Engineering Commons^™

Design, Construction, And Preliminary Testing Of A Square Cross-Sectional Mixing Chamber, Holly Holmes-Smith

Chemical Engineering Undergraduate Honors Theses

Throughout the US, large quantities of chlorine are produced and transported by rail. In the past, train accidents led to deadly accidental releases and the need for mass evacuation. However, moving people unnecessarily may cause pandemonium or danger to health for sensitive members of the public. In these past cases, the models used for evacuation distances did not accurately predict the impact of the chlorine release, but these models did not take into account the reactivity of chlorine. Because chlorine is a highly reactive gas, it is absorbed into the surrounding environment which reduced the amount of chlorine in the …

Chlorpyrifos Removal For Wastewater Reuse, Indran Kamalanathan

Chemical Engineering Undergraduate Honors Theses

Approximately 1.2 billion people around the world live in areas of physical water scarcity. This could increase to half of the world’s population by 2030 and could displace 24 to 700 million people unless steps are taken to ensure adequate water supply.¹ Water scarcity is an escalating issue within the United States, specifically in Western inland states with arid climates. This scarcity is encouraging communities to investigate tertiary level municipal wastewater treatment, allowing for reuse of wastewater. Unfortunately, wastewater contains numerous contaminants that are not regulated by the Environmental Protection Agency (EPA) under the Safe Drinking Water Act (SDWA). …

Haul Truck Tires Recycling, Omkar Bhave

Chemical Engineering Undergraduate Honors Theses

The disposal of large Off-the-Road (OTR) tires is an increasingly important concern. These tires can weigh up to 8,450 pounds with an overall diameter and width of approximately 140.7 inches and 45.1 inches respectively. OTR tires are used for mining vehicles such as haul trucks, wheel loaders, backhoes, graders, and trenchers.[1] These new tires cost between $38,000 and $50,000 each, depending on multiple factors including oil prices and the cyclical nature of the industry. Haul trucks contain six tires per vehicle, and mines replace these tires around every 9-12 months.[2] Statistics regarding discarded OTR tires are not provided by the …

Electrodeionization Versus Electrodialysis: A Clean-Up Of Produced Water In Hydraulic Fracturing, Brigitte Marie Rodgers

Graduate Theses and Dissertations

Electrodeionization (EDI) is a widely studied process ranging from applications in wastewater clean-up in the food and beverage industry to purifying organic compounds. To date, there are no apparent studies on applying this technology to produced wastewater recovered from hydraulic fracking sites. Water consumption within hydraulic fracturing sites can reach in the upwards of millions of gallons per site, so a need for a water recycling process becomes necessary within areas where water requirements are scarce. Implementation of an EDI module that is capable of handling high salt solutions from produced wastewater in subsequent fracturing practices will decrease overall water …

Nanofiltration Rejection Of Contaminants Of Emerging Concern From Municipal Water Resource Recovery Facility Secondary Effluents For Potable Reuse Applications, Steven Michael Jones

Graduate Theses and Dissertations

As reuse of municipal water resource recovery facility (WRRF) effluent becomes vital to augment diminishing fresh drinking water resources, concern exists that conventional barriers may prove deficient and the upcycling of contaminants of emerging concern (CECs) could prove harmful to human health and aquatic species if more effective and robust treatment barriers are not in place.

There are no federal Safe Drinking Water Act (SDWA) regulations in place specifically for direct potable reuse (DPR) of WRRF effluent. Out of necessity, some states are developing their own DPR reuse regulations. Currently, reverse osmosis (RO) is the default full advanced treatment (FAT) …

Werc Task #1 - Open: Efficiency And Particulate Matter Emissions Testing Of Wood Burning Heating Units, Teni R. Butler

Chemical Engineering Undergraduate Honors Theses

Wood burning has significant environmental and health impacts. This research focused on creating low-cost, reliable test methods for identifying particulate matter emissions to the atmosphere, while obtaining essential data for efficiency calculations of wood combustion.

