Engineering Commons^™

Enhanced Phosphate Flotation Using Novel Depressants, Lingyu Zhang

Theses and Dissertations--Mining Engineering

Froth flotation is the most efficient method for phosphate separation, which is a physic-chemical separation process based on the difference of surface properties between the valuable minerals and unwanted gangue minerals. However, the presence of clay slimes in the slurry after grinding consumes a large amount of reagents, decreases the collision probability between bubbles and minerals, prevents phosphate particle attachment to air bubbles, and thus considerably reduces flotation recovery and concentrate grade. Georgia Pacific Chemical, LLC has recently developed novel depressants, i.e., clay binders, which are a series of low molecular weight specialty polymers to help improve phosphate flotation performance …

A Review Of Pharmaceuticals And Endocrine-Disrupting Compounds: Sources, Effects, Removal, And Detections, Jimoh O. Tijani, Ojo O. Fatoba, Leslie F. Petrik

Mining Engineering Faculty Research & Creative Works

There are growing concerns about the increasing trends of emerging micropollutants in the environment due to their potential negative impacts on natural ecosystems and humans. This has attracted attention from both governmental and non-governmental organizations worldwide. Pharmaceuticals, personal care products, and endocrine disruptors are continuously being released consciously or unconsciously into water sources due to poor regulatory frameworks especially in the developing countries. The effects of these contaminants are poorly known. They are not easily biodegradable and have become an environmental nuisance and public health issue. This has heightened the risk of exposure to their deleterious effects in such countries …

Utilization Of Booster Fans In Underground Mines, Arash Habibi Javanbakht

Masters Theses

"Booster fans are large underground fans that can increase the volumetric efficiency of ventilation systems by balancing the pressure and quantity distribution throughout a mine, reducing leakage and reducing the total power requirement. The objective of this study is to provide potential users of booster fans with the necessary information on the design, installation and operation of main underground fans. The guidelines listed in this paper were formulated based on current U.S. and international standards, safe operating practices developed by the mining industry, and recommendations provided by fan manufacturers. The principles involved in the design and installation of booster fans …

Impacts Of Changes In Land Use And Land Cover On Atmospheric Chemistry And Air Quality Over The 21st Century, S. Wu, L. J. Mickley, J. O. Kaplan, D. J. Jacob

Michigan Tech Publications, Part 1

The effects of future land use and land cover change on the chemical composition of the atmosphere and air quality are largely unknown. To investigate the potential effects associated with future changes in vegetation driven by atmospheric CO 2 concentrations, climate, and anthropogenic land use over the 21st century, we performed a series of model experiments combining a general circulation model with a dynamic global vegetation model and an atmospheric chemical-transport model. Our results indicate that climate-and CO 2-induced changes in vegetation composition and density between 2100 and 2000 could lead to decreases in summer afternoon surface ozone of up …

Development Of Strategies To Minimize The Release Of Trace Elements From Coal Waste Sources, Mohammad Rezaee

Theses and Dissertations--Mining Engineering

To assess strategies aimed at minimizing the release of trace elements and the impact of disposal of coal waste materials on the environment, two long-term leaching experiments of up to five months duration were performed using waste materials from two plants cleaning high and low sulfur bituminous coal. The tests evaluated the mobility of major trace elements under different disposal scenarios: (i) a static leaching test designed to simulate the quiescent conditions encountered by coal waste material stored under water in a stable impoundment, and (ii) a dynamic test to simulate waste materials exposed to the atmosphere, either in variable …

Fractal Oxidation Kinetics And Risk Evaluation Of Spontaneous Combustion In Coal Mines, Yutao Zhang

Doctoral Dissertations

"The spontaneous combustion of coal occurs when air supply is sufficient for the oxidation of coal and air velocity is insufficient for the dissipation of generated heat. Spontaneous combustion, if not eradicated immediately, may lead to coal ignition and even a full-blown fire. The fire may engulf a large area and spread further if they are not immediately attended to. This will not only endanger miners and mining operations, but also result in possible mine closures and even fatalities.

Porous structure has a significant effect on coal adsorption and spontaneous combustion. In this research, fractal theory was utilized to quantitatively …

Effects Of Coal Comminution In Relation To Waterjet And Selected Feed Properties, Yaqing Li

Masters Theses

"The necessity to develop a viable alternative to oil means that the development of coal-water fuels (CWF) has become increasingly important. However, the existing methods of comminution to prepare ultrafine particles for CWF are very inefficient. Consequently, a number of novel methods of comminution have been investigated in order to increase the efficiency of the process.

