Engineering Commons^™

Development And Performance Assessment Of An Integrated Vermifiltration Based Treatment System For The Treatment Of Feedlot Runoff, Rajneesh Singh, Matteo D'Alessio, Yulie Meneses, Shannon L. Bartelt-Hunt, Brian Woodbury, Chittaranjan Ray

Nebraska Water Center: Faculty Publications

The objective of this study was to treat feedlot runoff by developing an ecologically sustainable, affordable, and resilient treatment system having a relatively long life span. Three horizontal flow soil biofilters were utilized in this study: 1) without earthworms and plants (Biofilter (BF)), 2) with earthworms only (Vermifilter (VF)), and 3) with earthworms and plants (Macrophyte Assisted Vermifilter (MAVF)). The experiments were conducted with a hydraulic retention time of four days using Lumbricus terestrris earthworms and Carex frankii wetland plants. The average COD removal from the BF, VF, and MAVF were 23.2–30.4%, 61.4–69.1%, and 68.3–78.1%, respectively. Average TN removal efficiencies …

Retention Of Swine Slurry Constituents In Soil And Crop Residue As Affected By Setback Distance, John E. Gilley, Shannon L. Bartelt-Hunt, Kent M. Eskridge, Xu Li, Amy M. Schmidt, Daniel D. Snow

Department of Biological Systems Engineering: Papers and Publications

Setbacks are prescribed distances from surface waters within which manure application is not allowed. Little information is available concerning the retention of swine slurry constituents in soil and crop residue materials within setback areas. This study was conducted to measure the retention of selected constituents within a setback area following the upslope application of swine slurry and the introduction of simulated rainfall. The no-till cropland site had a slope gradient of 4.9% and a mean winter wheat residue cover of 7.73 Mg ha−1 . Soil and vegetative samples were collected on 3.7 m wide by 23.2 m long plots with …

Swine Slurry Characteristics As Affected By Selected Additives And Disinfectants, Jon Duerschner, Shannon L. Bartelt-Hunt, Kent Eskridge, John E. Gilley, Xu Li, Amy M. Schmidt, Daniel D. Snow

Nebraska Water Center: Faculty Publications

Current swine industry practice is to house animals in confinement facilities which capture and store feces and urine as slurry in pits below the production area. Additives and disinfectants may be introduced into the manure pits. This study was conducted to measure the effects of additives and disinfectants on temporal changes in swine slurry characteristics. Slurry from a commercial swine production facility in southeast Nebraska, USA was collected and transferred to 57 L reactors located within a greenhouse. Selected additives and disinfectants were added to the reactors and physical properties, chemical characteristics, and antibiotic concentrations were monitored for 40 days. …

Swine Slurry Characteristics As Affected By Selected Additives And Disinfectants, Jon Duerschner, Shannon L. Bartelt-Hunt, Kent Eskridge, John E. Gilley, Xu Li, Amy M. Schmidt, Daniel D. Snow

Department of Biological Systems Engineering: Papers and Publications

Current swine industry practice is to house animals in confinement facilities which capture and store feces and urine as slurry in pits below the production area. Additives and disinfectants may be introduced into the manure pits. This study was conducted to measure the effects of additives and disinfectants on temporal changes in swine slurry characteristics. Slurry from a commercial swine production facility in southeast Nebraska, USA was collected and transferred to 57 L reactors located within a greenhouse. Selected additives and disinfectants were added to the reactors and physical properties, chemical characteristics, and antibiotic concentrations were monitored for 40 days. …

Influence Of Setback Distance On Antibiotics And Antibiotic Resistance Genes In Runoff And Soil Following The Land Application Of Swine Manure Slurry, Maria C. Hall, Noelle Mware, John E. Gilley, Shannon L. Bartelt-Hunt, Daniel D. Snow, Amy M. Schmidt Schmidt, Kent M. Eskridge, Xu Li

