Engineering Commons^™

Impact Of The Municipal Solid Waste Incineration Plant In Warsaw On Air Quality, Robert Oleniacz

Robert Oleniacz

The only Polish municipal solid waste (MSW) incinerator has been operating within the Municipal Solid Waste Disposal Plant in Warsaw since 2000. In the paper selected results of the air quality impact assessment for this incinerator during an operating period of one year (2008) are presented. With respect to the incinerated waste amounts and emission levels, the analysed period can be considered typical for this facility. Assessment of the air quality impact was carried out by assessing air pollutant emissions in reference to the applicable emission limit values and by modeling atmospheric dispersion of these pollutants. It has been found …

Assessment Of The Impact Of Municipal Waste Incineration Plants On Air Quality And The Possibilities Of Its Reduction, Robert Oleniacz

Robert Oleniacz

The planned construction of new municipal waste incineration plants over the next few years in Poland results in protests of local communities, which arise mainly from fear of an increase in the air pollution in its vicinity. These protests extend the investment process and hinder the selection of incineration plant location, but on the other hand they necessitate the use of more efficient solutions to reduce their impact on the air quality.This paper characterizes the world's most widely used technology for municipal solid waste incineration (MSWI) and assesses the possible maximum impact on the air quality of an exemplary MSWI …

Co-Incineration Of Large Quantities Of Alternative Fuels In A Cement Kiln – The Problem Of Air Pollutant Emissions, Robert Oleniacz, Magdalena Kasietczuk

Robert Oleniacz

Over the last few years, a significant increase in the use of alternative fuels in the Polish cement industry has been observed. These are mainly waste and waste-derived fuels. The national leader in this field is Chełm cement plant (Poland), with the share of alternative fuels in the cement kiln heat balance reaching in 2012 the level of 78.5%. In this paper, an analysis of the emission rate of air pollutants from cement clinkering process in the above-mentioned cement plant in the years 1998–2012 was carried out, using the results of continuous and periodic measurements. The compliance with the emission …

Współspalanie Odpadów W Suchym Piecu Cementowym A Emisja Dwutlenku Siarki I Chlorowodoru, Robert Oleniacz

Robert Oleniacz

The paper presents an assessment of the impact of waste co-combustion in a cement kiln on air emissions of HCl and SO2 recorded continuously. The subject of the research was cement kiln (dry method) with a capacity of 8500 Mg/day, equipped with a four cyclone heat exchangers and a calciner with an additional chamber for co-incineration. In the analysed period alternative fuels (mainly waste) were used in various amounts ranging up to about 35 kg / Mg clinker (with the heat substitution up to 20%) in the kiln and calciner. Chlorine and sulfur inputs to the process were up to …

Analiza Wpływu Planowanego Zakładu Termicznego Przekształcania Odpadów Komunalnych Na Jakość Powietrza W Krakowie, Robert Oleniacz, Maria Pilch

Robert Oleniacz

Construction of the Municipal Solid Waste Incineration (MSWI) plant is considered optimal in the Programme of Management of Solid Waste in Krakow as well as in proposed scenarios of Municipal Waste Management. Evaluation of impact of the incineration plant with a capacity of 255000 tons per year on air quality in Krakow is presented in this work. The evaluation is based on assumption that air pollutant emissions from the incinerator will be at the highest allowed level resulting from emission limit values for waste incineration plants with operation time each of two planned lines 7500 hours per year. Calculation results …

Czynniki Wpływające Na Skład Spalin I Wielkość Emisji Zanieczyszczeń Z Procesów Termicznego Przekształcania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The work summarizes factors influencing on air emissions from various full-scale hazardous waste incinerators (rotary kiln, multiple hearth furnace, starved-air incinerator, fluidized bed incinerator, liquid injection incinerator). Air pollutant emissions from hazardous waste incineration can be minimized not only by flue-gas cleaning. There are many factors that influence on flue-gas composition and the quantity of air pollutants formed during incineration: the type, the composition and the quantity of waste, the way of waste introducing to the incinerator, excess air ratio, combustion temperature, retention time of exhaust gases etc. Special attention was paid to the loading of waste and incineration conditions …

Odpady Pestycydowe Jako Paliwo Zastępcze W Piecach Obrotowych Do Wypalania Klinkieru Cementowego, Marian Mazur, Robert Oleniacz, Marek Bogacki, Stanisław Słupek

Robert Oleniacz

The clinker burning plant is ideally suited for processing a wide variety of hazardous waste materials. High temperatures existing in cement kilns (ca. 1350-1450 Centigrades in the burning zone) as well as long gas-residence time (ca. 6-10 s) provide potentially excellent conditions for destruction of toxic organic compounds. Non-volatile compounds are retained in the solid phase and built into the clinker. A lot of other (for example acid gases) can also be absorbed by alkaline solid phase. Old pesticide wastes present a big problem in Poland now. They can be use as waste-derived fuels in cement kilns, especially in the …

Dobór Systemu Oczyszczania Gazów Odlotowych Ze Spalania Odpadów Niebezpiecznych, Robert Oleniacz

Robert Oleniacz

The flue gas cleaning system is usually one of the most costly elements of the installation to the incineration of hazardous waste. Adapting the system to the actual needs could therefore bring obvious economic benefits.