In this research, a new method of comminution using a high-pressure waterjet has been tested to produce ultrafine particle sizes necessary for efficient CWF process. To establish the fundamental performance of the waterjet mill, the influence of the operational pressure, standoff distance, feed size, …

Calling For Justice In The Goldfields Of Tanzania, Madoshi H. Makene, Jody Emel, James T. Murphy

Geography

Tanzania is the third largest gold exporter in Africa, thanks in part to the liberalization of the mining sector which started in the early 1990s. Neoliberal mining reforms promised a win-win situation in which government, investors and local host communities would benefit through export earnings, profits, local employment, andcorporate social responsibility initiatives (e.g., the building of schools and clinics). While the rising price of gold and foreign investments in mining activities have delivered on some of these promises, many residents in mining regions have not benefited socioeconomically. Worse still, their communities have unjustly borne the brunt of the environmental, social, …

Ethane, Ethyne And Carbon Monoxide Concentrations In The Upper Troposphere And Lower Stratosphere From Ace And Geos-Chem: A Comparison Study, G. González Abad, N. D.C. Allen, P. F. Bernath, C. D. Boone, S. D. Mcleod, G. L. Manney, G. C. Toon, C. Carouge, Y. Wang, Shiliang Wu, X

Michigan Tech Publications, Part 1

Near global upper tropospheric concentrations of carbon monoxide (CO), ethane (C2H6) and ethyne (C2H2) from ACE (Atmospheric Chemistry Experiment) Fourier transform spectrometer on board the Canadian satellite SCISAT-1 are presented and compared with the output from the Chemical Transport Model (CTM) GEOS-Chem. The retrievals of ethane and ethyne from ACE have been improved for this paper by using new sets of microwindows compared with those for previous versions of ACE data. With the improved ethyne retrieval we have been able to produce a near global upper tropospheric distribution of C2H2 from space. Carbon monoxide, ethane and ethyne concentrations retrieved using …

Creating Lakes From Open Pit Mines: Processes And Considerations, Emphasis On Northern Environments, Christopher H. Gammons, Les N. Harris, James M. Castro, Peter A. Cott, Bruce W. Hanna

Geological Engineering

Creating Lakes from Open Pit Mines: Processes and Considerations, Emphasis on Northern Environments. This document summarizes the literature of mining pit lakes (through 2007), with a particular focus on issues that are likely to be of special relevance to the creation and management of pit lakes in northern climates. Pit lakes are simply waterbodies formed by filling the open pit left upon the completion of mining operations with water. Like natural lakes, mining pit lakes display a huge diversity in each of these subject areas. However, pit lakes are young and therefore are typically in a non-equilibrium state with respect …

Approaching Coal Mine Safety From A Comparative Law And Interdisciplinary Perspective, Anne Marie Lofaso

West Virginia Law Review

No abstract provided.

Perspective On Indicators Of Sustainability For The Gold And Silver Extraction Industry, Jarnes L. Hendrix

Papers in Sustainable Mining

No abstract provided.

Particles In The Great Pinatubo Volcanic Cloud Of June 1991:The Role Of Ice, Song Guo, William I. Rose, Gregg J. S. Bluth, M. I. Watson

Department of Geological and Mining Engineering and Sciences Publications

Pinatubo's 15 June 1991 eruption was Earth's largest of the last 25 years, and it formed a substantial volcanic cloud. We present results of analysis of satellite-based infrared remote sensing using Advanced Very High Resolution Radiometer (AVHRR) and TIROS Operational Vertical Sounder/High Resolution Infrared Radiation Sounder/2 (TOVS/HIRS/2) sensors, during the first few days of atmospheric residence of the Pinatubo volcanic cloud, as it drifted from the Philippines toward Africa. An SO₂-rich upper (25 km) portion drifted westward slightly faster than an ash-rich lower (22 km) part, though uncertainty exists due to difficulty in precisely locating the ash cloud. …

Re-Evaluation Of So2 Release Of The 15 June 1991 Pinatubo Eruption Using Ultraviolet And Infrared Satellite Sensors, Song Guo, Gregg J. S. Bluth, William I. Rose, M. I. Watson, A. J. Prata

Department of Geological and Mining Engineering and Sciences Publications

In this study, ultraviolet TOMS (Total Ozone Mapping Spectrometer) satellite data for SO₂ are re-evaluated for the first 15 days following the 15 June 1991 Pinatubo eruption to reflect new data retrieval and reduction methods. Infrared satellite SO₂ data from the TOVS/HIRS/2 (TIROS (Television Infrared Observation Satellite) Optical Vertical Sounder/High Resolution Infrared Radiation Sounder/2) sensor, whose data sets have a higher temporal resolution, are also analyzed for the first time for Pinatubo. Extrapolation of SO₂ masses calculated from TOMS and TOVS satellite measurements 19–118 hours after the eruption suggest initial SO₂ releases of 15 ± 3 …

Day 3. Wednesday, August 13, 2003: Oil Shale, University Of Colorado Boulder. Natural Resources Law Center

Energy Field Tour 2003 (August 11-16)

8 pages.

