Engineering Commons^™

Feeding Condensed Distillers Solubles To Feedlot Finishing Steers And The Effects Of Feed Additives In Adaptation Diets, Marie E. Harris

Department of Animal Science: Dissertations, Theses, and Student Research

By-products from the dry-milling ethanol process can be used in cattle diets to replace corn. There is a significant interaction between corn processing methods as CCDS concentration increases in the diet. Improvements are observed for SFC in final BW, ADG, and G:F over DRC. An experiment was conducted to determine if greater concentrations of CCDS could be fed in SFC based diets and maintain or improve performance. Performance and carcass characteristics were evaluated with increasing concentrations of CCDS at 0, 9, 18, 27, or 36% in place of SFC in feedlot finishing diets. As CCDS concentration increased, DMI decreased quadratically. …

Uncertainties In Life Cycle Greenhouse Gas Emissions From U.S. Beef Cattle, Quentin M. Dudley, Adam Liska, Andrea K. Watson, Galen E. Erickson

Adam Liska Papers

Beef cattle feedlots are estimated to contribute 26% of U.S. agricultural greenhouse gas (GHG) emissions, and future climate change policy could target reducing these emissions. Life cycle assessment (LCA) of GHG emissions from U.S. grain-fed beef cattle was conducted based on industry statistics and previous studies to identify the main sources of uncertainty in these estimations. Uncertainty associated with GHG emissions from indirect land use change, pasture soil emissions (e.g. soil carbon sequestration), enteric fermentation from cattle on pasture, and methane emissions from feedlot manure, respectively, contributed the most variability to life cycle GHG emissions from beef production. Feeding of …

Nutrient Concentrations Of Runoff As Affected By The Diameter Of Unconsolidated Material From Feedlot Surfaces, John E. Gilley, Gregory Boone, David B. Marx

Biological Systems Engineering: Papers and Publications

Beef cattle feedlots contain unconsolidated material that accumulates on the feedlot surface during a feeding cycle. This study was conducted to measure the effects of varying diameters of unconsolidated surface material and varying flow rates on nutrient concentrations in runoff. Unconsolidated surface material with an average diameter of 4.76, 9.53, 19.1, or 47.5 mm and a composite sample with a 15.2 mm mean diameter were placed within 0.75 m wide × 4.0 m long plot areas. Flow was then introduced at the top of the plots in successive increments, and runoff samples for water quality analyses were obtained. Particle diameter …

Transport Of Steroid Hormones In The Vadose Zone After Land Application Of Beef Cattle Manure, Simon Van Donk, Sagor Biswas, William L. Kranz, Daniel D. Snow, Shannon L. Bartelt-Hunt, Terry L. Mader, Charles A. Shapiro, David P. Shelton, David D. Tarkalson, Tian .. Zhang, Steve Ensley

Biological Systems Engineering: Papers and Publications

Few studies have been conducted to investigate the potential contamination of groundwater from manureborne steroid hormones. The objective of this study was to monitor leaching of steroid hormones at the bottom of 2.4 m deep percolation lysimeters installed in plots treated with beef cattle manure. Soil samples were also collected from surrounding field plots. Treatments consisted of application of manure from two treatment methods (stockpiling and composting) or no manure application. Laboratory analyses of manure, soil, and leachate samples used liquid chromatography and tandem mass spectrometry to identify 17 steroid hormones and metabolites. Progesterone, estrone, β-zearalenol, and 4-androstenedione were detected …

Nutrient Losses In Runoff From Feedlot Surfaces As Affected By Unconsolidated Surface Materials, John E. Gilley, Jason R. Vogel, Roger A. Eigenberg, David B. Marx, Brian L. Woodbury

Biological Systems Engineering: Papers and Publications

Beef cattle feedlots contain unconsolidated surface materials (loose manure pack) that accumulate during a feeding cycle. The effects of varying amounts of unconsolidated surface materials on runoff nutrient losses are not well understood. The objectives of this study were to (1) compare runoff nutrient losses from feedlot surfaces containing varying amounts of unconsolidated surface materials, (2) determine if differences in runoff nutrient losses exist among rainfall simulation runs, (3) relate runoff nutrient losses to selected feedlot soil characteristics, and (4) identify the effects of varying runoff rate on nutrient loss rates from feedlot surfaces. This study was conducted on 0.75 …

Runoff Nutrient Loads As Affected By Residue Cover, Manure Application Rate, And Flow Rate, Chance Thayer, John E. Gilley, Lisa M. Durso, David B. Marx

Biological Systems Engineering: Papers and Publications

Manure is applied to cropland areas with varying surface cover to meet single‐year or multiple‐year crop nutrient requirements. The objectives of this field study were to: (1) examine runoff water quality characteristics following land application of manure to sites with and without wheat residue, (2) compare the water quality impacts of land application of manure to meet 0‐, 1‐, 2‐, 4‐, and 8‐year P‐based requirements for corn, and (3) evaluate the effects of varying runoff rates on runoff nutrient loads. Three 30‐min simulated rainfall events, separated by 24 h intervals, were applied at an intensity of 70 mm h^{‐1 …}

