Food Processing Commons^™

Effect Of Processing On Microbiota Accessible Carbohydrates In Whole Grains, Caroline Smith

Department of Food Science and Technology: Dissertations, Theses, and Student Research

There is potential to increase microbiota accessible carbohydrates (MAC) in whole grains through food processing. Therefore, different processing conditions for boiling and extrusion of whole wheat flour were studied for their effect on MAC. Processing conditions had a minimal effect on fermentation response using 2 fecal samples of disparate composition. However, the processing method had an impact on the fermentation of non-digestible carbohydrates and subsequent short chain fatty acids production, but only for a microbiome with high diversity and a predominance of microbes associated with dietary fiber intake. Subsequently, five processing methods: boiling, extrusion, unleavened bread, yeast bread, and sourdough …

Formation Of Low Density And Free-Flowing Hollow Microparticles From Non-Hydrogenated Oils And Preparation Of Pastries With Shortening Fat Composed Of The Microparticles, Joshua Gudeman

Department of Food Science and Technology: Dissertations, Theses, and Student Research

Solid fats provide critical functionality in the structuring, shortening, and stabilizing of many foods. However, their use as an ingredient is foods can present a number of challenges. The physical properties of solid fat can make them difficult to apply to or incorporate into foods consistently. On an industrial food production scale, handling of solid fats can difficult because they are often packed in heavy cubes or totes, and production delays and inefficiencies may be caused by the need to remelt the oils before use. Oils as a macronutrient also contribute a relatively high number of calories at 9 calories …

Effects Of Poor Sanitation Procedures On Cross-Contamination Of Animal Species In Ground Meat Products, Sunjung Chung, Rosalee S. Hellberg

Food Science Faculty Articles and Research

The presence of <1% of an undeclared species in ground meat is generally thought to be indicative of cross-contamination as opposed to intentional mislabeling; however, this has not been experimentally tested. The objective of this study was to quantify the effects of poor sanitation on the cross-contamination of animal species in ground meat products, with the example of undeclared pork in ground beef. Cross-contamination was quantified using real-time polymerase chain reaction (PCR). Three different sanitation treatments were tested with a commercial grinder (“no cleaning”, “partial cleaning”, or “complete cleaning”) in between grinding of pork and beef samples (13.6 kg each). A 100-g sample was collected for each 0.91 kg (2 lb) of beef processed with the grinder and each sanitation treatment was tested twice. For the “no cleaning” treatment, the first 100-g sample of ground beef run through the grinder contained 24.42 ± 10.41% pork, while subsequent samples (n = 14) contained <0.2% pork. With “partial cleaning,” the first sample of ground beef contained 4.60 ± 0.3% pork and subsequent samples contained <0.2% pork. Pork was not detected in ground beef following “complete cleaning.” These results indicate that incomplete cleaning of grinding equipment leads to species cross-contamination at levels of <1% in most cases. Proper sanitation procedures must be followed when grinding multiple species in order to prevent cross-contamination and product mislabeling.

Development Of A Dna Mini-Barcoding Protocol Targeting Coi For The Identification Of Elasmobranch Species In Shark Cartilage Pills, Rowena J. Zahn, Anthony J. Silva, Rosalee S. Hellberg

Food Science Faculty Articles and Research

Many elasmobranch (shark and ray) species are considered threatened and their identification in processed products is important for conservation and authentication purposes. However, identification of elasmobranch species in shark cartilage pills has proven difficult using existing methodologies. The objective of this study was to develop a DNA mini-barcoding protocol using a ~130 bp region of the cytochrome c oxidase subunit I (COI) gene for species identification in shark cartilage pills. A total of 22 shark cartilage products underwent DNA extraction in duplicate using the DNeasy Blood and Tissue Kit (Qiagen). The effectiveness of a clean-up step following DNA extraction was …

Seaweeds As Nutraceuticals For Health And Nutrition, Emer Shannon, Nissreen Abu-Ghannam

