Engineering Commons^™

The Effect Of Steam Explosion On Lipids Extraction From Microalgae And Derivation Of Pectin Films From Waste Culture, Shahil Chhiba

Electronic Thesis and Dissertation Repository

The objective of this study was to investigate the properties of sustainable replacements for plastics and diesel fuel, derived from microalgae (Chlorella vulgaris) subjected to steam explosion. During the process, oven temperatures of up to 500 °C were reached, with the experiments left for different times after reaching their maximum internal temperature. Lipids were extracted from algal cultures using a modified Folch method. The waste microalgae were combined with pectin and glycerol to form biodegradable films, and their solubilities and tensile strengths were measured. The highest yield was 124 mg lipids/g microalgae from 400 °C steam explosion for …

Rabrs For Use In Biologically Enhanced Precipitation Of Struvite In Anaerobic Digester Effluent (Municipal Wastewater), Parker R. Goldsberry

All Graduate Theses and Dissertations, Fall 2023 to Present

Rotating Algae Biofilm Reactor (RABR) technology has been researched in studies over the past decade directed at nutrient management for water resource recovery facilities (WRRFs). This study investigated the growth of slow-release fertilizer crystals, referred to as struvite, in the algae biofilms of Rotating Algae Biofilm Reactors (RABRs) at the Central Valley Water Reclamation Facility, the largest water resource recovery facility in the State of Utah. RABRs used anaerobic digester (AD) filtrate as their nutrient source. AD effluent is high in nutrients like nitrogen and phosphorus. The levels of both phosphorus and nitrogen (in the form of ammonia) are regulated …

Numerical Investigation Of Flow And Thermal Behavior In Channels With Pcm-Filled Thermal Energy Storage Columns For Potential Application In Photobioreactors, Sameed Akber

Electronic Thesis and Dissertation Repository

Microalgae has been identified as a potential source in the production of biofuel. Photobioreactors, which are used for microalgae production, normally experience temperature variations over the diurnal cycle due to changes in ambient conditions. The thermal regulation of photobioreactors to minimize temperature variations will result in a higher yield of microalgae, which are sensitive to such variations. The present research is aimed to investigate a novel approach to thermally regulate photobioreactors using phase change materials (PCM) where the latent heat of the material is exploited as the energy storage. The present research uses a numerical approach to study the flow …

The Use Of Microalgal Sourced Biodiesel To Help Underground Mines Transition To Battery Electric Vehicles, Corey A. Laamanen, Kyle Moreau, Sabrina M. Desjardins, Shannon H. Mclean, John A. Scott

Journal of Sustainable Mining

The use of fossil fuel sourced diesel underground has various associated health and environmental hazards, and additional energy demand and costs associated with necessary ventilation. One way to reduce these impacts is by utilizing a biodieselblend, which generates lower levels of harmful emissions from underground equipment and can be produced regionally, reducing the impact of transportation. Furthermore, this would help allow use of existing machinery during transition towards more widespread electrification underground. Therefore, the concept of an integrated supply and use chain within the mining industry is examined based on biodiesel from acidophilic photosynthetic microalgae cultivated using CO 2 in …

Assessment Of Scientific Payload Carrying Spirulina Onboard Blue Origin’S New Shepard Vehicle, Pedro J. Llanos, Morgan Shilling, Kristina Andrijauskaite, Kody Kidder, Vijay V. Duraisamy

Publications

The research team at ERAU and UTHSCSA analyzed the effects of suborbital flight stressors and various light conditions (red, white, no light) on the Arthrospira platensis (Spirulina), onboard Blue Origin’s New Shepard vehicle. Commercially available cyanobacterium species were cultivated and closely monitored in mother colonies several months before the suborbital flight mission. The aim of this study was to estimate the biomass production and growth as a potential dietary alternative for prospective human spaceflight's life support system. Spirulina samples were flown in a NanoLab with adjacent avionics supporting the light conditions and sensors to monitor the temperature, relative humidity, and …

Co2 Derived Carbon Capture Using Microalgae In A Photobiocrec Unit, Maureen D. Cordoba Perez

Electronic Thesis and Dissertation Repository

Microalgae has the potential to contribute to carbon dioxide capture, resulting in the production of alternative fuels and valuable chemical products. To accomplish this, high-efficiency photobioreactors must be conceptualized, designed, and established, in order to achieve high inorganic carbon conversion, superior light utilization, and unique fluid dynamics.