Runoff, Erosion, And Size Distribution Of Sediment From Beef Cattle Feedlots, John E. Gilley, Jason R. Vogel, Roger Eigenberg, David B. Marx, Brian L. Woodbury

Biological Systems Engineering: Papers and Publications

The size distribution of sediment in runoff from feedlot surfaces influences erosion rates and settling velocity. The objectives of this study were to: (1) measure runoff, erosion, and size distribution of sediment in runoff from feedlot surfaces containing varying amounts of unconsolidated surface material (USM), and (2) determine the effects of varying runoff rate on erosion and sediment size distribution. Simulated rainfall was applied to 0.75 m wide by 2 m long plots located within feedlot pens. Sieve and pipette analyses were used to measure the diameters of the eroded materials. No significant differences in runoff and erosion were found …

Nutrient Transport In Runoff As Affected By Diet, Tillage, And Manure Application Rate, John E. Gilley, Lisa M. Durso, R.A. Eigenberg, David B. Marx, Brian L. Woodbury

Biological Systems Engineering: Papers and Publications

Feedlot operators may increase profitability by including distillers grains in finishing diets. However, the nutrients remaining in the by‐product are concentrated by about a factor of three during the distillation process. Manure can be applied to meet single‐ or multiple‐year crop nutrient requirements. The water quality effects of the use of distillers grains in feedlot diets and multiple‐year manure application have not been well quantified. The objectives of this study were to (1) compare the runoff water quality effects resulting from the application of manure derived from corn and distillers grain diets, (2) examine the effects of till and no‐till …

Nutrient Transport In Runoff From Feedlots As Affected By Wet Distillers Grain Diet, John E. Gilley, Jason R. Vogel, Roger A. Eigenberg, David B. Marx, Brian L. Woodbury

Biological Systems Engineering: Papers and Publications

Distillers byproducts can serve as valuable sources of protein and energy for beef cattle. However, the water quality effects of the use of distillers byproducts in cattle rations are not well understood. The objectives of this study were to: (1) measure soil properties and nutrient transport in runoff from feedlot surfaces as affected by corn‐based and wet distillers grain diets, (2) compare the effects of unconsolidated surface materials and consolidated subsurface materials on feedlot soil characteristics and runoff nutrient transport, (3) determine if runoff nutrient transport from feedlot surfaces is correlated to selected feedlot soil properties, and (4) identify the …

Nutrient And Bacterial Transport In Runoff From Soil And Pond Ash Amended Feedlot Surfaces, John E. Gilley, Jason R. Vogel, Elaine D. Berry, Roger Eigenberg, David B. Marx, Brian L. Woodbury

Biological Systems Engineering: Papers and Publications

The addition of pond ash (fly ash that has been placed in evaporative ponds and subsequently dewatered) to feedlot surfaces provides a healthier environment for livestock and economic advantages for the feedlot operator. However, the water quality effects of pond ash amended surfaces are not well understood. The objectives of this field investigation were to: (1) compare feedlot soil properties, and nutrient and bacterial transport in runoff, from pond ash amended surfaces and soil surfaces; (2) compare the effects of unconsolidated surface materials (USM) (loose manure pack) and consolidated subsurface materials (CSM) (compacted manure and underlying layers) on nutrient and …

Spatial Variations In Nutrient And Microbial Transport From Feedlot Surfaces, John E. Gilley, Elaine D. Berry, Roger A. Eigenberg, David B. Marx, Bryan L. Woodbury

Biological Systems Engineering: Papers and Publications

Nutrient and microbial transport by runoff may vary at different locations within a beef cattle feedlot. If the areas making the largest contributions to nutrient and microbial transport can be identified, it may be possible to institute site‐specific management practices to reduce runoff nutrient and microbial transport. The objectives of this study were to: (1) measure selected feedlot soil properties and nutrient and microbial transport in runoff from various feedlot locations, (2) compare the effects of unconsolidated surface materials (USM) (loose manure pack) and consolidated subsurface materials (CSM) (compacted manure and underlying layers) on nutrient and microbial transport, and (3) …

Characteristics Of Manure Harvested From Beef Cattle Feedlots, William F. Kissinger, Richard K. Koelsch, Galen E. Erickson, Terry J. Klopfenstein

Biological Systems Engineering: Papers and Publications

Open lot cattle production systems present unique challenges for nutrient planning processes. Previous estimates of quantities and characteristics of harvested manure from this type of facility are based upon data from the early 1970s. In addition, harvested manure is impacted by weather, feeding program, season, and pen management decisions. The objectives of this study are to characterize under commercial conditions for open lot beef systems: 1) harvested manure quantities and characteristics; 2) impact of factors such as feeding program, season, and management on harvested manure; and 3) mass balance for nitrogen (N) and phosphorus (P). Data from six commercial feedlots …

