Physical Sciences and Mathematics Commons^™

Impact Of The Municipal Solid Waste Incineration Plant In Warsaw On Air Quality, Robert Oleniacz

Robert Oleniacz

The only Polish municipal solid waste (MSW) incinerator has been operating within the Municipal Solid Waste Disposal Plant in Warsaw since 2000. In the paper selected results of the air quality impact assessment for this incinerator during an operating period of one year (2008) are presented. With respect to the incinerated waste amounts and emission levels, the analysed period can be considered typical for this facility. Assessment of the air quality impact was carried out by assessing air pollutant emissions in reference to the applicable emission limit values and by modeling atmospheric dispersion of these pollutants. It has been found …

Ocena Wpływu Na Jakość Powietrza Procesu Przygotowania Obszaru Wiertni Przy Poszukiwaniach Gazu Z Łupków, Marek Bogacki, Robert Oleniacz, Monika Janicka

Robert Oleniacz

This chapter presents the model calculation results of the level of concentration of air pollutants emitted during works related to the preparation of the drilling pad for the shale gas exploration. The most significant emission sources located in the drilling pad, including rig access roads, paved and unpaved, were analyzed. The emission field was defined by the parameterization of various sources/processes, taking into account the technical, technological, organizational and environmental conditions. The calculations of the pollutants dispersion in the air were carried out using the Gaussian reference model. The results of numerical calculations showed that the only substance likely to …

Ocena Efektów Termomodernizacji Budynków Jednorodzinnych. 2. Ograniczenie Wpływu Na Jakość Powietrza Atmosferycznego, Robert Oleniacz, Magdalena Kasietczuk, Mateusz Rzeszutek

Robert Oleniacz

The article assesses to what extent reduced the impact on air quality of a complex of detached coal-fired houses as a result of some thermal renovation works which lowered the fuel consumption and reduced emissions of pollutants into the air. The assessment was done on the basis of results of dispersion modelling for selected substances (SO2, NO2, CO, PM10, B(a)P and PCDD/F) in the ambient air with the use of CALMET/CALPUFF models. The calculation process encompassed preparation of the data on spatial features of the area, making a three-dimensional grid of meteorological data, definition of geometrical parameters of substitute emitters …

Niekontrolowane Spalanie Odpadów I Pozostałości Roślinnych Na Terenach Wiejskich – Przykład Inwentaryzacji Źródeł Emisji I Oceny Wpływu Na Jakość Powietrza, Robert Oleniacz, Barbara Bacik, Marcelina Spiszak

Robert Oleniacz

The most troublesome air pollutant emissions that occur in rural areas are associated with the operation of domestic furnaces (mainly during the heating season) and the processes of open burning of plant residues (mainly outside the heating season). The paper presents an example of emission inventory for this type of sources in two submontane villages of Małopolska Voivodeship (Poland) based on the results of the questionnaire survey and an attempt to assess the impact on air quality of these sources, including the potential uncontrolled burning of waste.The conducted questionnaire survey showed the use to home heating mainly solid fuels (first …

Assessment Of The Impact Of Municipal Waste Incineration Plants On Air Quality And The Possibilities Of Its Reduction, Robert Oleniacz

Robert Oleniacz

The planned construction of new municipal waste incineration plants over the next few years in Poland results in protests of local communities, which arise mainly from fear of an increase in the air pollution in its vicinity. These protests extend the investment process and hinder the selection of incineration plant location, but on the other hand they necessitate the use of more efficient solutions to reduce their impact on the air quality.This paper characterizes the world's most widely used technology for municipal solid waste incineration (MSWI) and assesses the possible maximum impact on the air quality of an exemplary MSWI …

Co-Incineration Of Large Quantities Of Alternative Fuels In A Cement Kiln – The Problem Of Air Pollutant Emissions, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

Over the last few years, a significant increase in the use of alternative fuels in the Polish cement industry has been observed. These are mainly waste and waste-derived fuels. The national leader in this field is Chełm cement plant (Poland), with the share of alternative fuels in the cement kiln heat balance reaching in 2012 the level of 78.5%. In this paper, an analysis of the emission rate of air pollutants from cement clinkering process in the above-mentioned cement plant in the years 1998–2012 was carried out, using the results of continuous and periodic measurements. The compliance with the emission …

