Environmental Health and Protection Commons^™

Impact Of The Municipal Solid Waste Incineration Plant In Warsaw On Air Quality, Robert Oleniacz

Robert Oleniacz

The only Polish municipal solid waste (MSW) incinerator has been operating within the Municipal Solid Waste Disposal Plant in Warsaw since 2000. In the paper selected results of the air quality impact assessment for this incinerator during an operating period of one year (2008) are presented. With respect to the incinerated waste amounts and emission levels, the analysed period can be considered typical for this facility. Assessment of the air quality impact was carried out by assessing air pollutant emissions in reference to the applicable emission limit values and by modeling atmospheric dispersion of these pollutants. It has been found …

Ocena Wpływu Na Jakość Powietrza Procesu Przygotowania Obszaru Wiertni Przy Poszukiwaniach Gazu Z Łupków, Marek Bogacki, Robert Oleniacz, Monika Janicka

Robert Oleniacz

This chapter presents the model calculation results of the level of concentration of air pollutants emitted during works related to the preparation of the drilling pad for the shale gas exploration. The most significant emission sources located in the drilling pad, including rig access roads, paved and unpaved, were analyzed. The emission field was defined by the parameterization of various sources/processes, taking into account the technical, technological, organizational and environmental conditions. The calculations of the pollutants dispersion in the air were carried out using the Gaussian reference model. The results of numerical calculations showed that the only substance likely to …

Ocena Efektów Termomodernizacji Budynków Jednorodzinnych. 2. Ograniczenie Wpływu Na Jakość Powietrza Atmosferycznego, Robert Oleniacz, Magdalena Kasietczuk, Mateusz Rzeszutek

Robert Oleniacz

The article assesses to what extent reduced the impact on air quality of a complex of detached coal-fired houses as a result of some thermal renovation works which lowered the fuel consumption and reduced emissions of pollutants into the air. The assessment was done on the basis of results of dispersion modelling for selected substances (SO2, NO2, CO, PM10, B(a)P and PCDD/F) in the ambient air with the use of CALMET/CALPUFF models. The calculation process encompassed preparation of the data on spatial features of the area, making a three-dimensional grid of meteorological data, definition of geometrical parameters of substitute emitters …

Emisja Dioksyn I Furanów Z Procesu Współspalania Paliw Alternatywnych W Piecach Cementowych, Magdalena Kasietczuk, Robert Oleniacz, Marian Mazur

Robert Oleniacz

The chapter discusses the problem of air emissions of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/PCDFs) from the process of cement clinker production. In the analyzed cement kilns significant amount of fossil fuels is replaced with alternative fuels, mainly waste-derived fuels. Thus, particular attention has been paid to the potential impact on the level of the emissions such factors as type and quantity of used wastes and their ways of introducing into the kiln during co-combustion. The analysis include the results of measurements of PCDD/PCDF concentrations in the flue gases of selected cement kilns and differences in used raw materials, methods of …

Niekontrolowane Spalanie Odpadów I Pozostałości Roślinnych Na Terenach Wiejskich – Przykład Inwentaryzacji Źródeł Emisji I Oceny Wpływu Na Jakość Powietrza, Robert Oleniacz, Barbara Bacik, Marcelina Spiszak

Robert Oleniacz

The most troublesome air pollutant emissions that occur in rural areas are associated with the operation of domestic furnaces (mainly during the heating season) and the processes of open burning of plant residues (mainly outside the heating season). The paper presents an example of emission inventory for this type of sources in two submontane villages of Małopolska Voivodeship (Poland) based on the results of the questionnaire survey and an attempt to assess the impact on air quality of these sources, including the potential uncontrolled burning of waste.The conducted questionnaire survey showed the use to home heating mainly solid fuels (first …

Assessment Of The Impact Of Municipal Waste Incineration Plants On Air Quality And The Possibilities Of Its Reduction, Robert Oleniacz

Robert Oleniacz

The planned construction of new municipal waste incineration plants over the next few years in Poland results in protests of local communities, which arise mainly from fear of an increase in the air pollution in its vicinity. These protests extend the investment process and hinder the selection of incineration plant location, but on the other hand they necessitate the use of more efficient solutions to reduce their impact on the air quality.This paper characterizes the world's most widely used technology for municipal solid waste incineration (MSWI) and assesses the possible maximum impact on the air quality of an exemplary MSWI …

