Engineering Commons^™

Activity Coefficients Of Gases In Binary Mixtures, John Gressler Engleman

Theses

The theory and usefulness of vapor phase activity coefficients have been developed. The equations, charts and calculation procedures to be used for the three methods are included with a set of sample calculations in their most convenient form.

Activity coefficients for 236 experimental points have been calculated by the three methods for both components of tour binary gaseous systems. These systems are Argon - Ethylene (36 points), Hydrogen - Nitrogen (32 points), Methane - Ethane (112 points) and Methane - n Butane (56 points). Wide ranges of pressure, temperature and mol fraction are included.

The % deviations of calculated from …

Transesterification Of Alkyl Borates, Garry Gustav Eichmann

Theses

An attempt was made to prepare pure methyl borate by an ester interchange using a high-boiling alkyl borate in combination with methyl benzoate or methyl phthalate. The product, assumed to be methyl borate, boiled at about 70°C., which is 5° higher than the expected boiling point, and analyzed at 88 to 95%.

Various catalysts, such as hydrochloric acid, sodium methoxide, p-toluene sulfonic acid, aluminum isopropoxide, and aluminum chloride, were tried before magnesium-aluminum ethoxide was chosen as the best catalyst for this particular tranesterification reaction.

Power Requirements In Pigment Comminution, Joseph Timothy Gildersleeve

Theses

The results of this work prove that the relation between total work and surface area developed in the wet grinding of pigments is an exponential function. The following equations were experimentally determined for the pigments studied:

For Zinc Oxide; P = .090 (Δs)1.05

For Titanium Dioxide: P = .086 (Δs)1.072

For Calcium Carbonate: P = .107 (Δs)0.98

This work shows that in the grinding of sub-sieve size pigments the Rittinger and Bond theories which state that surface area developed is directly proportional to total work, are not valid and cannot be applied.

It is also shown in another plot that …

Effect Of Concentration On The Mass Transfer Coefficient In The Liquid Film, Marvin Baker Schaffer, Philip Major Pomerantz

Theses

The effect of liquid concentration on the resistance to mass transfer across the liquid film is studied for an acetone-methyl isobutyl ketone-air system in a packed tower. The liquid film resistance is computed by measuring the overall resistance for various concentrations and subtracting the gas film resistance. The gas film resistance is determined at the same liquid and gas rates by measurements on the pure components.

In the theory developed to handle the calculations, it is assumed that the interface temperatures are the wet-bulb temperatures based on a dynamic equilibrium. This supposition is supported experimentally at a liquid rate of …

Thermodynamic Properties Of Trimethylamine, John Bernard Riley

Theses

The thermodynamic properties of trimethylamine have been evaluated at temperatures from 32°F to 600°F and from the saturation pressure to 2000 lb/in² based on available experimental data. An equation relating the pressure, volume and temperature of the system has been derived for the range in which experimental data were available and it was used to evaluate the thermodynamic properties in this range. Values for pressure, volume, temperature, enthalpy and entropy have been presented in the form of tables and graphs.

The Three Phase System N-Hexane - Aniline - Water, Charles S. Potosnak

Theses

This is a study of the three phase system - n-Hexane Aniline - Water at 50° Centigrade. The data obtained, coupled with data previously established at 36° Centigrade is used to predict a means of recovering aniline from 3-5% aqueous solutions by scrubbing with n-hexane.

The Preparation Of 3,4-Diaminopyridine, Emil John Fencl

Theses

The preparation of 3,4-diamincpyridine from pyridine was investigated, but found to be of little synthetic value because of the low yield obtained on the rearrangement of 4-nitraminopyridine to 3-nitro 4-aminopyridine. In attempt to nitrate nicotinamide-N-oxide resulted in the isolation of nicotinic acid-N-oxide. Attempts to nitrate nicotinic acid-N-oxide were unsuccessful. Attempts to oxidize 3-methylpyridine-N-oxide and 4-nitro-3-methylpyridine were unsuccessful. The nitration of 3-methylpyridine-N-oxide led to the isolation of 2-nitro-5-methylpyridine, which has not previously been reported as a by-product of that reaction.

Ammonia Catalized Phenol Formaldehyde Resins, Murlin Charles Ehrgott

Theses

The literature on ammonia-catalyzed phenol-formaldehyde resins is reviewed and critical comparisons are made of the manner in which the ammonia-catalyzed resins differ from both the alkali- and acid-catalyzed resins.

Intermediate products formea during the initial stapes of the ammonia-catalyzed phenol-formaldehyde reactions, as reported in the literature, are tabulated and % N contents are calculated.