Air Pollution Emissions During Baking Of Semi-Finished Graphite Products In A Tunnel Furnace, Marek Bogacki, Robert Oleniacz, Marian Mazur

Robert Oleniacz

The baking of semi-finished graphite products in a tunnel furnace is the source of many air pollutants present in both the gaseous and solid phases. The goal of this study was to assess emission rates into the air of the substances such as: CO, NOx, SO2, H2S, CH4, aliphatic hydrocarbons up to C6, benzene and its homologues (BTEX), total dust and tar substances, and polycyclic aromatic hydrocarbons (PAHs) contained in the dust. The research showed a small time-dependence of the emission rates for the majority of the substances analysed, which is, to a large extent, a result of the long …

Wpływ Procesu Współspalania Odpadów W Piecu Cementowym Na Jakość Powietrza / Impact Of Waste Co-Incineration Process In A Cement Kiln On Air Quality, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

The work presents the general requirements for the control of emissions to air from waste co-combustion (co-incineration) plants, with particular emphasis on rotary kilns used for clinker production. Air emissions from the cement kiln during co-combustion of alternative fuels and the impact assessment on air quality are also presented. The object of the study was one of the Polish cement plant, which uses significant amounts of solid waste derived fuels (with over 70% share in the cement kiln heat balance). Assessment of the impact on air quality was made based on the results of the modeling of atmospheric dispersion of …

Współspalanie Odpadów W Suchym Piecu Cementowym A Emisja Dwutlenku Siarki I Chlorowodoru, Robert Oleniacz

Robert Oleniacz

The paper presents an assessment of the impact of waste co-combustion in a cement kiln on air emissions of HCl and SO2 recorded continuously. The subject of the research was cement kiln (dry method) with a capacity of 8500 Mg/day, equipped with a four cyclone heat exchangers and a calciner with an additional chamber for co-incineration. In the analysed period alternative fuels (mainly waste) were used in various amounts ranging up to about 35 kg / Mg clinker (with the heat substitution up to 20%) in the kiln and calciner. Chlorine and sulfur inputs to the process were up to …

Emisja Zanieczyszczeń Pyłowo-Gazowych Z Procesu Wypalania Półproduktów Grafitowych W Piecu Tunelowym, Marek Bogacki, Robert Oleniacz, Marian Mazur, Przemysław Szczygłowski

Robert Oleniacz

The baking of semi-finished graphite products in a tunnel furnace is the source of many air pollutants present in both the gaseous and solid phases. The goal of this study was to assess emission rates into the air of the substances such as: CO, NOx, SO2, H2S, CH4, aliphatic hydrocarbons up to C6, benzene and its homologues (BTEX), total dust and tar substances, and polycyclic aromatic hydrocarbons (PAHs) contained in the dust. The research showed a small time-dependence of the emission rates for the majority of the substances analysed, which is, to a large extent, a result of the long …

Ocena Wpływu Arcelormittal Poland S.A. Oddział W Krakowie Na Jakość Powietrza, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

The work presents selected results of atmospheric dispersion modeling and air quality impact assessment for pollutant emissions from installations of ArcelorMittal Poland S.A. Unit in Krakow (Poland). The assessment was carried out for the most unfavourable emission variant probable to take place in the period 2007-2016. In the calculations were taken into consideration typical for steelworks particle matter pollutants (total dust, heavy metals, tar substances and PAHs including benzo-a-piren) and gaseous substances (SO2, NO2, CO, HC, HCl, HF, NH3, HCN, H2S, CS2, H2SO4, BTX, phenol and pyridine). As the result of estimations, carried out according to the Polish reference method …

Air Pollutant Emissions From Process Of Mixing Materials Used For Manufacturing Small Products From Carbon And Graphite, Marian Mazur, Marek Bogacki, Robert Oleniacz, Przemysław Szczygłowski

Robert Oleniacz

The paper characterises the method of preparing the HCC and Rubba-type materials used to manufacture small carbon and graphite products, and the composition of waste gases escaping from the mixers for these materials. For the process of mixing the two materials under examination, two measurement series were completed, mainly covering the period from when the binder was added to the properly pre-heated dry mass until the mixer discharged. The results shown apply only to those substances which occur just in the gaseous phase, that is CO, CO2, O2, H2, aliphatic hydrocarbons (C1-C6) and BTX (benzene, toluene, ethylbenzene and xylene) as …