Wykorzystanie Atmosferycznego Modelu Dyspersji Calpuff Do Oceny Oddziaływania Na Jakość Powietrza Planowanego Zakładu Termicznego Przekształcania Odpadów Komunalnych W Krakowie, Mateusz Rzeszutek, Robert Oleniacz

Robert Oleniacz

The aim of this study was to determine the influence of the planned Municipal Waste Thermal Treatment Plant in Krakow on air pollution. Air quality impact assessment was based on the current state of the legal formalities (including emission limit values for waste incineration plants) and the results of the air pollutant atmospheric dispersion modeling for one month period. In this study to calculate of air pollutant dispersion was used model system CALMET/CALPUFF. Using the CALMET model variables in time and space weather condition were calculated. CALPUFF model were performed to computing of propagation of air pollution. Analysis of the …

Co-Incineration Of Large Quantities Of Alternative Fuels In A Cement Kiln – The Problem Of Air Pollutant Emissions, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

Over the last few years, a significant increase in the use of alternative fuels in the Polish cement industry has been observed. These are mainly waste and waste-derived fuels. The national leader in this field is Chełm cement plant (Poland), with the share of alternative fuels in the cement kiln heat balance reaching in 2012 the level of 78.5%. In this paper, an analysis of the emission rate of air pollutants from cement clinkering process in the above-mentioned cement plant in the years 1998–2012 was carried out, using the results of continuous and periodic measurements. The compliance with the emission …

Air Pollution Emissions During Baking Of Semi-Finished Graphite Products In A Tunnel Furnace, Marek Bogacki, Robert Oleniacz, Marian Mazur

Robert Oleniacz

The baking of semi-finished graphite products in a tunnel furnace is the source of many air pollutants present in both the gaseous and solid phases. The goal of this study was to assess emission rates into the air of the substances such as: CO, NOx, SO2, H2S, CH4, aliphatic hydrocarbons up to C6, benzene and its homologues (BTEX), total dust and tar substances, and polycyclic aromatic hydrocarbons (PAHs) contained in the dust. The research showed a small time-dependence of the emission rates for the majority of the substances analysed, which is, to a large extent, a result of the long …

Wpływ Procesu Współspalania Odpadów W Piecu Cementowym Na Jakość Powietrza / Impact Of Waste Co-Incineration Process In A Cement Kiln On Air Quality, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

The work presents the general requirements for the control of emissions to air from waste co-combustion (co-incineration) plants, with particular emphasis on rotary kilns used for clinker production. Air emissions from the cement kiln during co-combustion of alternative fuels and the impact assessment on air quality are also presented. The object of the study was one of the Polish cement plant, which uses significant amounts of solid waste derived fuels (with over 70% share in the cement kiln heat balance). Assessment of the impact on air quality was made based on the results of the modeling of atmospheric dispersion of …

Problem Niekontrolowanego Spalania Odpadów I Pozostałości Roślinnych W Obszarze Wiejskim Na Wybranym Przykładzie, Robert Oleniacz, Barbara Bacik

Robert Oleniacz

This paper presents the results of surveys on the problem of uncontrolled burning of waste in domestic stoves and boilers for central heating and open burning of plant residues in rural areas. The questionnaires were conducted among the inhabitants of one of Polish village (Łąkta Dolna), located in the Malopolska province, in the submontane area. The study comprised 80.2% of all households. As is clear from conducted surveys waste were burned in more than 80% of surveyed houses and more than half of respondents admitted to the open burning of plant residues. The percentage of people burning waste and plant …

Współspalanie Odpadów W Suchym Piecu Cementowym A Emisja Dwutlenku Siarki I Chlorowodoru, Robert Oleniacz

Robert Oleniacz

The paper presents an assessment of the impact of waste co-combustion in a cement kiln on air emissions of HCl and SO2 recorded continuously. The subject of the research was cement kiln (dry method) with a capacity of 8500 Mg/day, equipped with a four cyclone heat exchangers and a calciner with an additional chamber for co-incineration. In the analysed period alternative fuels (mainly waste) were used in various amounts ranging up to about 35 kg / Mg clinker (with the heat substitution up to 20%) in the kiln and calciner. Chlorine and sulfur inputs to the process were up to …

