Bioresource and Agricultural Engineering Commons^™

Field Research Report: Results From The Enreec Vri Field For The 2021, 2022, And 2023 Crop Seasons, Derek M. Heeren, Ali T. Mohammed, Eric Wilkening, Christopher M. U. Neale, Alan L. Boldt, Ankit Chandra, Precious Nneka Amori, Ivo Z. Goncalves, Yeyin Shi, Guillermo R. Balboa

Department of Biological Systems Engineering: Conference Presentations and White Papers

Long-term irrigation management research has been conducted from 2014 to 2023 for corn and soybean at the Eastern Nebraska Research, Extension, and Education Center (ENREEC) Variable Rate Irrigation (VRI) Field located in subhumid east-central Nebraska (in the Lower Platte North Natural Resources District). The objective of this report was to present the overall results from the VRI Field for 2021 to 2023. Across the three growing seasons, there were the following irrigation treatments: Best Management Practice (BMP), 50% BMP, 125% BMP, rainfed, Spatial ET Modeling Interface (SETMI), SDD1, SDD2, machine-learning-based Cyber-Physical System (CPS), a student team recommended rate, and industry …

Assessing The Impact Of Spatial Resolution Of Uas-Based Remote Sensing And Spectral Resolution Of Proximal Sensing On Crop Nitrogen Retrieval Accuracy, Kianoosh Hassani, Hamed Gholizadeh, Saleh Taghvaeian, Victoria Natalie, Jonathan Carpenter, Jamey Jacob

Biological Systems Engineering: Papers and Publications

Foliar nitrogen (N) plays a central role in photosynthetic machinery of plants, regulating their growth rates. However, field-based methods for monitoring plant N concentration are costly and limited in their ability to cover large spatial extents. In this study, we had two objectives: (1) assess the capability of unoccupied aerial system (UAS) and non-imaging spectroscopic data in estimating sorghum and corn N concentration and (2) determine the impact of spatial and spectral resolution of reflectance data on estimating sorghum and corn N concentration. We used a UAS and an ASD spectroradiometer to collect canopy- and leaf-level spectral data from sorghum …

Studies On Air Injection In A Wastewater-Fed Subsurface Drip Irrigation System, Henry A. Gonzalez Hernandez

Department of Agricultural and Biological Systems Engineering: Dissertations, Theses, and Student Research

In 2020, the Ogallala High Plains Aquifer supplied irrigation water for approximately 3.6 million hectares in Nebraska, making it the most irrigated state in the United States. Although Nebraska is highly dependent in groundwater, locations included in the Gering-Fort Laramie Irrigation District (border of Nebraska and Wyoming) rely on surface water resources. In addition to these conventional water sources, using non-conventional alternatives for crop production can be just as important during water shortage times such as the one that e occurred in 2019 with the collapse of the Goshen/Gering-Fort Laramie Canal. Feedlot runoff presents a great opportunity in Nebraska, but …

Detecting Recent Crop Phenology Dynamics In Corn And Soybean Cropping Systems Of Kentucky, Yanjun Yang, Bo Tao, Liang Liang, Yawen Huang, Christopher J. Matocha, Chad D. Lee, Michael Sama, Bassil El Masri, Wei Ren

Geography Faculty Publications

Accurate phenological information is essential for monitoring crop development, predicting crop yield, and enhancing resilience to cope with climate change. This study employed a curve-change-based dynamic threshold approach on NDVI (Normalized Differential Vegetation Index) time series to detect the planting and harvesting dates for corn and soybean in Kentucky, a typical climatic transition zone, from 2000 to 2018. We compared satellite-based estimates with ground observations and performed trend analyses of crop phenological stages over the study period to analyze their relationships with climate change and crop yields. Our results showed that corn and soybean planting dates were delayed by 0.01 …

Comparison Of Static And Active Downforce On Corn At The Kansas River Valley Experiment Field In 2020, E. A. Adee

