Mining Engineering Commons^™

Optimization Of Blast Design For Better Fragmentation & Reduction Of Ground Vibration At Khao Mai Nuan Pyrophyllite Mine, Saraburi Province, Thailand, Arif Khan

Chulalongkorn University Theses and Dissertations (Chula ETD)

Control blasting with better fragmentation is very important to decrease the environmental impacts of blasting and the cost of downstream mining operations such as loading, transportation, crushing, and milling. Proper blasting designs with optimized parameters such as burden, spacing, stemming, sub-drilling, and amount of explosive ensure the required fragmentation with ground vibration within the standards set by different monitoring agencies. This study dealt with the blasting design parameters, fragmentation, and ground vibration at the Khao Mai Nuan Pyrophyllite quarry Saraburi province, Thailand. First, grab samples were collected from the quarry's active benches and tested in a lab for strength, compositions …

Effect Of Salinity Contrast Between Formation Water And Injected Low Salinity Water On Low Salinty Water Flooding In Dolostone Formation, Nuttapol Junput

Chulalongkorn University Theses and Dissertations (Chula ETD)

Low Salinity Waterflooding (LSWF) has gained substantial prominence in current scientific method for oil recovery improvement, owing to its simplicity, cost-effectiveness, and environmental friendliness as an Enhanced Oil Recovery (EOR) technique. Various studies have highlighted the crucial role of injected brine salinity and the concentration of Potential Determining Ions (PDI) in stimulate oil recovery mechanisms. However, the majority of these studies have predominantly concentrated on sandstone reservoirs. In light of the fact that over 50% of hydrocarbon reserves are situated in carbonate reservoirs, this research focuses specifically on dolomite reservoirs to examine the applicability and feasibility of implementing LSWF in …

Simulation Study On Co2 Enhanced Oil Recovery For Offshore Area In Thailand, Pariwat Wongsriraksa

Chulalongkorn University Theses and Dissertations (Chula ETD)

Fossil fuels are widely used all over the world. It generates carbon dioxide (CO2) which is one of the main causes for climate change and global warming. One practical technology to reduce CO2 emission is carbon capture, utilization, and storage (CCUS) which includes the use of CO2 for enhanced oil recovery (CO2EOR) and storage in the geological reservoir. In Thailand, there are some potential geological reservoirs for CO2EOR due to crude properties, depth of the reservoir and oil saturation, especially in the Gulf of Thailand. However, the high temperatures gradient in the Gulf of Thailand can lead to higher minimum …

Physical Property Measurement Of Surfactant Coupled With Nanoparticles For Enhanced Oil Recovery, Phoo Pwint Nandar

Chulalongkorn University Theses and Dissertations (Chula ETD)

The residual oil remained in the reservoir after the primary recovery and water flooding can either be produced by increasing the mobility of the oil or by altering the reservoir rock wetting behavior and diminishing the oil water interfacial tension. The surfactant flooding is one of the chemical enhanced oil recovery methods. At the optimal concentration, the surfactant flooding can provide the low interfacial tension favoring to the enhanced oil recovery. In contrast, the loss of the surfactant at the solid-liquid interface due to an adsorption lessens the amount of the surfactant required for oil displacement during the flooding. Therefore, …

Effect Of Salinity Contrast Between Formation Water And Injected Low Salinity Water On Low Salinity Waterflooding In Shaly-Sandstone Formation, Sarun Phuenghansaporn

Chulalongkorn University Theses and Dissertations (Chula ETD)

Low salinity waterflooding is an improving oil recovery technique that is highly mentioned nowadays as it is cost-efficient and environmentally friendly. The technique involves injecting water with lower salinity compared to formation salinity to shift the surface equilibrium toward the liberation of oil from the rock surface. Nevertheless, successful of this technique depends on many parameters especially the presence of clays. Several types of clays can be found in oil reservoirs, and they may react to different cations in inject low salinity in different ways, resulting in different magnitudes of oil recovery. Moreover, the contrast of salinity between formation water …

Pore Pressure Prediction Using Combination Drilling Efficiency And Hydro-Mechanical Specific Energy Methods, Munawir Arge Pratama Otolomo

Chulalongkorn University Theses and Dissertations (Chula ETD)

Several methods of pore pressure prediction using drilling parameters were introduced and improved to meet the challenges of accurate prediction at a relatively low cost. Knowledge of pore pressure is essential for safe well planning, cost-effective drilling, and operational decision-making. Conventional methods in pore pressure prediction using drilling parameters have limitations on its application of making the normal compaction trendline that is only applicable in clean shale intervals. In this work, the concept of drilling efficiency (DE) and hydro-mechanical specific energy (HMSE) for predicting formation pore pressure is proposed. This method, termed DE-HMSE, is based on the theory that the …

Development Of An Entry-Scale Modeling Methodology To Provide Ground Reaction Curves For Longwall Gateroad Support Evaluation, Haochen Zhao

Graduate Theses, Dissertations, and Problem Reports (ETD)

