Open Access. Powered by Scholars. Published by Universities.®

Engineering Commons™

Open Access. Powered by Scholars. Published by Universities.®

2015

Bioenergy

Articles 1 - 9 of 9

Full-Text Articles in Engineering

Engineering, Nutrient Removal, And Feedstock Conversion Evaluations Of Four Corn Stover Harvest Scenarios, Reed L. Hoskinson, Douglas L. Karlen, Stuart J. Birrell, Corey W. Radtke, W. W. Wilhelm Dec 2015

Engineering, Nutrient Removal, And Feedstock Conversion Evaluations Of Four Corn Stover Harvest Scenarios, Reed L. Hoskinson, Douglas L. Karlen, Stuart J. Birrell, Corey W. Radtke, W. W. Wilhelm

Douglas L Karlen

Crop residue has been identified as a near-term source of biomass for renewable fuel, heat, power, chemicals and other bio-materials. A prototype one-pass harvest system was used to collect residue samples from a corn (Zea mays L.) field near Ames, IA. Four harvest scenarios (low cut, high-cut top, high-cut bottom, and normal cut) were evaluated and are expressed as collected stover harvest indices (CSHI). High-cut top and high-cut bottom samples were obtained from the same plot in separate operations. Chemical composition, dilute acid pretreatment response, ethanol conversion yield and efficiency, and thermochemical conversion for each scenario were determined. Mean grain …

Go to article

Multilocation Corn Stover Harvest Effects On Crop Yields And Nutrient Removal, Douglas L. Karlen, Stuart J. Birrell, Jane M. F. Johnson, Shannon L. Osborne, Thomas E. Schumacher, Gary E. Varvel, Richard B. Ferguson, Jeff M. Novak, James R. Fredrick, John M. Baker, John A. Lamb, Paul R. Adler, Greg W. Roth, Emerson D. Nafziger Dec 2015

Multilocation Corn Stover Harvest Effects On Crop Yields And Nutrient Removal, Douglas L. Karlen, Stuart J. Birrell, Jane M. F. Johnson, Shannon L. Osborne, Thomas E. Schumacher, Gary E. Varvel, Richard B. Ferguson, Jeff M. Novak, James R. Fredrick, John M. Baker, John A. Lamb, Paul R. Adler, Greg W. Roth, Emerson D. Nafziger

Douglas L Karlen

Corn (Zea mays L.) stover was identified as an important feedstock for cellulosic bioenergy production because of the extensive area upon which the crop is already grown. This report summarizes 239 site-years of field research examining effects of zero, moderate, and high stover removal rates at 36 sites in seven different states. Grain and stover yields from all sites as well as N, P, and K removal from 28 sites are summarized for nine longitude and six latitude bands, two tillage practices (conventional vs no tillage), two stover-harvest methods (machine vs calculated), and two crop rotations {continuous corn (maize) …

Go to article

Corn Grain, Stover Yield And Nutrient Removal Validations At Regional Partnership Sites, Douglas L. Karlen, Stuart J. Birrell, Jane M. F. Johnson, Shannon L. Osborne, Thomas E. Schumacher, Gary E. Varvel, Richard B. Ferguson, Jeff M. Novak, James R. Fredrick, John M. Baker, John A. Lamb, Paul R. Adler, Greg W. Roth, Emerson D. Nafziger Dec 2015

Corn Grain, Stover Yield And Nutrient Removal Validations At Regional Partnership Sites, Douglas L. Karlen, Stuart J. Birrell, Jane M. F. Johnson, Shannon L. Osborne, Thomas E. Schumacher, Gary E. Varvel, Richard B. Ferguson, Jeff M. Novak, James R. Fredrick, John M. Baker, John A. Lamb, Paul R. Adler, Greg W. Roth, Emerson D. Nafziger

Douglas L Karlen

Corn (Zea mays L.) stover has been identified as a major feedstock for cellulosic bioenergy. This report summarizes grain and stover yield as well as N, P, and K removal at several Sun Grant Regional Partnership (SGRP) sites. National Agricultural Statistical Service (NASS) grain yields were used to assess the relevancy of plot-scale yields with county averages. Seasonal variation in weather patterns caused yields to differ substantially among sites and years. Nutrient removal estimates were significantly influenced by the sampling method (i.e. analysis of hand samples between physiologic maturity and grain harvest versus stover collected during the harvest operation). Based …

Go to article

Development Of Sustainable Corn Stover Harvest Strategies For Cellulosic Ethanol Production, Stuart J. Birrell, Douglas L. Karlen, Adam Wirt Dec 2015

Development Of Sustainable Corn Stover Harvest Strategies For Cellulosic Ethanol Production, Stuart J. Birrell, Douglas L. Karlen, Adam Wirt

