Engineering Commons^™

Separation Of Radionuclides From A Rare Earth-Containing Solution By Zeolite Adsorption, Deniz Talan, Qingqing Huang

Faculty & Staff Scholarship

The increasing industrial demand for rare earths requires new or alternative sources to be found. Within this context, there have been studies validating the technical feasibility of coal and coal byproducts as alternative sources for rare earth elements. Nonetheless, radioactive materials, such as thorium and uranium, are frequently seen in the rare earths’ mineralization, and causes environmental and health concerns. Consequently, there exists an urgent need to remove these radionuclides in order to produce high purity rare earths to diversify the supply chain, as well as maintain an environmentally-favorable extraction process for the surroundings. In this study, an experimental design …

Design And Development Of A Multi-Nodal Methane Detection System For Longwall Coal Mining, Amber P. Barr

Graduate Theses, Dissertations, and Problem Reports

Methane (CH4) explosions pose significant dangers in longwall mining that may lead to injuries and fatalities. Safety is improved through diligent monitoring of CH4 concentration. Currently, regulations require a CH4 monitor be placed on the shearer, downwind of the cutting head. Portable monitor measurements must be taken at various times and locations. If any CH4 monitor measures a concentration greater than 1%, a warning signal must be given. Based on previous research and the location of the CH4 monitor mounted on the shearer (closest monitor to the face), if 1% methane is measured, the concentration at the face may be …

Rational Drilling Control Parameters To Reduce Respirable Dust During Roof Bolting Operations, Hua Jiang

Graduate Theses, Dissertations, and Problem Reports

Roof bolting has been the primary means to improve mine safety in the aspect of preventing different types of roof falls in underground mines. However, based on the published researches, underground roof bolting operators exhibit a continued risk for overexposure to high levels of respirable coal and crystalline silica dust from the roof drilling operation. Inhaling these dust can cause coal workers’ pneumoconiosis (CWP), also known as black lung. Another job-related lung disease silicosis, a disabling and even fatal and irreversible illness, could be developed through overexposure to quartz-laden dust. A recent NIOSH research shows that the quartz content in …

Solution Tool To Predict Filter Cake Formation For Acid Mine Drainage (Amd) Slurries, Roberto Ecuador Martinez Ochoa

Graduate Theses, Dissertations, and Problem Reports

Acid Mine Drainage (AMD), also known as alkaline mine drainage resulted from abandoned and active coal mining areas has been a major water pollutant in the mid-Atlantic region of the United States affecting aquatic life, recreational areas, tourism, etc. AMD results from during and post mining activities all around the US and the world containing high levels of acidic materials such as sulfate and other heavy metals.

The United States Environmental Protecting Agency (EPA) has recommended the use of different mechanisms for mitigation purposes due to considerable existing and potential damage generated by AMD. This report focuses on the usage …

Adaptation Of Coal Mine Floor Rating (Cmfr) To Eastern U.S. Coal Mines, Sena Cicek

Graduate Theses, Dissertations, and Problem Reports

Floor heave—the excessive deformation and failure of floor strata—is a serious problem for many underground coal mining operations in the U.S. There is an accepted floor heave design methodology developed for the Illinois basin coal mines (Gadde, 2009). However, for Eastern U.S. coal mines in the Appalachian region, there is not any systematic design method to assess floor heave potential. In order to prevent stability problems associated with floor failure and to ensure the safety of the miners in this region, a systematic and proactive method to assess the potential of floor stability that also takes the floor failure mechanisms …

Development, Analysis And Case Studies Of Impact Resistant Steel Sets For Underground Roof Fall Rehabilitation, Dakota D. Faulkner

Graduate Theses, Dissertations, and Problem Reports

Underground mines often experience roof falls in entries, crosscuts, and intersections of active mining sections, main travel ways, and belt entries. Roof fall heights greater than 20 ft (6 m) make re-bolting of the newly exposed roof dangerous and impractical. To protect mine personnel, belts, moving vehicles, and other equipment, mine operators typically install steel structures such as square or arch sets in the roof fall areas. Wood lagging is usually installed between the steel-sets to enclose the area and protect the entry from recurring falls. Usually the void space above the steel-sets and wood lagging is backfilled. However, backfilling …

Fundamental Studies On The Recovery Of Rare Earth Elements From Acid Mine Drainage, Xue Huang

Graduate Theses, Dissertations, and Problem Reports

The Rare Earth Elements (REEs) are a group of 17 chemically similar elements that are essential raw materials for modern society. Given their increasing importance in civil and defense applications, many national governments, including the US, have denoted the REEs as critical materials and emphasized the need to identify and develop both conventional and unconventional resources to meet the growing demand. To address this challenge, the US Department of Energy has recently spearheaded efforts to evaluate the technical and economic feasibility of recovering REEs from coal and coal byproducts, which have been shown to contain REEs at an elevated concentration …

Solutions To Some Mine Subsidence Research Challenges, Jian Yang

Graduate Theses, Dissertations, and Problem Reports

The objective of this work is to address three challenging topics, (1) effects of overburden key strata on subsurface subsidence; (2) effects of longwall subsidence on interstate highways and highway bridges; and (3) effects of dewatering mine water on surface subsidence over inactive room-and-pillar mines, in mine subsidence and to continue improvement of mine safety and health by reducing mine-subsidence related hazards.

Surface and subsurface subsidence events induced by underground mining activities are often capable of causing significant disturbances not only to surface structures, but also to subsurface structures. In this work, models and techniques to study three challenging topics …

An Interactive Mobile Equipment Task-Training With Virtual Reality, Lazar Zujovic

Graduate Theses, Dissertations, and Problem Reports

Improving the quality of equipment training for the Heavy Equipment Operators (HEO) is a critical task in the ever-lasting effort to improve safety and eliminate equipment-related injuries in mining environments. Traditional miner training includes the use of hardcopy documents and video instructions. However, modern mobile and computer technology offers tremendous potential to improve the training process. One major responsibility for the heavy-machine operators is proper machine inspection. Establishing new training methods that utilize modern technologies—such as 360-degree images, videos, and Virtual Reality—and implementing computers for training purposes have a potential to help new operators learn how to conduct proper machine …

The Influence Of Spatial Variance On Rock Strength And Mechanism Of Failure, Danqing Gao

Graduate Theses, Dissertations, and Problem Reports

The heterogeneity in the rock formation affects both rock behavior and the strength. The effect of heterogeneity is observed both at the laboratory scale and at the rockmass level. The mechanical properties of intact rock vary considerably at laboratory scale and often an average value is used for design purposes. Similarly, the values are arbitrarily scaled when used at rockmass level. In underground coal mines, the effect of variability of properties is often observed with the erratic roof failure events that occur throughout the mine. The approach often was to use the deterministic values from limited site data to estimate …

Upstream Tailings Dam - Liquefaction, Mladen Dragic

Graduate Theses, Dissertations, and Problem Reports

The collapse of Dam I, tailings dam, at Vale S.A.’s (“Vale”) of the Córrego do Feijão Iron Ore Mine in Brazil was an accident that caused over 270 casualties and made irreparable damage to the surrounding environment. The exact reason for the failure is not known however, liquefaction was suspected to be the most influencing factor in the failure. Liquefaction failure of impoundment is increasing concern in the mining community and especially mine planners who will have to design and build the tailings dam. Different design methods are available with varied degree of challenges. Upstream construction methods, as one of …