Longwall gateroad entries are generally subjected to severe mining-induced stress changes and deformations; they are prone to large roof falls, floor heaves, and rib sloughing. The standing support system in underground mines needs to be carefully designed to compensate for the mining-induced deformation of the surrounding rock mass and consecutively protect the integrity of gateroad entries. Local geology, together with mining-induced stress redistribution, influences the ground response and plays a major role in the performance of a standing support design. In the US, Support Technology Optimization Program (STOP) and its Ground Reaction Curve (GRC) design criteria have been applied to …

Integrated Large Discontinuity Factor, Lamodel And Stability Mapping Approach For Stone Mine Pillar Stability, Mustafa Baris Ates

Graduate Theses, Dissertations, and Problem Reports (ETD)

The objective of this research is to develop a software tool that integrates the large discontinuity factor (LDF) and the Boundary Element Method software (BEM), LaModel, to allow stone mine operators to assess the impact of the large discontinuities on local pillar stability. National Institute for Occupational Safety and Health (NIOSH) published design guidelines for underground stone mines to guide the industry in designing pillar and roof support. These guidelines emphasize the impact of large, angular discontinuities on pillar strength. Esterhuizen et al. (2011) derived the large discontinuity factor (LDF) to account for the impact of discontinuities on pillar stability …

Investigation Of Geomechanical Behavior Of Laminated Rock Mass Through Experimental And Numerical Approach, Qingwen Shi

Graduate Theses, Dissertations, and Problem Reports (ETD)

Roof failure in the Appalachian underground coal fields occurs often in laminated shale. Laminated shale roof in coal mines fails in unique ways, such as cutter failure or delamination failure. Extensive studies have investigated the influential factors that cause laminated roof failure, which include in-situ stress, entry layout, roof span, and roof support. However, cutter failure continues to occur frequently and erratically. This is due to the lack of in-depth understanding of the inherent properties of the laminations, such as bedding plane strength, matrix strength, and bedding plane spacing, which in turn influence the geomechanical behavior of the laminated rock. …

Noise Exposure Trends Among Violating Coal Mines, 2000 To 2021, Hanna Grace Davis

Graduate Theses, Dissertations, and Problem Reports (ETD)

Noise-induced hearing loss has continued to be a significant issue within the mining industry, even after the passing of the MSHA’s improved noise standard in 2000. NIOSH has recognized that the noise standard enacted by both MSHA and OSHA does not properly protect workers with the 5 dBA exchange rate (i.e., the increase in noise level leading to a doubling of energy) and the lack of emphasizing the use of engineering controls over administrative controls and overreliance on hearing protection device usage. The primary objective of this study is to investigate statistical sound relationships between MSHA noise-related violations and samples …

Calcite Depression In Bastnaesite-Calcite Flotation System Using Organic Acids, Emmy Muhoza

Graduate Theses, Dissertations, and Problem Reports (ETD)

Bastnaesite is the primary source of light REEs, namely cerium (Ce), lanthanum (La), praseodymium (Pr), neodymium (Nd), to name a few. Bastnaesite is typically concentrated using the froth flotation beneficiation method. Flotation of bastnaesite suffers from high reagent consumption due to the similar surface characteristics of bastnaesite and associated gangue minerals, including calcite. Additionally, complex stages of high-temperature conditioning are often required to suppress the detrimental impact of dissolved calcium ions on the flotation of bastnaesite. This research seeks to investigate the capabilities of organic acids in the bastnaesite-calcite flotation systems to selectively depress calcite minerals and effectively chelate calcium …

Experimental And Theoretical Investigation On The Initiation Mechanism Of Low-Rank Coal's Self-Heating Process, Yinan Zhang

Graduate Theses, Dissertations, and Problem Reports (ETD)

Coal spontaneous combustion remains a safety concern during coal mining, transportation, and storage and requires further investigation to develop effective prevention and control strategies. While various intrinsic and extrinsic conditions may influence coal self-heating, low-rank coals are more prone to spontaneous combustion, especially in humid climates. Therefore, quantifying the effect of extrinsic moisture on the self-heating of low-rank coals is critical for understanding the high propensity of low-rank coals for spontaneous combustion. Many studies have qualitatively evaluated the role of extrinsic moisture on the coal self-heating. Despite this, few studies have quantified the contribution of extrinsic moisture on wetting and …

Size Effect And Anisotropy On The Strength Of Shale Under Compressive Stress Conditions, Yun Zhao

Graduate Theses, Dissertations, and Problem Reports (ETD)

The underground coal mines in the Appalachian region report the highest rate of roof falls in the United States. The immediate roof of these mines is mostly composed of shale. The in-situ strength of shale is necessary for designing roof support to prevent roof falls. Estimating the in-situ strength of shale requires the knowledge of both size effect and anisotropy. This research used literature review, theoretical analysis, numerical modeling, and laboratory experiment to systematically investigate the size effect and anisotropy of shale strength under compressive strength conditions.