Contains references.

A Comparison Of Air Leakage Prediction Techniques For Auxiliary Ventilation Ducting Systems, A. D. Stewart Gillies, Hsin Wei Wu

U.S. Mine Ventilation Symposium

This paper briefly reviews prediction techniques for determination of leakage and friction along auxiliary ventilation ducting systems. In order to compare various prediction techniques that have been developed over the past, a macroscopic investigation of air leakage and friction resistance of auxiliary ventilation ducting systems has been undertaken. Measurements were conducted on 450 and 915 mm diameter fabric ducting over 100 m duct length to determine frictional resistances and the extent of leakage. Due to the high degree of accuracy required and the large volume of data that needed to be collected, electronic pressure transducers were used with computer for …

Controlled Recirculation In Deep South African Gold Mines, Mark Butterworth

U.S. Mine Ventilation Symposium

Despite the many advantages and potential benefits of using controlled recirculation in Deep South African gold mines the strategy has found little favour. Indeed, controlled recirculation of air is at present rarely considered as an option in the planning and implementation of these underground ventilation systems. This paper broadly examines controlled recirculation, the benefits and advantages that could accrue from its use, reasons that may detract from its use and some solutions for addressing shortcomings. A brief historical review of controlled recirculation in the context of the South African gold mining industry is given. The advantages, which could result from …

Environ 2.5 — A Mine Ventilation And Cooling Network Simulation Tool, W. M. Marx

U.S. Mine Ventilation Symposium

As mining operations progress, ore reserves are depleted and alternative are almost invariably found at increasing depth and a host of attendant difficulties in this regard face· the mine operator. Most significant among these is the control of the increasingly hostile environment encountered at depth in terms of both ground behaviour and the increasing hot environment. To enable the practical and economical design of mine ventilation and cooling systems, ventilation practitioners need effective and efficient tools to perform their duty. One such tool is the Environ 2.5, an interactive network simulation program that allows for the simultaneous simulation of airflow …

Management Of Mine Explosion Risks, Jan J. L. Du Plessis, J. W. Oberholzer

U.S. Mine Ventilation Symposium

The management of explosions in the underground mining environment has been a high priority for managers since the turn of the century. In the early 1900s explosions, worldwide, reached catastrophic dimensions. In a number of large explosions more than 1000 people have died. In the early years of research, the basics of why explosions occurred were investigated and the participation of coal dust in underground coal mine explosions was proved. Taffanel, a French researcher, was one of the pioneers in establishing the use of stone dust and was instrumental in the design and development of the first stone-dust barriers. Throughout …

Performance Assessment Of A Multi-Stage Cooling System At San Manuel Mine, Kuda R. Mutama

U.S. Mine Ventilation Symposium

This paper describes the mine ventilation cooling system at San Manuel Mine, which has evolved as new deeper and hotter working levels were added to the mine, between 1979 -1997. The expansion philosophy was based on utilizing existing facilities, providing lower capital cost and operational convenience. The cooling system is comprised of three surface chillers of 10.55 Megawatts (3,000 tons) total cooling capacity. Cooling towers, also located on surface, ultimately reject all the heat from underground system. The chilled water is pumped to a shell and tube heat exchanger station located 915 metres underground in a high pressure circulating water …

Rapid Extinguishing Of Sponcom Fires In Underground Mines, Zygmunt Kajdasz, George Zieba

U.S. Mine Ventilation Symposium

The main purpose presented in this paper is to present active and passive methods to fight a sponcom fire. The active method uses an inert gas generator called the GAG while the passive method is through the use of ventilation software. In most sponcom situations a combination of these two methods results in rapid extinguishing of the overheated areas. The presented software allows for accurate and "real time" analysis of the ventilation network. Application of the GAG has been proven on many occasions as an effective means of large volumes of mine atmosphere.

Flammable Gas Emissions In South African Gold And Platinum Mines Review Of Incidents And Accidents, A. P. Cook, C. F. Meyer, K. Balt

U.S. Mine Ventilation Symposium

Flammable gas emissions are relatively common and widespread across the South African gold and platinum mines, but a general lack of awareness has lead to an increase in flammable gas related accidents and fatalities over the last ten years. The gas is usually a mixture of hydrocarbons C1 to C4 with hydrogen, each in varying quantities, with methane and hydrogen predominant. The three most common causes leading to gas accidents are changes to the ventilation, lack of testing for gas, and contraband, with gas ignitions caused by contraband and illegal tampering with caplamps. Development work accounts for 70 percent of …

A Proposed New Method To Determine The Effectiveness Of In-Heading Methane Control, F. J. Van Zyl