Kansas Agricultural Experiment Station Research Reports

Uniformity of plant spacing and emergence have been shown to be significant contributing factors to increasing corn yields. Improved seed meters that offer very precise seed drop have been available on planters for a number of years. However, uniformity in plant emergence continues to be a challenge, especially with reduction of tillage and in fields with variable soils. Correct, consistent depth is critical for uniform corn emergence. By keeping the gauge wheels on the ground, consistent depth is achieved. An active downforce system, such as Precision Planting’s DeltaForce, applies hydraulic downforce or lift to the row unit. With a Precision …

Sistema De Ensilaje Como Modelo De Producción En El Municipio De San José Departamento Del Guaviare, Nelby Nerieth Urrego Ramos

Ingeniería Agronómica

El presente trabajo se basó en el desarrollo del proyecto productivo a través de un sistema de ensilaje como modelo de producción en el municipio de San José departamento del Guaviare, en el que se describe la metodología y resultados obtenidos del desarrollo de cada uno de los componentes trabajados en el proyecto. En cuanto al componente de ingeniería agronómica se implementó una hectárea de maíz (Zea mays) del híbrido ATL 200 en el municipio de San José, con fines de ensilaje para consumo animal principalmente ganado bovino. De tal forma, que el componente de emprendimiento se basó en la …

Proyecto Productivo De Maíz (Zea Mays) Variedad Ica V109 Como Alternativa Económica En El Municipio De La Primavera, Departamento De Vichada, Raúl Andrés Aldana Andueza

Ingeniería Agronómica

Se realizó el establecimiento de un proyecto productivo agrícola de maíz (Zea mays) variedad ICA V109 en el resguardo La Pascua, municipio de La Primavera, departamento del Vichada, en un área de 15.000 m2, teniendo en cuenta todos los requerimientos técnicos necesarios en este sistema de producción agrícola, buscando así una alternativa económica para los habitantes del resguardo. Dentro del proyecto productivo se realizó un plan de manejo técnico que incluyó un plan de fertilización basado en un análisis de suelo, se efectúo un plan de manejo integrado de plagas, enfermedades y arvenses con los controles y umbrales de acción …

Analysis Of The Flow Behaviors Of Corn Meal During Extrusion, Daniel N. Hauersperger, Martin R. Okos, Troy Tonner

The Summer Undergraduate Research Fellowship (SURF) Symposium

Food extrusion can be used to make many products we consume today, including pasta, cereals and more. The ability to predict the characteristics of the final product from an extruder using raw material characteristics and operating conditions is vital to the extrusion process. In order to answer this need, the flow behavior of corn meal was measured in a lab viscometer (off-line) and compared to the flow behaviors from an extruder (in-line) at three different moisture contents (32.5%, 35%, 37.5% wet basis). The extruder and product are heated through the friction of the corn meal passing through the barrel not …

Temporal Evaluation Of Corn Respiration Rates Using Pressure Sensors, Gagandeep Singh Ubhi

Graduate Theses and Dissertations

High respiration rate of a grain indicates faster degradation of its dry matter. Proper grain management requires chronological and precise measurements of carbon dioxide evolved from grain respiration during the postharvest storage duration. Therefore the main goal of this research was to develop a new technique that evaluates temporal corn respiration rate using pressure sensors. It was based on measuring pressure drop associated with the grain respiration in a closed container and using it to calculate the grain respiration rates.

Dry corn (Zea Mays L.) was procured from a local farmer and stored at 4ºC. Corn rewetting technique was applied …

Field-Observed Angles Of Repose For Stored Grain In The United States, Rumela Bhadra, Mark E. Casada, Sidney A. Thompson, Josephine M. Boac, Ronaldo G. Maghirang, Michael D. Montross, Aaron P. Turner, Samuel G. Mcneill

Biosystems and Agricultural Engineering Faculty Publications

Bulk grain angle of repose (AoR) is a key parameter for inventorying grain, predicting flow characteristics, and designing bins and grain handling systems. The AoR is defined for two cases, piling (dynamic) or emptying (static), and usually varies with grain type. The objective of this study was to measure piling angles of repose for corn, sorghum, barley, soybeans, oats, and hard red winter (HRW) wheat in steel and concrete bins in the United States. Angles were measured in 182 bins and 7 outdoor piles. The piling AoR for corn ranged from 15.7° to 30.2° (median of 20.4° and standard deviation …

