Environmental Health and Protection Commons^™

Emisja Zanieczyszczeń Z Procesu Grafityzacji Elektrod Węglowych W Piecach Lwg (Castnera). Cz. 1. Wybrane Substancje Gazowe, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The results of measurements of quantity pollutants originated and emitted to air from LWG (Castner) furnaces were introduced. The investigation was carried out during the graphitisation process of coal electrodes, until moment of end of ventilation the stove across applied installations of cleaning of cool gases (catalytic burning and the wet desulphurization). The measurement results of CO, CO2, HC+H2, SO2, H2S, CS2, NO, NO2, NH3 as well as chosen hydrocarbons (C1-C6) and aromatic hydrocarbons (BTX) were presented. In result of conducted investigations was qualified courses of changeability of concentrations in gases these substances before and for the cleaning system. The …

Emisja Chlorowodoru Ze Spalania Węgla W Kotle Pyłowym, Marian Mazur, Robert Oleniacz, Przemysław Szczygłowski, Marek Bogacki

Robert Oleniacz

Emission of hydrogen chloride (HCl) from coal combustion is not controlled just like for example sulpfur dioxide emission. But HCl emission is also important, because chlorine content in some types of coal can reach the similar level to sulfur content. In the paper the measurement results of HCl emission to the air during combustion of three types of coal with law content of chlorine were presented. The researches were carried out for a steam pulverized coal boiler (max. boiler efficiency – 430 t/h) during three various loads (respectively 65, 80 and 95 % of maximum efficiency) without flue gas desulfurization. …

Metoda Oceny Trudności Oczyszczania I Toksyczności Spalin Powstających Podczas Spalania Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents a methodology for evaluating the cleaning difficulty and toxicity of combustion gases from waste incineration based on the knowledge of gases composition. This type of evaluation may be applicable to selection or modernization of flue gas cleaning systems for waste incineration plants and to comparative analy-sis of a pollution degree of raw (unclean) combustion gases. In the evaluation of the cleaning difficulty of gases six categories of difficulty have been identified for removal of selected substances or groups of substances. The evaluation is made individually for substances or groups of substances on condition their concentrations in flue …

Emisja Btx Towarzysząca Produkcji Wyrobów Węglowych I Grafitowych, Marian Mazur, Przemysław Szczygłowski, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The work presents results of direct measurements of benzene, toluene, ethyl benzene and xylenes (BTX or BTEX) emissions to the air from technological processes related with carbon and graphite manufacturing. The most important from all mentioned pollutants is benzene considered as one of the main factor of air pollution in the European Union. The highest concentrations of BTX were found in the fumes emitted from the tanks of liquid raw materials, while the highest levels of their emissions were from furnaces used for baking of green electrodes and other carbon products.

English title: BTX emission from production of graphite and …

Emisja Rtęci Z Energetycznego Spalania Węgla, Marian Mazur, Przemysław Szczygłowski, Robert Oleniacz, Janusz Dańko

Robert Oleniacz

In the paper, some results of the measurement of mercury emission from OP-430 boiler working in the Combustion Plant “Kraków S.A.” are presented. The tests were carried out during combustion of various coals and changeable the boiler efficiency. Apart from investigation of mercury emission to the atmosphere (in gaseous and solid phase), total mercury concentration in coal, bottom ash and dust collected in electrostatic precipitators were analysed as well. Thus emission amount could be verified by means of the approximate mercury balance performed for the coal combustion process.

English title: Mercury emission from coal combustion.

