Engineering Commons^™

Reduction Of Amine Emissions From An Aqueous Amine Carbon Dioxide Capture System Using Charged Colloidal Gas Aphrons, Xiaobing Li, Jesse G. Thompson, Kunlei Liu

Center for Applied Energy Research Faculty Patents

The present invention includes a system and process to reduce amine mist emissions (or MEA) from carbon capture systems using colloidal gas aphrons (CGA), and includes a method for separating and recovering an amine solvent (e.g., in the form of entrained droplets/mist and/or fine aerosol particles) from a carbon dioxide scrubbed flue gas stream exiting a carbon capture system (e.g., oil-fired power plants, coal-fired power plants, and/or natural gas combined cycle plants).

Fischer–Tropsch: Product Selectivity–The Fingerprint Of Synthetic Fuels, Wilson D. Shafer, Muthu Kumaran Gnanamani, Uschi M. Graham, Jia Yang, Cornelius M. Masuku, Gary Jacobs, Burtron H. Davis

Center for Applied Energy Research Faculty and Staff Publications

The bulk of the products that were synthesized from Fischer–Tropsch synthesis (FTS) is a wide range (C₁–C₇₀₊) of hydrocarbons, primarily straight-chained paraffins. Additional hydrocarbon products, which can also be a majority, are linear olefins, specifically: 1-olefin, trans-2-olefin, and cis-2-olefin. Minor hydrocarbon products can include isomerized hydrocarbons, predominantly methyl-branched paraffin, cyclic hydrocarbons mainly derived from high-temperature FTS and internal olefins. Combined, these products provide 80–95% of the total products (excluding CO₂) generated from syngas. A vast number of different oxygenated species, such as aldehydes, ketones, acids, and alcohols, are also embedded in this product range. …

Method Of Increasing Mass Transfer Rate Of Acid Gas Scrubbing Solvents, Joseph E. Remias, Cameron A. Lippert, Kunlei Liu

Center for Applied Energy Research Faculty Patents

A method of increasing the overall mass transfer rate of acid gas scrubbing solids is disclosed. Various catalyst compounds for that purpose are also disclosed.

Effect Of Pt Promotion On The Ni-Catalyzed Deoxygenation Of Tristearin To Fuel-Like Hydrocarbons, Ryan Loe, Kelsey Huff, Morgan Walli, Tonya Morgan, Dali Qian, Robert Pace, Yang Song, Mark Isaacs, Eduardo Santillan-Jimenez, Mark Crocker

Center for Applied Energy Research Faculty and Staff Publications

Pt represents an effective promoter of supported Ni catalysts in the transformation of tristearin to green diesel via decarbonylation/decarboxylation (deCO_x), conversion increasing from 2% over 20% Ni/Al₂O₃ to 100% over 20% Ni-0.5% Pt/Al₂O₃ at 260 °C. Catalyst characterization reveals that the superior activity of Ni-Pt relative to Ni-only catalysts is not a result of Ni particle size effects or surface area differences, but rather stems from several other phenomena, including the improved reducibility of NiO when Pt is present. Indeed, the addition of a small amount of Pt to the supported Ni …

Continuous Catalytic Deoxygenation Of Waste Free Fatty Acid-Based Feeds To Fuel-Like Hydrocarbons Over A Supported Ni-Cu Catalyst, Ryan Loe, Yasmeen Lavoignat, Miranda Maier, Mohanad Abdallah, Tonya Morgan, Dali Qian, Robert Pace, Eduardo Santillan-Jimenez, Mark Crocker

Center for Applied Energy Research Faculty and Staff Publications

While commercial hydrodeoxygenation (HDO) processes convert fats, oils, and grease (FOG) to fuel-like hydrocarbons, alternative processes based on decarboxylation/decarbonylation (deCO_x) continue to attract interest. In this contribution, the activity of 20% Ni-5% Cu/Al₂O₃ in the deCO_x of waste free fatty acid (FFA)-based feeds—including brown grease (BG) and an FFA feed obtained by steam stripping a biodiesel feedstock—was investigated, along with the structure-activity relationships responsible for Ni promotion by Cu and the structural evolution of catalysts during use and regeneration. In eight-hour experiments, near quantitative conversion of the aforementioned feeds to diesel-like hydrocarbons was achieved. …