In this PhD Dissertation, experiments with Chlorella vulgaris were carried out, in a 0.175L especially designed PhotoBioCREC unit, under controlled radiation and high mixing conditions. This unique design involves 1 mm-2 mm alumina particles, which keep photoreactor walls always clean, without compromising photon transmittance. Sodium bicarbonate (NaHCO₃) was supplied as the …

Investigative Study Of Microalgal And Electrochemical Wastewater Treatment Systems And Modeling Of The Wafer-Enhanced Electrodeionization Using Supervised Learning, Humeyra Betul Ulusoy Erol

Graduate Theses and Dissertations

Wastewater has a serious impact on environment and public health due to its high concentration of nutrients and toxic contaminants. Without proper treatment, excess nutrients discharged in wastewater can cause a damage to the ecosystem such as undesirable pH shifts, cyanotoxin production, and low dissolved oxygen concentrations.

Main objectives of this dissertation work were to investigate i) the biofuel potential of P. cruentum when grown in swine wastewater, ii) the influence of four most commonly used ion exchange resins on the system efficiency and selectivity for the removal of sodium, calcium, and magnesium ions, and iii) the modeling of wafer-enhanced …

Value-Added Lipids Extraction From Wet Microalgae Using Ionic Liquids, Yujie Zhang

Electronic Thesis and Dissertation Repository

Microalgae have gained interest as sources of renewable lipids in the biofuel sector due to their ability to sequester carbon dioxide into triacylglycerol (TAG), a biodiesel feedstock. However, industrial-scale production of microalgae exclusively for fuel production is limited by technical and economic challenges. Some marine microalgae can accumulate large amounts of polyunsaturated fatty acids (PUFAs) such as docosahexaenoic acid (DHA) and other unsaturated fatty acids, which are high-value compounds linked to the prevention of various cardiovascular diseases. This thesis therefore examines the extraction of lipids and DHA from two microorganisms (Chlorella vulgaris, a model organism for lipid production, …

Growth Of Microalgae For Simultaneous Treatment Of Industrial Wastewater And Biodiesel Production, Mohammed Ahmad Abujayya

Chemical and Petroleum Engineering Theses

The treatment of industrial wastewater contaminated with phenols is among the main challenges in the chemical, and particularly the petrochemical industry. Phenols, which present in considerable amounts in industrial wastewater, are toxic even at low concentrations. Therefore, it is essential to reduce their concentrations in water to harmless levels before being discharged. On the other hand, the dependence on the conventional fossil sources of energy, which is non-renewable, is not sustainable and can cause harmful environmental impacts. Therefore, in this work, the dual utilization of microalgae as a cheap and efficient means to remove phenolic compounds commonly found in refinery …

Experimental Investigation Of Flow And Thermal Behavior In Channels With Pcm-Filled Thermal Energy Storage Columns For Potential Application In Photobioreactors, Kira Toxopeus

Electronic Thesis and Dissertation Repository

Microalgae has been identified as a potential source for the production of biofuels and other bio-products. The growth of microalgae is sensitive to the temperature variations inside the photobioreactor. The present research investigated an innovative approach to thermally regulate photobioreactors by introducing passive thermal energy storage using phase change material (PCM). The research was specifically focused on a novel design to integrate thermal storage in the reactor channel in the form of offset columns containing PCM. Two column shapes were considered: circular and square. The first part of the study was focused on characterizing the influence of offset column shapes …

Nitrate And Herbicides Removal From Groundwater Using Immobilized Algae, Sara Mollamohammada

Department of Civil and Environmental Engineering: Dissertations, Theses, and Student Research

To improve crop yield and control broadleaf weeds, many farmers apply nitrate-based fertilizers and chemical herbicides to their fields. Excessive use of these chemicals can cause contamination in waterbodies and impact on the public health. The physical and chemical methods have been suggested to remove these herbicides are usually costly. In this study, the capability of immobilized algal beads in removing nitrate and several herbicides of environmental concern from synthetic and actual groundwater and surface water was evaluated.

The experiments were performed in batch, sequencing batch and continuous flow modes and the effect of different operational conditions (light intensity, cultivation …

Integration Of Sodium Hypochlorite Pretreatment With Co-Immobilized Microalgae/Bacteria Treatment Of Meat Processing Wastewater, Xinjuan Hu, Yulie Meneses, Ashraf Aly Hassan

Department of Food Science and Technology: Faculty Publications

Wastewater with 0.2, 0.4, 0.8, 1.0 mg/L free chlorine was biologically treated using co-immobilized microalgae/ bacteria. In contrast, non-pretreated wastewater was treated with beads (control) and blank beads (blank) under the same operating condition. Results showed that NaClO pretreatment removed 8–33% total nitrogen (TN), 31–45% true color and 0.7–2.5 log CFU/mL aerobic-bacteria. At the end of treatment, maximum algal biomass (2,027 dry weight mg/L) was achieved with 0.2 mg/L free chlorine. Bacterial growth in wastewater was decreased by NaClO pretreatment before reaching 7.2–7.7 log CFU/mL on the fifth day. Beads with microorganisms (control) removed 15% more chemical-oxygen-demand (COD), 16% more …