Влияние На Окружающую Среду Технологии Непрерывного Литья, Marian Mazur, Marek Bogacki, Robert Oleniacz, Agnieszka Łopata

Robert Oleniacz

This article presents a complex analysis of the impact of the technology of continuous casting of steel (CCS) on the rate of the air pollutant emissions from one of the Polish steel and iron plants. The emission sources occurring in the production process have been identified and their rate has been determined. The implementation of CCS has brought about significant changes in the production cycle of the steel plant and it also has caused an increase of the production effectiveness of steel products. The calculated environment effects have shown a considerable emission decrease of all pollutants in the scale of …

Likwidacja Strefy Ochronnej Wokół Huty Katowice W Dąbrowie Górniczej, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the history of the creation, management and liquidation of the protective zone around the Katowice Steelworks and Coke "Przyjaźń" (originally belonging to the "Katowice Steelworks") in Dąbrowa Górnicza (Poland). This zone was created in 1978 on the basis of the air quality impact assessment performed for the steelworks on the assumption steel production capacity of 9 million tons/year and planned production of coke at 3.3 million tons/year. These production volumes have never been achieved. In the 80's and 90's of the 20th century were conducted studies and calculations aimed to verify the nuisance of these plants on …

Termiczne Przekształcanie Odpadów Medycznych W Instalacji Fluidalnej Firmy Seghers – Emisja Zanieczyszczeń Gazowych I Możliwości Jej Ograniczenia, Robert Oleniacz

Robert Oleniacz

The paper presents the results of measurements of concentrations and mass streams of selected components in the flue gases from the thermal treatment of medical waste in the Seghers incinerator based on fluidized bed reactor.

The tests were carried out at the measuring points located both before and after of the flue-gas cleaning system based on the injection of dry hydrated lime and carbon sorbent and a ceramic filter. In this way it was possible to determine the effectiveness of the removal of selected air pollutants in the dry cleaning system. Analysis of the results of measurements made ​​it possible …

Przebieg Zmienności Stężeń Wybranych Zanieczyszczeń W Gazach Odlotowych Z Procesu Mokrego Gaszenia Koksu, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

Continuous measurement results of selected constituent concentrations in the gases emitted to the air during the coke wet quenching process were presented and discussed in the paper. The measurements were carried out for the standard wet quenching tower. The research covered such substances as carbon dioxide, carbon monoxide, hydrogen sulfide, nitrogen oxide, nitrogen dioxide and a total content of hydrocarbons and hydrogen (combustible gases). Changeability of the substance concentrations depending of the quenching process duration was analyzed. Among other things the beginning of these substances formation, appearance of the maximum and the range of observed concentrations were taken into consideration. …

Likwidacja Strefy Ochronnej Huty Katowice I Zakładów Koksowniczych "Przyjaźń" W Dąbrowie Górniczej, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

Legislation changes in Poland concerning the protective zones (created around industrial plants particularly harmful to the environment) were presented in the paper. Conditions connected with forming, developing and partial elimination of the protective zone existing around the "Katowice" steelworks and the coke plant Przyjaźń in Dąbrowa Górnicza (Poland) since 1978 were characterized as well.

English title: Elimination of the protective zone of the Katowice steelworks and the coke plant Przyjaźń in Dąbrowa Górnicza.

Weryfikacja Emisji Pyłowej Z Huty Katowice I Zasięgu Jej Oddziaływania, Marian Mazur, Robert Oleniacz, Marek Bogacki, Agnieszka Łopata

Robert Oleniacz

Preliminary analysis of the results of atmospheric dispersion modeling for dust emission from the Katowice Steelworks (Poland) showed necessity of verification the particulate matter, lead and cadmium emission from the plant. The verification was limited to the substance emission sources influencing air pollution to the largest extent. Both scale of dust emission and its granulometric and chemical composition were re-evaluated. Further calculations of the air propagation for the pollutants were carried out and calculation results were compared with direct measurements. Thus the Katowice Steelworks impact on air quality and the level of total dust, lead and cadmium ground deposition was …

Ocena Składu Gazów Odlotowych Z Procesów Spopielania Odpadów Niebezpiecznych Pod Kątem Trudności Oczyszczania I Toksyczności, Robert Oleniacz

Robert Oleniacz

Tightening of the European Union law in the field of the air emission limit values from waste incineration causes necessity for existing and new incineration plants to conform to the standards. It will often involve modernization of the flue gas cleaning system. Proposed in the paper the methodology of evaluation of the combustion gases composition in point of view cleaning difficulty should be useful to this end. Average toxicity factors for hazardous waste incineration flue gases were defined as well. Among other things they can be used in comparative analysis of the air pollutant concentration in the raw gas (before …

