on subsurface drainage characteristics in Indiana watersheds. Nitrate was selected as the study object because of the high loads common in Midwestern streams, and its important influence on hypoxia in the Gulf of Mexico.

A standard error propagation method was used to quantify the uncertainty from …

Specific Salt Effects On The Formation And Thermal Transitions Among Β-Lactoglobulin And Pectin Electrostatic Complexes, Stacey Ann Hirt

Open Access Theses

Factors of ion specificity and ionic strength (I~0-100) were studied in the electrostatic complex formation and protein particle formation by thermal treatment for a β-lactoglobulin and pectin system. ζ-potential showed β-lactoglobulin and pectin began to interact near pH 5.50 and interactions were strengthened with decrease in pH. Visible light turbidimetry and light scattering at 90° revealed a trend in critical pH transitions for electrostatic complex formation based on both the ionic strength and the anion of the salt species, while effects of the monovalent cation was insignificant. Critical pH values for complex formation and separation (pHc and pHΦ) decreased with …

Rheological Properties Of Gluten Free Dough Systems, Stephany Aurea Tandazo

Open Access Theses

Bread is the one of the oldest processed foods and a major wheat based product. The basic process involves mixing of ingredients until the flour is converted into dough, followed by baking the dough into a loaf. A very important step in breadmaking is to know how to make good quality dough. However, the increasing knowledge of people being diagnosed with celiac disease (gluten intolerance) has encouraged scientists to develop healthier and better quality gluten-free products that would greatly improve the quality of life of celiac patients. The main objective of this study was to create a dough system composed …

Life Cycle Boundaries And Greenhouse Gas Emissions From Beef Cattle, Quentin M. Dudley

Department of Agricultural and Biological Systems Engineering: Dissertations, Theses, and Student Research

Beef cattle are estimated to directly contribute 26% of U.S. agricultural greenhouse gas (GHG) emissions, and future climate change policy may target reducing these emissions. Life cycle assessment (LCA) of GHG emissions from U.S. feedlot beef cattle was conducted to compare methods of the U.S. Environmental Protection Agency (EPA) with a more complete evaluation of emissions. The inclusion of emissions from crop production for feed, associated land use change, and other minor factors nearly doubled GHG emissions associated with beef feedlots from the EPA Annual Inventory estimate of 1611 kgCO₂e hd^-1 yr^-1 to 3182 ± 167 …

Observations Of Localised Effects Of The Busselton Compensating Basins On Surface Water, Groundwater And Soil Salinity, D L. Bennett, Richard J. George Dr

Resource management technical reports

Between 2001 and 2009 the Water Corporation constructed three flood-compensating basins on farmland in the Vasse and Sabina river catchments, upstream of in the city of Busselton. The basins are designed to reduce the risk of flooding in urban areas of Busselton by temporarily storing and then regulating runoff during flood events. This report fulfils the reporting requirements of a contract between the Water Corporation and the Department of Agriculture and Food. Data relating to the local groundwater and surface-water dynamics, salinity, nutrients and pH, plus changes to shallow and deep-soil salinity (from repeat ground-based electromagnetic induction [EM] surveying), was …

The Effect Of Chlorine And Ozone In Controlling Microbes On Organically Grown Cilantro And Carrots, Adam Holtz

BioResource and Agricultural Engineering

This senior project investigates the relative efficacy of ozonated water and chlorinated water for the purpose of sanitizing freshly-harvested organic produce. The aim of this study was to assist the Cal Poly Organic Farm in deciding whether or not to invest in an ozone generator. The crops used for testing were grown organically in the same field. Carrots and cilantro were harvested and promptly treated with 5 ppm ozone solution or 25 ppm sodium hypochlorite solution. Carrots were sampled at 0, 7, and 14 days storage to determine microbial populations. Cilantro was similarly tested at 0, 6, and 12 days …

Design, Acnd Construction Of A Portable Artificial Insemination Chute, Chris Herrera

BioResource and Agricultural Engineering

This senior project report discusses the design, construction, and evaluation of a portable artificial insemination chute for the use of the Cal Poly Beef Department. The design was based on the suggested modifications from operators of several other chutes currently in use.

The main areas considered for the design were; Ergonomics, cattle safety, factors effecting maximum breeding conception rates, and Portability.

The breeding chute proved superior over traditional chutes in a variety of ways. Improvement occurred in the areas of consideration as follows, user operation was simplified, animal stress was decreased, and maximum breeding efficiency was obtained.