Thermoresponsive Switchable Solvents For Enhanced, Simultaneous Microalgae Oil Extraction Reaction For Biodiesel Production, Mukhtar Ahmed Ismail

Mechanical Engineering Theses

In this study, a thermo-responsive switchable solvent (TSS), with a tunable hydrophobicity by simply changing the temperature (between 25 to 45oC) was used for simultaneous lipids extraction from wet microalgae and biodiesel production. By manipulating the hydrophobicity of the solvent, the cell wall disruption, lipid extraction and transesterification, and product separation steps were all carried out in a single pot, while eliminating the need for the energy intensive and time-consuming drying step. To overcome the problems currently encountered by using conventional alkaline catalysts in the transesterification of lipids, immobilized enzyme has been used. The proposed TSS consisted of an ionic …

Bioremediation Of Refinery Desalter Effluent Using Debaryomyces Hansenii And Parachlorella Kessleri, Leila Azimian

Electronic Thesis and Dissertation Repository

Crude oil desalting operations produce an effluent stream which is challenging to treat due to its salt, heavy metal and hydrocarbon content. Consequently, desalter effluent (DE) is usually diluted into other effluent streams and sent to conventional wastewater treatment plants which may lead to upsets the plant operation.

In this study, a novel microbial approach was applied which investigated DE treatment using halotolerant yeast Debaryomyces hansenii (LAF-3 10 U) or the environmentally robust micro-algae Parachlorella kessleri strain CPCC 266. The effect of these two different approaches on both synthetic and actual DE was investigated in both batch and/or continuous mode. …

Lipid Extraction From Spirulina Sp. And Schizochytrium Sp. Using Supercritical Co2 With Methanol, Shihong Liu, Husam A. Abu Hajar, Guy Riefler, Ben J. Stuart

Civil & Environmental Engineering Faculty Publications

Microalgae are one of the most promising feedstocks for biodiesel production due to their high lipid content and easy farming. However, the extraction of lipids from microalgae is energy intensive and costly and involves the use of toxic organic solvents. Compared with organic solvent extraction, supercritical CO₂ (SCCO₂) has demonstrated advantages through lower toxicity and no solvent-liquid separation. Due to the nonpolar nature of SCCO_2, polar organic solvents such as methanol may need to be added as a modifier in order to increase the extraction ability of SCCO₂. In this paper, pilot scale lipid …

Application Of A Floating Membrane Algal Photobioreactor For Freshwater Aquaculture, Hsiang-Yang Shyu

USF Tampa Graduate Theses and Dissertations

As the global population grows, water and food demand also increase. The intensive aquaculture industry has helped to mitigate these problems. In order to make aquaculture sustainable, it is necessary to remove the abundant nutrients produced by fish in the water. In this study, the role of the microalga of Chlorella vulgaris in the Isolated Cultivation of Algal Resources Utilizing Selectivity (ICARUS) membrane photobioreactor was evaluated for nutrient control in the aquaculture system. The production of algal biomass, the removal rate of nutrients, and the impact of microalgae on cultured organisms were monitored during the operation of aquaculture systems. At …

Extraction Of Astaxanthin From H. Pluvialis Using Deep Eutectic Solvents, Roya Barzegar

Electronic Thesis and Dissertation Repository

Haematococcus pluvialis (H. pluvialis) is one of the main sources of astaxanthin, a high value carotenoid and a strong antioxidant. Astaxanthin extraction is hindered by the thick cell wall of H. pluvialis which is composed of sporopollenin. Mechanical cell disruption methods, high cost and energy-consuming, are required to enhance astaxanthin extraction. This study employed a novel technology using deep eutectic solvents (DESs) to demonstrate the possibility of direct extraction of astaxanthin without a disruption step. It was established that 68% of astaxanthin can be extracted from intact H. pluvialis cells using choline chloride-glycerol (ChCl-G) mixture with 12.5% (v/v ) water …

Development And Optimization Of A Produced Water, Biofilm Based Microalgae Cultivation System For Biocrude Conversion With Hydrothermal Liquefaction, Benjamin L. Peterson

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Extraction of oil and gas in Utah’s Uintah Basin results in large quantities of wastewater, or produced water, with nutrients and residual organic chemical that represent a significant resource for producing energy-related and value-added products. Produced water was obtained as a biomass producing nutrient source from industries operating in Utah’s Uintah Basin. Within the Uintah Basin (defined as Uintah and Duchesne Counties within Utah) approximately 93 million barrels of water were produced in 2013 while only 11% of the water was disposed of through evaporation, with the national average at 2%. The rest is reinjected into the subsurface.