Department of Biological Systems Engineering: Papers and Publications

The environmental spread of antibiotics and antibiotic resistance genes (ARGs) from the land application of livestock wastes can be a potential public health threat. The objective of this study was to assess the effects of setback distance, which determines how close manure may be applied in relation to surface water, on the transport of antibiotics and ARGs in runoff and soil following land application of swine manure slurry. Rainfall simulation tests were conducted on field plots covered with wheat residues, each of which contained an upslope manure region where slurry was applied and an adjacent downslope setback region that did …

Effect Of Swine Manure Pit Additives And Facility Disinfectants On The Fate Of Antibiotics And Manure Composition During Simulated Swine Manure Slurry Storage, Jon Duerschner

Department of Civil and Environmental Engineering: Dissertations, Theses, and Student Research

This thesis investigates the effect of time and of swine manure slurry treatment on the physical properties, nutrient content, and the concentrations of antibiotics chlortetracycline, lincomycin, and tiamulin in simulated storage of swine manure. In one experiment the slurry was treated with six additive products. In a second experiment a set of four disinfectant products were used. Control consisted of unamended slurry. Manure was stored in 60 liter stainless steel bioreactors to simulate deep pit storage and was sampled 7 times over a 40 day incubation.

From an ANOVA of the results, it was concluded that evaporation may be contributing …

Setback Distance Requirements For Removal Of Swine Slurry Constituents In Runoff, John E. Gilley, Shannon L. Bartelt-Hunt, Kent M. Eskridge, Xu Li, Amy M. Schmidt, Daniel D. Snow

Department of Biological Systems Engineering: Papers and Publications

The use of setback distances for manure application on cropland areas adjacent to surface water bodies could serve a function similar to vegetative filter strips. However, little information currently exists to identify the setback distances necessary to effectively reduce the transport of contaminants in runoff. The objective of this study was to determine the effects of setback distance and runoff rate on concentrations of selected constituents in runoff following land application of swine slurry to a no-till cropland area in southeast Nebraska. The study site had a residue cover of 7.73 Mg ha-1 and a slope gradient of 4.9%. The …

Influence Of The Method And Timing Of The Land Application Of Manure On The Fate And Transport Of Manure Constituents In Soil, Xu Li

Department of Civil and Environmental Engineering: Faculty Publications

Swine manure has been used as a soil amendment for crop production because it can provide nutrients, increase soil productivity, improve water infiltration, and reduce the potential for soil erosion. It is important to understand how different land application strategies may affect the fate and transport of various manure constituents in the environment. The objective of this project was to determine how the method and timing of swine manure application may impact the levels of multiple manure constituents in soil. The manure constituents included nutrients, antimicrobials, and antimicrobial resistance genes (AMR genes).

A series of plot-scale field experiments were performed. …

Runoff Water Quality Characteristics Following Swine Slurry Application Under Broadcast And Injected Conditions, Nicole R. Schuster, Shannon L. Bartelt-Hunt, Lisa M. Durso, John E. Gilley, Xu Li, David B. Marx, Amy M. Schmidt, Daniel D. Snow

Department of Biological Systems Engineering: Papers and Publications

This study was conducted to measure the effects of swine slurry application method, time following slurry application, and runoff rate on selected water quality characteristics. Slurry from a commercial swine operation was broadcast or injected on field plots at a rate required to meet annual nitrogen requirements for corn. Rainfall simulation tests were conducted at five varying periods following slurry application. During each study period, three simulated rainfall events, separated by 24 h intervals, were applied for 30 min duration at an intensity of approximately 70 mm h^-1. Following the third rainfall simulation event, inflow was applied at …

Removal Of Cattle Manure Constituents In Runoff From No-Till Cropland As Affected By Setback Distance, John E. Gilley, Aaron J. Sindelar, Bryan L. Woodbury