Articles

Throughout human history, seaweeds have been used as food, folk remedies, dyes, and as mineral-rich fertilisers. Seaweeds as nutraceuticals or functional foods with dietary benefits beyond their fundamental macronutrient content are now a major research and industrial development concept. The occurrence of dietary and lifestyle related diseases, notably type 2 diabetes, obesity, cancer, and metabolic syndrome has become a health epidemic in developed countries. Global epidemiological studies have shown that countries where seaweed is consumed on a regular basis have significantly fewer instances of obesity and dietary-related disease. This review outlines recent developments in seaweed applications for human health from …

Multi-Instrument Evaluation Of A Real-Time Pcr Assay For Identification Of Atlantic Salmon: A Case Study On The Use Of A Pre-Packaged Kit For Rapid Seafood Species Identification, Amanda A. Naaum, Rosalee S. Hellberg, Tara A. Okuma, Robert H. Hanner

Food Science Faculty Articles and Research

Protecting the seafood supply chain from species substitution is critical for economic, health, and conservation reasons. DNA-based methods represent an effective means to detect species substitution, but current methods can be time consuming or costly, and require specialized instruments and operators. Real-time PCR provides an alternative that can be performed quickly, and in some cases even on-site. The use of commercial kits reduces the expertise required by the operator and therefore increases accessibility to testing. This potentially increases the likelihood of adoption into the supply chain, but only if the kits are robust across multiple operators, instruments, and samples. In …

Physiological Response Of ‘Fuji’ Apples To Irradiation And The Effect On Quality, Nasim Kheshti, Anderson Adriano Martins Melo, Alan Baquero Cedeno, David Obenland, Anuradha Prakash

Food Science Faculty Articles and Research

The objective of this study was to determine the influence of irradiation-induced physiological responses on quality parameters in ‘Fuji’ apples. Apples were treated at 377 and 1148 Gy, stored for 7 days at 1 °C to mimic ground transportation to Mexico and another 7 days at ambient temperature to simulate retail and consumer storage conditions. Irradiation suppressed ethylene production, especially in the 1148 Gy treated apples, which was consistent with lower activities of 1-aminocyclopropane-1-carboxylate oxidase (ACO). A dose-dependent increase in respiration rate corresponded with decreases in titratable acidity (TA) and organic acids. Higher electrolyte leakage in apples irradiated at the …

Sustainability Assessment Of U.S. Beef Processing And Its Antimicrobial Systems, Shaobin Li

Department of Civil and Environmental Engineering: Dissertations, Theses, and Student Research

With the increasing meat demand and awareness of sustainability, concerns have been raised regarding the sustainability of beef production and processing. However, scarce data and inadequate sustainability assessment frameworks for the U.S. beef processing industry limit the ability to develop new technologies and policies comprehensively without shifting sustainability burdens. To fill those gaps, various assessments of the U.S. beef processing industry were conducted from multiple perspectives regarding the environmental, economic, microbial effectiveness of its antimicrobial systems, and human health impacts from foodborne illness, occupational hazards, and environmental pollution.

First, process-level water and energy usage at a typical large-size beef processing …

Hart County Foodways (Fa 1291), Manuscripts & Folklife Archives

FA Finding Aids

Finding aid only for Folklife Archives Project 1291. Collection of projects conducted by students for Dr. Ann Ferrell's 2018 fieldwork class. Projects address traditional and contemporary foodways practices throughout Hart County, Kentucky.

Encapsulation Of Astaxanthin-Enriched Camelina Seed Oil Obtained By Ethanol-Modified Supercritical Carbon Dioxide Extraction, Liyang Xie

Department of Food Science and Technology: Dissertations, Theses, and Student Research

Astaxanthin is a high-value carotenoid widely used in the food, feed, nutraceutical, and pharmaceutical industries. Natural sources of astaxanthin are preferable to synthetic sources. However, current sources of natural astaxanthin are limited and fall short of global demand. In addition, effective extraction and stabilization strategies are needed before the utilization of natural astaxanthin in food applications. This work investigated 1) the feasibility of ethanol-modified supercritical carbon dioxide (SC-CO2) extraction of astaxanthin from engineered camelina seed, a potential source of natural astaxanthin, and 2) the potential of an emulsion-based system to protect astaxanthin after extraction. The physical properties of the emulsion …