Czynniki Wpływające Na Skład Spalin I Wielkość Emisji Zanieczyszczeń Z Procesów Termicznego Przekształcania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The work summarizes factors influencing on air emissions from various full-scale hazardous waste incinerators (rotary kiln, multiple hearth furnace, starved-air incinerator, fluidized bed incinerator, liquid injection incinerator). Air pollutant emissions from hazardous waste incineration can be minimized not only by flue-gas cleaning. There are many factors that influence on flue-gas composition and the quantity of air pollutants formed during incineration: the type, the composition and the quantity of waste, the way of waste introducing to the incinerator, excess air ratio, combustion temperature, retention time of exhaust gases etc. Special attention was paid to the loading of waste and incineration conditions …

Ocena Udziału Huty Katowice W Poziomie Opadu Pyłu, Ołowiu I Kadmu Na Powierzchnię Terenu Wokół Zakładu, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the results of modeling of deposition on the land surface of dust, lead and cadmium emitted from the "Katowice" Steelworks. The calculations were carried out in the vicinity of the location of the dust deposition measuring points existing around the plant. Computational data were compared with the results obtained from direct measurements for the same calendar year. The responsibility of this plant in shaping the level of dust and heavy metal deposition in the region of the protective zone was determined.

English title: Participation of the "Katowice" Steelworks in the level of dust, lead and cadmium deposition …

Prognoza Wpływu Na Stan Zanieczyszczenia Powietrza Procesu Unieszkodliwiania Odpadów Pestycydowych W Piecu Cementowym, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the general conditions associated with running of pesticide waste co-incineration in rotary kilns for cement clinker burning, and describes the behavior of toxic substances entering to this process with waste materials or forming as the result of thermal decomposition. Additional air emissions and their impact on air quality were also assessed.

English title: Prediction of the impact on the state of air pollution for the process of pesticide waste disposal in a cement kiln.

Niezorganizowana Emisja Zanieczyszczeń Powietrza Z Hal Ciągłego Odlewania Stali, Marian Mazur, Marek Bogacki, Robert Oleniacz, Agnieszka Łopata

Robert Oleniacz

Air pollutant emissions occurring in an uncontrolled way do not be subject to the regular verification just like it takes place in case of the controlled sources, for which the routine measurements are carried out. In the paper a methodology and the results of some research were presented. The research consisted in determination the quantity of dust and gaseous pollutants emitted from the halls in which technological processes connected with the steel continuous casting were being run. Stocktaking of all the uncontrolled emission sources were carried out and the technological operations predominating in the level of the particle matter and …

Ocena Zasięgu Istotnego Oddziaływania Emisji Zanieczyszczeń Z Huty Katowice Pod Kątem Likwidacji Strefy Ochronnej, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the results of air quality impact assessment of Katowice Steelworks in Dąbrowa Górnicza (Poland) in the protective zone. On the basis of calculations, it was found that in terms of air pollution there is a reasonable possibility of complete elimination of existing protective zone around these industrial plants.

English title: Assessment of the extent of significant effects of pollutant emissions from the "Katowice" Steelworks in terms of liquidation of the environmental protection zone.

Struktura Emisji Związków Fluoru Z Hutnictwa Żelaza Na Przykładzie Huty Katowice, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

As recently as a dozen or so years ago ferrous metallurgy was known as one of the biggest source of fluorine compound emissions to the atmosphere. Nevertheless production technology and raw material changes occurring in this industry cause continuous decreasing of their participation in the total fluorine emission. On the ground of investigations that have been carried out in the Katowice Steelworks (Poland) in the last few years, participation of particular technological processing in the water-soluble fluorine compound emissions (which are regarded as toxic) were presented in the paper, as well as a position of fuel combustion process (that take …

Analiza Możliwości Likwidacji Stref Ochronnych Wokół Wybranych Zakładów Przemysłu Hutniczego I Koksochemicznego, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