Department of Biological Systems Engineering: Papers and Publications

Vegetative filter strips located at the bottom of a hillslope have been shown to substantially reduce nutrients and sediment in runoff. Cropland areas could serve a similar function. However, little scientifically derived information is available to help identify the setback distances required to effectively reduce the transport of contaminants in runoff. The objective of this study was to determine the effects of setback distance and runoff rate on the concentrations and mass transport rates of selected constituents following land application of beef cattle manure to a no-till cropland area. The study site had a residue cover of 8.84 Mg ha …

Removal Of Cattle Manure Constituents In Runoff From No-Till Cropland As Affected By Setback Distance, John E. Gilley, Aaron J. Sindelar, Brian L. Woodbury

Department of Biological Systems Engineering: Papers and Publications

Vegetative filter strips located at the bottom of a hillslope have been shown to substantially reduce nutrients and sediment in runoff. Cropland areas could serve a similar function. However, little scientifically derived information is available to help identify the setback distances required to effectively reduce the transport of contaminants in runoff. The objective of this study was to determine the effects of setback distance and runoff rate on the concentrations and mass transport rates of selected constituents following land application of beef cattle manure to a no-till cropland area. The study site had a residue cover of 8.84 Mg ha-1 …

The Effect Of Manure Application Method On Nutrient And Microbial Runoff Transport And Soil Biological Health Indicators, Nicole R. Schuster

Department of Biological Systems Engineering: Dissertations and Theses

Two projects were completed to provide significant new information to the agricultural industry regarding the environmental implications and soil health impacts related to land application of swine manure. The first study reports on the runoff transport of nutrients and microbials as affected by manure application method and time following application. The second study provides information about the effect of application method and time following application on soil health indicators using arthropod abundance and diversity as a biological indicator. The information gained through these studies will provide beneficial information to the pork industry on the impact of manure application method and …

Narrow Grass Hedge Effects On Nutrient Transport Following Swine Slurry Application, John E. Gilley, Shannon L. Bartelt-Hunt, Seth J. Lamb, Xu Li, David B. Marx, Daniel D. Snow, David B. Parker, Brian L. Woodbury

Department of Biological Systems Engineering: Papers and Publications

The effectiveness of a narrow grass hedge in reducing runoff nutrient loads following swine slurry application was examined. Slurry was applied to 0.75 m wide by 4.0 m long plots established on an Aksarben silty clay loam soil located in southeast Nebraska. Manure treatments consisted of no manure application and manure application to meet the 1, 2, or 3 year nitrogen (N) requirements for corn. Runoff water quality was measured during three 30 min simulated rainfall events. The grass hedge did not significantly reduce runoff nutrient transport after the swine slurry, which contained relatively small amounts of manure, was applied. …

Runoff Nutrient Transport As Affected By Land Application Method, Swine Growth Stage, And Runoff Rate, J. E. Gilley, Shannon L. Bartelt-Hunt, S. J. Lamb, X. Li, D. B. Marx, D. D. Snow, D. B. Parker, B. L. Woodbury

Department of Biological Systems Engineering: Papers and Publications

This study was conducted to measure the effects of slurry application method, swine growth stage, and flow rate on runoff nutrient transport. Swine slurry was obtained from production units containing grower pigs, finisher pigs, or sows and gilts. The swine slurry was applied using broadcast, disk, or injection methods at a rate required to meet annual nitrogen requirements for corn. Three 30 min simulated rainfall events, separated by 24 h intervals, were applied to the experimental plots at an intensity of 70 mm h^-1. Inflow was applied at the top of each plot in four successive increments after …

Wheat Strip Effects On Nutrient Loads Following Variable Manure Applications, Chance Thayer, John E. Gilley, Lisa M. Durso, David B. Marx

Department of Biological Systems Engineering: Papers and Publications

Vegetative filters have been found to significantly reduce nutrient loads in runoff. This study was conducted to: (1) evaluate the effects of a narrow wheat strip, varying manure application rates, and different overland flow rates on runoff nutrient loads following application of beef cattle manure; (2) determine the upper capacity of a narrow wheat strip to reduce nutrient loads by applying excessive amounts of manure; and (3) compare the effectiveness of narrow wheat strips and grass hedges in reducing runoff nutrient loads. A 1.4 m wide strip of actively growing winter wheat was located at the bottom of selected 0.75 …