Error Analysis Of Stored Grain Inventory Determination, Aaron P. Turner, Michael D. Montross, Joshua J. Jackson, Samuel G. Mcneill, Mark E. Casada, Josephine M. Boac, Rumela Bhadra, Ronaldo G. Maghirang, Sidney A. Thompson

Biosystems and Agricultural Engineering Faculty Publications

Estimation of the quantity of stored grain is important for crop insurance, financial statements, and inventory control. Traditionally, the height of grain has been measured using weighted tape measures, and the volume is subsequently computed using standard geometric shapes (cylinders and cones) along with visual correction of the grain surface. Field measurements by four trained USDA Farm Service Agency and crop insurance agents on older farm-sized bins (8.2 to 11.0 m, or 27 to 36 ft, in diameter) resulted in standard deviations between 0.02 and 0.30 m for the equivalent height when the grain surface was not level. The largest …

Pack Factor Measurements For Corn In Grain Storage Bins, Rumela Bhadra, Aaron P. Turner, Mark E. Casada, Michael D. Montross, Sidney A. Thompson, Josephine M. Boac, Samuel G. Mcneill, Ronaldo G. Maghirang

Biosystems and Agricultural Engineering Faculty Publications

Shelled yellow corn is commonly stored in concrete or corrugated steel bins. Granular materials compact under their own weight, primarily due to particle rearrangement, leading to an increase in bulk density and a change in volume when stored. Reliable grain pack factors are needed to estimate storage capacities and to accurately monitor grain inventories. A science-based model (WPACKING) of pack factors is available that uses the differential form of Janssen's equation and takes into account the variation in density caused by pressure variation with height and moisture content of the grain and accounts for the effects of grain type, test …

Response Of Drought Tolerant And Conventional Corn To Limited Irrigation, I. Kisekka, F. Lamm, J. D. Holman

Kansas Agricultural Experiment Station Research Reports

With declining water levels in the Ogallala aquifer, many wells cannot supply peak irrigation water needs for corn. Emerging drought-tolerant (DT) corn hybrids could help farmers maintain yield with limited capacity wells. A knowledge gap exists comparing transgenic DT and conventional corn hybrids in yield response to water level. The purpose of this study was to compare yield, yield components, water productivity, and irrigation water use efficiency response of DT corn with cspB (DKC 6267 DGVT- 2PRO) transgene trait and conventional corn hybrid (DKC 62-98 VT2PRO) with similar maturity to full and limited irrigation. Preliminary results from the 2014 growing …

Effects Of Varying Methodologies On Grain Particle Size Analysis, J. R. Kalivoda, C. K. Jones, C. R. Stark

Kansas Agricultural Experiment Station Research Reports

Particle size reduction is an important component of feed manufacturing that impacts pellet quality, feed flowability, and pig feed efficiency. The correct determination of particle size is important for feed manufacturers, nutritionists, and pork producers to meet target specifications. The current method for determining the geometric mean diameter (dgw) and geometric standard deviation (Sgw) of grains has been published by the ANSI/ASAE S319.4. This method controls many variables, including the suggested quantity of initial material and the type, number, and size of sieves. However, the method allows for variation in shake time, sieve agitators, and the use of a flow …

Field Evaluation Of Arbuscular Mycorrhizal Fungal Colonization In Bacillus Thuringiensis Toxin-Expressing (Bt) And Non-Bt Maize, Tanya E. Cheeke, Mitchell B. Cruzan, Todd N. Rosenstiel

Biology Faculty Publications and Presentations

The cultivation of genetically engineered Bacillus thuringiensis toxin-expressing (Bt) maize continues to increase worldwide, yet the effects of Bt crops on arbuscular mycorrhizal fungi (AMF) in soil are poorly understood. In this field experiment, we investigated the impact of seven different genotypes of Bt maize and five corresponding non-Bt parental cultivars on AMF and evaluated plant growth responses at three different physiological time points. Plants were harvested 60 days (active growth), 90 days (tasseling and starting to produce ears), and 130 days (maturity) after sowing, and data on plant growth responses and percent AMF colonization of roots at each harvest …

Water Productivity Of Corn And Dry Bean Rotation On Very Fine Sandy Loam Soil In Western Nebraska, William E. Spurgeon, C. Dean Yonts