U.S. Mine Ventilation Symposium

Various methods have been derived to determine the effectiveness with which ventilation systems clears headings of methane in a bord-and-pillar sections. A problem with applying these methods in underground sections is that the either require the face-area air quantity to be measured, which is virtually impossible in South African collieries, or they were developed for test galleries, making it difficult to use in production sections. Taking this into consideration the methane safety index (MSI) method was developed. The method utilizes methane data recorded around an active continuous miner (CM) and an activity log of cm operations to quantitatively assess methane …

Evaluation Of A Continuous Miner Half-Curtain Dust Control System In A South African Underground Coal Mine, Bharath K. Belle, J. J. L. Du Plessis

U.S. Mine Ventilation Symposium

The issues of public health and safety in the mining industry have been dealt with around the world through the intervention of governments. In 1997 the South African Department of Minerals and Energy (DME) sent out a directive to reduce the dust concentration level to /m³ at the operator's position for the sampling period. The reasons for the difficulty with compliance are: long headings up to 35m, inherently high dust generation rates of coal, and the increased use of highly mechanized equipment. A project was formulated under SIMRAC auspices with the title of "Underground Mechanical Miner Environmental Control" to …

Axial Fan Monitoring By Pressure Transients Close To The Blades, A Preliminary Study, Ian Loomis, Shaun Ramsay

U.S. Mine Ventilation Symposium

As the axial fan blades move within the fan case pressure transients are developed, which can be measured and qualified by a fixed point monitor. The nature of the pressure transient pattern observed close to the fan blade varies with the location on the fan performance curve. Measurement of the pressure fluctuation around the fan blade ring reveals the minute variation in pressure associated with the movement of the air within the fan. Such observations could be the basis for an on-line fan monitoring system based on the acoustic emissions from the fan blade. This paper describes a preliminary study …

Performance Of Distributed Bagged Stone Dust Barrier In Combating Coal-Dust Explosions, Jan J. L. Du Plessis, Pierre S. Vassard

U.S. Mine Ventilation Symposium

The Kloppersbos Research Facility of the CSIR's Division of Mining Technology has developed a new method of building stone dust barriers. The new barrier makes use of a previous concept of containing stone dust in a bag, but incorporates a new method of rupturing the bag. This was achieved by adapting the closing mechanism and by balancing the stone dust content with the void in the bag. The bagged barrier was extensively tested in the 200-m test gallery. During these tests, it became evident that these bags could be made to rupture and spread stone dust when subjected to smaller …

An Integrated Strategy For Emergency Egress From An Underground Metal Mine, Rick Brake

U.S. Mine Ventilation Symposium

The fact that major fires are rare events in underground metal mines means there is often little on-site experience in dealing with these situations. Elaborate strategies that rely on a high degree of training at all levels to be effective are likely to fail, especially with the trend in Australia towards smaller mines and "fly in-fly out" operations. A robust strategy is required. The key items in such a strategy are: early detection and warning of personnel, personal belt-worn oxygen-generating self-rescuers, high integrity escape routes and self-contained refuge stations, simple procedures, reliable personnel ''tagging" systems and sufficient, trained, search and …

Characteristics Of Airborne Dust In The Return Airways Of The Mechanized Longwall Face, Tevfik Güyagüler, Sinan Keskin

U.S. Mine Ventilation Symposium

In this paper the results of a research study on the characterisation of airborne dust in the return airway of the mechanized longwall face at Middle Anatolian Lignite Mine, OAL are presented. Dust, temperature, moisture and air velocity measurements were carried out in the return airways of the fully mechanized longwalls. Then the analyses of results on real-time concentration data, mass concentration data, effect of moisture, heat and air velocity on dust concentration are made. It has been found that amount of dust in return airway is directly related to the face activities and to the amount of settled dust …

Increased Methane Emissions For Mechanical Miners Working In Burnt Coal, A. P. Cook

U.S. Mine Ventilation Symposium

An intensive research programme has quantified the methane conditions around mechanical miners in production conditions. Methane seam gas contents show an increase of up to 26 times when mining burnt coal compared with normal increase in emission rates. Coal seam methane contents at the face increased from 1 m³/t to 6m³/t in one section, and from 0.1 m³/t to 2.6 m³/t in another. Emission rates from burnt coal were as high as 300 lit/min as it was mined. These increases in content and emission occur immediately after cutting into the burnt coal. …

Personal Cooling In Hot Workings, Michael A. Tuck

U.S. Mine Ventilation Symposium

The number of mines experiencing climatic difficulties worldwide is increasing. In a large number of cases these climatic difficulties are confined to working areas only or to specific locations within working areas. Thus the problem in these mines can be described as highly localised, due to a large extent not to high rock temperatures but due to machine heat loads and low airflow rates. Under such situations conventional means of controlling the climate can be inapplicable and/or uneconomic. One possible means of achieving the required level of climatic control, to ensure worker health and safety whilst achieving economic gains, is …