Experimental determinations of N content of resins with molar ratios of 1:1.25 phenol to formaldehyde with ammonia at 0.2, 0.5, and 1.0 moles per mole of phenol, show that at the 0.2 molar ratio of ammonia, all the N enters into the resin and remains during …

The Fatty Acid Alkanolamide Reaction, Julius Galender

Theses

An alkanolamide detergent can be formed by the condensation of coconut fatty acid and diethanolamine. A great many factors can influence this formation. It is shown that varying the molar ratio of amine to acid, results in a change in the fraction of acid converted. It similarly affects the molar quantities of amine converted. Molar conversion of acid or amine is dependent upon the type of atmosphere in the reaction; more acid is converted when a nitrogen sweep is employed than when it is not used. However, proportionately more amine is converted, when a nitrogen sweep is not used. When …

Composting Coffee Waste, Lawrence James Hickey

Theses

Disposal of waste, and specifically organic waste, has become a serious problem in such industries as the canning, meat-packing, dairy and other food producing industries. Recently, with the introduction of instant coffee powder, this particular industry now has a waste disposal problem with the resultant coffee residue. Composting or biologically decomposing this waste to yield an organic fertilizer is one of the many ways to solve this problem.

There are no papers in the literature concerning composting of coffee waste and only one paper (65) is available covering studies of high rate composting of garbage and refuse. It is known …

Heat Transfer Coefficients Of Condensing Vapors, Charles Rocco Lipuma, Earl Adolph Nirmaier

Theses

The film coefficients of heat transfer for vapors condensing on a single horizontal tube have been measured for methyl, i-propyl, and n-butyl alcohols. The equipment used was specifically designed for these studies, and represents an improvement over that used by other investigators. The data collected were analyzed usingmodified Wilson method which is based on a rigorous theoretical analysis.

It has been found that the condensing film coefficients for methyl and i-propyl alcohols vary with the heat duty. This is to be expected from the analysis mentioned above. Me variation was found for n-butyl alcohol.

The observed values of the heat …

The Condensation Of Vapors From Gas-Vapor Mixtures, Stanley Anthony Mruk, William Charles Kraemer

Theses

Superheated mixtures of cyclohexane vapor and nitrogen gas were passed at various rates downward through a single tube condenser with the cooling water flowing countercurrently in an annular space outside the condenser.

The method of Colburn and Rougen for the design of cooler-condensers was applied and the calculated condenser lengths are compared to the experimental length.

Relatively good agreement with the design method was found for cases where there was little or no streamline flow of the gas-vapor mixture in the condenser. With increasing amounts of streamline flow* the design method tends to be increasingly conservative.

Correlation Of Curtis And Gullett Equation For Viscosity Of Non-Newtonian Suspensions And Franks And Rinaldi Equation For Heat Transfer Coefficients, Irene S. Wisla, John L. Kukowski

Theses

Curtis and Gullett (7) developed an equation correlating the effect of velocity, concentration and particle size on apparent viscosity of non-Newtonian water slurries.

μ/μ_w=1.02(AK/GC)^.105

The object of this paper was to determine the validity of using the viscosity, as determined by the Curtis-GulLett (7) equation, in predicting the heat transfer coefficient of non-Newtonian fluids, where the suspending medium is something other than pure water . The authors used various concentrations of sugar solutions as the dispersion medium, for the slurries.

A dimensionless equation resembling the flittusBoelter equation with modified exponents and additional dimensionless groups has been developed …

A Study Of The Partial Oxidation Of Monosubstituted-P-Xylenes, Frederick John Honold

Theses

In the oxidation of 2-nitro-p-xylene (I) using alkaline potassium permanganate, the only product isolated was 2-nitro-terephthalic acid (II). Approximately half of the starting material was oxidized. The other half remained as unreacted starting material.

The chromium trioxide oxidation of 2-nitro-p-xylene (I) in glacial acetic acid, using sulfuric acid as a catalyst, yielded only 3-nitro-p-toluic acid (III).

The chromium trioxide oxidations, of 2-N-acetylamino-p-xylens (IV) with and without sulfuric acid catalyst, yielded no oxidation products which could be identified. About half of the starting material was recovered in each case.

In a low temperature alkaline potassium permanganate oxidation of 2-N-acetyIamino-p-xylene a small …

A Study Of The Functional Stability Of Sunscreen Compounds, Jesse Howard Starkman

Theses

Previous work reported in literature, indicates that commercial sunscreen compounds were subject to breakdown on exposure to ultraviolet radiation with consequent change in their functional efficiencies.