Polish industrial plants with protective zones delimited in the past, have been faced with the necessity to liquidation of these zones before 2005. At the same time the plants must not cause any harmful influence over environment outside the area which they have title deed to. Determination of the current range of this impact is very important due to the high costs of a possible purchase of land exposed to the harmful effects. The study analyzes the possibility of verifying the course of borders two existing protective zones: around Katowice Steelworks and Coking Plant "Przyjaźń" in Dąbrowa Górnicza (the first …

Technologia Ciągłego Odlewania Stali I Jej Wpływ Na Ograniczenie Emisji Zanieczyszczeń Z Procesów Hutniczych, Marian Mazur, Marek Bogacki, Robert Oleniacz, Agnieszka Łopata, Anita Niedojadło

Robert Oleniacz

The paper presents a comprehensive analysis of the impact of continuous casting of steel technology on air pollutant emissions in one of the Polish steelworks - Huta Katowice S.A. in Dąbrowa Górnicza. Emission sources occurring in the production process and the levels of pollutant emissions into the air were described. Implementation of continuous casting of steel brought significant changes in the production cycle in steelworks and caused an increase in the efficiency of manufacture of products. Calculated environmental effects showed a significant reduction of all pollutant emissions in the whole plant.

English title: Technology of continuous casting of steel and …

Emisja Związków Fluoru Z Hutnictwa Żelaza, Marian Mazur, Marek Bogacki, Robert Oleniacz

Robert Oleniacz

The article presents the results of the last few years of comprehensive researches related to the emission of fluorine compounds from iron metallurgy in Poland. Determined of the levels of flue-gas concentrations and air emissions for fluorine in the form of gaseous and solid compounds, including water-soluble compounds (considered to be toxic). The study also made it possible to analyze of raw materials used in these processes taking into account fluorine content and its impact on the amount of fluorine compounds emitted to the air.

English title: Emissions of fluorine compounds with iron metallurgy.

Analiza Źródeł Emisji Związków Fluoru Z Procesów Hutnictwa Żelaza, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the results of many years of complex research issues related to the emission of fluorine compounds of iron and steel processes. They allowed to examine these processes used in raw materials in terms of the fluorine content and their impact on the amount of emissions of fluorine compounds to the air. Were determined by measuring the levels of concentration in flue gases and stack emissions of fluorine in the form of gaseous and solid compounds, including water-soluble components (considered to be toxic).

English title: Analysis of emission sources of fluorine compounds from the processes of ferrous metallurgy.

Spalanie Odpadów Niebezpiecznych W Piecach Cementowych. Część 2. Destrukcja Paliwa I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

Conditions occurring in cement rotary kilns assure high destruction and removal efficiency (DRE) of the most stable substances, efficacious dry sorption of acid gases in the alkaline raw meal and heavy metals bounding in the clinker. Adequate operation of hazardous waste incineration in the process connected with cement clinker production does not cause increasing air pollutant emissions. Magnitude of the emissions often does not depend of this if there are using wastes in the cement kiln at all. The work presents a review of DRE levels and stack emissions for selected flue-gas constituents during hazardous waste co-combustion in cement kilns …

Ocena Zasięgu Oddziaływania Emisji Zanieczyszczeń Z Huty Katowice I Zk “Przyjaźń” W Dąbrowie Górniczej W Aspekcie Weryfikacji Wielkości Strefy Ochronnej, Marian Mazur, Marek Bogacki, Robert Oleniacz

Robert Oleniacz

The paper presents the results of an analysis of current pollutant emissions from "Katowice" Steelworks and Coke Plant "Przyjaźń" in the Dąbrowa Górnicza (Poland) and calculations of spreading of these pollutants in the atmosphere. The research have shown that there is a reasonable possibility of reducing the existing protective zone around these plants, which should significantly reduce the costs incurred for the purchase of the land and management of the zone area.

