Environmental Engineering Commons^™

Impact Of The Municipal Solid Waste Incineration Plant In Warsaw On Air Quality, Robert Oleniacz

Robert Oleniacz

The only Polish municipal solid waste (MSW) incinerator has been operating within the Municipal Solid Waste Disposal Plant in Warsaw since 2000. In the paper selected results of the air quality impact assessment for this incinerator during an operating period of one year (2008) are presented. With respect to the incinerated waste amounts and emission levels, the analysed period can be considered typical for this facility. Assessment of the air quality impact was carried out by assessing air pollutant emissions in reference to the applicable emission limit values and by modeling atmospheric dispersion of these pollutants. It has been found …

Assessment Of The Impact Of Municipal Waste Incineration Plants On Air Quality And The Possibilities Of Its Reduction, Robert Oleniacz

Robert Oleniacz

The planned construction of new municipal waste incineration plants over the next few years in Poland results in protests of local communities, which arise mainly from fear of an increase in the air pollution in its vicinity. These protests extend the investment process and hinder the selection of incineration plant location, but on the other hand they necessitate the use of more efficient solutions to reduce their impact on the air quality.This paper characterizes the world's most widely used technology for municipal solid waste incineration (MSWI) and assesses the possible maximum impact on the air quality of an exemplary MSWI …

Co-Incineration Of Large Quantities Of Alternative Fuels In A Cement Kiln – The Problem Of Air Pollutant Emissions, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

Over the last few years, a significant increase in the use of alternative fuels in the Polish cement industry has been observed. These are mainly waste and waste-derived fuels. The national leader in this field is Chełm cement plant (Poland), with the share of alternative fuels in the cement kiln heat balance reaching in 2012 the level of 78.5%. In this paper, an analysis of the emission rate of air pollutants from cement clinkering process in the above-mentioned cement plant in the years 1998–2012 was carried out, using the results of continuous and periodic measurements. The compliance with the emission …

Współspalanie Odpadów W Suchym Piecu Cementowym A Emisja Dwutlenku Siarki I Chlorowodoru, Robert Oleniacz

Robert Oleniacz

The paper presents an assessment of the impact of waste co-combustion in a cement kiln on air emissions of HCl and SO2 recorded continuously. The subject of the research was cement kiln (dry method) with a capacity of 8500 Mg/day, equipped with a four cyclone heat exchangers and a calciner with an additional chamber for co-incineration. In the analysed period alternative fuels (mainly waste) were used in various amounts ranging up to about 35 kg / Mg clinker (with the heat substitution up to 20%) in the kiln and calciner. Chlorine and sulfur inputs to the process were up to …

Impact Of A Large Medical Waste Incinerator On Air Quality, Robert Oleniacz

Robert Oleniacz

In the paper, an assessment of the compliance with air emission limit values and the impact on air quality of one of the largest medical waste incinerators in Poland, with a total capacity of about 300 kg/h (two incineration lines) is presented. The assessment took the results of continuous and periodic measurements of emissions in the plant’s installation over a period of 12 months’ operation into account. For this period, a calculation was performed for the spread of air pollutants emitted by the two operating incineration lines. According to the analysis and calculations, the analysed medical waste incineration plant does …

Ocena Wpływu Planowanego Zakładu Termicznego Przekształcania Odpadów Komunalnych Na Jakość Powietrza W Krakowie, Robert Oleniacz, Maria Pilch

Robert Oleniacz

Construction of the Municipal Solid Waste Incineration (MSWI) plant is considered optimal in the Programme of Management of Solid Waste in Krakow as well as in proposed scenarios of Municipal Waste Management. Evaluation of impact of the incineration plant with a capacity of 255000 tons per year on air quality in Krakow is presented in this work. The evaluation is based on assumption that air pollutant emissions from the incinerator will be at the highest allowed level resulting from emission limit values for waste incineration plants with operation time each of two planned lines 7500 hours per year. Calculation results …

Analiza Wpływu Planowanego Zakładu Termicznego Przekształcania Odpadów Komunalnych Na Jakość Powietrza W Krakowie, Robert Oleniacz, Maria Pilch

