Food Science Commons^™

Crystal Morphology Of Shortenings And Margarines, P. Chawla, J. M. Deman, A. K. Smith

Food Structure

An improved method is proposed for isolation of fat crystals with isobutanol, followed by fixation using osmium tetroxide vapours or cryo-fixation and visualization in the Scanning Electron Microscope (SEM). The cryo-fixation method revealed the presence of well defined needle-shaped or rod-shaped fat crystals. The osmium fixed crystals did not appear as distinct. The crystals existed as single crystals, platelets and spherulites. Polarized light micrographs did not show the details of the crystal morphology that were observed in the SEM.

Microstructure Of Peanut Seed: A Review, Clyde T. Young, William E. Schadel

Food Structure

Mature peanut seed microstructure of importance to the food industry is examined with regard to: (1) anatomy and cytology of peanut seed; (2) the effects of environment on peanut seed; and (3) the effects of various processing procedures on peanut seed. Current peanut seed microstructure research by the authors is directed toward evaluation of the quality of processed peanuts including using TEM, SEM and LM to evaluate the effects of different times of oven roasting at the same temperature, and a method for evaluating quality of homogenization of broken cell and tissue fragments, protein bodies and starch in stabilized peanut …

Particle Characteristics Of Flake-Cut Meat, P. R. Sheard, A. Cousins, P. D. Jolley, C. A. Voyle

Food Structure

The size of flake-cut meat is an Important quality determinant of comminuted meat products which. potentially. depends upon a large number of factors. Temperature and whether or not the meat is pre-broken have a major Influence on the resulting particle size distribution, as does aperture size. Meat flaked at -7'C produced two to three times more flakes than at -3' C. Under some conditions the particles produced were as little as 0.4 mm thick and characteristically were thicker at one end.

High speed photography, used to visualise the cutting action. Indicated that size reduction occurs In a controlled manner providing …

Light And Scanning Electron Microscopy Of The Peanut (Arachis Hypogaea L. Cv. Florunner) Cotyledon After Roasting, Clyde T. Young, William E. Schadel

Food Structure

Changes in the microstructure of peanut (Arachls ~ L. cv Florunner) cotyledons after roasting at a temperature of 160°C (16 min) were investigated with light and scanning electron microscopy. Major changes included: (1) pitting and pock -marking of the epidermis of the cotyledons caused by the escape of steam and on released during roasting; (2) loss of cellular organization of the cytoplasmic network surrounding the Jipid bodies, protein bodies, and starch grains ; (3) alteration of the structures of cytoplasmic network. lipid bodies, and protein bodies; and (4) heat destruction of some middle lamellae of cell - t o-cell junctions.

Microscopic Measurement Of Apple Bruise, N. K. Kim, Y. C. Hung

Food Structure

Microstructural differences between unbruised and bruised apple tissues were evaluated. Cell connections appeared to be looser in bruised tissue than in unbruised tissue. Bruised tissue exhibited more empty regions which are not occupied by cells than unbruised tissue. Empty reg ions in unbruised and bruised tissues were about 0.7 and 2.4 per mm2, respectively, comprising 0.7% and 2.7% of the respective total volume. Stereology is a body of mathematical methods relating three-dimensional parameters defining a structure to two- dimensional measurements. Two methods based on a stereological principle were also used to quantify the fraction of total volume occupied by cells. …

Scanning Electron Microscopy: Tissue Characteristics And Starch Granule Variations Of Potatoes After Microwave And Conductive Heating, J. Huang, W. M. Hess, D. J. Weber, A. E. Purcell, C. S. Huber

Food Structure

In order to determine cytological effects of microwave heating compared to conductive heating, whole potatoes were heated in a microwave oven in plastic bags for 0.5, 1 and 2 minutes and in boiling water for 5. 10 and 20 minutes. Both heating treatments caused swelling and partial disruption of starch granules. However, as observed with scanning electron microscopy, swelling patterns of starch granules were different in potatoes using the two heating processes. In conductive heating potatoes were heated from the outside to the inside. Microwave heated potatoes were heated fairly uniformly in different regions of tubers. The weight loss of …

Changes In The Rheology And Microstructure Of Ropy Yogurt During Shearing, J. A. Teggatz, H. A. Morris

Food Structure

Rheological and microstructural changes that occurred in ropy yogurt during shearing were observed. Yogurt made with an exopolymer-producing (ropy) strain of Lactobacillus delbrueckii subsp. bulgaricus and non-ropy strain of Streptococcus thermophilus was subjected to an increasing shear rate from 0-833 s-1 using a Haake Rotovisco RV2. Shear stress niticeably increased to a peak value and then decreased to a plateau value as the shear rate continued to increase. Samples taken at eight different shear rates were examined by scanning electron microscopy (SEM). At low shear rates, the exopolysaccharide (EPS) existed as a filamentous network attached to the lactobacilli and casein …

A Method For The Examination Of The Microstructure Of Stabilized Peanut Butter, Clyde T. Young, William E. Schadel

Food Structure

A method for light and scanning electron microscopy of damaged resting peanut seed tissue was adapted as a research tool for evaluating the microstructural features of commercially available stabilized peanut butter. This method was used in the present study to evaluate the degree of homogenization of stabilized peanut butter by examining the spatial relationship which exists among the microstructural features. Light and scanning electron microscopy of three commercially available stabilized peanut butters revealed varying degrees of homogenization of broken cell and tissue fragments, protein bodies, and starch grains within a matrix of stabilized oil.

Transmission And Scanning Electron Microscopy Of Peanut (Arachis Hypogaea L. Cv. Florigiant) Cotyledon After Roasting, Clyde T. Young, William E. Schadel

Food Structure

Changes in the microstructure of peanut (Arachis~ L. cv. Florigiant) cotyledon after roasting at a temperature of 160°C for 16 minutes were investigated with transmission and scanning electron microscopy. Thermal modifications were documented with photomicrographs of t he cytoplasmic network , protein bodies, starch grains and cell-to-cell junctions after oven roasting. These thermal modifications include disruption of the cytoplasmic network, distension of protein bodies, decreased stain affinity of starch grains , and disintegration of middle lamellae in some cell-t o-cell junctions.

Applications Of Microscopy In The Paper Industry: Case Histories Of The Mead Corporation, A. J. Leonardi, B. A. Blakistone, S. W. Kyryk

Food Structure

Microscopial application in the Mead Corporation are herein discussed: 1) defining proper starch cook for maintaining paper quality, 2) microbial degradation of paperboard used for beverage cartons, and 3) examination of high oxygen barrier plastic cups for hermetic seal and barrier construction. Visualization of the cooked starch by iodine staining and polarized light (PL) microscopy is a quick diagnostic aid to Mead mills. Scanning electron microscopy (SEM) and particularly PL proved useful in examining fiber biodegration by fungi on Coated Natural Kraft beverage cartons. Nomarski differential interference contrast (DIC), PL, and SEM aided in qualifying lid materials for Mead's Crosscheck …