Literature review involved a comprehensive summary of previous research on the size effect …

Saxs-Based Nano-Scale Pore Structure Characteristics Of Coals With Different Metamorphic Degrees, Zhang Yu, Li Yong, Wang Yanbin, Wang Zhuangsen, Zhao Shihu, Han Wenlong

Coal Geology & Exploration

In order to reveal the characteristics of nano-scale pores in coals with different metamorphic degrees, the small-angle X-ray scattering method (SAXS) is used to obtain the porosity, pore size distribution, specific surface area and fractal dimension of 15 samples whose vitrinite reflectance R_max is 0.31%-6.24%, and the low temperature CO₂ and N₂ adsorption DFT model results are used to verify the pore size distribution. The results show: during coalification process, when R_max is < 0.5%, the porosity and the specific surface area of coal increase with the increase of metamorphic degree, the micropores(< 2 nm) content increases seldomly, the mesoporous(2-50 nm) and microporous(50-100 nm) content increase greatly, and the surface of coal is gradually smooth. When R_max=0.5%-1.4%, the porosity and the specific surface area decrease, and each type of pore content is reduced, and the surface of …

Factors Affecting The Attitude Accuracy Of Wireless Electromagnetic Wave Mwd System, Wang Xiaobo

Coal Geology & Exploration

In broken soft coal seams of coal mine where hydraulic driving directional drilling is used, hole collapse and hole wall instability are easy to occur. Electromagnetic wave measurement while drilling system is suitable for gas driving drilling, so it is widely used in broken soft coal seams. The accuracy of drilling trajectory is the key to gas drainage effect in broken soft coal seams. In the use of electromagnetic wave measurement while drilling system, the phenomenon of insufficient accuracy and large error of trajectory measurement appears irregularly. In order to solve this problem, this paper analyzes all the factors that …

Characteristics Of The Shale Gas Reservoirs And Evaluation Of Sweet Spots In Wufeng Formation And Longmaxi Formation In Jingmen Exploration Area, Li Xiaoming, Liu Jirong, Lin Wen, Ma Lihong, Liu Dexun, Chen Yujie

Coal Geology & Exploration

In order to further clarify the resource potential of shale gas from Wufeng Formation to Longmaxi Formation in Jingmen exploration area, sweet spots were selected. The shale in Wufeng Formation and 1th Member of Longmaxi Formation of the well X was taken as the research object in this study. Using sliced kerogen, X-ray diffraction, nuclear magnetic resonance, micro nano CT scanning, geochemical analysis and other testing methods, combined with logging interpretation results, based on the petrology, organic geochemical and mineral composition, physical properties, pore types and structure characteristics and hydrocarbon content, the reservoir characteristics of Wufeng-1^th Member of the …

Analysis Of Organic Matter Maturity Of Sapropel Coal In Oil Layer A Of Haishiwan Mine Field Of Yaojie Mining Area, Song Xiaozhong, Zhang Bingzhong, Lei Ying, Song Yanqiang

Coal Geology & Exploration

The vitrinite reflectance is recognized as the only comparable evaluation index of organic matter maturity of source rock in the exploration and development of oil and gas, shale gas and coalbed methane resources. Current research was done to determine the organic matter maturity of sapropel coal in oil layer A in Haishiwan mine field more accurately. Coal samples were collected from boreholes and observation of the optical characteristics of reflected light and fluorescence microscopic components were studied under the microscope. It was found that there are two different characteristic vitrinites in sapropel coal in oil layer A. One was fluorescent …

Deformation Characteristics Of Coal Measures And Gas Occurrence Law Of Coal Mines In North China, Wang Wei, Wei Yanzhao, Jia Tianrang, Yan Jiangwei

Coal Geology & Exploration

Gas is not only one of the important disaster-causing factors in coal mines, but also an important clean energy. Understanding the deformation characteristics of coal measures and the occurrence of gas is the basis for coal mine gas disaster prevention and coalbed methane development. Taking the North China coal measures as the research object, taking the tectonic evolution and control as the main line, using the theory of plate tectonics, tectonic evolution and step by step control of gas-occurring structures, the deformation characteristics of the North China coal-measures and the law of coal mine gas occurrence were systematically studied. The …

Discussion On The Water-Preserved Coal Mining By Dewatering-Reflooding Water Curtain In Open-Pit Coal Mines, Li Ying, Yang Zhuo, Wu Tong

Coal Geology & Exploration

To suppress the attenuation of groundwater resources caused by drainage and control the influence range of coal mining on groundwater resources, the coal mining technology with water curtain was adopted. Taking an open-pit coal mine as the background, this paper established a sand trough recharge platform to carry out physical experiments, and used a numerical method to simulate the irrigation area, so as to analyze the formation and variation of the dewatering-reflooding water curtain. Physical experiments were carried out to observe the formation of a fixed head boundary by water injection curtain which prevented the expansion of funnel, the influence …

Case Study On The Effects Of Seismic Exploration Beneath The Goafs Of Different Ages, Zhang Zhao, Yin Quanzeng

Coal Geology & Exploration

With the continuous development of coal resources, the upper group of coal in some coal mines has been mined out, and it is urgent to solve the detection problem of the lower group of coal. Affected by the goaf formed by the upper group of coal, the seismic energy absorption and scattering attenuation of the lower group of coal are significant, and the signal-to-noise ratio of the data is low. The detection of the lower group of coal under the goaf by 3D seismic exploration is still in the exploration stage. In this paper, the 3D seismic exploration project of …