Ocena Skuteczności Działania Suchego Systemu Oczyszczania Spalin Ze Spalania Odpadów Medycznych Opartego Na Wtrysku Sorbentu Wapniowo-Węglowego, Robert Oleniacz

Robert Oleniacz

The research object was a medical waste incineration plant with a capacity of 150 kg per hour equipped with a flue gas treatment system based on dry sorption process using a lime-carbon reagent with adsorbent removing in high-efficiency particulate collector. As the dry sorption agent was used a mixture of high reactive hydrated lime and activated carbon injected to combustion gases by pneumatic feeder. Activated carbon content in the mixture was 5-10 % by mass. Applied collector was ceramic filter with total filtration area of 120 m2 and guaranteed outlet dust concentration under 5 mg/Nm3. Among others things the aims …

Wpływ Dużej Spalarni Odpadów Przemysłowych I Niebezpiecznych Na Jakość Powietrza, Robert Oleniacz, Lidia Rusztowicz

Robert Oleniacz

Waste incineration causes unavoidable pollutant emissions to atmosphere and thus negative impact on air quality, but scale of the influence is often exaggerated. In the paper computation results of the atmospheric dispersion of pollutants were presented for one of the largest industrial and hazardous waste incineration plant existing in Poland (processing capacity: 3 ton per hour). These results confirm the fact that the incinerator meets the requirements of best available techniques (BAT) for the waste incineration and its impact on air quality is relatively small. This effect is caused mainly by proper operation of the rotary kiln incinerator, high efficiency …

Analiza Możliwości Ograniczenia Emisji Zanieczyszczeń Powietrza Z Instalacji Spalania Odpadów Medycznych W Tarnowie, Robert Oleniacz

Robert Oleniacz

The paper presents initial research of effects of some factors on the amount of gaseous pollutants formation during medical waste incineration in a two-stage starved air fluidised bed reactor. In the research was included the impact of such factors as oxygen contents in flue gases, frequency of waste loading, momentary mass flow of waste and temperature in the secondary combustion chambers. Measurements showed that the waste incineration in large amount periodically caused excessive emissions incomplete combustion products (CO, HC), especially during wrong operation of the combustion system. The work demonstrated that the essential importance for CO and HC formation reducing …

Emisja Zanieczyszczeń Z Pieca Achesona Do Grafityzacji Wyrobów Drobnych, Marian Mazur, Robert Oleniacz, Marek Bogacki, Przemysław Szczygłowski

Robert Oleniacz

Research results of the air pollutant emissions from the graphitisation process of fine products in the Acheson electric resistance furnace (discharge capacity 5,5 Mg) were presented in the paper. Research was performed for two kinds of raw material inputs (based on petroleum coke and pitch coke). Approximately 40-hours measurement series were carried out for each material including mainly such substances like carbon monoxide, hydrocarbons, nitrogen oxides, sulphur dioxide, hydrogen sulphide, carbon disulphide, ammonia, benzene, toluene, xylenes, total dust, tar substances and polycyclic aromatic hydrocarbons. Both average and maximum concentrations and mass streams in the flue gases and average emission factors …

Emisja Zanieczyszczeń Ze Spalania Odpadów Podestylacyjnych Z Produkcji Witaminy C W Piecu Fluidalnym, Robert Oleniacz

Robert Oleniacz

Some results of continuous or periodical measurements of selected air pollutant concentrations and mass streams in the flue gases from liquid waste incineration in a fluidized bed incinerator were presented in the paper. During the researches distillation tails from vitamin C production, that is waste traces from regeneration such solvents as for example ethylene chloride, chloroform or trichloroethylene were incinerated. As a result of the researches there was determined optimal temperature of the fluidized bad in which the waste incineration should be carried out to minimization of CO and NOx formation. Required effectiveness of HCl removal from combustion gases to …

Emisja Chlorowodoru Ze Spalania Węgla W Kotle Pyłowym, Marian Mazur, Robert Oleniacz, Przemysław Szczygłowski, Marek Bogacki