Wastewater Reuse, Zachary J. Bare

Chemical Engineering Undergraduate Honors Theses

Approximately 1.2 billion people around the world live in areas of physical water scarcity. This could increase to half of the world’s population by 2030 and could displace 24 to 700 million people unless steps are taken to ensure adequate water supply. Water scarcity is an escalating issue within the United States, specifically in Western inland states with arid climates. This scarcity is encouraging communities to investigate tertiary level municipal wastewater treatment, allowing for reuse of wastewater. Unfortunately, wastewater contains numerous contaminants that are not regulated by the Environmental Protection Agency (EPA) under the Safe Drinking Water Act (SDWA). Many …

Removal Of Endocrine Disrupting Compounds From Secondary Municipal Wastewater, Dustin R. Resz

Chemical Engineering Undergraduate Honors Theses

Approximately 1.2 billion people around the world live in areas of physical water scarcity. This could increase to half of the world’s population by 2030 and could displace 24 to 700 million people unless steps are taken to ensure adequate water supply.1 Water scarcity is an escalating issue within the United States, specifically in Western inland states with arid climates. This scarcity is encouraging communities to investigate tertiary level municipal wastewater treatment, allowing for reuse of wastewater. Unfortunately, wastewater contains numerous contaminants that are not regulated by the Environmental Protection Agency (EPA) under the Safe Drinking Water Act (SDWA). Many …

Haul Truck Tires Recycling, Marina E. Lee

Chemical Engineering Undergraduate Honors Theses

The Ball Hogs competed in Task 2 - Haul Truck Tires in the 2016 Waste-Management Education and Research Consortium (WERC) International Environmental Design Contest. This task required designing a solution to recycle discarded haul truck tires from mining sites. Our solution was to use the treads of these haul truck tires to construct liners for ball mills. Recycling haul truck tires in this manner would save the mining companies a substantial amount of money and would result in a decrease of carbon emissions.

Development Of A Simple Handheld Biosensor For Waterborne Pathogens, Bryce C. Jones

Chemical Engineering Undergraduate Honors Theses

Current methods of detecting waterborne pathogens involve testing strips which take 24-48 hours to yield results, or require expensive equipment in order to function. In minimalist environments, these two technologies are not always applicable to test water quality. With the emergence of a new method of PCR, named LAMP PCR, it is possible to quickly and accurately detect pathogen DNA in a water sample. In order to scale this technique into a simple device, the aspects of the reaction must be accommodated, and a visual detection method chosen. A handheld device which keeps the isothermal LAMP PCR stable for the …

Werc Task #1 - Efficiency And Particulate Matter Emissions Testing Of Wood Burning Heating Units, Jonathan A. Shumaker

Chemical Engineering Undergraduate Honors Theses

A design of a method for calculating the efficiency and particulate matter emission rates was developed for use on wood stoves. The project was completed for the WERC competition which is an international design contest. The prevalence of wood burning as a form of heating, current EPA regulations, and current market conditions were major factors in forming the necessity of this testing method. Design was not limited to outlining the design specifications, the apparatus was built and run. Optimization of the method continued until completion of the project. If the method would continue to be improved then it would be …

Efficiency And Particulate Matter Emissions Testing Of Wood Burning Heating Units, Lindsey Mayo

Chemical Engineering Undergraduate Honors Theses

The performance and use of wood-burning stoves as a heating source is carefully regulated by the Environmental Protection Agency (EPA). The EPA requires a rigorous and exhaustive testing protocol be conducted on each unit before it can be sold commercially in order to ensure that the stove in question will not have a detrimental effect on the surrounding environment. However, this testing routine is incredibly time intensive and costly, resulting in a 90% decrease in the number of stove manufacturers since 1988. This decreased competition has ultimately fostered an industry free from competition and motivation to produce clean and efficient …