Food Processing Commons^™

The Physicochemical Properties Of Soy Protein Hydrolysate And Its Formulation And Stability With Encapsulated Probiotic, John Stricklin Edwards

Graduate Theses and Dissertations

Soy protein isolate (SPI) and probiotics can serve as a functional ingredient and beneficial supplement, respectively, to food formulations, but few studies focus on the compatibility of these two ingredients. The objective of this study was to prepare soy protein isolate (SPI) from defatted soybean flour and identify an optimal hydrolysis protocol to create soy protein hydrolysates (SPH) with improved solubility and functional properties and achieve an optimum encapsulation technique for probiotics and to determine the in vitro viability of encapsulated probiotic cells with SPH in a gastrointestinal environment. The SPI was prepared using an alkaline extraction procedure for solubility …

Effect Of Processing On Microbiota Accessible Carbohydrates In Whole Grains, Caroline Smith

Department of Food Science and Technology: Dissertations, Theses, and Student Research

There is potential to increase microbiota accessible carbohydrates (MAC) in whole grains through food processing. Therefore, different processing conditions for boiling and extrusion of whole wheat flour were studied for their effect on MAC. Processing conditions had a minimal effect on fermentation response using 2 fecal samples of disparate composition. However, the processing method had an impact on the fermentation of non-digestible carbohydrates and subsequent short chain fatty acids production, but only for a microbiome with high diversity and a predominance of microbes associated with dietary fiber intake. Subsequently, five processing methods: boiling, extrusion, unleavened bread, yeast bread, and sourdough …

Formation Of Low Density And Free-Flowing Hollow Microparticles From Non-Hydrogenated Oils And Preparation Of Pastries With Shortening Fat Composed Of The Microparticles, Joshua Gudeman

Department of Food Science and Technology: Dissertations, Theses, and Student Research

Solid fats provide critical functionality in the structuring, shortening, and stabilizing of many foods. However, their use as an ingredient is foods can present a number of challenges. The physical properties of solid fat can make them difficult to apply to or incorporate into foods consistently. On an industrial food production scale, handling of solid fats can difficult because they are often packed in heavy cubes or totes, and production delays and inefficiencies may be caused by the need to remelt the oils before use. Oils as a macronutrient also contribute a relatively high number of calories at 9 calories …

Socio-Ecological Barriers To Dry Grain Pulse Consumption Among Low-Income Women: A Mixed Methods Approach, Shelly M. Palmer, Donna M. Winham, Ann M. Oberhauser, Ruth E. Litchfield

Ann Oberhauser

The purpose of this study was to determine the socio-ecological influences on dry grain pulse consumption (beans, peas, lentils, chickpeas) among low-socioeconomic women in Iowa. Seven focus groups were conducted, with 36 women who qualified for income-based federal assistance. Data were collected from October 2017 to January 2018. Participants completed a survey that gathered individual demographics, assessed perceptions of dry grain pulses, and level of food security. Fifty-eight percent of the women were non-Hispanic white, and 39% were African American, all with an average age of 34.7 years. Thirty-three percent of the women consumed pulses less than once per week. …

Impact Of Sanitizers On Salmonella Enterica Contamination And Microbial Populations Of Poultry Processing Reuse Water, Andrew Micciche

Graduate Theses and Dissertations

As human populations increase in numbers, access to clean, fresh water is becoming increasingly difficult to balance between agricultural and municipal demands. Water scarcity is a limiting factor of food production in many countries, whether they are emerging or established economies. In conventional poultry processing systems, access to water is particularly critical for the maintenance and disinfection of processing areas, as well as in processing operations such as scalding, chilling, and carcass washing. The need for sustainable alternatives to single-use water supplies is becoming increasingly more urgent, and as a result, the implementation of water reuse in poultry processing plants …

Effects Of Germination Conditions Of Brown Rice In Relation To Flour Physicochemical Properties And Bread Qualities, Wipada Wunthunyarat

Graduate Theses and Dissertations

Gluten-free products from rice are gaining popularity among consumers because of its hypoallergenic characteristic. The absence of gluten results in inferior bread qualities such as hard texture, reduced volume and shorter shelf-life, which can be improved by the addition of external hydrolytic enzymes. Hydrolytic enzymes are activated during germination to stimulate plant growth, and hence these enzymes may function similarly to the external enzymes to improve gluten-free bread from brown rice. Therefore, the objective of this work was to investigate the activities of amylases and protease in germinated brown rice (GBR) from long-grain and short-grain rices under different germination conditions …

