Engineering Commons^™

Waste Heat Recovery Options In A Large Gas-Turbine Combined Power Plant, Ularee Upathumchard

Open Access Theses

This study focuses on power plant heat loss and how to utilize the waste heat in energy recovery systems in order to increase the overall power plant efficiency. The case study of this research is a 700-MW natural gas combined cycle power plant, located in a suburban area of Thailand. An analysis of the heat loss of the combustion process, power generation process, lubrication system, and cooling system has been conducted to evaluate waste heat recovery options. The design of the waste heat recovery options depends to the amount of heat loss from each system and its temperature. Feasible waste …

High Voltage Rear Electric Drivetrain Design For A Parallelthrough-The-Road Plug-In Hybrid Electric Vehicle, Adam Garrett Fogarty

Open Access Theses

Purdue University was selected as one of 15 universities to participate in a three year Advanced Vehicle Technology Competition (AVTC) called EcoCar2: Plugging Into the Future. The vehicle built by the Purdue team was a Parallel-Through-The-Road Plug-in Hybrid Electric Vehicle (PTTR PHEV). The vehicle utilized a B20 diesel powertrain to power the front wheels, as well as a custom electric drivetrain to power the rear wheels. Using this vehicle during the final year of the competition, the team was successful in placing 4th overall as well as 2nd in the category of Well-To-Wheel (WTW) Greenhouse Gas Emissions. A stock 2013 …

Catalysts For Portable, Solid State Hydrogen Genration Systems, Jason Robert Gabl

Open Access Theses

Hydrogen and air powered proton exchange membrane fuel cells are a potential alternative to batteries. In portable power systems, the design requirements often focus on cost efficiency, energy density, storability, as well as safety. Ammonia borane (AB), a chemical hydride containing 19.6 wt. % hydrogen, has a high hydrogen capacity and is a stable and non-toxic candidate for storing hydrogen in portable systems.

Throughout this work, Department of Energy guidelines for low power portable hydrogen power systems were used as a baseline and comparison with commercially available systems. In order to make this comparison, the system parameters of a system …

A Novel Microgrid Demand-Side Management System For Manufacturing Facilities, Terance Jerome Harper

Open Access Theses

Thirty-one percent of annual energy consumption in the United States occurs within the industrial sector, where manufacturing processes account for the largest amount of energy consumption and carbon emissions. For this reason, energy efficiency in manufacturing facilities is increasingly important for reducing operating costs and improving profits. Using microgrids to generate local sustainable power should reduce energy consumption from the main utility grid along with energy costs and carbon emissions. Also, microgrids have the potential to serve as reliable energy generators in international locations where the utility grid is often unstable.

For this research, a manufacturing process that had approximately …

High Temperature Flooded Expansion For Solar Thermal Power Generation, Nelson Alexander James

Open Access Theses

Even though solar power usage has seen rapid growth over the past decade, fossil fuel generation sources are still generally a less expensive means of producing power. The Liquid-Flooded Ericsson Cycle (LFEC) was investigated as a high efficiency power cycle for reducing the cost of concentrated solar power (CSP) plants and helping to address this cost disparity. High temperature flooded expansion was identified as one of the main challenges in regards to utilizing the LFEC as a power cycle. Thermodynamic models were developed to help assess the performance of the LFEC and a load stand was constructed to test a …

Identifying, Monitoring, Quantifying And Converting Algae To Bio-Fuels In Bio-Reactors, Alice C. Jernigan

Graduate Theses and Dissertations

Growing algae as a source for bio-fuels has become an area of interest due to concerns about global warming and the reliability and ecology of the production of fossil fuels. Dried algae harvested from a pilot water quality improvement technology at the Rockaway Wastewater Treatment Facility in New York were examined as a source of carbohydrates and lipids for the production of bio-fuels in bio-reactors. The length of storage time, storage conditions, sugar and lipid extraction processes, and fuel production were studied. The results show that if the algae is stored dry (0.015 g/g algae even after a year in …

Cztsse Thin Film Solar Cells : Surface Treatments, Chinmay S. Joglekar

Open Access Theses

Chalcopyrite semiconducting materials, specifically CZTS, are a promising alternative to traditional silicon solar cell technology. Because of the high absorption coefficient; films of the order of 1 micrometer thickness are sufficient for the fabrication of solar cells. Liquid based synthesis methods are advantageous because they are easily scalable using the roll to roll manufacturing techniques.

Various treatments are explored in this study to enhance the performance of the selenized CZTS film based solar cells. Thiourea can be used as a sulfur source and can be used to tune band gap of CZTSSe. Bromine etching can be used to manipulate the …

Improving Indoor Air Quality Through Botanical Air Filtration In Energy Efficient Residences, Daniel William Newkirk

Open Access Theses

According to the U.S. EPA, the average American spends 90% of their time indoors where pollutants are two to five times more prevalent than outside. The consequences of these pollutants are estimated to cost the U.S. 125 billion dollars in lost health and productivity. Background literature suggests botanical air filtration may be able to solve this problem by leveraging the natural ability of plants to purify indoor air. By improving indoor air quality, energy consumption can also be reduced by bringing in less outside air to dilute contaminants within the space. A botanical air filter, called the Biowall, was designed …

Effectiveness Of Air Sealing Measures And Other Energy Retrofit Measures In Lafayette Energy Improvement Program, Jia Ye

Open Access Theses

From September 2011 to March 2013, the City of Lafayette, IN implemented Lafayette Improvement Program. The goal of this project was to "increase energy efficiency of existing homes through retrofitting, thereby lowering the costs of home ownership within the Vinton and Glen Acres Neighborhood Target Area (The City of Lafayette, 2011)." Energy audit companies carried out before blower door test and after blower door test to identify air tightness of subjects. This paper finds out there was an improvement in air tightness in the population of 85 houses and the degree of improvement was between 16.85% and 17.85%.

Change point …