Runoff Nutrient Loads As Affected By Residue Cover, Manure Application Rate, And Flow Rate, Chance Thayer, John E. Gilley, Lisa M. Durso, David B. Marx

Department of Biological Systems Engineering: Papers and Publications

Manure is applied to cropland areas with varying surface cover to meet single‐year or multiple‐year crop nutrient requirements. The objectives of this field study were to: (1) examine runoff water quality characteristics following land application of manure to sites with and without wheat residue, (2) compare the water quality impacts of land application of manure to meet 0‐, 1‐, 2‐, 4‐, and 8‐year P‐based requirements for corn, and (3) evaluate the effects of varying runoff rates on runoff nutrient loads. Three 30‐min simulated rainfall events, separated by 24 h intervals, were applied at an intensity of 70 mm h^{‐1 …}

Narrow Grass Hedge Control Of Nutrient Loads Following Variable Manure Applications, John E. Gilley, Lisa M. Durso, Roger Eigenberg, David B. Marx, Brian L. Woodbury

Department of Biological Systems Engineering: Papers and Publications

The effectiveness of a narrow grass hedge in reducing runoff nutrient loads following manure application was examined in this study. Beef cattle manure was applied to 0.75 m wide by 4.0 m long plots established on an Aksarben silty clay loam located in southeast Nebraska. Manure was added at rates required to meet none or the 1, 2, or 4 year nitrogen requirements for corn. Runoff water quality was measured during three 30 min simulated rainfall events. Manure application rate significantly affected dissolved phosphorus (DP) and total phosphorus (TP) loads in runoff on the plots without a grass hedge. However, …

Software Tool For Integrating Feed Management Into Nutrient Planning, Richard K. Koelsch, Ray Massey, Galen E. Erickson, Virgil R. Bremer

Department of Biological Systems Engineering: Conference Presentations and White Papers

The introduction of ASABE Standard D384.2, Manure Production and Characteristics, has created the opportunity to integrate feed management decisions and animal performance measures into nutrient planning processes. This paper introduces a software tool that integrates estimates of nutrient excretion based on the new standard with estimates of land need, labor and equipment time allocation, and economic cost and benefit for manure application. This tool will be used to evaluate the economic implications for two scenarios using beef cattle examples as a means of illustrating tool application. The first scenario will look at the impact of feeding ethanol co-products on the …

Leaching And Sorption Of Nitrogen And Phosphorus By Crop Residue, J. D. Cermak, John E. Gilley, Bahman Eghball, B. J. Weinhold

Department of Biological Systems Engineering: Papers and Publications

Overland flow from cropland areas often contains nutrients and residue materials can either contribute to runoff nutrient load through leaching or remove nutrients by sorption. Measurements were made of leaching and sorption of nitrogen and phosphorus from corn (Zea mays L.), soybean (Glycine max (L.) Merr.) and winter wheat (Triticum aestivum L. cv. Pastiche) residues placed in solutions containing inorganic nutrients. Variables used were type of residue material, nutrient constituent, solution concentration, and residue / solution contact time. For a given residue material and nutrient constituent, four different solution concentrations were used (PO₄ -P: 0 to …

Vegetative Filter Treatment Of Livestock Feedlot Runoff, Elbert C. Dickey, D. H. Vanderholm

Department of Biological Systems Engineering: Papers and Publications

Four vegetative filters were installed on feedlots in central and northern Illinois. Two configurations were used: channelized Dow and overland Dow. After settling for partial solids removal, runoff was applied directly to the filters and allowed to Dow from the inlet to the outlet section. Results from measurement analyses and sampling of influent, effluent, and surface Dow at intermediate points were reported.

Most runoff events were infiltrated completely, resulting in no filter discharge. Runoff from larger events was partially discharged. Filters removed as much as 95% of nutrients and oxygen-demanding materials from the applied runoff on a weight basis, and …