Emisja Zanieczyszczeń Pyłowo-Gazowych Z Procesu Wypalania Półproduktów Grafitowych W Piecu Tunelowym, Marek Bogacki, Robert Oleniacz, Marian Mazur, Przemysław Szczygłowski

Robert Oleniacz

The baking of semi-finished graphite products in a tunnel furnace is the source of many air pollutants present in both the gaseous and solid phases. The goal of this study was to assess emission rates into the air of the substances such as: CO, NOx, SO2, H2S, CH4, aliphatic hydrocarbons up to C6, benzene and its homologues (BTEX), total dust and tar substances, and polycyclic aromatic hydrocarbons (PAHs) contained in the dust. The research showed a small time-dependence of the emission rates for the majority of the substances analysed, which is, to a large extent, a result of the long …

Ocena Wpływu Arcelormittal Poland S.A. Oddział W Krakowie Na Jakość Powietrza, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The work presents selected results of atmospheric dispersion modeling and air quality impact assessment for pollutant emissions from installations of ArcelorMittal Poland S.A. Unit in Krakow (Poland). The assessment was carried out for the most unfavourable emission variant probable to take place in the period 2007-2016. In the calculations were taken into consideration typical for steelworks particle matter pollutants (total dust, heavy metals, tar substances and PAHs including benzo-a-piren) and gaseous substances (SO2, NO2, CO, HC, HCl, HF, NH3, HCN, H2S, CS2, H2SO4, BTX, phenol and pyridine). As the result of estimations, carried out according to the Polish reference method …

Air Pollutant Emissions From Process Of Mixing Materials Used For Manufacturing Small Products From Carbon And Graphite, Marian Mazur, Marek Bogacki, Robert Oleniacz, Przemysław Szczygłowski

Robert Oleniacz

The paper characterises the method of preparing the HCC and Rubba-type materials used to manufacture small carbon and graphite products, and the composition of waste gases escaping from the mixers for these materials. For the process of mixing the two materials under examination, two measurement series were completed, mainly covering the period from when the binder was added to the properly pre-heated dry mass until the mixer discharged. The results shown apply only to those substances which occur just in the gaseous phase, that is CO, CO2, O2, H2, aliphatic hydrocarbons (C1-C6) and BTX (benzene, toluene, ethylbenzene and xylene) as …

Badania Zawartości Substancji Gazowych W Gazach Odprowadzanych Z Procesu Przygotowania Tworzyw Do Produkcji Drobnych Wyrobów Węglowych I Grafitowych, Marian Mazur, Marek Bogacki, Robert Oleniacz, Przemysław Szczygłowski

Robert Oleniacz

The paper characterises the method of preparing the HCC and Rubba-type materials used to manufacture small carbon and graphite products, and the composition of waste gases escaping from the mixers for these materials. For the process of mixing the two materials under examination, two measurement series were completed, mainly covering the period from when the binder was added to the properly pre-heated dry mass until the mixer discharged. The results shown apply only to those substances which occur just in the gaseous phase, that is CO, CO2, O2, H2, aliphatic hydrocarbons (C1-C6) and BTX (benzene, toluene, ethylbenzene and xylene). Due …

Badania Zawartości Pyłu Ogółem I Węglowodorów Wyższych W Gazach Odprowadzanych Z Procesu Przygotowania Tworzyw Do Produkcji Drobnych Wyrobów Węglowych I Grafitowych, Marian Mazur, Marek Bogacki, Robert Oleniacz, Przemysław Szczygłowski

Robert Oleniacz

The paper presents the results of measurements of concentrations of dust substances in flue gases from the mixing process of two type od raw materials (HCC and Rubba) used in the manufacture of fine carbon and graphite products. These raw materials differed in the method of preparation including the heating temperature in various stages of mixing and duration of the process. Due to the use in the mixing process liquid binders, significant amounts of tar substances in liquid and solid phase were discharged from the mixers. In the analyzed flue gases was determined total dust content of tar substances, polycyclic …

Ocena Skuteczności Działania Suchego Systemu Oczyszczania Spalin Ze Spalania Odpadów Medycznych Opartego Na Wtrysku Sorbentu Wapniowo-Węglowego, Robert Oleniacz

