Digital Commons Network^™

The Investigation Of Frequency Response And Stability Of A Heat Exchanger Under Condensate Control, Louis F. Fornoff

Theses

Control of a condensing steam heat exchanger by condensate throttling was investigated theoretically by a frequency response analysis. The theoretical analysis was verified by experimental operation of the heat exchanger.

The system was characterized by heat transfer calculations and Laplace transform functions. The transfer functions were used to complete a frequency response analysis of the system which predicted the controller settings, the stability of the system and its response to a step set point change. The calculations were verified by experimental operation and reasonable agreement was obtained.

It was calculated that condensate throttling can be used to obtain stable control …

Prediction Of Ternary Azeotropes From Binary Data, Eric Lustig

Theses

The Margules equation as modified by Wohl for ternary liquid-vapor systems, is used to develop ternary activity coefficients at different concentrations and varying temperatures. Corresponding binary experimental data are necessary to mathematically obtain these ternary activity coefficients. A trial and error graphical technique is used to examine the ternary data for azeotropic conditions. Convergence on ternary graph paper can be easily detected after the first two trials. Divergence is an indication that the system under consideration is nonazeotropic.

Most of the azeotropic systems investigated agreed quite well with published data. The range of disagreement of concentrations for component a in …

Isobaric Vapor-Liquid Equilibria System : Benzene, Chlorobenzene, Phenol, Larry Madestau

Theses

Isobaric vapor-liquid equilibria were determined experimentally for the three binary systems benzene-chlorobenzene, benzene-phenol, and chlorobenzene-phenol; and for the corresponding ternary system benzene-chlorobenzene-phenol. Constants for the Chao modified Redlich-Kistler equations were calculated from the experimental data by the method of least squares. These constants were then used to predict vapor-liquid equilibria for the ternary system. The predicted values showed satisfactory agreement with those found experimentally.

A modified Ellis still was used for obtaining equilibrium data. Samples of vapor and liquid phases were analyzed by means of the F & M Model 720 vapor phase chromatograph. Benzene, chlorobenzene, and phenol used in …

Classroom Discipline, Lorene H. Armstrong

Theses

Constructive classroom discipline is an important part of the educative process. It provides children with the opportunity to experience the satisfaction of fitting into a social group in an atmosphere which is conducive to learning and which promotes healthy emotional control. Academic learning and disciplined behavior are inseparable. If the latter breaks down, the former is impaired. Good teaching is made possible only by good discipline. This paper will explore, by means of the research, what is considered good discipline in the classroom.

Spenser: Reflections And Parallels In The Romantic Poets, Sara Rivers Aderholdt

Theses

This paper calls attention to reasonable effects, noticeable echoes, and remarkable parallels of Edmund Spenser's philosophy and his treatment of myth and symbol as found in the Romantic poets.

Viscosity-Vapor Pressure Correlation Of Alcohols, Methyl Ketones And Alkyl Halides, Kevin Frank

Theses

A linear relationship was found to exist between the logarithms of viscosity and vapor pressure measured at the same temperature for certain homologous series. Previous work by Di Geronimo, healing, and McGuire substantiated this correlation for n-paraflin hydrocarbons, n-paraffin fatty acids and esters, n-alkyl cyclohexanes, n-alkyl benzenes and n-l-monoolefins. The relationship takes the form

logη= A log vp + B

where A and B are constants characteristic of the homologous series.

The adaptation of this linear relationship to alcohols methyl ketones, and alkyl halides in the present work indicates a wide applicability of the correlation. the values of the series …

Heat Conductivity Of Adhesively Bonded Assemblies, Stanley I. Klosowski

Theses

The thermal conductivity of an epoxy compound commonly used as an adhesive, was measured using asimple apparatus specially designed to simulate adhesion, to minimize heat losses, and to simplify measurement and correction for heat losses. Variation of heat conductivity coefficient with glue line thickness and temperature was investigated. The results do not indicate that there is any consistent correlation between the heat conductiv¬ity coefficient and glue line thickness or between heat conductivity coefficient and temperature. However, the small number of samples measured does not permit any definite conclusions to be drawn. The sample with glue line thickness below 0.025 millimeters …

Vapor-Liquid Equilibria System : Acetone, Ethylene Dichloride, Toluene, Donald Warren Krech

Theses

The vapor-liquid equilibria data have been determined for the ternary system acetone (C₃H₆O), ethylene dichloride (C₂H4Cl₂), and toluene (C₇H₈), using a modified Othmer continuous distillation equilibrium still. The data were correlated to theoretical values using the Margules three-suffix ternary equations.