The paper presents the method of the preselection of the configuration of the cleaning system based on knowledge of the level of concentration of selected components of the raw exhaust gas (sulfur dioxide, hydrogen chloride, hydrogen fluoride, total dust, mercury, cadmium and thallium, and other heavy metals). Twelve examples of flue-gas cleaning systems were proposed and extreme concentration values of the substances in the raw …

Pesticide Waste Incineration In The Wet Process Cement Kiln, Marian Mazur, Robert Oleniacz, Marek Bogacki, Stanisław Słupek

Robert Oleniacz

The presentation discusses the problem of pesticide wastes in Poland that have been accumulated underground in concrete graveyards or bunkers. Their progressive unsealing poses a significant health risk to people due to groundwater, soil and air pollution. There are not many of professional hazardous waste incineration plants in Poland, therefore, the paper proposes the use of cement kiln for thermal treatment of such waste. Polish cement industry is interested in utilization of various wastes (e.g. in the capacity of alternative fuels) in the process connected with the cement clinker production in rotary kilns. High temperatures existing in cement kilns (ca. …

Pirolityczne Metody Utylizacji Odpadów Niebezpiecznych - Przykładowe Rozwiązania I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

The paper presents the pyrolysis and gasification processes of organic matter and the main directions of their use for the thermal disposal of hazardous waste. Used for this purpose the basic technical solutions are discussed with regard to existing and new technologies. Given the fact that the pyrolytic methods in Poland were primarily used for the incineration of medical waste, most attention was paid to a facility designated for such waste disposal. The problem of air pollutant emissions from this type of installation and some operating guidelines was also presented on the basis of the literature analyses and own research. …

Zastosowanie Procesów Pirolizy I Zgazowania Do Termicznej Utylizacji Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents characteristic of pyrolysis and gasification processes and main trends to their application for the waste thermal treatment. Selected examples of the applications and course of these processes as well as sorts of their final products is here also discussed.

English title: The use of pyrolysis and gasification processes to waste thermal utilization.

Spalanie Odpadów Niebezpiecznych W Piecach Cementowych. Część 2. Destrukcja Paliwa I Emisja Zanieczyszczeń, Robert Oleniacz

Robert Oleniacz

Conditions occurring in cement rotary kilns assure high destruction and removal efficiency (DRE) of the most stable substances, efficacious dry sorption of acid gases in the alkaline raw meal and heavy metals bounding in the clinker. Adequate operation of hazardous waste incineration in the process connected with cement clinker production does not cause increasing air pollutant emissions. Magnitude of the emissions often does not depend of this if there are using wastes in the cement kiln at all. The work presents a review of DRE levels and stack emissions for selected flue-gas constituents during hazardous waste co-combustion in cement kilns …

Spalanie Odpadów Niebezpiecznych W Piecach Cementowych. Część 1. Informacje Podstawowe, Robert Oleniacz

Robert Oleniacz

A widely employed method of reducing cement production costs is the substitution of traditional fuels with alternative and waste-derived fuels to heat the cement kiln. Cement industry offers the most acceptable method of hazardous waste incineration and co-combustion with significantly lower cost in comparison to incinerators. The high temperatures and long residence times inherent in the operation of cement kilns ensure the almost complete destruction of the organic compounds introduced together with waste fuels. This part of the article presents general characteristic of sort of waste incinerated in cement kilns, way of their charging, advantages and limitations of waste co-combustion …

Piece Cementowe - Konkurencja Dla Spalarni Odpadów, Robert Oleniacz

Robert Oleniacz

The paper presents the advantages of cement kilns and the possibility of their use for thermal waste utilization. The most common types of waste incinerated in these kilns and the possible degree of replacing traditional fuels with waste fuels have also been characterized. The work also discusses the problem of air pollutant emissions from the process of waste co-incineration in cement kilns. Attention has been paid to the possible increase in the use of Polish cement industry in the waste management, system, especially in the field of energy recovery from solid municipal waste, waste tires and waste from the refinery …

Emisja Zanieczyszczeń Podczas Składowania I Termicznej Utylizacji Osadów Ściekowych Z Przemysłu Koksochemicznego / Emissions During Storage And Thermal Utilization Of Sewage Sludge From Coke-Chemical Industry, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

Both storage and thermal disposal of sewage sludge from industrial wastewater treatment plants are a significant source of air pollutant emissions. The study included the sludge generated in the coke-chemical industry. The paper presents the results of measurements of emissions of selected substances during storage of the waste in a closed storage hall with natural ventilation and during incineration of the mechanically dewatered sludge in a multiple hearth furnace.

Spalanie Odpadów Poszpitalnych I Farmaceutycznych W Piecu Obrotowym / Incineration Of Hospital And Pharmaceutical Wastes In A Rotary Kiln Incinerator, Robert Oleniacz, Marian Mazur, Marek Bogacki

Robert Oleniacz

The paper presents selected results of research on hospital and pharmaceutical waste incineration in a full-scale rotary kiln with variable loads of the kiln. As part of these studies measurements of air pollutant concentrations in flue gases and leaching tests of solid combustion products were carried out. Based on these studies, the maximum dose of hospital and pharmaceutical waste was proposed in the mixture with industrial wastes, which does not cause excessive air emissions. The average emission factors for the waste mixture loading were also determined.

Spalarnia Odpadów Lobbe W Dąbrowie Górniczej, Marian Mazur, Robert Oleniacz, Ryszard Januszek

Robert Oleniacz

This paper is a general characteristic of the industrial and hazardous waste incineration plant which was operated in Dąbrowa Górnicza (Poland) in the 90. The waste incineration plant is based on two incinerators - a rotary kiln and a multiple hearth furnace. Levels of selected air pollutant emissions presented in the work allow to assess the potential impact of this facility on air quality.

English title: The LOBBE incineration plant in Dąbrowa Górnicza.