Engineering Commons^™

Sugarcane Bagasse Hydrolysis Enhancement Using Bsa, Antonio Carlos Freitas Dos Santos

Open Access Theses

Lignocellulose is composed of polysaccharides linked to lignin and other aromatic compounds, making the sugars not readily available to fermentation. This entails that biomass must go through the unit operations of pretreatment and enzyme hydrolysis. Pretreatment opens the structure to allow the enzymes to act on and hydrolyze cellulose and hemicellulose to glucose and/or xylose which in turn are fermented to ethanol. Concomitantly, the enzymes interact with soluble phenols and insoluble solids derived from lignin that inhibit hydrolysis. This leads to high enzyme loadings and higher production costs. Soluble phenols can be eliminated through washing. Insoluble lignin, however, demands another …

Design And Plan Of A Modified Hydroponic Shipping Container For Research, John A. Houtman

Open Access Theses

As the world’s population continues to increase, food production will need to increase in order to meet the predicted rise in food demand. However, with increased pressure on cropland available from environmental effects and urbanization, new innovative methods of crop production need to be researched in order to increase agricultural production with limited land. This research focuses on the design of a single form of urban agriculture that is considered Zfarming and has the potential to produce quality urban agricultural produce through ground-based measures. This project produced detailed step-by-step analysis of the design process, develop variability within the modified hydroponic …

Exploring The Cause Of Injury Or Death In Grain Entrapment, Engulfment And Extrication, Salah F. Issa

Open Access Dissertations

Grain entrapments and engulfments are one of most common hazards associated with grain storage facilities. Since the 1970’s over 1,880 incidents have been documented in agricultural confined spaces of which 65% of all recorded incidents were grain entrapments and engulfments. There have been several studies conducted on the contributing factors behind these incidents; however, there have been very few attempts to understand the environmental, physiological or psychological factors the victims experience while entrapped, engulfed, or extricated. This includes understanding how secondary injuries are caused by grain or during extrication by first responders. The research effort was divided into three segments. …

Investigation Of Methods For Reducing Aflatoxin Contamination In Distillers Grains, Hu Shi

Open Access Dissertations

The overall goal of this project was to reduce the aflatoxin level in the final coproduct of ethanol bioprocessing--DDGS. This was pursued by examining the effects of reduction of aflatoxin in the incoming corn prior to bioprocessing, the degradation of aflatoxin in the intermediate products, namely DWG and CDS, during processing, and aflatoxin degradation in the DDGS. Segregation techniques (size screening and density sorting) and detoxification methods (conventional and microwave heating, food additives, and high voltage atmospheric cold plasma) were evaluated for their effectiveness in aflatoxin reduction.

Effectiveness of physical segregation of aflatoxin contaminated corn was investigated by size screening …

Organizing Historical Agricultural Data And Identifying Data Integrity Zones To Assess Agricultural Data Quality, Elizabeth Marie Hawkins

Open Access Dissertations

As precision agriculture transitions into decision agriculture, data driven decision- making has become the focus of the industry and data quality will be increasingly important. Traditionally, yield data cleaning techniques have removed individual data points based on criteria primarily focused on the yield values. However, when these methods are used, the underlying causes of the errors are often overlooked and as a result, these techniques may fail to remove all of the inaccurate data or remove “good” data. As part of this research, an alternative to data cleaning was developed. Data integrity zones (DIZ) within each field were identified by …

Simulation Of Flow And Water Quality From Tile Drains At The Watershed And Field Scale, Colleen Moloney

Open Access Theses

Simulation models such as the Soil and Water Assessment Tool (SWAT) have become widely used in determining the water quality impacts of various management practices. Ensuring that the algorithms accurately represent the processes simulated has become an important goal. Tile drainage is a standard practice in the Midwest, US in order to reduce risk of yield loss due to excess water. Multiple tile drainage and water table algorithms have been available in the SWAT model between the initial SWAT release and revision 638 used in this study. Testing of those algorithms is often limited. Furthermore, algorithms in the current version …