Fractionation And Characterization Of Lignin Streams From Unique High-Lignin Content Endocarp Feedstocks, Wenqi Li, Kirtley Amos, Mi Li, Yunqiao Pu, Seth Debolt, Arthur J. Ragauskas, Jian Shi

Biosystems and Agricultural Engineering Faculty Publications

Background: Lignin is a promising source of building blocks for upgrading to valuable aromatic chemicals and materials. Endocarp biomass represents a non-edible crop residue in an existing agricultural setting which cannot be used as animal feed nor soil amendment. With significantly higher lignin content and bulk energy density, endo-carps have significant advantages to be converted into both biofuel and bioproducts as compared to other biomass resources. Deep eutectic solvent (DES) is highly effective in fractionating lignin from a variety of biomass feedstocks with high yield and purity while at lower cost comparing to certain ionic liquids.

Results: In the present …

Synergistic Interactions Of H2 And N2 With Molten Gallium In The Presence Of Plasma, Maria L. Carreon, Daniel F. Jaramillo-Cabanzo, Indira Chaudhuri, Madhu Menon, Mahendra K. Sunkara

Physics and Astronomy Faculty Publications

The present study examines the interaction of hydrogen and nitrogen plasmas with gallium in an effort to gain insights into the mechanisms behind the synergetic effect of plasma and a catalytic metal. Absorption/desorption experiments were performed, accompanied by theoretical-computational calculations. Experiments were carried out in a plasma-enhanced, Ga-packed, batch reactor and entailed monitoring the change in pressure at different temperatures. The results indicated a rapid adsorption/dissolution of the gas into the molten metal when gallium was exposed to plasma, even at a low temperature of 100 °C. The experimental observations, when hydrogen was used, indicate that gallium acts as a …

Catalytic Oxidation And Depolymerization Of Lignin In Aqueous Ionic Liquid, Lalitendu Das, Siquan Xu, Jian Shi

Biosystems and Agricultural Engineering Faculty Publications

Lignin is an integral part of the plant cell wall, which provides rigidity to plants, also contributes to the recalcitrance of the lignocellulosic biomass to biochemical and biological deconstruction. Lignin is a promising renewable feedstock for aromatic chemicals; however, an efficient and economic lignin depolymerization method needs to be developed to enable the conversion. In this study, we investigated the depolymerization of alkaline lignin in aqueous 1-ethyl-3-methylimidazolium acetate [C₂C₁Im][OAc] under oxidizing conditions. Seven different transition metal catalysts were screened in presence of H₂O₂ as oxidizing agent in a batch reactor. CoCl₂ and …

Enhancements In Mass Transfer For Carbon Capture Solvents Part I: Homogeneous Catalyst, Leland R. Widger, Moushumi Sarma, Jonathan J. Bryant, David S. Mannel, Jesse G. Thompson, Cameron A. Lippert, Kunlei Liu

Center for Applied Energy Research Faculty and Staff Publications

The novel small molecule carbonic anhydrase (CA) mimic [Co^III(Salphen-COO⁻)Cl]HNEt₃ (1), was synthesized as an additive for increasing CO₂ absorption rates in amine-based post-combustion carbon capture processes (CCS), and its efficacy was verified. 1 was designed for use in a kinetically slow but thermally stable blended solvent, containing the primary amines 1-amino-2-propanol (A2P) and 2-amino-2-methyl-1-propanol (AMP). Together, the A2P/AMP solvent and 1 reduce the overall energy penalty associated with CO₂ capture from coal-derived flue gas, relative to the baseline solvent MEA. 1 is also effective at increasing absorption kinetics of kinetically fast solvents, such …

Solvent Degradation And Emissions From A 0.7mwe Pilot Co2 Capture System With Two-Stage Stripping, Jesse Thompson, Heather Nikolic, Megan Combs, Saloni Bhatnagar, Jonathan Pelgen, Keemia Abad, Kunlei Liu

Center for Applied Energy Research Faculty and Staff Publications

The UKy-CAER team successfully tested an advanced 0.7 MWe post-combustion CO₂ capture system on a coal-fired power plant using a heat integration process combined with two-stage stripping to enhance the CO₂ absorber performance. One of the unique feature of the UKy-CAER integrated process is a two-stage stripping unit for solvent regeneration. The secondary stripper is empowered by the heat rejection from a conventional steam-heated (primary) stripper. The secondary stripper outlet stream at the commercial scale can be used as boiler secondary combustion air, consequently enriching the flue gas with CO₂, resulting in less energy penalty required …