Robert Oleniacz

The research object was a medical waste incineration plant with a capacity of 150 kg per hour equipped with a flue gas treatment system based on dry sorption process using a lime-carbon reagent with adsorbent removing in high-efficiency particulate collector. As the dry sorption agent was used a mixture of high reactive hydrated lime and activated carbon injected to combustion gases by pneumatic feeder. Activated carbon content in the mixture was 5-10 % by mass. Applied collector was ceramic filter with total filtration area of 120 m2 and guaranteed outlet dust concentration under 5 mg/Nm3. Among others things the aims …

Wpływ Dużej Spalarni Odpadów Przemysłowych I Niebezpiecznych Na Jakość Powietrza, Robert Oleniacz, Lidia Rusztowicz

Robert Oleniacz

Waste incineration causes unavoidable pollutant emissions to atmosphere and thus negative impact on air quality, but scale of the influence is often exaggerated. In the paper computation results of the atmospheric dispersion of pollutants were presented for one of the largest industrial and hazardous waste incineration plant existing in Poland (processing capacity: 3 ton per hour). These results confirm the fact that the incinerator meets the requirements of best available techniques (BAT) for the waste incineration and its impact on air quality is relatively small. This effect is caused mainly by proper operation of the rotary kiln incinerator, high efficiency …

Analiza Wpływu Planowanego Zakładu Termicznego Przekształcania Odpadów Komunalnych Na Jakość Powietrza W Krakowie, Robert Oleniacz, Maria Pilch

Robert Oleniacz

Construction of the Municipal Solid Waste Incineration (MSWI) plant is considered optimal in the Programme of Management of Solid Waste in Krakow as well as in proposed scenarios of Municipal Waste Management. Evaluation of impact of the incineration plant with a capacity of 255000 tons per year on air quality in Krakow is presented in this work. The evaluation is based on assumption that air pollutant emissions from the incinerator will be at the highest allowed level resulting from emission limit values for waste incineration plants with operation time each of two planned lines 7500 hours per year. Calculation results …

Analiza Możliwości Ograniczenia Emisji Zanieczyszczeń Powietrza Z Instalacji Spalania Odpadów Medycznych W Tarnowie, Robert Oleniacz

Robert Oleniacz

The paper presents initial research of effects of some factors on the amount of gaseous pollutants formation during medical waste incineration in a two-stage starved air fluidised bed reactor. In the research was included the impact of such factors as oxygen contents in flue gases, frequency of waste loading, momentary mass flow of waste and temperature in the secondary combustion chambers. Measurements showed that the waste incineration in large amount periodically caused excessive emissions incomplete combustion products (CO, HC), especially during wrong operation of the combustion system. The work demonstrated that the essential importance for CO and HC formation reducing …

Emisja Zanieczyszczeń Z Procesu Grafityzacji Elektrod Węglowych W Piecach Lwg (Castnera). Cz. 2. Wybrane Substancje Pyłowe, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The measurement results of quantity of dust pollutants originated and emitted to air from LWG (Castner) furnaces during graphitisation process of coal electrodes were presented in the paper. The investigation was carried out for total dust, total tar substances and polycyclic aromatic hydrocarbons (PAHs). The measurements were performed both before and after the flue gas control system (catalytic burning and wet cleaning). Thus changes of the substance concentrations in the gases for the cleaning system were estimated. As a result of the investigation was conclusion that the graphite process of coal electrodes in LWG stoves is not a significant source …

Emisja Zanieczyszczeń Z Pieca Achesona Do Grafityzacji Wyrobów Drobnych, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

Research results of the air pollutant emissions from the graphitisation process of fine products in the Acheson electric resistance furnace (discharge capacity 5,5 Mg) were presented in the paper. Research was performed for two kinds of raw material inputs (based on petroleum coke and pitch coke). Approximately 40-hours measurement series were carried out for each material including mainly such substances like carbon monoxide, hydrocarbons, nitrogen oxides, sulphur dioxide, hydrogen sulphide, carbon disulphide, ammonia, benzene, toluene, xylenes, total dust, tar substances and polycyclic aromatic hydrocarbons. Both average and maximum concentrations and mass streams in the flue gases and average emission factors …

Ocena Oddziaływania Mittal Steel Poland S.A. Oddział W Krakowie Na Jakość Powietrza W Aspekcie Likwidacji Strefy Ochronnej, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The paper presents results of the air quality impact assessment for Mittal Steel Poland S.A. unit in Krakow (Poland). The assessment included all emission sources working in the unit in 2003 as well as emission sources belonging to companies separated from the steelworks in the past. A special attention was taken to comply of air quality standards in area of the protective zone in connection with their planned liquidation by the end of 2005 (the requirement of the new environmental law).