These findings ware retested under conditions more closely approximating actual usage.

A new method of evaluation which closely correlates to actual experience in large scale usage, was applied. This method provides, from simple spectral data, a reliable index of physiological efficiency of the sunscreen compound. As a result, twelve commercial sunscreen compounds were exposed to ultraviolet radiation for varying periods. Analysis indicated that, contrary to the previous reports, no significant Changes in physiological efficiency …

Calcination Of Missouri Flint, Burley And Diaspore Clays In A Rotary Kiln, Richard Addison Parker

Professional Degree Theses

"This thesis will concern itself primarily with the preparation, handling and calcination of Missouri fire clays that are subsequently used as "grog" for manufacture of fire brick. This "grog", i.e., calcined flint, burley or diaspore clay is then mixed with ether clays having plastic qualities to form desired shapes of high temperature refractories, and burned as a final product in tunnel kilns and as required, in “beehive” or periodic kilns. The actual manufacture of fire brick will not be dealt with since it is, in itself, a highly specialized industry. We are immediately concerned with the proper preparation of calcined …

Heat Transfer Coefficient Of Paint Films, Richard F. Justus

Masters Theses

"Many studies of heat transmission have been carried out on various kinds of surfaces. But relatively few investigators have studied the loss of heat from a painted surface. Any surface will lose or gain heat by one or more of the three mechanisms of heat transmission: conduction, convection, and radiation. These mechanisms are thoroughly discussed by McAdams.

Heat transmission can be analyzed by determining thermal conductivity for conduction, overall coefficient for convection, and emissivity for radiation. The resistance concept is useful in indicating the various components of the overall coefficients and in analyzing problems in thermal conduction.

In studying heat …

A Study Of The Production Of Thorium Nitrate, K. P. Chona Panikkar

Masters Theses

"The purpose of this investigation was to study the various methods of producing Thorium Nitrate from monozite sand. This investigation includes a study of the Chemistry of Thorium and estimation of the Thorium Oxide content of monozite sand obtained from North Carolina"--Introduction, page 1.

Promotion Of Dropwise Condensation By Silicones, Charles Orlando Reed Jr.

Masters Theses

"Within this rather extensive field of study, transfer of heat through fluid films and heat transfer during the condensation process have been the subject of considerable thought and investigation both from a theoretical standpoint and with the aim of collecting data on specific systems to aid the design and construction of equipment in which heat transfer is involved….

The phenomenum of dropwise condensation has not become a common one in industrial practive for a number of reasons, namely, the difficulty in maintaining the activity of the promoter without frequent makeup because of impermanent attachment and volatility, the difficulty in finding …

Correlation Of Crystal Growth Rates In Supersaturated Solutions, Josef Frank Palme

Theses

This investigation has shown that crystals of copper sulfate and magnesium sulfate when grown in supersaturated solutions exhibit a growth rate according to the following equation:

R_L = 5.0 (ΔCD_m)^1/ρU V_s^.292

where, R_L, is the growth rate in Microns/min, is the change in concentration, D_m, the diffusivity coefficient, , density of solution, U, viscosity and V_s, solution velocity past the crystal.

The equation shown demonstrates that a mass transfer process is taking place from the solution to the crystal surface, and that within the velocity range studied, there …

The Recovery Of Krypton From Dilute Gas Mixtures By Elution Techniques, David Graham Brown

Theses

An analytical method has been empirically developed for the analysis of dilute inorganio inert gas mixtures.

The method is based on a combined sorption-elution technique which makes possible the resolving of complex inert gas mixtures into their constituents.

Particularly the recovery of krypton from dilute gas mixtures was accomplished. Recovery efficiencies were as high as ninety-eight percent, while the average krypton purity was better than ninety-nine percent.

Heat Transfer Coefficients For Condensing Vapors On A Horizontal Tube, Maurice Edward Brown, Rodwin Edwin Gulick

Theses

Film coefficients of heat transfer for vapors condensing on a smooth horizontal tube have been experimentally determined by many investigators. The so-called Thermocouple Method and the Wilson Method, have been used and generally accepted as the two methods for determining these film coefficients. A number of different organic vapors have been studied on various condensing surfaces. Nusselt has also developed a theoretical equation,

hN = 0.725 4√k_f³ρf²λg/D_oμfΔtcf

for evaluating the film coefficients of vapors condensing on hori?zontal tubes.