Although equilibria data are available in the literature for the three binary systems, new data were collected for each system to evaluate the validity of the experimental apparatus and techniques. Consistency of the experimental data was demonstrated.

For the acetone-ethylene dichloride binary system, where similar apparatus was …

Vapor-Liquid Equilibria System : Carbon Tetra-Chloride, Toluene, N-Heptane, Joel Philip Pearlstein

Theses

A study was made of the vapor-liquid equilibria of the ternary system: carbon tetrachloride (CCl₄), n-Heptane (C₇H₁₆) and Toluene (C₇H₈). An Othmer still was used for the determination of the equilibria and the liquid and vapor compositions were ascertained by refractive index and density measurements. A comparison between experimental values and theoretical values was made using the Margules 3-suffix ternary equations for the correlation. Although the Margules equations did not correlate the experimental data very well, this is most likely due to the fact that the ternary solution was close …

Program Evaluation And Review Technique, Anthony Immaculate Agresta

Theses

The problem of planning, controling and evaluating complex projects both engineering and non-engineering has existed as long as the projects themselves. In the past the approach of management to this problem has been one which was based heavily on the use of historical information. There have been very few attempts to predict and control the occurrence of the objective event of these projects.

This thesis deals with a review of this problem and a new approach to the planning, control, and evaluation of these complex projects. This new approach is the Program Evaluation and Review Technique (PERT) which was developed …

Modified Coates-Orr Vapor-Liquid Equilibrium Still : The Effect Of Pressure On Binary Azeotropes, John K. Jacob

Theses

In order to test the effect of pressure on binary azeotropes, an all stainless steel Coates-Orr vapor-liquid equilibrium still was constructed and then tested at atmospheric and superatmospheric pressure. To overcome operating difficulties at superatmospheric pressures, it was necessary to modify the original still design by (1) coiling a Nichrome resistance wire around the entire still body and insulating heavily over the coil, (2) substituting a "canned" seal-less pump in place of the original centrifugal pump.

A survey of the literature shows that the difficult-to-operate Jones-type equilibrium stills, from which the Coates-Orr still was developed, approach true phase equilibrium. Therefore, …

Preparation Of Aryl Sulfones By Sulfonation In The Presence Of Phosphrous Oxychloride, Donald Frederick Kruse

Theses

The use of phosphorus oxychloride as a dehydrating agent in the sulfonation of aromatic compounds has been investigated, particularly with respect to the formation of aryl sulfones. The sulfonation of several aromatic compounds using reagent grade sulfuric acid and phosphorus oxychloride has produced sulfone yields which exceed yields reported in the literature and obtained by more tedious methods. The presence of alkyl side groups on the benzene ring generally favors high yields of sulfone; whereas the presence of halogens generally reduces the yield. Sulfone formation is shown to be dependent upon the reactant ratios and upon the reaction time and …

The Electrolytic Refining Of Tellurim, Patsy Patrick Napolitano

Theses

The purpose of this investigation was to obtain new and to extend existing information on the method or methods used to produce high purity Tellurium using electrolytic refining methods. All available methods were investigated, in order to substantiate or disprove the available procedures. The main concern of this investigation is the outlined procedure to produce a metallic Tellurium product of 99.9999% purity. Any information which proved to be correct was used in attaining the ultimate goal of this thesis.

A literature search revealed only one good source of information. A United States patent, No. 2,258,963, dated October 14, 1941, issued …

Properties Of Non-Newtonian Fluids, George Robert Ferment

Theses

The purpose of this work was to investigate the fluid properties of non-Newtonian solutions.

The effect of temperature on the viscometric properties, flow behavior index (n) and fluid consistency index (K), was investigated. It was established that the flow behavior index was temperature dependent, tending to approach Newtonian behavior as the temperature was raised. The fluid consistency index was also temperature dependent; a plot of K vs temperature will yield a straight line on semilogarithmic coordinates.

The specific heats of non-Newtonian solutions were also determined. For systems containing large mass fractions of water, it was established that the presence of …

The Effect Of Liquid Surface Tension On Wire Mesh Entrainment Separators, Herbert Franklyn Schroeder

Theses

The effect of liquid surface tension on the capacity of a wire mesh entrainment separator was studied. An air-rater system was used and, the surface tension of the water was reduced through the use of surfactants.

Five test series were run, each with a different surface tension of water. The surface tensions examined covered the range of 30 dynes/cm to 70 dynes/cm. For each test run series, the effect of liquid loading was investigated. Liquid loading rates were varied between 55 and 550 lbs/hr/ft².