Potential Antimicrobials For Controlling Listeria Monocytogenes In Frankfurters, Aaron Rashad Bodie

Graduate Theses and Dissertations

Listeria monocytogenes is a pathogenic microorganism that causes Listeriosis. Listeriosis is a highly mortal disease with approximately 20% mortality rate. Listeria is psychrophilic, therefore it is able to survive in the refrigerator. This affects foods at cool storage such as fresh produce and RTE meats. To ensure the safety of RTE meat, post processing treatments are used such as vacuum packing, edible films, dip and treatment. One-way RTE can be treated is with the use of antimicrobials. However, in the past chemical substances were used. Currently, consumers want more natural and organic preservatives to combat health problems from toxic components …

The Influence Of Different Packaging Materials And Atmospheric Conditions On The Properties Of Pork Rinds, Kristi Kõrge, Katrin Laos

Journal of Applied Packaging Research

Rancidity development in high fat content products is a common off-flavor flaw in snack foods. Packaging is often used to avoid spoilage and extend shelf-life. The properties of pork rinds packaged in four different packaging materials with and without nitrogen were studied during 120 days of storage (22 °C, RH 60%, absence of light). The influence of different packaging materials and atmospheric conditions on pork rinds’ water activity, hardness, crispness and rancidity development was determined. The PET/PE packaging material had lower barrier properties for the product in both atmospheric conditions compared with PP/metPP (40 and 50 μm) and PET/PETmet/PE. PP/metPP …

Determining Kinetic Parameters Of Thiamine Degradation In Three Nasa Spaceflight Foods In Thermal Processing And Long-Term Storage And Methods For Analyzing Microstructure And Precipitant Development In Real And Model Wines, Timothy R. Goulette

Doctoral Dissertations

The current NASA spaceflight food program encompasses a wide variety of commercial and custom-made edible products. These foods are designed to ensure each crewmember receives the Recommended Dietary Allowance (RDA) of vitamins and minerals to maintain adequate health during the entire spaceflight mission. With the desire for long-duration and exploration-class missions, such as the impending mission to Mars, the retention of important nutrients such as labile vitamins in spaceflight foods is critically important. For this reason, multiple studies were conducted to determine the vitamin degradation behavior of thiamine (vitamin B₁) within three spaceflight foods which demonstrated both significant …

Saponin Removal From Quinoa By Abrasion Processing, Luke Lundberg

Master's Theses

Quinoa is coated with a thin layer of saponins, glycosylated triterpenoids, that produce a bitter flavor when consumed. The average saponin content in commercial varietals from Bolivia average around 2.7% saponins and organoleptic testing shows the threshold for noticing a bitter flavor is below 0.12% (Medina-Meza et al., 2016). Current industrial processing methods use a combination of abrasion and turbulent water flow to remove saponin. This study will address the following research question: How will grain-to-grain and grain-to-surface abrasion affect the processing time to remove saponin from quinoa? In particular, can effective saponin removal be achieved in less than 10 …

Encapsulation Of Astaxanthin-Enriched Camelina Seed Oil Obtained By Ethanol-Modified Supercritical Carbon Dioxide Extraction, Liyang Xie

Department of Food Science and Technology: Dissertations, Theses, and Student Research

Astaxanthin is a high-value carotenoid widely used in the food, feed, nutraceutical, and pharmaceutical industries. Natural sources of astaxanthin are preferable to synthetic sources. However, current sources of natural astaxanthin are limited and fall short of global demand. In addition, effective extraction and stabilization strategies are needed before the utilization of natural astaxanthin in food applications. This work investigated 1) the feasibility of ethanol-modified supercritical carbon dioxide (SC-CO2) extraction of astaxanthin from engineered camelina seed, a potential source of natural astaxanthin, and 2) the potential of an emulsion-based system to protect astaxanthin after extraction. The physical properties of the emulsion …

Desarrollo De Una Bebida Refrescante Con Antioxidantes A Base De Café Verde (Coffea Arábica) Y Pulpa De Gulupa (Passiflora Edulis Sims), Iendy Sharik Gil Ruiz, Gina Viviana Deaza Mancera