Biological Systems Engineering: Papers and Publications

Subsurface drip irrigation (SDI) was used to irrigate corn and dry beans in a crop rotation study for four years from 2005 to 2008 to evaluate the accumulative effect of irrigation amount on yield and irrigation water use efficiency (I_WUE). This study was conducted on a very fine sandy loam soil using a short season corn hybrid typical for the area. Four irrigation treatments based on providing a fraction of the estimated crop evapotranspiration (ET_c) were evaluated. The treatments were designed to replace a certain percentage of ET_c and were denoted as I₁₂₅, …

Insect-Damaged Corn Stalks Decompose At Rates Similar To Bt-Protected, Non-Damaged Corn Stalks, R. Michael Lehman, Shannon L. Osborne, Deirdre A. Prischmann-Voldseth, Kurt A. Rosentrater

Kurt A. Rosentrater

The relative decomposability of corn (Zea mays L.) residues from insect (Bt)-protected hybrids and conventional hybrids cultivated under insect pressure was investigated in two studies. Above-ground biomass, residue macromolecular composition, and stalk physical strength were also measured. In the first decomposition study, chopped residues (stalks and leaves) were used from a corn rootworm-protected (Cry3Bb1) hybrid and its non-Bt near isoline that were grown in replicated plots infested with corn rootworms (Diabrotica spp.). In the second study, residue (intact stalk sections) was used from three European corn borer (ECB, Ostrinia nubilalis Hübner)-resistant (Cry1Ab) hybrids representing different seed manufacturer/maturity date series, their …

Effect Of Elusieve Fractionation On Physical Properties Of Distillers Dried Grains With Solubles (Ddgs), Kurt A. Rosentrater, Radhakrishnan Srinivasan

Kurt A. Rosentrater

The production of corn-based ethanol in the U.S. has been dramatically increasing in recent years, and consequently so has the quantity of coproduct materials generated from this processing sector. These streams are primarily utilized as livestock feed, and can partially offset the need for corn in feed rations. As the industry evolves, new technologies are being developed to improve the value proposition of the coproducts, especially distillers dried grains with solubles (DDGS). One of these is the Elusieve process, which combines sieving and air classification to accomplish fractionation of the DDGS into component-rich (i.e., protein, lipid, fiber) streams. Previous studies …

Examining The Effects Of Ethanol Processing And Drying Conditions On The Physical Properties Of Distillers Dried Grains With Solubles (Ddgs), Kurt A. Rosentrater, Brian A. Wrenn

Kurt A. Rosentrater

The production of corn-based ethanol in the U.S. has been dramatically increasing in recent years, and consequently so has the quantity of coproduct materials generated from this processing sector. These streams are primarily utilized as livestock feed, which partially offsets the need for corn in feed rations. Because of its use as an animal feed, considerable research has been conducted into the nutritional properties, and to some extent the physical properties, of commerciallyavailable distillers dried grains with solubles (DDGS). There are, however, occasions when the quality of coproducts is not consistent. Thus questions regarding the influence of production operations on …

Adsorption And Desorption Of Phosphorus And Nitrogen By Immersed Stalks, John E. Gilley, Bahman Eghball, David B. Marx

Biological Systems Engineering: Papers and Publications

Adsorption and desorption of phosphorus (P) and nitrogen (N) by stalk residues may influence the concentrations of P and N in runoff. A laboratory study was conducted to measure the effects of P and N constituents in solution on adsorption and desorption of P and N by corn, soybean, and wheat stalk residues. Experimental variables included type of stalk material (corn, soybean, and wheat), inorganic nutrients in solution (PO₄-P and NO₃-N; PO₄-P and NH₄-N; NO₃-N and NH₄-N; and PO₄-P, NO₃-N, and NH₄-N), …

Physical Properties Of Low Oil Distillers Dried Grains With Solubles (Ddgs), Jessica A. Herr Saunders, Kurt A. Rosentrater