Robert Oleniacz

Construction of the Municipal Solid Waste Incineration (MSWI) plant is considered optimal in the Programme of Management of Solid Waste in Krakow as well as in proposed scenarios of Municipal Waste Management. Evaluation of impact of the incineration plant with a capacity of 255000 tons per year on air quality in Krakow is presented in this work. The evaluation is based on assumption that air pollutant emissions from the incinerator will be at the highest allowed level resulting from emission limit values for waste incineration plants with operation time each of two planned lines 7500 hours per year. Calculation results …

Czynniki Wpływające Na Skład Spalin I Wielkość Emisji Zanieczyszczeń Z Procesów Termicznego Przekształcania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The work summarizes factors influencing on air emissions from various full-scale hazardous waste incinerators (rotary kiln, multiple hearth furnace, starved-air incinerator, fluidized bed incinerator, liquid injection incinerator). Air pollutant emissions from hazardous waste incineration can be minimized not only by flue-gas cleaning. There are many factors that influence on flue-gas composition and the quantity of air pollutants formed during incineration: the type, the composition and the quantity of waste, the way of waste introducing to the incinerator, excess air ratio, combustion temperature, retention time of exhaust gases etc. Special attention was paid to the loading of waste and incineration conditions …

Pirolityczne Metody Utylizacji Odpadów Niebezpiecznych - Przykładowe Rozwiązania I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

The paper presents the pyrolysis and gasification processes of organic matter and the main directions of their use for the thermal disposal of hazardous waste. Used for this purpose the basic technical solutions are discussed with regard to existing and new technologies. Given the fact that the pyrolytic methods in Poland were primarily used for the incineration of medical waste, most attention was paid to a facility designated for such waste disposal. The problem of air pollutant emissions from this type of installation and some operating guidelines was also presented on the basis of the literature analyses and own research. …

Spalanie Odpadów Niebezpiecznych W Piecach Cementowych. Część 2. Destrukcja Paliwa I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

Conditions occurring in cement rotary kilns assure high destruction and removal efficiency (DRE) of the most stable substances, efficacious dry sorption of acid gases in the alkaline raw meal and heavy metals bounding in the clinker. Adequate operation of hazardous waste incineration in the process connected with cement clinker production does not cause increasing air pollutant emissions. Magnitude of the emissions often does not depend of this if there are using wastes in the cement kiln at all. The work presents a review of DRE levels and stack emissions for selected flue-gas constituents during hazardous waste co-combustion in cement kilns …

Piece Cementowe - Konkurencja Dla Spalarni Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents the advantages of cement kilns and the possibility of their use for thermal waste utilization. The most common types of waste incinerated in these kilns and the possible degree of replacing traditional fuels with waste fuels have also been characterized. The work also discusses the problem of air pollutant emissions from the process of waste co-incineration in cement kilns. Attention has been paid to the possible increase in the use of Polish cement industry in the waste management, system, especially in the field of energy recovery from solid municipal waste, waste tires and waste from the refinery …

Emisja Zanieczyszczeń Podczas Składowania I Termicznej Utylizacji Osadów Ściekowych Z Przemysłu Koksochemicznego / Emissions During Storage And Thermal Utilization Of Sewage Sludge From Coke-Chemical Industry, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

Both storage and thermal disposal of sewage sludge from industrial wastewater treatment plants are a significant source of air pollutant emissions. The study included the sludge generated in the coke-chemical industry. The paper presents the results of measurements of emissions of selected substances during storage of the waste in a closed storage hall with natural ventilation and during incineration of the mechanically dewatered sludge in a multiple hearth furnace.

Spalarnia Odpadów Lobbe W Dąbrowie Górniczej, Marian Mazur, Robert Oleniacz, Ryszard Januszek

Robert Oleniacz

This paper is a general characteristic of the industrial and hazardous waste incineration plant which was operated in Dąbrowa Górnicza (Poland) in the 90. The waste incineration plant is based on two incinerators - a rotary kiln and a multiple hearth furnace. Levels of selected air pollutant emissions presented in the work allow to assess the potential impact of this facility on air quality.

English title: The LOBBE incineration plant in Dąbrowa Górnicza.