Development Of A Noncontact Sensor For Monitoring Milk Coagulation And Cutting Time Prediction In Cheese Making, Molly D. Craft-Jenkins

Theses and Dissertations--Biosystems and Agricultural Engineering

Cheese products are manufactured more consistently and with better quality if the curd cutting time can be consistently selected. An optical sensor that accurately predicts cutting time has been developed for large cheese vats, but the initial cost of these sensors makes them uneconomical for small artisan cheese manufacturers. The small artisan cheese vats require an inexpensive sensor technology that can be implemented simply. The initial cost of purchasing a sensor and installing these sensors plus the need for a computational program for implementing the algorithm make this technology excessively expensive for these smaller cheese manufacturers. The objective of this …

An Investigation Of Reflective Mulches For Use Over Capillary Mat Systems For Winter-Time Greenhouse Strawberry Production, George E. Meyer, Ellen T. Paparozzi, Elizabeth Walter-Shea, Erin E. Blankenship, Stacy A. Adams

Department of Agronomy and Horticulture: Faculty Publications

Photosynthethically active radiation (PAR) is a principle environmental variable used by horticultural specialists, agronomists and ecosystem modelers to characterize the quantity and quality of light conducive to plant growth and development. Spatial distribution of PAR in a greenhouse can be quite variable and diffuse throughout the day time photoperiod, especially at low sun angles in northern regions of the United States. Four colors of reflective plastic mulches (white, red, olive, and black) were evaluated for winter-time strawberry (Fragaria × ananassa Duch.) production based on their reflectance and transmittance properties in a double-polyethylene, plastic-glazed Quonset greenhouse inNebraska. The spectral properties …

History Of The Biological Systems Engineering Program In Nebraska, University Of Nebraska-Lincoln, William E. Splinter

Department of Agricultural and Biological Systems Engineering: Faculty Publications

The Farm Machinery/Agricultural Engineering/Biological Systems Engineering program current and former faculty members at the University of Nebraska, as demonstrated here, has made a statewide, national, and worldwide impact on the efficient production of food. The quality of this recognition is evidenced best by peer professionals through recognized ASABE awards received by Nebraska alumni or professors. Since its inception in 1909 and until 2010, there have been 10 national presidents, 19 gold medal recipients and 33 named national award recipients. Currently there are 31 ASABE Fellows and two members of the National Academy of Engineering. This national recognition comes as a …

Identifying Changes In Climatic Trends And The Fingerprints Of Landuse And Landcover Changes In The High Plains Of The Usa, Denis Mutiibwa

Department of Agricultural and Biological Systems Engineering: Dissertations, Theses, and Student Research

Human activities such as conversion of natural ecosystem to croplands and urban-centers, deforestation and afforestation impact biophysical properties of land surface such as albedo, energy balance, and surface roughness. Alterations in these properties affect the heat and moisture exchanges between the land surface and atmospheric boundary layer. The objectives of this research were; (i) to quantitatively identify the High plains’ regional climate change in temperatures over the period 1895 to 2006, (ii) detect the signatures of anthropogenic forcing of LULC changes on the regional climate change of the High Plains, and (iii) examine the trends in evolving regional latent heat …

Biofilter Media Characterization Using Water Sorption Isotherms, Guilherme Del Nero Maia, George B. Day, Richard S. Gates, Joseph L. Taraba

Biosystems and Agricultural Engineering Faculty Publications

Compost material has been used extensively as a gas‐phase biofilter media for contaminant gas treatment in recent years. One of the biggest challenges in the use of this type of material is adequate control of compost moisture content and understanding its effect on the biofiltration process. The present work provides a methodology for characterization of biofilter media under low moisture conditions. Results indicated that low levels of equilibrium moisture content (EMC) were obtained for high levels of equilibrium relative humidity (ERH), i.e., 99% ERH produced EMC of approximately 20% (dry basis) at 25° C. Most bacteria struggle to survive in …

Long Term, Continuous Temperature Monitoring Of A Simple Anaerobic Digester And Open Manure Storage Pond In Eastern South Dakota, J. Darrington, E. Cortus

The Journal of Undergraduate Research

A two-cell manure storage system with a cover on the first cell was constructed in the late summer of 2009 in Eastern South Dakota. The covered cell acts as a simple anaerobic digester. Continuous temperature monitoring for 8 months shows the winter effluent temperature equilibrated to around 6°C, and that the effluent temperature trend lagged the ambient temperature trend by a month. Manure composition was also analyzed and was found to be relatively steady throughout the system. Volatile solids were the only component that dropped appreciably across the treatment cell, with an observed maximum of 50% reduction.

Influence Of Fan Operation On Fan Assessment Numeration System (Fans) Test Results, Gabriela Munhoz Morello

University of Kentucky Master's Theses

The use of velocity traverses to measure in-situ air flow rate of ventilation fans can be subject to significant errors. The Fan Assessment Numeration System (FANS) was developed by the USD-ARS Southern Poultry Research Laboratory and refined at the University of Kentucky to measure air flow of fans in-situ. The procedures for using the FANS unit to test fans in-situ are not completely standardized. This study evaluated the effect of operating fan positions relative to the FANS unit for ten 1.22 m diameter fans in two types of poultry barns, with fans placed immediately next to each other and …