Robert Oleniacz

Emission of hydrogen chloride (HCl) from coal combustion is not controlled just like for example sulpfur dioxide emission. But HCl emission is also important, because chlorine content in some types of coal can reach the similar level to sulfur content. In the paper the measurement results of HCl emission to the air during combustion of three types of coal with law content of chlorine were presented. The researches were carried out for a steam pulverized coal boiler (max. boiler efficiency – 430 t/h) during three various loads (respectively 65, 80 and 95 % of maximum efficiency) without flue gas desulfurization. …

Metoda Oceny Trudności Oczyszczania I Toksyczności Spalin Powstających Podczas Spalania Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents a methodology for evaluating the cleaning difficulty and toxicity of combustion gases from waste incineration based on the knowledge of gases composition. This type of evaluation may be applicable to selection or modernization of flue gas cleaning systems for waste incineration plants and to comparative analy-sis of a pollution degree of raw (unclean) combustion gases. In the evaluation of the cleaning difficulty of gases six categories of difficulty have been identified for removal of selected substances or groups of substances. The evaluation is made individually for substances or groups of substances on condition their concentrations in flue …

Влияние На Окружающую Среду Технологии Непрерывного Литья, Marian Mazur, Marek Bogacki, Robert Oleniacz, Agnieszka Łopata

Robert Oleniacz

This article presents a complex analysis of the impact of the technology of continuous casting of steel (CCS) on the rate of the air pollutant emissions from one of the Polish steel and iron plants. The emission sources occurring in the production process have been identified and their rate has been determined. The implementation of CCS has brought about significant changes in the production cycle of the steel plant and it also has caused an increase of the production effectiveness of steel products. The calculated environment effects have shown a considerable emission decrease of all pollutants in the scale of …

Termiczne Przekształcanie Odpadów Medycznych W Instalacji Fluidalnej Firmy Seghers – Emisja Zanieczyszczeń Gazowych I Możliwości Jej Ograniczenia, Robert Oleniacz

Robert Oleniacz

The paper presents the results of measurements of concentrations and mass streams of selected components in the flue gases from the thermal treatment of medical waste in the Seghers incinerator based on fluidized bed reactor.

The tests were carried out at the measuring points located both before and after of the flue-gas cleaning system based on the injection of dry hydrated lime and carbon sorbent and a ceramic filter. In this way it was possible to determine the effectiveness of the removal of selected air pollutants in the dry cleaning system. Analysis of the results of measurements made ​​it possible …

Przebieg Zmienności Stężeń Wybranych Zanieczyszczeń W Gazach Odlotowych Z Procesu Mokrego Gaszenia Koksu, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

Continuous measurement results of selected constituent concentrations in the gases emitted to the air during the coke wet quenching process were presented and discussed in the paper. The measurements were carried out for the standard wet quenching tower. The research covered such substances as carbon dioxide, carbon monoxide, hydrogen sulfide, nitrogen oxide, nitrogen dioxide and a total content of hydrocarbons and hydrogen (combustible gases). Changeability of the substance concentrations depending of the quenching process duration was analyzed. Among other things the beginning of these substances formation, appearance of the maximum and the range of observed concentrations were taken into consideration. …

Weryfikacja Emisji Pyłowej Z Huty Katowice I Zasięgu Jej Oddziaływania, Marian Mazur, Robert Oleniacz, Marek Bogacki, Agnieszka Łopata

Robert Oleniacz

Preliminary analysis of the results of atmospheric dispersion modeling for dust emission from the Katowice Steelworks (Poland) showed necessity of verification the particulate matter, lead and cadmium emission from the plant. The verification was limited to the substance emission sources influencing air pollution to the largest extent. Both scale of dust emission and its granulometric and chemical composition were re-evaluated. Further calculations of the air propagation for the pollutants were carried out and calculation results were compared with direct measurements. Thus the Katowice Steelworks impact on air quality and the level of total dust, lead and cadmium ground deposition was …

Ocena Składu Gazów Odlotowych Z Procesów Spopielania Odpadów Niebezpiecznych Pod Kątem Trudności Oczyszczania I Toksyczności, Robert Oleniacz