Douglas L Karlen

To prepare for a 2014 launch of commercial scale cellulosic ethanol production from corn/maize (Zea mays L.) stover, POET-DSM near Emmetsburg, IA has been working with farmers, researchers, and equipment dealers through “Project Liberty” on harvest, transportation, and storage logistics of corn stover for the past several years. Our objective was to evaluate seven stover harvest strategies within a 50-ha (125 acres) site on very deep, moderately well to poorly drained Mollisols, developed in calcareous glacial till. The treatments included the following: conventional grain harvest (no stover harvest), grain plus a second-pass rake and bale stover harvest, and single-pass …

Go to article

Compounds Released From Biomass Deconstruction: Understanding Their Effect On Cellulose Enzyme Hydrolysis And Their Biological Activity, Angele Djioleu Dec 2015

Compounds Released From Biomass Deconstruction: Understanding Their Effect On Cellulose Enzyme Hydrolysis And Their Biological Activity, Angele Djioleu

Graduate Theses and Dissertations

The effect of compounds produced during biomass pretreatment on cellulolytic enzyme was investigated. Liquid prehydrolyzates were prepared by pretreating switchgrass using 24 combinations of temperature, time, and sulfuric acid concentration based on a full factorial design. Temperature was varied from 140°C to 180°C; time ranged from 10 to 40 min; and the sulfuric acid concentrations were 0.5% or 1% (v/v). Identified products in the prehydrolyzates included xylose, glucose, hydroxymethylfurfural (HMF), furfural, acetic acid, formic acid, and phenolic compounds at concentration ranging from 0 to 21.4 g/L. Pretreatment conditions significantly affected the concentrations of compounds detected in prehydrolyzates. When assayed in …

Go to article

High-Solids Anaerobic Digestion Of The Organic Fraction Of Municipal Solid Waste State Of The Art, Outlook In Florida, And Enhancing Methane Yields From Lignocellulosic Wastes, Gregory Richard Hinds Oct 2015

High-Solids Anaerobic Digestion Of The Organic Fraction Of Municipal Solid Waste State Of The Art, Outlook In Florida, And Enhancing Methane Yields From Lignocellulosic Wastes, Gregory Richard Hinds

USF Tampa Graduate Theses and Dissertations

Anaerobic digestion (AD) is a biotechnology that employs natural microbial metabolism under oxygen-free conditions to stabilize organic waste. AD has been shown to be the most environmentally sustainable technology for treating the organic fraction of municipal solid waste (OFMSW), as it allows for the recovery of energy and nutrients from the waste. AD of OFMSW also saves landfill space and reduces leachate generation and fugitive methane emissions from landfills. High-solids AD (HS-AD) technologies (those designed to process feedstocks with >15% total solids content) have been shown to yield additional benefits when compared with liquid AD (L-AD) for treating OFMSW, including …

Go to article

Application Of 3d Printing Technology In Porous Anode Fabrication For Enhanced Power Output Of Microbial Fuel Cells, Bin Bian Sep 2015

Application Of 3d Printing Technology In Porous Anode Fabrication For Enhanced Power Output Of Microbial Fuel Cells, Bin Bian

Electronic Thesis and Dissertation Repository

Microbial fuel cells (MFCs) are widely researched for application in wastewater treatment. However, the current anodes used in MFCs often suffer from high fabrication cost and uncontrollable pore sizes. In this thesis, three-dimensional printing technique was utilized to fabricate anodes with different micro pore sizes for MFCs. Copper coating and carbonization were applied to the printed polymer anodes to increase the conductivity and specific surface area. Voltages of MFCs with various anodes were measured as well as other electrochemical tests such as linear sweep voltammetry and electrochemical impedance spectroscopy. 3D copper porous anode produced higher maximum voltages and power densities …

Go to article

Uintah Basin’S Wastewater Evaporation Ponds Could Yield Bioenergy | Biological Engineering, Usu College Of Engineering Sep 2015

Uintah Basin’S Wastewater Evaporation Ponds Could Yield Bioenergy | Biological Engineering, Usu College Of Engineering

College of Engineering News

LOGAN, Utah, Sept. 15, 2015 – The wastewater evaporation ponds that support the oil and natural gas extraction industries in the Uintah Basin may soon help spur the development of alternative bio-based fuels.

Go to article

Modeling Water Quality For Switchgrass Crop Production: Implications For Bioenergy Sustainability In East Tennessee, Zachariah Tzvi Seiden Aug 2015

Modeling Water Quality For Switchgrass Crop Production: Implications For Bioenergy Sustainability In East Tennessee, Zachariah Tzvi Seiden

Masters Theses

With passing of the US Energy Independence and Security Act (EISA) of 2007, there has been considerable research conducted on the sustainability of bioenergy crop production in the United States; switchgrass has shown particular potential for bioenergy production in East Tennessee. Many studies evaluating the environmental impact switchgrass has on runoff and water quality use the Soil and Water Assessment Tool (SWAT) for watershed modeling. Because SWAT is a lumped watershed model, it evaluates the result of hydrological processes for each hydrologic response unit (HRU), without accounting for the physical interactions between these HRUs. The Water Erosion Prediction Project (WEPP) …

Go to article