English title: Assessment of the impact extent of pollutant emissions from "Katowice" Steelworks and Coke Plant "Przyjaźń" in the Dąbrowa Górnicza in terms of verification the size of …

Emisja Zanieczyszczeń Ze Spalania Odpadów Niebezpiecznych W Piecu Obrotowym, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The article presents measurement results of air pollutant emissions from incineration of selected hazardous wastes in a full-scale rotary kiln equipped with afterburner and a wet installation for flue gas cleaning. This type of kiln is suitable for thermal disposal of many sorts of wastes, both solid and liquid. Four groups of waste were being incinerated during the tests: coke tars, medical (hospital) and pharmaceutical wastes added to greased cleaning materials, a sawdust and used gloves, varnish and lubrication wastes, as well as waste rubber and resins. The study was performed in order to answer the question: is the process …

Emisja Metali Ciężkich Ze Spalania Odpadów Niebezpiecznych, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The paper presents the results of measurements of air emissions of heavy metals from hazardous waste incineration in a multiple hearth furnace and a rotary kiln incinerator equipped with a single wet flue gas cleaning systems. In the multiple hearth furnace an industrial sewage sludge (from coke industry) was being incinerated. In the rotary kiln such wastes were being incinerated as: waste paints, varnish and lubricant, coal tars waste, contaminated cleaning rags, sawdust and used gloves, waste resins and plastics, rubber waste, outdated pharmaceuticals and medicines, and hospital waste. The research allowed us to determine the levels of pollutant concentrations …

Emisja Zanieczyszczeń Podczas Składowania I Termicznej Utylizacji Osadów Ściekowych Z Przemysłu Koksochemicznego / Emissions During Storage And Thermal Utilization Of Sewage Sludge From Coke-Chemical Industry, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

Both storage and thermal disposal of sewage sludge from industrial wastewater treatment plants are a significant source of air pollutant emissions. The study included the sludge generated in the coke-chemical industry. The paper presents the results of measurements of emissions of selected substances during storage of the waste in a closed storage hall with natural ventilation and during incineration of the mechanically dewatered sludge in a multiple hearth furnace.

Emisja Zanieczyszczeń Ze Spalania Odpadów Ściekowych W Piecu Półkowym, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The article presents incineration tests of silty-tar sludge produced in the wastewater treatment plant for coke industry. Sewage sludges were incinerated in a full-scale multiple hearth incinerator equipped with a wet flue-gas cleaning system (alkaline scrubber). Measurements of air pollutant emissions were carried out both before and after the cleaning system. The obtained results allow to conclude that the thermal utilization of sewage sludge in this type of installation might be just a little cumbersome for the environment, using the appropriate equipment for the purification of exhaust gases. The paper also specifies minimum exhaust gas cleaning performance that guarantees compliance …

Emisja Zanieczyszczeń Ze Spalania Odpadów Przemysłowych W Piecu Obrotowym, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The paper presents the results of measurements of the concentration of selected pollutants in the flue gases from the incineration of industrial wastes in a full-scale rotary kiln. The study included three waste mixtures introduced into the kiln: 1) coal tar waste (tar origin of coke); 1) waste paints, varnish and lubricant; 3) resin and rubber waste. The article also assesses the effectiveness of the existing wet flue gas cleaning system (alkaline scrubber) and specifies minimum exhaust gas purifying performance guarantees compliance with European emission standards for waste incineration.

English title: Pollutant emissions from incineration of industrial waste in a …

Emisja Chlorowodoru I Związków Fluoru Ze Spalania Odpadów Niebezpiecznych, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the results of measurements of the concentration of hydrogen chloride (HCl) and fluoride compounds (as HF) in raw and purified combustion gases discharged from the incineration of selected hazardous wastes. The study included two installations operating on an industrial scale: a multiple hearth furnace and a rotary kiln incinerator equipped with a single wet flue gas cleaning systems. In the multiple hearth furnace was being incinerated sludge from coke industry. In the rotary kiln were being incinerated coal (coke) tars, contaminated cleaning rags, sawdust, used gloves, outdated pharmaceuticals and medicines, hospital waste, waste paints, varnish and lubricant, …