The earlier investigators have shown that theoretical values, hN do not check with experimentally determined …

Bis Phenol Epichlorohydrin Condensate Modification Of Alkyd Resins, Raymond Francis Carmody

Theses

A method is given for the modification of alkyd resin systems with Bis-Phanol Epichlorohydrin Condensates.

The properties of the modified alkyd resins are evaluated using similar unmodified alkyd resins as reference.

A theory of linear esterification is postulated.

The Analogy Between Heat And Mass Transfer In Packed Beds, Jasper Joseph Correnti

Theses

An operation which recurs in many branches of chemical engineering is that in which a fluid - gas or liquid - is passed through a bed of granular solids for the purpose of removing from, or adding something to the fluid (or both). In the oil and sugar industries, oils or syrups are passed through beds of adsorbents to remove impurities causing color and other undesireable effects. In the recovery of volatile solvents, air charged with solvent vapor is passed over solid adsorbents. In leaching, liquids are passed through beds of solids to remove some constituent of the solids. In …

The Effect Of Reduced Pressure On Variables In Distillation, Joseph Peter Cummins

Theses

To determine the effects of reduced pressure on pressure drop and holdup in distillations seven different liquids were distilled at varying rates at atmospheric pressure and under vacuum at pressures down to 50 mm Hg, using protruded stainless steel packing. Pressure drop and holdup were found to vary exponentially with masste at each pressure. At constant mass rate pressure drop was higher for decreased head pressure. Use of material of higher molecular weight led to lower pressure drop at same rate and pressure. Greatest effect of pressure on pressure drop was observed below 300 mm Hg. Liquid holdup was not …

Heat Capacity Ratios Calculated From The Benedict-Webb-Rubin Equation State, Edward George Delaney

Theses

The ratio of the isobaric heat capacity to the constant volume heat capacity has been calculated over a range of temperatures and pressures for the following hydrocarbons: methane, ethylene, ethane, propane, and n-butane. Graphs and tables of calculated data are presented showing the effect of temperature and pressure on the ratio of the heat capacities for these compounds.

The deviations of the heat capacities from ideal gas behavior were calculated by previous investigators from an equation based on the Benedict-Webb-Rubin equation of state, Experimental data were used to evaluate the heat capacities of the ideal gases, and were used together …

The Sulfonation Of Some Aromatic Compounds Using Sulfuric Acid In The Presence Of Thionyl Chloride, Paul Juergens

Theses

The rate of reaction in the sulfonation of some aromatic compounds with sulfuric acid was increased by the presence of thionyl chloride which, by reacting with the water of formation, effectively maintained the concentration of sulfuric acid above the level at which sulfonation can occur. The thionyl chloride had no measurable effect on the formation of isomers.

The sulfonstion reactions studied included those of toluene, naphthalene, bromobenzene, ortho-bromotoluene, and chlorobenzene.

Prediction Of Vapor-Liquid Equilibria, Daniel James Mchale

Theses

Several equations for predicting vapor-liquid equilibria from the physical properties of the components have been proposed in the literature. Two equations of this type proposed by O. Redlich and others have been investigated to determine their utility.

Results indicate the two equations give fairly satisfactory results for nearly ideal solutions, but are unsatisfactory for non-ideal solutions. Knowledge of molecular interactions in the solution would be necessary before the predictions could be used with confidence.

Variation Of Thickness Of Hard Anodic Films, Alphons Raymond O'Konski

Theses

An investigation was made of the effects of varying processing conditions on the thickness of anodic films produced by the Martin Hard Coat (4) process on commercially pure aluminum and nine aluminum alloys.

This study was conducted to provide sufficient data for designing coating thicknesses on aircraft accessory parts that would conform to the close tolerances maintained in the course of manufacture of precision components. Coating thicknesses up to 0.0051 in. were obtained. Changes in electrolyte strength, temperature of the bath, alloy composition, and current density were made to see their effect on the thickness of the film and growth …

The Determination Of Thoria In Tungsten Electrodes, Louis Arthur Prince

Theses

Two methods of analysis to determine thoria (thorium oxide, ThO₂) content of thoriated tungsten electrodes are investigated.

Chlorination methods are shown to leave thoria residues contaminated with tungstic oxide which may not be removed by extended chlorination. Ignition of the sample in air before chlorination increases contamination. A correction for the tungstic oxide in the residue is obtained colorimetrically.

The classical hydrofluoric-nitric mixed acid method is modified and shown to be equally as accurate, less exposed to operator's error, and more rapid than chlorination methods. Thin-walled polyethylene beakers are preferable to platinum ware for dissolving the sample, and …