Entrainment separator capacity was found to vary linearly with liquid surface tension. As surface tension decreased, …

Packed Bed Heat Transfer, Anthony William Sposaro

Theses

The use of various published correlations to determine apparent thermal conductivities was found to give results of differing ma; magnitudes. For this reason when these values were utilized in the theoretical relationships proposed by McAdams:

tw-t2/tw-t1 = 0.692e^-23.14X + 0.1312e^-121.9X + 0.0535e^-299.6X

in which X is defined as

X = (KaL/CpGoD²t)

For packed bed systems the results were found to be inconsistent.

In this investigation a dimensionless equation:

Ka/kg = 0.00105 (DpGo/εpμ)^1.32

has been developed which permits the prediction of apparent thermal conductivities to air flowing through a 1 inch tube picked with glass …

Power Consumption In Horizontal Cylindrical Tanks, John J. Schlager

Theses

The general correlation of Power Number vs. Reynolds Number for flat six blade turbines in a horizontal cylindrical tank without baffles has been determined. The correlation has been found to apply to this system and corresponds to the 4 - 10% baffle region in the vertical cylindrical tank as determined by Rushton, et. al. ⁽¹⁾

An important variable to be considered is the length of tank to impeller diameter ratio which was found to seriously affect the power consumption.

A power fall off was observed at high Reynolds Numbers and coincided with visual vortexing. This power fall off was found …

Dimensional Stability And Acutance : An Investigation Into The Dimensional Properties Of Various Aerial Films And A Study Of Their Acutance, Basilio J. Battaglia

Theses

An experiment was run to determine if differences in drying temperature humidity conditions have any effect on the dimensional characteristics of five quite different aerial films used for various military applications. Acutance measurements were made from microdensitometer traces of each film-temperature and the data was statistically analysed.

Each sample was exposed through a precision stainless steel template to a density of about 1.0. Using an optical comparitor, the difference in size between the film and the template was measured to 10^-4 inch. As the image is circular, the size in any direction can be found by mere rotation on …

Contrast Threshold For A Spot On A Photographic Print, Myron A. Berkovitz

Theses

A psychophysical investigation was carried out to determine the contrast threshold (represented by a density difference) for a spot on a photographic print with a uniform background density. Problems associated with determining a single value which is represenative of the existing density difference between the spot and surround, resulted from the inherent density variation of photographic print material. A series of eighty density difference measurements of the spot and immediatly adjacent surround are presented for prints which had 0, 50, and 100% frequencies of spot detection. A discussion concerning how the eye may be responding in this type of a …

Heat Transfer Coefficients Of Non-Newtonian Slurries In Laminar Flow, Robert Frederick Roth, David B. Swanson

Theses

A total of 51 heat transfer runs were made in the first 25 runs, slurries of half micron and finer kaolin at 3.0, 5.6, 9.6 and 12.9% solids were used. Slurries of two microns and finer kaolin at 10.1, 13.7, 20.4 and 23.1% solids were used in the remaining 26 runs.

The Reynolds Numbers ranged from 0.9 to 2,020 for the 51 runs.

The data was correlated by the following equation:

H_f/C_bV_bP_b C_bR_b/K_b ^2/3 = 0.70 DV_bP_b/R_b ^-2/3

for an L/D ratio of …

Physical And Electrical Properties Of The Manganin-Type Alloys, Wallace William Macintosh

Theses

This thesis is a report on the physical and electrical properties of the manganin-type alloys as compiled from the published literature on the subject. The peculiarities of these alloys, as related to mechanical history, heat treatment, and composition, are discussed. Empirical formulae, by which the temperature coefficient of resistance, the temperature of maximum resistance, the temperature-resistance equation, and the thermoelectric emf of these alloys against copper may be calculated, are shown.

A comparison of the effect of elongation on the specific resistivity of several sizes of manganin wire is made on the basis of experimental results. The effect of impurities …

Catalytic Activity Studies In Aromatic Sulfonation, William Marvin Jayne Jr.

Theses

The object of this investigation has been to determine the catalytic activity of several inorganic materials in promoting the sulfonation of aromatic organic compounds. Initial work involved sulfonation of p-nitroaniline with an excess of sulfuric acid. However, due to insufficient precision of the method of analysis, this system was abandoned. Thereafter, the study was concerned chiefly with the benzene and other aromatic compounds in nitrobenzene solution. This phase of the work proved to be successful, and the results are reported in the text of the thesis.