Ingeniería de Alimentos

La presente investigación tiene como objeto el desarrollo de una bebida refrescante, el cual aporte la capacidad antioxidante del café verde (Coffea arabica) y la gulupa (Passiflora edulis Sims), incluyendo sus características fisicoquímicas. Para ello, se evaluaron diferentes formulaciones de la bebida refrescante. La bebida se elaboró a partir de la mezcla de una infusión de café verde y pulpa de gulupa previamente caracterizadas, teniendo en cuenta que los niveles de cafeína no superaran lo recomendado por el INVIMA en el Acta 03/06 (250 mg / L). Las formulaciones evaluadas fueron: T1: 0% infusión de café verde, 100% agua (Patrón); …

Antimicrobial Effects Of Microwave-Induced Plasma Torch (Minimip) Treatment On Candida Albicans Biofilms, Oliver Handorf, Uta Schnabel, André Bösel, Thomas Weihe, Sander Bekeschus, Alexander C. Graf, Jörg Ehlbeck

Articles

The susceptibility of Candida albicans biofilms to a non-thermal plasma treatment has been investigated in terms of growth, survival and cell viability by a series of in vitro experiments. For different time periods , the C. albicans strain SC5314 was treated with a microwave-induced plasma torch (MiniMIP). The MiniMIP treatment had a strong effect (reduction factor (RF) = 2.97 after 50 s treatment) at a distance of 3 cm between the nozzle and the superior regions of the biofilms. In addition, a viability reduction of 77% after a 20 s plasma treatment and a metabolism reduction of 90% after a …

Thermal, Interfacial, And Application Properties Of Pea Protein Modified With High Intensity Ultrasound, Aeneas Koosis

Theses and Dissertations--Animal and Food Sciences

The overall objective of the study was to investigate different food ingredient conditions and ultrasound treatment on pea protein in terms of surface morphology and thermal characteristics. The motivation of this work was based on previous studies focusing on non-chemical physical modifications of plant proteins and the increasing demand for functional alternative proteins.

Ultrasonication time and amplitude, pH, protein concentration, and salt concentration all influenced the thermal and interfacial properties of pea protein. Ultrasound treatment altered the quaternary and tertiary structure of the storage protein and disrupted non-covalent bonds. The structural altercations and a reduction in particle size led to …

Development And Diagnostics Of Novel Non-Thermal Plasmatreatment Systems, Laurence Scally

Doctoral

Non-thermal plasma (NTP) has been a point of interest in many areas over the last few decades. Much research has been,and continues to beundertaken,to understand the fundamentals of plasma discharges. This is such a broad topic due to the very nature and variable dependencies that set the conditions for plasma discharge to occur. This can come in the form of electrode geometry and spacing, dielectric barrier thickness, humidity of environment, material selection for electrodes and dielectric barriers, the power supply used, and the operating gas(es) used. A lot of these influencing factors can be set and kept constant, but still …

Effect Of Cold Plasma On The Techno-Functional Properties Of Animal Protein Food Ingredients, Juan M. Pérez-Andrés, Carlos Álvarez, Patrick Cullen, Brijesh K. Tiwari

Articles

Proteins, as food ingredients, are employed in the food industry, not only for their high nutritional value, but also because of their techno-functional properties. Modifications of their native structure due to the action of external factors such as pH, temperature or processing by emerging technologies, can lead to changes in their functionality; and consequently, their applicability. The present study investigates the effects of cold atmospheric air plasma on the techno-functional properties of two common food ingredients (haemoglobin and gelatine from pork), and a novel source of functional proteins extracted from a meat co-product (bovine lung protein). Significant effects were found …

Characterization Of Lipids And The Protein Co-Products From Various Food Sources Using A One-Step Organic Solvent Extraction Process, Alleda Rose

Graduate Theses, Dissertations, and Problem Reports

Traditional lipid extraction methods are labor intensive and time-consuming so interest in one-step methods using various organic solvents are gaining in popularity. Extraction efficiency depends heavily on the solvents used yet comparisons between different solvents are lacking. Defatting techniques are commonly used to concentrate crude protein and may be useful for enhancing protein content in food sources. The objective of this research was to 1) determine the lipid extraction efficiencies of hexane (H), 3:2 hexane-isopropanol (HI), chloroform (C), 2:1 chloroform-methanol (CM), and methyl-tert-butyl-ether (MTBE) using a one-step organic solvent lipid extraction method on whole insect, egg yolk, and krill powders …