Fischer–Tropsch Synthesis: Effect Of Ammonia On Product Selectivities For A Pt Promoted Co/Alumina Catalyst, Venkat Ramana Rao Pendyala, Wilson D. Shafer, Gary Jacobs, Michela Martinelli, Dennis E. Sparks, Burtron H. Davis

Center for Applied Energy Research Faculty and Staff Publications

The effects of co-fed ammonia in synthesis gas on the activity and product selectivities of a typical cobalt catalyst (0.5% Pt–25% Co/Al₂O₃) were investigated during the Fischer–Tropsch synthesis using a continuously stirred tank reactor (CSTR). The product selectivities were compared at a similar CO conversion level for various concentrations (10–1000 ppmv) of ammonia, as well as clean (un-poisoned) conditions. The addition of 10–1000 ppmv ammonia (concentration of ammonia with respect to the syngas feed) significantly decreased activity; the percentage of deactivation was similar (∼40%) for the various concentrations of ammonia used. At similar CO conversions, the …

Evaluation Of Flocculation, Sedimentation, And Filtration For Dewatering Of Scenedesmus Algae, Nicholas A. Rhea, Jack Groppo, Czarena Crofcheck

Biosystems and Agricultural Engineering Faculty Publications

Algae can be used as a feedstock for agricultural fertilizers, livestock and poultry feeds, anaerobic digestion, and biofuel production. For each end product, the requirements for moisture content (or solids content) vary, such that a desirable water removal strategy needs to be adaptable to varying levels of water removal. Flocculation, sedimentation, and filtration were evaluated as possible strategies for thickening and dewatering of algae. The goal of this study was to validate that algae cells treated by such means could be processed by vacuum belt filters and to determine the conditions under which the solids content could be increased to …

Application Of Recycled Media And Algae-Based Anaerobic Digestate In Scenedesmus Cultivation, Xinyi E, Czarena Crofcheck, Mark Crocker

Biosystems and Agricultural Engineering Faculty Publications

To make large-algae cultivation systems sustainable, commercial fertilizer inputs should be minimized. One means of achieving this is to maximize the recycle of nutrients used in algae cultivation. In addition to recycling nutrient-containing water from algae harvesting and dewatering, after harvesting algal biomass can be used as a substrate for anaerobic digestion, which can then generate mineralized nutrients to be used for further cultivation. In this study, the effect of recycling media and using mineralized nutrients during Scenedesmus cultivation was investigated. The recycled media proved to be able to support cell growth with nutrient replenishment, and it could be recycled …

First Proof Of Concept Of Sustainable Metabolite Production From High Solids Fermentation Of Lignocellulosic Biomass Using A Bacterial Co-Culture And Cycling Flush System, Wanying Yao, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

To improve the lignocellulose conversion for ABE in high solids fermentation, this study explored the feasibility of cycling the process through the cellulolytic or/and solventogenic phases via intermittent flushing of the fermentation media. Five different flushing strategies (varying medium ingredients, inoculum supplement and cycling through phases) were investigated. Flushing regularly throughout the cellulolytic phase is necessary because re-incubation at 65 °C significantly improved glucose availability by at least 6-fold. The solvents accumulation was increased by 4-fold using corn stover (3-fold using miscanthus) over that produced by flushing only through the solventogenic phase. In addition, cycling process was simplified by re-incubating …

Co2 Recycling Using Microalgae For The Production Of Fuels, Michael H. Wilson, John Groppo, Andrew Placido, S. Graham, S. A. Morton Iii, Eduardo Santillan-Jimenez, Aubrey Shea, Mark Crocker, Czarena Crofcheck, Rodney Andrews

Center for Applied Energy Research Faculty and Staff Publications

CO₂ capture and recycle using microalgae was demonstrated at a coal-fired power plant (Duke Energy’s East Bend Station, Kentucky). Using an in-house designed closed loop, vertical tube photobioreactor, Scenedesmus acutus was cultured using flue gas as the CO₂ source. Algae productivity of 39 g/(m² day) in June–July was achieved at significant scale (18,000 L), while average daily productivity slightly in excess of 10 g/(m² day) was demonstrated in the month of December. A protocol for low-cost algae harvesting and dewatering was developed, and the conversion of algal lipids—extracted from the harvested biomass—to diesel-range hydrocarbons via catalytic …