The goal …

Nutrient Removal In Microalgae Raceway Ponds And Nitrification Modeling, Esmeralda Diego

Master's Theses

This thesis explores the treatment of municipal wastewater using pilot-scale raceway ponds and looks specifically at the capability of the raceways in removing BOD and nitrogen. Nine 33 square-meter algal raceway ponds were used to conduct research at the San Luis Obispo Water Resources Recovery Facility. Main objectives of this study were to increase the removal of total ammonia nitrogen (NH₃-N plus NH₄⁺-N) from municipal wastewater through increased assimilation and nitrification. Raceway ponds with CO₂ addition were operated in series with an intermediate settling step and a total hydraulic retention time (HRT) of 4 …

Hydrothermal Liquefaction Of Microalgae For The Production Of Bio-Crude Oil, Yulin Hu

Electronic Thesis and Dissertation Repository

Due to the depletion of fossil fuels and climate change, extensive research has performed towards renewable energy production from microalgal biomass. Microalgae have several inherent benefits, such as high photosynthetic efficiencies, fast growth rates, and high lipid contents. In addition, microalgae can be cultivated in the non-arable lands (e.g., saline and waste water), thereby no competition with food crops production.

Transesterification is the one of commonly used technologies for converting microalgae into liquid bio-fuels (i.e., biodiesel). Normally, an energy-intensive drying step is required in the transesterification treatment, which accounts for nearly half of the energy input. Hence, if “wet” microalgal …

Algal Biofuel: The Future Of Green Jet Fuel In Air Transportation, Rajee Olaganathan

Publications

The aviation industry is one of the major contributors for the greenhouse gases. As air travel has become inevitable in this modern era, and fossil fuel usage is not sustainable, it is essential to produce renewable fuel and commercialize it to reduce the greenhouse gas emissions. In order to produce an alternate aviation biofuel a lot of industrial and academic collaborations have been developed worldwide. The main concern of this collaborative research is to produce aviation biofuel from renewable resources with low environmental impacts, and which is sustainable at an economically viable price. This mini-review briefly discusses the biotechnological approaches …

Techno-Economic And Life Cycle Assessment Of Hydrothermal Processing Of Microalgae For Biofuels And Co-Product Generation, Andrew P. Bessette

Civil & Environmental Engineering Theses & Dissertations

Traditional processing methods of algae to biofuels require dewatering after harvesting of the algae before the lipids can be extracted. This is typically the most energy intensive and therefore the most expensive step. Old Dominion University (ODU) has successfully utilized a flash hydrolysis (a kind of hydrothermal) process where proteins are solubilized into the liquid phase of product and the remainder lipid-rich, low nitrogen product is separated into a solid phase. The solid phase (lipid-rich) is then an ideal candidate for biofuel feedstock and the liquid phase, or hydrolysate, can be used for coproducts such as a source of nutrients …

Determination Of Growth Kinetics, Yield Coefficients And Biodiesel Properties For The Green Microalgae Scenedesmus Dimorphus In Freshwater And Saline Medias, Morgan L. Cohara

ETD Archive

Of the many alternative resources capable of generating biofuel, microalgal oil serves as a promising feedstock. Unfortunately, biodiesel production from microalgae is currently hindered by high operational costs. One primary causes for these high costs is the large quantity of freshwater required for cultivation. This experiment was designed to assess the feasibility of growing the green, freshwater microalgae Scenedesmus dimorphus in an increasingly saline environment. Both average yield coefficients and growth rates were monitored with increasing salt concentration. Determination of average yield coefficients allows for process scale-up and the optimization of production costs by minimizing raw material waste. Salinity was …

Holistic Approach In Microalgae Conversion To Bioproducts And Biofuels Through Flash Hydrolysis, Ali Teymouri

Civil & Environmental Engineering Theses & Dissertations

In recent years, the demand for renewable energy, mainly biomass has increased. The U.S. Energy Information Administration reported that more than 13.3% of the total energy production in the first seven months of 2017 was produced from a biomass source. Among all biomass resources, microalgae has brought a lot of attention due to their numerous advantages such as higher growth rate and productivity compared with the conventional energy crops, higher energy conversion efficiency by photosynthesis, and less water requirement than terrestrial crops. However, its development is far behind industrial production. Several research efforts across the globe have been concerned with …

Investigation Of Lutein Production And Recovery From Chlorella Vulgaris Using Phototrophic Cultivation, Mengyue Gong

Electronic Thesis and Dissertation Repository

Microalgae have been recognized as a natural reservoir of the valuable commercial carotenoid lutein due to its high lutein content and fast growth cycle. However, the production of lutein from microalgal sources is not yet sufficiently cost-effective to compete with traditional marigold flower-based processing (Park et al., 2015). This thesis aims to investigate the factors affecting lutein production and recovery from microalgae using a phototrophic cultivation mode.