The author gratefully acknowledges the suggestions and counsel given throughout these investigations by Professor …

Binary Vapor Liquid Equilibria Isobaric Systems, Ira Lichtenstein

Theses

Oalculations of activity coefficients for thirty isobaric binary systems from vapor-liquid equilibria data were made using the Gilmont equation© An extensive literature survey showed the Gilmont equation provides an excellent means of correlating equilibrium data in most binary isothermal systems° However, the Gilmont equation’s applicability to isobaric systems had not been satisfactorily proven, and became the object of this investigation.

The Gilmont equation gave satisfactory correlation of the binary isobaric data for various systems. The correlation was found to improve as the systems approached ideal behavior. The introduction of a temperature correction to the relative volatility, term improved the correlation …

Investigation Of The Stability And Response Of A Reboiler Under Condensate Control, Francis Arthur Winter

Theses

Control of heat flux by condensate throttling was investigated theoretically by frequency response analysis and experimentally on a simulated reboiler control system.

Transfer functions were derived for each component and ware used to describe the response of the experi- mental system. Experimental controller settings were in reasonable agreement with the calculated results. However, general overall control was poor because of dead time and cyclic disturbances. Experiments showed that the process contained dead time in the order of three to seven times the ultimate period (0.5 - 1.0 minutes). Several sources of disturbances prevented an accurate evaluation of stability at low …

Fugacity Coefficients Of Gases In Binary Mixtures, Louis David Mazzeii

Theses

A method of Pitzer for predicting component fugacity coefficients of gases in binary mixtures is evaluated by calculating 2100 fugacity coefficients and comparing the results to experimental data.

Pitzer employed the technique of Gamson and Watson in deriving an expression for fugacity coefficients. The expression is based on a three parameter corresponding states theory set of equations, and a definition of pseudo critical properties of mixtures, both previously proposed by Pitzer.

A further comparison with values calculated by similar methods of Edmister and Ruby, and Redlich et al (which previously were established as the most accurate general methods) indicates Pitzer's …

Thermodynamic Properties Of Hydrazine, Michael Perlswieg

Theses

The thermodynamic properties of hydrazine have been evaluated for the saturated region and for the superheated vapor. The superheated vapor properties were determined for temperatures up to 2200°F and pressures to 3000 psia. Enthalpy, entropy, and specific volume are reported for the saturated vapor and liquid and the superheated vapor. Results are reported in the form of tables.

Enthalpy values are relative to the saturated liquid at 32°F. Entropy values are absolute. The thermodynamic properties have been based on experimental data where possible. Due to the lack of experimental pressure-volume-temperature data, however, the generalized correlations of Lydersen, Greenkorn, and Hougen …

Thermodynamic Properties Of Formaldehyde, Raymond H. Koo

Theses

The thermodynamic properties of saturated and superheated formaldehyde were evaluated at ten degree temperature intervals from -19°C. to 400°C. and at various pressures up to 150 atmospheres.

Lydersen's correlations were used to estimate the critical constants.

Vapor pressure data were calculated using Riedel's method.

The generalized thermodynamic correlations of Hougen, Lydersen,'and Greenkorn were employed to obtain values of the thermodynamic properties in the saturated and superheated regions.

The values for temperature, pressure, specific volume, enthalpy, and entropy for saturated and super-heated formaldehyde are presented in the form of tables and graphs.

Effect Of Cleaning Methods Upon Electrochemical Behavior Of High-Carbon Steel Cathodes In A Chromic Acid Electrolyte, George Chaplenko

Theses

The quality of electrodeposited coatings is to a great ex- tent determined by cleaning or surface-conditioning methods employed in preparing the basis metal for plating. Cleaning pro- cedures are usually established empirically, by trial and error. Little or no experimental work was devoted to a quantitative stu- dy of measurable parameters that are influenced by the relative effectiveness of individual cleaning processes. The present ex- periment was designed in an attempt to establish a correlation between one such parameter (namely, the single-electrode poten- tial of polarized cathode) and the quality of subsequent plating.

High-carbon steel cathodes, -a material that is …

Structure, Wood, And The Form Of Furniture, William Keyser

Theses

None provided.

Hiding Power Of White Pigments : Theory And Measurement, Parker Bovaird Mitton, Lawrence Vejnoska

Theses

Optical properties of pigmented films such as hiding power, scattering coefficient, and absorption coefficient were measured at three bands of wavelength of light (blue, green, red) for ten white pigments at seven pigment concentrations in a paint. These pigments range from the highest index of refraction (rutile) to the very low index of an extender pigment (CaC031); they range from a fine particle size (average 0.2 microns) to a relatively coarse size (average 2.2 microns).

Among the findings presented below the first two confirm the general observations of pigment behavior found by others; the rest of the findings are new. …