Robert Oleniacz

Tightening of the European Union law in the field of the air emission limit values from waste incineration causes necessity for existing and new incineration plants to conform to the standards. It will often involve modernization of the flue gas cleaning system. Proposed in the paper the methodology of evaluation of the combustion gases composition in point of view cleaning difficulty should be useful to this end. Average toxicity factors for hazardous waste incineration flue gases were defined as well. Among other things they can be used in comparative analysis of the air pollutant concentration in the raw gas (before …

Czynniki Wpływające Na Skład Spalin I Wielkość Emisji Zanieczyszczeń Z Procesów Termicznego Przekształcania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The work summarizes factors influencing on air emissions from various full-scale hazardous waste incinerators (rotary kiln, multiple hearth furnace, starved-air incinerator, fluidized bed incinerator, liquid injection incinerator). Air pollutant emissions from hazardous waste incineration can be minimized not only by flue-gas cleaning. There are many factors that influence on flue-gas composition and the quantity of air pollutants formed during incineration: the type, the composition and the quantity of waste, the way of waste introducing to the incinerator, excess air ratio, combustion temperature, retention time of exhaust gases etc. Special attention was paid to the loading of waste and incineration conditions …

Ocena Udziału Huty Katowice W Poziomie Opadu Pyłu, Ołowiu I Kadmu Na Powierzchnię Terenu Wokół Zakładu, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the results of modeling of deposition on the land surface of dust, lead and cadmium emitted from the "Katowice" Steelworks. The calculations were carried out in the vicinity of the location of the dust deposition measuring points existing around the plant. Computational data were compared with the results obtained from direct measurements for the same calendar year. The responsibility of this plant in shaping the level of dust and heavy metal deposition in the region of the protective zone was determined.

English title: Participation of the "Katowice" Steelworks in the level of dust, lead and cadmium deposition …

Prognoza Wpływu Na Stan Zanieczyszczenia Powietrza Procesu Unieszkodliwiania Odpadów Pestycydowych W Piecu Cementowym, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

The paper presents the general conditions associated with running of pesticide waste co-incineration in rotary kilns for cement clinker burning, and describes the behavior of toxic substances entering to this process with waste materials or forming as the result of thermal decomposition. Additional air emissions and their impact on air quality were also assessed.

English title: Prediction of the impact on the state of air pollution for the process of pesticide waste disposal in a cement kiln.

Dobór Systemu Oczyszczania Gazów Odlotowych Ze Spalania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The flue gas cleaning system is usually one of the most costly elements of the installation to the incineration of hazardous waste. Adapting the system to the actual needs could therefore bring obvious economic benefits.

The paper presents the method of the preselection of the configuration of the cleaning system based on knowledge of the level of concentration of selected components of the raw exhaust gas (sulfur dioxide, hydrogen chloride, hydrogen fluoride, total dust, mercury, cadmium and thallium, and other heavy metals). Twelve examples of flue-gas cleaning systems were proposed and extreme concentration values of the substances in the raw …

Niezorganizowana Emisja Zanieczyszczeń Powietrza Z Hal Ciągłego Odlewania Stali, Marian Mazur, Marek Bogacki, Robert Oleniacz, Agnieszka Łopata

Robert Oleniacz

Air pollutant emissions occurring in an uncontrolled way do not be subject to the regular verification just like it takes place in case of the controlled sources, for which the routine measurements are carried out. In the paper a methodology and the results of some research were presented. The research consisted in determination the quantity of dust and gaseous pollutants emitted from the halls in which technological processes connected with the steel continuous casting were being run. Stocktaking of all the uncontrolled emission sources were carried out and the technological operations predominating in the level of the particle matter and …

Struktura Emisji Związków Fluoru Z Hutnictwa Żelaza Na Przykładzie Huty Katowice, Marian Mazur, Robert Oleniacz, Marek Bogacki

Robert Oleniacz

As recently as a dozen or so years ago ferrous metallurgy was known as one of the biggest source of fluorine compound emissions to the atmosphere. Nevertheless production technology and raw material changes occurring in this industry cause continuous decreasing of their participation in the total fluorine emission. On the ground of investigations that have been carried out in the Katowice Steelworks (Poland) in the last few years, participation of particular technological processing in the water-soluble fluorine compound emissions (which are regarded as toxic) were presented in the paper, as well as a position of fuel combustion process (that take …