Phanerochaete Chrysosporium Pretreatment Of Biomass To Enhance Solvent Production In Subsequent Bacterial Solid-Substrate Cultivation, Wanying Yao, Sue E. Nokes

Biosystems and Agricultural Engineering Faculty Publications

This study investigated pretreatment of corn stover using solid substrate cultivation (SSC) of Phanerochaete chrysosporium (P. chrysosporium) to improve subsequent accessibility to cellulose. Thereafter, Clostridium thermocellum (C. thermocellum) was directly inoculated onto the pretreated biomass to accomplish hydrolysis, followed by solventogenesis by introducing Clostridium beijerinckii (C. beijerinckii).

An enzyme suite containing laccase, lignin peroxidase and manganese peroxidase activity was detected during the cultivation of P. chrysosporium on corn stover within 288 h at an initial moisture content 𝓌_H2O = 80% (mass of water/total mass). Incubation factors, such as substrate moisture content and cultivation …

Influence Of Media Composition On The Growth Rate Of Chlorella Vulgaris And Scenedesmus Acutus Utilized For Co2 Mitigation, Czarena L. Crofcheck, Xinyi E, Aubrey Shea, Michael D. Montross, Mark Crocker, Rodney Andrews

Biosystems and Agricultural Engineering Faculty Publications

Atmospheric carbon dioxide levels have increased since the industrial revolution due to increasing combustion of fossil fuels. One possible CO₂ mitigation strategy is the use of microalgae for mitigation of CO₂. This paper focuses on the influence of media composition on the growth rate of two microalgae strains, Chlorella vulgaris and Scenedesmus actus. A KNO₃ based medium was found to work better for Chlorella, while a urea based equivalent worked better for Scenedesmus. The urea based media investigated here resulted in growth similar to that found with previously reported KNO₃ based media. …

Influence Of Flue Gas Components On The Growth Rate Of Chlorella Vulgaris And Scenedesmus Acutus, Czarena Crofcheck, Aubrey Shea, Michael D. Montross, Mark Crocker, Rodney Andrews

Biosystems and Agricultural Engineering Faculty Publications

Atmospheric carbon dioxide levels have increased since the industrial revolution due to the increase in combustion of fossil fuels. One possible alternative strategy is the use of microalgae for CO₂ capture and recycling. Major components in coal-derived flue gas that may accumulate and effect algae growth include both sulfur oxides and fly ash. However, in practical application, sulfur oxides will be converted quickly to the acid product (H₂SO₄) in the aerobic aqueous conditions of algae cultivation. In this article, the influence of elevated H₂SO₄ levels and the presence of coal-derived fly ash …

Economic Analysis Of Cellulase Production Methods For Bio-Ethanol, Jun Zhuang, Mary A. Marchant, Sue E. Nokes, Herbert J. Strobel

Biosystems and Agricultural Engineering Faculty Publications

The cost of cellulase enzymes has limited the feasibility of producing ethanol from fibrous biomass. Traditional submerged fermentation (SmF) was compared to an alternative method of producing cellulase, solid state cultivation (SSC). Results from an economic analysis indicated that the unit costs for cellulase enzyme production were $15.67 (The prices are all 2004 prices in this article, except otherwise stated. We deflated newer prices to 2004 prices using a deflation factor 0.9 per year and inflated older prices to 2004 prices using an inflation factor 1.1.) per kilogram ($/kg) and $40.36/kg, for the SSC and SmF methods, respectively, while the …

Use Of High-Energy Radiation For Degradation Of Environmental Pollutants, Robert D. Guthrie, Manjiri Patwardhan

KWRRI Research Reports

The purpose of this project was to explore the advantages and/or limitations of high-energy radiation treatment as a method for degrading organic pollutants, particularly aryl halides, in an aqueous medium. We have done analyses of ⁶⁰Co-irradiated samples and kinetic studies using pulsed electron beams. For aryl halides containing no more than two fused rings, the main products detected are those of simple halogen replacement by hydrogen, although the amount of aryl halide destroyed was always greater than the total amount of products detected. To accomplish halogen replacement by H, the reaction solvent may not be pure water but must …