Mapping And Analyzing Energy Use And Efficiency In A Modified Hydroponic Shipping Container, Rachel E. Sparks

Open Access Theses

In urban centers today, vertical farming is becoming a popular alternative to conventional agriculture in an effort to increase local food production and improve urban food security by growing crops using hydroponic methods in controlled environment spaces. More specifically, one vertical method involves growing crops inside refurbished shipping containers, or a “farm-in-a-box” concept, which offers a flexible, mobile, and scalable means of year-round food production in a variety of climates. Despite benefits of producing food locally, some of the concerns associated with these vertical farming systems include high energy consumption from climate control and electric lighting systems as well as …

Enzymatic Liquefaction Of Untreated Corn Stover, Neal N. Hengge

Open Access Theses

There is an ever increasing need for renewable alternatives to fossil fuels derived from petroleum. This makes feedstocks in the form of lignocellulosic biomass attractive substrates for the production of ethanol and value added chemicals. However, the economics of converting lignocellulosic materials involve high processing costs attributed with pretreatment of the biomass and the use of enzymes for saccharification. Corn stover was obtained for the examination of an upstream processing step to transform the material into a pumpable slurry for subsequent pretreatment and saccharification. Biomass liquefaction was carried out using the enzyme Depol 692L (Biocatalysts, Wales, UK) at 50°C with …

Investigation Of Climate Variability And Climate Change Impacts On Corn Yield In The Eastern Corn Belt, Usa, Ruoyu Wang

Open Access Dissertations

The increasing demand for both food and biofuels requires more corn production at global scale. However, current corn yield is not able to meet bio-ethanol demand without jeopardizing food security or intensifying and expanding corn cultivation. An alternative solution is to utilize cellulose and hemi-cellulose from perennial grasses to fulfill the increasing demand for biofuel energy. A watershed level scenario analysis is often applied to figure out a sustainable way to strike the balance between food and fuel demands, and maintain environment integrity. However, a solid modeling application requires a clear understanding of crop responses under various climate stresses. This …

Simulation Of Conservation Practice Effects On Water Quality Under Current And Future Climate Scenarios, Carlington W. Wallace

Open Access Dissertations

Analysis of the effects of implementing different conservation practices, as well as increased levels of conservation practices under existing and projected future climate, will determine if current conservation practice recommendations will be sufficient to maintain soil and water resources. The Soil and Water Assessment Tool (SWAT) was used to study four watersheds of different sizes (CCW = 680 km2, F34 = 183 km2, AXL = 42 km 2 and ALG = 20 km2) located in Northeastern Indiana. The overarching goal of this study was to evaluate the effect of various agricultural practices on runoff and agricultural chemical losses under current …

Assessment Of An Industrial Type Radiant Heating System For Drying Rough Rice, Anne Adhiambo Okeyo

Graduate Theses and Dissertations

Rough rice is normally harvested at moisture contents (MCs) higher than that for safe storage. The objective for this study was to investigate the effectiveness of scaled-up infrared (IR) heating followed by tempering steps to dry freshly-harvested rough rice. An industrial type, pilot scale, IR drying equipment, designed to convey rough rice on a vibrating conveyor belt was used in this study. The heating zone of the equipment had catalytic IR emitters powered by natural gas. Freshly-harvested rough rice of long-grain pureline (cv. Cheniere), long-grain hybrid (cv. 6XP 756) and medium-grain (cv. CL 271) cultivars at initial moisture contents (IMCs) …

Effect Of Bioenergy Crops And Fast Growing Trees On Hydrology And Water Quality In The Little Vermilion River Watershed, Tian Guo