Kurt A. Rosentrater

Corn-based ethanol production is exponentially growing in the U.S. As the use of ethanol as a fuel source increases, so does the need to find valuable uses for coproducts of the production process, such as distillers dried grains with solubles (DDGS). DDGS is a good source of nutrients, energy, and protein. Currently DDGS is sold by ethanol processors as livestock feed, thereby increasing profit for the production plants. As the industry continues to grow, there will be a growing need to find additional uses for DDGS. Physical and chemical properties of coproduct streams are becoming increasingly investigated, as these characteristics …

Physical Properties Of Distillers Dried Grains With Solubles (Ddgs), Kurt A. Rosentrater

Kurt A. Rosentrater

The production of corn-based ethanol in the U.S. is dramatically increasing, and consequently so is the amount of coproduct materials generated from this processing sector. These streams are primarily utilized as livestock feed, which is a route that provides ethanol processors with a substantial revenue source and significantly increases the profitability of the production process. With the construction and operation of many new plants in recent years, these residuals do, however, have much potential for value-added processing and utilization in other sectors as well. Extensive research has been conducted into determining the nutritional properties of distillers dried grains with solubles …

Methodology To Determine Soluble Content In Dry Grind Ethanol Coproduct Streams, Vykundeshwari Ganesan, Kurt A. Rosentrater, Kasiviswanathan Muthukumarappan

Kurt A. Rosentrater

Distillers grains and syrup are coproducts from fuel ethanol dry grind processing. Ethanol manufacturing is dramatically increasing in the United States, primarily in Midwestern states, and thus the availability of these feed products is also growing. Confusion currently exists in industrial nomenclature regarding "solubles" in these streams because no standards are in place. In our study, dissolved materials were considered soluble matter. We developed a methodology to determine the dry basis soluble content in condensed distillers solubles (CDS) and distillers dried grains with solubles (DDGS). A mass balance analytical approach was initially used, but results were not in good agreement …

Some Physical Properties Of Distillers Dried Grains With Solubles (Ddgs), Kurt A. Rosentrater

Kurt A. Rosentrater

With the rapid growth in the fuel ethanol industry in recent years, considerable research is being devoted to determining distillers dried grains with solubles (DDGS) nutritional properties and to optimizing their inclusion in livestock diets; physical properties of these materials, however, have been largely ignored. Using standard laboratory methods, several physical properties for typical DDGS streams were determined, including moisture content, water activity, thermal properties (conductivity, resistivity, and diffusivity), bulk density, angle of repose, and color. The DDGS samples in this study were golden-brown in color and exhibited physical properties similar to other dry feed ingredients, such as hominy feed, …

Effect Of Moisture Content And Broken Kernels On The Bulk Density And Packing Of Corn, Samuel G. Mcneill, Sidney A. Thompson, Michael D. Montross

Biosystems and Agricultural Engineering Faculty Publications

Shelled yellow dent corn samples were conditioned to three moisture content levels (12%, 15%, and 18% w.b.) and mixed with a prescribed amount of broken corn particles of known size (geometric mean diameter of 1.0, 1.4, 2.0, 2.8, and 4.0 mm) and concentration (2.5%, 5.0%, and 7.5% by weight) levels. The initial bulk density and grain compaction under simulated overburden pressure tests were determined for each sample. Uniaxial compression tests were performed for seven vertical pressure levels (3.4, 6.9, 14, 28, 55, 110, and 165 kPa) with a minimum of three replications each. Tests were performed at two locations with …

Aircraft In Agriculture, N. E. Shafer, J. D. Furrer, J. W. Lomax

Nebraska Agricultural Experiment Station: Historical Circulars

Airplanes were first used in agriculture shortly after the close of World War I. They proved valuable for locating mosquito breeding areas, for forest fire patrol work, as an aid in locating outlaw cotton fields in the campaign against pink bollworm, and for surveying damage caused in large forested areas by the spruce budworm.

Measuring Silage And Capacity Of Silos, L. W. Chase

Nebraska Agricultural Experiment Station: Historical Circulars

The condition of the corn at filling time, the rate of filling, and the length of time settling has taken place before measuring the depth of the silage, all tend to cause variations in the weight per cubic foot of the silage and in the tonnage that can be placed in a silo. The greatest variation comes when very green corn or very ripe corn is used, and because of this it is possible that a cubic foot of green silage, which may weigh fifty pounds, holds no more dry matter than a cubic foot of overripe silage which weighs …