The closed photobioreactors can offer controlled conditions for faster microalgae growth. A coiled tubular tree photobioreactor (CTPBR) design was first investigated for cultivating the cold tolerant microalgae, Chlorella vulgaris UTEX 265, under various …

Evaluation Of The Fertilization Properties Of Algal Biomass And Assessment Of Koh-Induced Flocculation Of Pw95 Algal Cells, Olakunle Ogunsakin

Graduate Theses & Non-Theses

Microalgae from the Coal Bed Methane (CBM) ponds of the Powder River Basin (PRB) in Southeastern Montana have the potential to be utilized as fertilizer for use on the economically important plants of Montana. Three very important economic field crops of Montana (winter wheat - Triticum aestivum, potato - Solanum tuberosum, and flax - Linum usitatissimum) were used for the fertilization experiments. Isolates of unicellular green algae - PW95 (sequenced as Neospongiococcum sp.) from the CBM ponds, and blue-green microalgae – Cyanobacteria (Anabaena Cylindrica) were cultured in the laboratory and the cells were concentrated using gravity sedimentation. Nutrient analysis of …

Carbon And Nutrient Balances In Microalgal Bioenergy System, Eunyoung Lee

USF Tampa Graduate Theses and Dissertations

This research investigated life cycle environmental impacts and benefits of an integrated microalgae system with wastewater treatment system using an integrated process modeling approach combined with experimentation. The overall goal of this research is to understand energy, carbon and nutrient balances in the integrated system and to evaluate the environmental impacts and benefits of the integrated system from a carbon, nutrient, and energy perspective. In this study, four major research tasks were designed to contribute to a comprehensive understanding of the environmental and economic sustainability of the integrated system, which included development of an integrated co-limitation kinetic model for microalgae …

Magnetic Stimulation On The Growth Of The Microalga Nannochloropsis Oculata, Manuella Oliveira

Electronic Thesis and Dissertation Repository

Fossil fuels, our principal sources of energy supply, are non-renewable and research is needed on alternatives that are renewable and potentially more environmentally friendly. Microalgae have been investigated as a future feedstock alternative to petroleum but the technology is still expensive and improvements are needed. Reduction in costs might be achieved by increasing algal biomass and lipid productivity. The lipids can be used to produce biofuels such as biodiesel and biojet fuel. The marine microalga Nannochloropsis oculata grows well and can accumulate high lipid content. In this study, the effects of static magnetic field stimulation (SMF) of 0 (control), 5, …

Anaerobic Digestion Of Wastewater: Effects Of Inoculants And Nutrient Management On Biomethane Production And Treatment, Jason Peterson

All Graduate Theses and Dissertations, Spring 1920 to Summer 2023

Due to population expiation and the increased awareness of the impact on the environment by wastewater treatment, improved wastewater treatment systems are needed to treat municipal and agricultural wastewater. Treating wastewater with oxygen decreases carbon compounds at the expense of energy to move carbon and oxygen to be in contact with each other. Anaerobic digestion of wastewater can reduce the cost by utilizing microbes to treat high amounts of carbon in wastewater without the need for extensive oxygen requirement. With a proper balance of nutrients, microbes also produce methane, a renewable energy source.

It has been suggested that microalgae be …

Supercritical Fluid Extraction Of Valuable Chemicals: Application Of Microalgae And Pyrolysis Oil As Feedstocks, Osariemen Ogbeide

Electronic Thesis and Dissertation Repository

In this dissertation, pure and modified carbon dioxide were used as non-conventional solvents for the investigation of lutein, chlorophyll a, chlorophyll b extraction from microalgae and for caffeine extraction from the pyrolysis oil of spent coffee grounds. The use of toxic organic solvents in supercritical fluid extraction has propelled research efforts to develop new solvents that are environmentally friendly and provide faster extraction compared to conventional extraction processes. For this reason, phosphatidylethanolamine (PE), a major phospholipid consisting of 14% of the entire soybean lecithin was acetylated with acetic anhydride, providing a surfactant (N-A-PE).

Then, the synthesized N-A-PE was employed as …