Ammonia And Hydrogen Sulfide Flux From Beef Cattle Pens: Implications For Air Quality Measurement Methodologies And Evaluation Of Emission Controls, Jacek A. Koziel, David B. Parker, Bok-Haeng Baek, Kevin J. Bush, Marty Rhoades, Zena Perschbacher-Buser

Jacek A. Koziel

Ammonia (NH 3 ) and hydrogen sulfide (H 2 S) are emitted from beef cattle feedlots with NH 3 being greater by nearly three orders of magnitude. Nearly 30% of the U.S. beef cattle are fed in the High Plains of Texas. Earlier research indicates that abatement technologies may be needed to significantly reduce NH 3 emissions. To date, little is known about the appropriate measurement methods to evaluate the effectiveness of NH 3 emission controls. In this research, we determined the (a) variability of NH 3 and H 2 S fluxes within a single pen and (b) the relationships …

Application Rate And Timing Effects On Urease Inhibitor Performance For Minimizing Ammonia Emissions From Beef Cattle Feedyards, David B. Parker, Syam Pandrangi, L. Wayne Greene, Lal K. Almas, N. Andy Cole, Marty B. Rhoades, Jacek A. Koziel

Jacek A. Koziel

A laboratory study was conducted to evaluate how rate and timing of urease inhibitor application affects ammonia emissions from simulated beef cattle feedyard surfaces. The urease inhibitor N-(n-butyl)thiophosphoric triamide (NBPT) was applied at rates of 0, 1 and 2 kg/ha, at 8, 16, and 32 day frequencies, and with or without simulated rainfall. Synthetic urine was added every 2 days to the manure surface. Gaseous NH3 was trapped in a sulfuric acid solution using a vacuum system and analyzed for nitrogen using automated procedures. NBPT applied every 8 days was most effective, with the 1 and 2 kg/ha NBPT treatments …

Proposed Beef Cattle Manure Excretion And Characteristics Standard For Asae, Galen E. Erickson, B. Auvermann, R. A. Eigenberg, L. W. Greene, Terry J. Klopfenstein, Richard K. Koelsch

Department of Biological Systems Engineering: Conference Presentations and White Papers

A committee was formed consisting of both animal scientists and agricultural engineers to evaluate and update current ASAE standards. An intake minus retention model was developed to estimate nutrient excretion. This approach allows users (producers, engineers, etc.) to develop site specific information based on known variables such as protein or phosphorus content of diets and cattle performance. This approach illustrates the importance of nutrition on nutrient excretion in livestock operations. Our focus is for feedlot cattle and updates excretion of dry matter (DM or total solids), organic matter (OM or volatile solids), N, P, Ca, K, Na, Mg, S, Cu, …

Runoff And Erosion Following Field Application Of Beef Cattle Manure And Compost, John E. Gilley, Bahman Eghball

Biological Systems Engineering: Papers and Publications

Manure or compost from beef cattle feedlots can be excellent sources of nutrients and organic matter when added to soils. This study was conducted to determine the effect of a single application of manure and compost on runoff and erosion under no-till and tillage conditions. Tillage consisted of a single disking operation up and down the slope on a Sharpsburg soil which was cropped to grain sorghum or wheat the previous season. Manure and compost were applied at rates required to meet corn fertility requirements. Additional experimental treatments included the application of inorganic fertilizer and an untreated check. The addition …

Nutrient And Energy Composition Of Beef Cattle Feedlot Waste Fractions, C. B. Gilbertson, J. A. Nienaber, J. R. Ellis, T. M. Mccalla, T. J. Klopfenstein, S. D. Farlin

Historical Research Bulletins of the Nebraska Agricultural Experiment Station

This bulletin describes nutrient and energy composition of beef cattle waste fractions as a function of the ration roughage level and type of feedlot. Results can be used to plan engineering system approaches and research to develop handling and processing equipment necessary for recovery of the most valuable portion of waste.

Lot Feeding Of Beef Cattle. 3. Facilities Required For A Feed Lot, W J O Wilkie

Journal of the Department of Agriculture, Western Australia, Series 4

MANY THINGS must be considered in planning a feed lot.

The site must be well chosen, fencing, gates and yards must be adequate for the cattle carried and feeding and watering facilities should be of a high standard.

Other things to consider are the provision of shelter and shade for the cattle and buildings for feed storage and other purposes.

Lot Feeding Of Beef Cattle. 1. Introduction, W J O Wilkie

Journal of the Department of Agriculture, Western Australia, Series 4

"LOT FEEDING" of cattle is the name given to the operation of bringing cattle in from pasture and giving them the total ration they are to receive in open or partly roofed yards.

The roof would be intended to protect the feed trough and not the cattle.

Good Facilities Help T.B. Testing, Department Of Agriculture, Western Australia

Journal of the Department of Agriculture, Western Australia, Series 4

Owner co-operation is needed for the smooth working of the tuberclin testing of cattle, compulsory in the South-West Land Division.

This article describes suitable facilities for the testing and how they operate.