Efficacy Of Cold Plasma Functionalised Water For Improving Microbiological Safety Of Fresh Produce And Wash Water Recycling, Apurva Patange, Peng Lu, Daniela Boehm, Patrick Cullen, Paula Bourke

Articles

Atmospheric cold plasma (ACP) is an effective method for microbiological decontamination. This study evaluated an alternative water-based decontamination approach for inactivation of bacterial population from fresh produce and in the wash water generated from fresh produce washing. The study characterised ACP inactivation of attached Listeria innocua and Pseudomonas fluorescens inoculated on lettuce in comparison to chlorine treatment. P. fluorescens was sensitive to ACP treatment and was reduced below detection limit within 3 min of treatment. L. innocua population was reduced by ∼2.4 Log10 CFU/g after 5 min of treatment; showing similar inactivation efficacy to chlorine treatment. The microbial load in …

Atmospheric Cold Plasma Interactions With Microbiological Risks In Fresh Food Processing, Apurva Patange

Doctoral

Atmospheric cold plasma (ACP) is a novel emerging non-thermal technology that has attracted attention as a decontamination tool in several industrial, food and healthcare sectors. This study investigated the anti-microbial efficacy of ACP against microbiological risks associated with fresh foods. Treatment was performed using in-package ‘dry’ ACP technology and plasma functionalised liquid to decontaminate microorganisms, exploring the responses to real and challenging microbiological risks pertinent to both fresh foods themselves as well as the effluents generated from food processing industry. A range of critical control process parameters were investigated with respect to key pathogenic and spoilage microorganisms commonly implicated in …

Antimicrobial Effects Of Microwave-Induced Plasma Torch (Minimip) Treatment On Candida Albicans Biofilms, Oliver Handorf, Uta Schnabel, André Bösel, Thomas Weihe, Sander Bekeschus, Alexander C. Graf, Jörg Ehlbeck

Articles

The susceptibility of Candida albicans biofilms to a non-thermal plasma treatment has been investigated in terms of growth, survival and cell viability by a series of in vitro experiments. For different time periods , the C. albicans strain SC5314 was treated with a microwave-induced plasma torch (MiniMIP). The MiniMIP treatment had a strong effect (reduction factor (RF) = 2.97 after 50 s treatment) at a distance of 3 cm between the nozzle and the superior regions of the biofilms. In addition, a viability reduction of 77% after a 20 s plasma treatment and a metabolism reduction of 90% after a …

Development And Diagnostics Of Novel Non-Thermal Plasmatreatment Systems, Laurence Scally

Doctoral

Non-thermal plasma (NTP) has been a point of interest in many areas over the last few decades. Much research has been,and continues to beundertaken,to understand the fundamentals of plasma discharges. This is such a broad topic due to the very nature and variable dependencies that set the conditions for plasma discharge to occur. This can come in the form of electrode geometry and spacing, dielectric barrier thickness, humidity of environment, material selection for electrodes and dielectric barriers, the power supply used, and the operating gas(es) used. A lot of these influencing factors can be set and kept constant, but still …

Effect Of Cold Plasma On The Techno-Functional Properties Of Animal Protein Food Ingredients, Juan M. Pérez-Andrés, Carlos Álvarez, Patrick Cullen, Brijesh K. Tiwari

Articles

Proteins, as food ingredients, are employed in the food industry, not only for their high nutritional value, but also because of their techno-functional properties. Modifications of their native structure due to the action of external factors such as pH, temperature or processing by emerging technologies, can lead to changes in their functionality; and consequently, their applicability. The present study investigates the effects of cold atmospheric air plasma on the techno-functional properties of two common food ingredients (haemoglobin and gelatine from pork), and a novel source of functional proteins extracted from a meat co-product (bovine lung protein). Significant effects were found …