English title: Evaluation of impact of Mittal Steel Poland S.A. unit in Krakow on air quality in connection with …

Emisja Zanieczyszczeń Ze Spalania Odpadów Podestylacyjnych Z Produkcji Witaminy C W Piecu Fluidalnym, Robert Oleniacz

Robert Oleniacz

Some results of continuous or periodical measurements of selected air pollutant concentrations and mass streams in the flue gases from liquid waste incineration in a fluidized bed incinerator were presented in the paper. During the researches distillation tails from vitamin C production, that is waste traces from regeneration such solvents as for example ethylene chloride, chloroform or trichloroethylene were incinerated. As a result of the researches there was determined optimal temperature of the fluidized bad in which the waste incineration should be carried out to minimization of CO and NOx formation. Required effectiveness of HCl removal from combustion gases to …

Emisja Zanieczyszczeń Z Procesu Grafityzacji Elektrod Węglowych W Piecach Lwg (Castnera). Cz. 1. Wybrane Substancje Gazowe, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The results of measurements of quantity pollutants originated and emitted to air from LWG (Castner) furnaces were introduced. The investigation was carried out during the graphitisation process of coal electrodes, until moment of end of ventilation the stove across applied installations of cleaning of cool gases (catalytic burning and the wet desulphurization). The measurement results of CO, CO2, HC+H2, SO2, H2S, CS2, NO, NO2, NH3 as well as chosen hydrocarbons (C1-C6) and aromatic hydrocarbons (BTX) were presented. In result of conducted investigations was qualified courses of changeability of concentrations in gases these substances before and for the cleaning system. The …

Emisja Chlorowodoru Ze Spalania Węgla W Kotle Pyłowym, Marian Mazur, Robert Oleniacz, Przemysław Szczygłowski, Marek Bogacki

Robert Oleniacz

Emission of hydrogen chloride (HCl) from coal combustion is not controlled just like for example sulpfur dioxide emission. But HCl emission is also important, because chlorine content in some types of coal can reach the similar level to sulfur content. In the paper the measurement results of HCl emission to the air during combustion of three types of coal with law content of chlorine were presented. The researches were carried out for a steam pulverized coal boiler (max. boiler efficiency – 430 t/h) during three various loads (respectively 65, 80 and 95 % of maximum efficiency) without flue gas desulfurization. …

Metoda Oceny Trudności Oczyszczania I Toksyczności Spalin Powstających Podczas Spalania Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents a methodology for evaluating the cleaning difficulty and toxicity of combustion gases from waste incineration based on the knowledge of gases composition. This type of evaluation may be applicable to selection or modernization of flue gas cleaning systems for waste incineration plants and to comparative analy-sis of a pollution degree of raw (unclean) combustion gases. In the evaluation of the cleaning difficulty of gases six categories of difficulty have been identified for removal of selected substances or groups of substances. The evaluation is made individually for substances or groups of substances on condition their concentrations in flue …

Emisja Btx Towarzysząca Produkcji Wyrobów Węglowych I Grafitowych, Marian Mazur, Przemysław Szczygłowski, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The work presents results of direct measurements of benzene, toluene, ethyl benzene and xylenes (BTX or BTEX) emissions to the air from technological processes related with carbon and graphite manufacturing. The most important from all mentioned pollutants is benzene considered as one of the main factor of air pollution in the European Union. The highest concentrations of BTX were found in the fumes emitted from the tanks of liquid raw materials, while the highest levels of their emissions were from furnaces used for baking of green electrodes and other carbon products.

English title: BTX emission from production of graphite and …

Emisja Rtęci Z Energetycznego Spalania Węgla, Marian Mazur, Przemysław Szczygłowski, Robert Oleniacz, Janusz Dańko

Robert Oleniacz

In the paper, some results of the measurement of mercury emission from OP-430 boiler working in the Combustion Plant “Kraków S.A.” are presented. The tests were carried out during combustion of various coals and changeable the boiler efficiency. Apart from investigation of mercury emission to the atmosphere (in gaseous and solid phase), total mercury concentration in coal, bottom ash and dust collected in electrostatic precipitators were analysed as well. Thus emission amount could be verified by means of the approximate mercury balance performed for the coal combustion process.

English title: Mercury emission from coal combustion.