Open Access Dissertations

Energy security and sustainability require a suite of biomass crops, including woody species. Short rotation woody crops (SRWCs) such as Populus have great potential as biofuel feedstocks. Quantifying biomass yields of bioenergy crop and hydrologic and water quality responses to growth is important should it be widely planted in the Midwestern U.S. Subsurface tile drainage systems enable the Midwest area to become highly productive agricultural lands, but also create environmental problems like nitrate-N contamination of the water it drains. The Soil and Water Assessment Tool (SWAT) has been used to model watersheds with tile drainage, but the new tile drainage …

Investigating U.S. Resident Perceptions Of Corporate Social Responsibility In Food And Agriculture, Carissa Jae Morgan

Open Access Theses

Corporations are prioritizing corporate social responsibility (CSR) activities by investing in and actively promoting their social practices. In the U.S. of the modern food supply chain creates a unique challenge for corporations to address concerns about social issues of consumers and non-consumers alike. This study is motivated by the need to better understand individuals’ perceptions of CSR as it pertains to the food supply chain. In April 2015 an online survey collected information from 1,201 U.S. residents with the objective of investigating individuals’ perceptions of relative importance of eight prominent CSR areas relevant to food and agriculture. Demographic, household consumption, …

Enhancing Bioethanol Fermentation Through Removal Of Acetic Acid Using Liquid-Liquid Extraction, Mahdieh Aghazadeh

Open Access Dissertations

The concern for the ever growing human population as well as the depletion of fossil fuel resources and their impact on global warming have long been motivations for the researchers to investigate means for sustainable producing carbon-neutral energy. Second-generation biofuel refers to liquid fuels that are produced from non-food resources and reduce the total greenhouse gas emission by at least 60 %. Acetic acid has been shown to be one of the most ubiquitous fermentation inhibitors in a bioethanol production facility which slows down the bioethanol production and reduces its yield through inhibition of the ethanol producing microorganisms. The use …

Development And Evaluation Of A Watershed-Scale Hybrid Hydrologic Model, Younghyun Cho

Open Access Dissertations

A watershed-scale hybrid hydrologic model (Distributed-Clark), which is a lumped conceptual and distributed feature model, was developed to predict spatially distributed short- and long-term rainfall runoff generation and routing using relatively simple methodologies and state-of-the-art spatial data in a GIS environment. In Distributed-Clark, spatially distributed excess rainfall estimated with the SCS curve number method and a GIS-based set of separated unit hydrographs (spatially distributed unit hydrograph) are utilized to calculate a direct runoff flow hydrograph, and time-varied SCS CN values and conditional unit hydrograph approach for different runoff depth-based flow convolution are also used to compute long-term rainfall-runoff flow hydrographs. …

Rearward Visibility Issues Related To Agricultural Machinery: Contributing Factors, Potential Solutions, Shawn Gregory Ehlers

Open Access Dissertations

As the size, complexity, and speed of tractors and other agricultural self-propelled machinery have increased, so have the visibility-related issues, placing significant importance on the visual skills, alertness, and reactive abilities of the operator. Rearward movement of large agricultural equipment has been identified in the literature as causing not only damage to both machine and stationary objects, but also injuries (even fatalities) to bystanders not visible to the operator. Fortunately, monitoring assistance, while not a new concept, has advanced significantly, offering operators today more options for increasing awareness of the area surrounding their machines. In this research, an attempt is …

Hydrologic And Water Quality Impacts From Perennial Crop Production On Marginal Lands, Qingyu Feng

Open Access Dissertations

Marginal lands are proposed as a viable option for producing biofeedstocks as these lands are not heavily engaged in agricultural production or may not be suitable for intensive row-crop food/feed production. However, meeting biofeedstock production goals will require large amount of marginal lands and the unintended consequences of producing biofeedstocks on marginal lands are not fully clear. The overall goal of this study was to evaluate the productivity of biofeedstocks on marginal lands and the potential impacts on hydrologic and water quality processes from the land use conversion.

This study was conducted in the Upper Mississippi River Basin (UMRB). First, …